Websphere Commerce Developer Enterprise v6 Installation is done! Make sure you don't have a wasprofile directory under WCDE_installdir. This will open an "MSDos Prompt" window and start the workspace creation in background.
Websphere Commerce Developer Enterprise v6 Installation is done! Make sure you don't have a wasprofile directory under WCDE_installdir. This will open an "MSDos Prompt" window and start the workspace creation in background.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as DOC, PDF, TXT or read online from Scribd
Websphere Commerce Developer Enterprise v6 Installation is done! Make sure you don't have a wasprofile directory under WCDE_installdir. This will open an "MSDos Prompt" window and start the workspace creation in background.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as DOC, PDF, TXT or read online from Scribd
Step: 3 Accept the license agreement.Click on Next.
Step: 4 Give the directory path. Click on Next. Step: 5 Select the environment as shown in the below screen shot. Uncheck IBM Sales Center. Step: 6 Click on Next. Step:7 Click on Next. Step: 8 WCD Installation starts here. It will take few minutes. Step: 9 Configuration happens automatically. It will take some time.
Step: 10 Click on Finish.
WCD Installation is done! 2. Configuring WebSphere Commerce Developer v6 to co-exist with Rational Software Architect v6 Make sure you don't have a wasprofile directory under WCDE_installdir. If you do, delete it.
where , WCDE_installdir E:\IBM\WCToolkitEE60
Edit the “setenv.bat” file (in WCDE_installdir\bin)
Locate the RAD_HOME variable and set it to the RSA install directory. In our case, it should be "E:\IBM\Rational\SDP\6.0". Save the file and exit Run “setup.bat” manually from WCDE_installdir. This will open an “MSDos Prompt” window and start the workspace creation in background. This will take approximately 15-20 minutes to complete. When it finishes, the “MSDos Prompt” window will get closed. Check the contents of the WCDE_installdis\logs\setup.log and verify that it was successful. Start WCD and test.