You are on page 1of 3

Mitsubishi Diagnostic Trouble Code Retrieval

Magna, Verada, TE-TJ, KE-KJ 1996-2004 Manual or Automatic Transmission V6 3.0 & 3.5

Engine Codes: The Two Digit Engine Fault Codes are displayed as flashes of the Check Engine Lamp. There is an initial pause of 3 Seconds followed by the Code. Long Flashes (1.5 Seconds) represent the Tens. Short Flashes (0.5 Seconds) represent the Units. A 2 Second Pause separates the Tens and Units. If more than one Code is in Memory, they will be displayed in sequence. If No Codes are present, continuous 0.5 Second Flashes will be displayed. Transmission Codes (Auto): The Two Digit Transmission Fault Codes are displayed as flashes of the Neutral "N" Lamp in the Dash. If a Fault develops with the Transmission, the "N" Lamp will flash. Flashes at 2Hz, (2 Flashes/Second) indicate that the Transmission has overheated. Flashes at 1Hz, (1 Flash/Second) indicate that a Fault Code is in Memory.

Fault Code Extraction 1. 2. 3. 4. Switch Ignition ON. Ground Terminal 1 on the Diagnostic Connector. Read Engine Codes as Flashes of the Check Engine Lamp. Read Transmission Codes as Flashes of the Neutral "N" Lamp in the Dash.

Mitsubishi DTCs (Diagnostic Trouble Codes) 11 12 13 14 21 22 23 24 25 36 41 44 52 53 54 61 Oxygen Sensor Air Flow Sensor Intake Air Temperature Sensor Throttle Position Sensor Engine Coolant Temperature Sensor Crank Angle Sensor Top Dead Centre (TDC) Sensor Vehicle Speed Sensor Barometric Air Pressure Sensor Ignition Timing Circuit Fuel Injectors Ignition Circuit Ignition Circuit Ignition Circuit Immobiliser System Automatic Transmission Communication PCM Failure

Page 1 of 3

obd-obdii.com

Fault Code Table (Automatic Transmission) 11 12 14 15 21 22 23 26 31 32 33 34 36 41 42 43 44 46 51 52 54 55 Throttle Position Sensor Sensor Shorted or Disconnected Throttle Position Sensor Sensor Disconnected Throttle Position Sensor Sensor Adjustment Incorrect Transmission Fluid Temperature Sensor Sensor Disconnected Crank Angle Sensor Sensor Disconnected Auto Transmission Pulse Generator `A' (Input Shaft Speed Sensor) Sensor Shorted or Disconnected Auto Transmission Pulse Generator `B' (Output Shaft Speed Sensor) Sensor Shorted or Disconnected Brake Lamp Switch Switch Shorted Auto Transmission Low/Reverse Solenoid Solenoid Shorted or Disconnected Auto Transmission Underdrive Solenoid Solenoid Shorted or Disconnected Auto Transmission Second Solenoid Solenoid Shorted or Disconnected Auto Transmission Overdrive Solenoid Solenoid Shorted or Disconnected Auto Transmission Damper Clutch Control Solenoid Solenoid Shorted or Disconnected First Shift Shift not perfect Second Shift Shift not perfect Third Shift Shift not perfect Fourth Shift Shift not perfect Reverse Shift Shift not perfect Engine ECM Communication Error Damper Clutch Control Solenoid Malfunction Auto Trans Control Relay Ground Shorted or Disconnected Auto Trans Control Relay Contact Points melted or sticking

Page 2 of 3

obd-obdii.com

56 71

N Range Lamp System Shorted to Ground Auto Trans ECM Malfunction

To Erase Codes: Turn the ignition switch OFF. Disconnect the negative battery cable from the battery terminal for 20 seconds or more and then reconnect it.

Page 3 of 3

obd-obdii.com

You might also like