Professional Documents
Culture Documents
Low Pressure Sodium Light High Pressure Sodium Light Mercury Light Halogen Light
BLDG. UTILITIES
BLDG. UTILITIES
The minimum Height of Refrigerant Pipe along a building passageway a. b. c. d. 2.44m 2.30m 2.50m 2.66m
BLDG. UTILITIES
What is the most effective material against Echo? a. b. c. d. Cavity Wall Heavy Curtain Foam Insulation Cavity Resonator
BLDG. UTILITIES
The transmission of sound along a curved surface a. b. c. d. Echo Creep Bounce Noise
BLDG. UTILITIES
What is Decibels? The decibel (dB) is a logarithmic unit that indicates the ratio of a physical quantity (usually power or intensity) relative to a specified or implied reference level. A ratio in decibels is ten times the logarithm to base 10 of the ratio of two power quantities. A decibel is one tenth of a bel, a seldom-used unit.
BLDG. UTILITIES
20,000 hertz is called
BLDG. UTILITIES
The Power of Sound is __________. a. b. c. d. Volume Pitch Frequency Echo
BLDG. UTILITIES
It is the Magnitude of Sound a. b. c. d. Intensity Amplitude Loudness Frequency
BLDG. UTILITIES
Smoke prevention is _________. a. b. c. d. More important than Fire Prevention Less important than Fire Prevention As important as Fire Prevention It doesnt matter
BLDG. UTILITIES
What is Luminous Flux? It is often used as an objective measure of the useful power emitted by a light source, and is typically reported on the packaging for light bulbs, although it is not always prominent. Energy conscious consumers commonly compare the luminous flux of different light bulbs since it provides an estimate of the apparent amount of light the bulb will produce, and is useful when comparing the luminous efficacy of incandescent and compact fluorescent
BLDG. UTILITIES
bulbs. The SI unit of luminous flux is the lumen (lm). One lumen is defined as the luminous flux of light produced by a light source that emits one candela of luminous intensity over a solid angle of one steradian. In other systems of units, luminous flux may have units of power.
BLDG. UTILITIES
Type of lighting used for Billboards a. b. c. d. Metal Halide Low pressure Sodium Lamp Spotlight Mercury
BLDG. UTILITIES
What is the main reason why Cable wires and Grounding wires are shielded? a. b. c. d. Cause magnet Protect against water Damage due to heating It doesnt matter
BLDG. UTILITIES
Why are telephone wires and electrical wires NOT placed together? a. b. c. d. Heat Accumulation Telephone wire will burn Data Interference Signal will be interrupted
BLDG. UTILITIES
A machine used to convert mechanical energy to electrical energy. a. Rectifier b. Generator c. Alternator
If you are to relocate a large office space using numerous cables, aside from the size of the new location, what should you know?
BLDG. UTILITIES
BLDG. UTILITIES
Which is the most rigid? a. b. c. d. EMT RSC IMT UPD
What material used as a conduit is threaded and how much thinner than RSC? a. b. c. d. EMT IMT RSC USP
BLDG. UTILITIES
BLDG. UTILITIES
What is used for service entrance? a. b. c. d. RSC EMT IMT UPB
What property is used to distinguish between Potable and Sanitary uPVC Pipes? a. b. c. d. Color Thickness Diameter Length
BLDG. UTILITIES
BLDG. UTILITIES
What is the Standard water consumption (gallon/person/day) used in a 2-storey residence? a. b. c. d. 30-40 40-60 100-120 120-140
BLDG. UTILITIES
What is used to shut off flow of water during maintenance? a. b. c. d. Angle Valve Gate Valve Check Valve Globe Valve
BLDG. UTILITIES
What is the BEST location for a Pump? a. b. c. d. Service Pipe Cistern Storage Tank Roof Top
Where is Cleanout? a. b. c. d.
