Professional Documents
Culture Documents
Check the status of the GBTS, make sure the GTMU board is power on and working normal. Put the USB flash into the USB port of the GTMU.
Do not remove the USB flash drive during the period from plugging in the flash drive to the duration of normal operation of the base station. Otherwise, the file load fails. Check with BSC integration team whether the BSC can Ping to the BTS IP.
Use an Ethernet cable to connect the BTS and the laptop. One end is connected to the ETH port on the GTMU of the main cabinet, and the other end is connected to the Ethernet port on the a laptop. Run the SMT software.
Obtaining the Site Management Rights by click the Site Management Right and then click Get.
In the left pane of the SMT System window, select Site. In the right pane of the window, double-click IP over FE Static IP and Confirm the static IP network, and then click OK.
Integration Steps Commands 1 2 3 4 5 6 7 8 9 Enable Static IP Enter BTS IP & Mask Enter BSC IP & Mask Enter VLAN Enter Router 1 IP's Enter Router 2 IP's Enter Router 3 Ip's Qauery & Verify Check Ping
In this dialog box, set the IP addresses of the BTS and BSC and other related parameters step by step like below, the parameters in the red box are the same to all the sites, the parameters in the yellow box are different to different sites. Click Config Para to complete the settings of the IP addresses and VLAN parameters.
Click the Config Router tab. On the Config Router tab page, set the route of the BTS, as shown in the below snapshot. other one goes to IPCLK1,the last one goes to IPCLK2. Add the router to BSC like below:
Every site we need add 3 router(1,2,3), first one goes to BSC DEVIP,
Add the router to IPCLK2 like below: Click Config Para to complete the setting of the route
Click the Query tab. On the Query tab page, click Query to query the static IP addresses Make sure all the parameters are correct according to the IP design.
Click the Board in the left panel ,then click Board Management, then right click GTMU board, choose Board Reset to reset the site.
After the site reset, you should contact the BSC integration team and check whether they can PING to the BTS IP, if the site is UP, you can see the board is OK. If the site is UP, also you should check with the BSC integration Team whether there are any alarms in the BTS and Clear all the alarms.