You are on page 1of 2

UE Timer and Constant:

The following settings can only be changed when call status is Idle .

T300 RRC Conn Req Retransmit Timer

This setting determines how long the UE waits for the RRC Connection Setup after sending an RRC Connection Setup Request. T300 can be set to one of the following values: 400, 600, 800, 1000, 1200, 1400, 1600, 1800, 2000, 3000, 4000, 6000, 8000 ms.

N300 RRC Conn Req Max Retransmits

This setting specifies the maximum number of retransmissions of the RRC Connection Request message. N300 can be set to any integer value from 0 to 7.

T312 Link Establishment Timer (Idle)

This setting determines how long the UE waits for an N312 "in-sync" indication from layer 1 when establishing a dedicated channel and the connection status is Idle. T312 can be set to any integer value from 1 to 15.

T312 Link Establishment Timer (Connected)

This setting determines how long the UE waits for an N312 "in-sync" indication from layer 1 when establishing a dedicated channel in connected status. The value 0 is not used.

N312 Link Establishment In-Sync Count (Idle)

This setting specifies the number of " in-syncs" required when establishing a dedicated channel when the connection status is Idle. N312 can be set to one of the following values: 1, 2, 4, 10, 20, 50, 100, 200, 400, 600, 800, 1000.

N312 Link Establishment In-Sync Count (Conn.)

This setting specifies the number of " in-syncs" required when establishing a dedicated channel in connected status. N312 can be set to one of the following values: 1, 2, 4, 10, 20, 50, 100, 200, 400, 600, 800, 1000.

T313 Out-of-Sync Reception Timer

3GPP TS 25.331 8.5.6 states that after receiving N313 consecutive "out of sync" indications from layer, the UE shall start the T313 timer. Upon receiving N315 successive "in sync" indications from layer 1, the UE shall stop and reset the T313 timer. If T313 expires, a "Radio Link failure" has occurred, and the UE shall drop the call.

N313 Successive Out-Of-Sync Reception Max

N313 specifies the maximum number of successive "out of sync" received from L1. N313 can be set to one of the following integer values: 1, 2, 4, 10, 20, 50, 100, 200.

N315 Successive In-Sync Reception Counter

N315 specifies the maximum number of successive "in sync" received from L1 during T313 is activated. N315 can be set to one of the following integer values: 1, 2, 4, 10, 20, 50, 100, 200, 400, 600, 800, 1000.

T308 RRC Conn Release Comp Retransmit Timer

T308 specifies the time between the transmissions of RRC Connection Release Complete message.

N308 RRC Conn Release Comp Max Retransmits

N308 specifies the maximum number of retransmissions of the RRC CONNECTION RELEASE COMPLETE message.

T3212 Periodic Location Update Timer

T3212 specifies how often the UE will perform the periodic location update procedure. It is signaled in SIB1. When T3212 is set to zero, the UE will regard the timer to be infinite.

You might also like