BLDG. UTILITIES
the BEST location for a
Inside the T&B At the Exterior Wall of T&B Below the Walls Beside the Walls
BLDG. UTILITIES
What is used, up to 12 degrees, to transport pedestrian/carts? a. b. c. d. Walkalator Escalator Travelator Elevator
BLDG. UTILITIES
The maximum length of a walkalator is 250 meters. What is the reason why it should be used for short runs only? a. b. c. d. To allow users to exit at the sides For maintenance and control To allow reversal of directions All of the above
BLDG. UTILITIES
What Interior Element controls Echo? a. b. c. d. Concrete Wall Heavy Drapery Ceiling Door
BLDG. UTILITIES
A protective device used in the Kitchen a. b. c. d. Heat Detector Smoke Detector Alarm CCTV
BLDG. UTILITIES
Which one is the LEAST effective in preventing materials from transmitting to other side of the room? a. Figure A b. Figure B c. Figure C d. Figure D
BLDG. UTILITIES
What is the BEST sound insulation to be used for a house fronting a busy highway? a. Figure A b. Figure B c. Figure C d. Figure D
BLDG. UTILITIES
BLDG. UTILITIES
BLDG. UTILITIES
On what kind of project is the Daylight Lamp BEST suited? a. b. c. d. Textile Manufacturing Bakery Restaurant Mall
BLDG. UTILITIES
What is NOT part of a Lighting Arrester? a. b. c. d. Down Conductor Earthen Material Transmitter Lighting Rod
BLDG. UTILITIES
The owner hired an electrician to prepare and install the electrical wiring for his house. The electrician, with the Owners consent, decided to use a larger size of wiring for the circuit breaker to anticipate overloading. After some time, the house was on fire. After the investigation, it was proven that the cause of the fire was faulty wiring. Why did the Circuit Breaker fail to detect the short circuit/overloading?
BLDG. UTILITIES
What should have been done by the Electrician to prevent the fire? a. Use the appropriate wiring capacity b. None, his plans and actions were appropriate c. Studied more to become a Master Electrician and do better Electrical Plans d. None of the Above
BLDG. UTILITIES
Why is it necessary to plan the Data Connection Tables? a. b. c. d. Data Cables are expensive To avoid Visual chaos To optimize Data Transfer Speed None of these
BLDG. UTILITIES
NOT be buried
B.I. Pipe Polyethylene Pipe To optimize Data Transfer Speed None of these
BLDG. UTILITIES
Which type of piping material is NOT suitable for underground installation? a. b. c. d. uPVC Wrought Iron Stainless Steel Galvanized Iron
BLDG. UTILITIES
Which is NOT a rule of thumb in designing a drainage? a. As much as possible, pipes must run in a straight line b. Underground drainage line should be on top of compacted soil c. It should be underneath the driveway d. None of these
BLDG. UTILITIES
Which plumbing fixture does NOT have a water-saving feature? a. b. c. d. Lavatory with pop-up 1.5-gallon Flush Water Closet Flow Limiting Valve Waterless Urinal
BLDG. UTILITIES
Given a set of drawing details, indicate which is the: a. b. c. d. Cleanout Grease Trap Floor Drain Gate Valve
BLDG. UTILITIES
For a 3-storey building that is intended for a Senior Citizen Center with a limited budget and space, what is the appropriate type of elevator?
a. b. c. d.
BLDG. UTILITIES
For a 1-hp ACU, what should be the size of the wire/cable? a. b. c. d. Hydraulic Elevator Traction Elevator Stretcher Accessible None (not required)
BLDG. UTILITIES
Which among the considerations will best increase the efficiency in air-conditioning? a. b. c. d. Decrease Floor Area Decrease Ceiling Height Increase mounting height of ACU Decrease slope of roof
BLDG. UTILITIES
Which among the considerations will best increase the efficiency in air-conditioning? a. b. c. d. Decrease Floor Area Decrease Ceiling Height Increase mounting height of ACU Decrease slope of roof
BLDG. UTILITIES
If you are to install a Centralized Aircondition System for your building, what additional utility will you provide? a. b. c. d. Cooling Tower AHU Pipe Chase Ducts
BLDG. UTILITIES
What will be used to distribute the air from the Air Handing Unit? a. b. c. d. Cooling Tower Chiller Pipe Chase Ducts