You are on page 1of 2

********************************************************************************

***************************************
UNIFIED SOFTECH AIRFORT ROAD HUBLI "QUICK START"
Your embedded partner
********************************************************************************
***************************************
PRODUCT NAME : GSM MODEM
HARDWARE : SIM 300 MODULE
COMMUNICATION : RS232
COMMANDS : AT
INPUT VOLTAGE : 12VDC / 1AMP
********************************************************************************
*****************************************
ANTENNA - PULL THE ANTENNA OUT IF THE SIGNAL IS WEAK
HOW TO TEST!!!!
1. INSERT THE SIMCARD INTO SIM TRAY BACKSIDE
2. CONNECT THE RS232 CABLE TO THE PC SERIAL PORT - SERIAL PORT PROPERTIES ( RES
TORE DEFAULTS - 9600 BAUD RATE)
3. OPEN HYPERTERMINAL FROM WINDOWS START>PROGRAMS>ACCESARIES>COMMUNICATIONS>HYPE
RTERMINAL
4. SELECT THE COMPORT WITH BAUD RATE 9600
5. TYPE "AT " ECHO "OK" IF ECHO IS OK COMMUNICATION IS OK !!!!!!!!!+

6. CHECK THE LED STATUS ( NETWORK SERCHING , NETWORK CONNECTED, IS SHOWN IN LED
STATUS GIVEN BELOW)
********************************************************************************
********************************************
Working state of network status indication LED OUTPUT
State SIM300 function
Off SIM300 is not running
64ms On/ 0.8SEC Off SIM300 does not find the network
64ms On/ 3 SEC Off SIM300 find the network
64ms On/ 300ms Off GPRS communication
********************************************************************************
*********************************************
TO CHQ GAIN - AT+CSQ=?
TO CHK NETWORK - AT+COPS=?
//9243288826
Examples for send and receive SMS
For sending SMS in text Mode:
AT+CMGF=1 press enter
AT+CMGS= mobile number press enter
Once The AT commands is given > prompt will be displayed on the screen.
Type the message to sent via SMS. After this, press ctrl+Z to send the SMS.
If the SMS sending is successful, ok will be displayed along with the message numb
er.

For reading SMS in the text mode:


AT+CMGF=1 Press enter
AT+CMGR= no.
Number (no.) is the message index number stored in the sim card. For new SMS, UR
C will be received
on the screen as +CMTI: SM no . Use this number in the AT+CMGR number to read the m
essage.
Voice call
Initiating outgoing call:
ATD+ mobile number; press enter
For disconnecting the active call:
ATH press enter
For receiving incoming call:
ATA press enter

**************************************************USEFUL AT COMMANDS FOR SETTING


S *****************************************************************
TO CHANGE BAUDRATE - AT+IPR=BAUDRATE(Ex 9600) 0-115200 For maore details refer
AT commands Document page 33
TO SAVE THE SETTINGS AT&W
TO RESTORE FACTORY DEFAULTS TYPE AT&F THEN SAVE IT AT&W
********************************************************************************
*******************************************************
********************************************************TESTING*****************
***********************************************

TESTED USING HYPERTERMINAL DAILING THE NUMBER,INCOMING RING,Etc


FOR MORE DETAILS REFER HARDWARE AND COMMAND MANUAL

********************************************************************************
***************************************
For embedded products contact : www.unifiedsoftech.com
********************************************************************************
***************************************

You might also like