You are on page 1of 2

Thanks for buying DMS Internationals BSC621-2 C/Ku LB!

You should have the following


parts in addition to the main
body of the BSC621-2 C/Ku
!B"#
1# $he S%alar &ing' used to
mount the BSC621-2 to
your dish# You will noti%e
it has holes that allow you
to use ( support arms or )
support arms depending
on your dish# $here is a
pa%*age of bolts that
mount the dish arms to
the s%alar ring# +t in%ludes
the bolt that mounts the
BSC621-2 to the s%alar
ring#
2# $he di-ele%tri% plate is
used for %ir%ular signals# +t %onverts your linear polarity to %ir%ular#
)# $he Coa, -umper is used to %onne%t the Ku part of the BSC621-2 to the
swit%hing devi%e lo%ated on the side of the BSC621-2#
$his diagram shows how to %onne%t the Ku and
C-band so it %an be delivered down one %oa,#
oo*ing at the diagram' you will see the Ku
%onne%tion is at the end of the BSC621-2# .sing
the Coa, -umper' %onne%t it to the port mar*ed
/!B0 on the side of the BSC621-2# Conne%t the
%oa, that delivers signal to your re%eiver to the
remaining port' mar*ed /&C10#
$he band swit%hing is a%%omplished by 2iS34C
%ontrol sent from your re%eiver# Setting your
re%eiver 2iS34C to 51 or 6 will give you C-band'
and setting your re%eiver 2iS34C to 52 or B will
give you Ku-band#
7roperly installing the !B" on your dish is %riti%al# 6fter atta%hing the s%alar ring
to your support arms' you should %onfirm that it is pointing to the %enter of your
dish# 8ne way to do this is to measure from the edge of your dish to the edge of
the s%alar ring in several pla%es around your dish# $hese measurements should
be the same# +f not' your feed is not pointing to the %enter of your dish and will
not perform as intended#
6fter finding a signal' turn the !B" to find the best polarity performan%e# 2o
this on both polarities# Carefully move the !B" toward the dish and away from
the dish to find the best operating distan%e#
6fter finding the best possible performan%e tighten the set s%rew to hold the !B"
in pla%e#
The BSC621-2 has the ability to re"ei#e "ir"ular $olari%e& signals'
&emove the end %ap from the !B"#
+nsert the di-ele%tri% plate in the throat
guides# &epla%e the end %ap#
29S +nternational : )2; B !orthpoint 7ar*way S3 : 6%worth' <6 );1;2 .S6
$el= >>;-?2@-6A;; : "a,= >>;-?2@-6A(;
email= salesBdmsiusa#%om - http=//www#dmsiusa#%om

You might also like