Professional Documents
Culture Documents
COPYRIGHT
© Standards Australia/Standards New Zealand
All rights are reserved. No part of this work may be reproduced or copied in any form or by any
means, electronic or mechanical, including photocopying, without the written permission of the
publisher.
Jointly published by Standards Australia International Ltd, GPO Box 5420, Sydney, NSW 2001
and Standards New Zealand, Private Bag 2439, Wellington 6020
ISBN 0 7337 1668 7
AS/NZS 3128:1998 2
PREFACE
This Standard was prepared by the Joint Standard Australia/Standards New Zealand
Committee EL-041, Lamps and related equipment, to supersede AS/NZS 3128:1993.
This Standard incorporates Amendment No. 1 (November 1998) and Amendment No. 2
(July 2002). The changes arising from the Amendment are indicated in the text by a
marginal bar and amendment number against the clause, note, table, figure, or part thereof
affected.
This Standard is one of a series of Approval and test specifications issued by Standards
Australia and Standards New Zealand. These Standards are to be read in conjunction with
AS/NZS 3100, Approval and test specification— General requirements for electrical
equipment. The purpose of these Standards is to outline the conditions that must be met to
secure approval for the sale and use of electrical equipment. Only safety matters and related
This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.
CONTENTS
Page
1 SCOPE ........................................................................................................................ 4
2 APPLICATION........................................................................................................... 4
3 REFERENCED DOCUMENTS .................................................................................. 4
4 DEFINITIONS ............................................................................................................ 5
5 DESIGN AND CONSTRUCTION.............................................................................. 5
6 MEANS OF CONNECTION ...................................................................................... 6
7 FLEXIBLE CORD AND CONNECTING PLUG ....................................................... 6
8 EARTHING FACILITIES........................................................................................... 6
This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.
1 SCOPE
This Standard applies to electric portable lamp standards and brackets designed for direct or
alternating current at low or extra-low supply voltages.
This is a free 6 page sample. Access the full version at http://infostore.saiglobal.com.
A2
Portable child appealing luminaires are excluded from the scope of this Standard.
NOTE: Portable child appealing luminaires are covered in AS/NZS 60598.2.10.
This Standard does not apply to any electric handlamp within the scope of AS/NZS 3118.
For the purpose of this Standard a portable lamp standard or bracket is called a lighting
fitting.
2 APPLICATION
2.1 General requirements of AS/NZS3100
This Standard shall be read in conjunction with AS/NZS 3100,and the appropriate
provisions of AS/NZS 3100 shall apply to the construction of the lighting fitting and the
insulation and safeguarding of parts that normally carry current.
2.2 Specific requirements of this Standard
A lighting fitting shall be deemed to comply with this Standard only if it complies with all
the requirements of this Standard and passes the test specified herein.
2.3 Requirements of other Standards
Equipment and components incorporated in a lighting fitting, which are depended upon for
safety, shall comply with the appropriate requirements of any relevant Approval and test
specification, unless such requirements are varied herein.
3 REFERENCED DOCUMENTS
The following documents are referred to in this Standard:
APPROVAL AND TEST SPECIFICATIONS
AS
3117 (NZS/AS 3117) Bayonet lampholders
3134 a.c. supplied electronic ballasts for tubular fluorescent lamps
3140 (NZS/AS 3140) Edison-type screw lampholders
3168 Fluorescent lamp ballasts
3191 (NZS/AS 3191) Electric flexible cords
AS/NZS
3100 General requirements for electrical equipment
3108 Particular requirements for isolating transformers and safety isolating
transformers
COPYRIGHT
This is a free preview. Purchase the entire publication at the link below: