You are on page 1of 3

MATERIAL SAFETY DATA SHEET

1. PRODUCT AND SUPPLIER IDENTIFICATION Product Name: Supplier

CleanSafe 787C
Petroferm Inc. 3938 Porett Drive Gurnee, IL 60031 (847) 244-3410 www.petroferm.com CHEMTREC EMERGENCY RESPONSE US: (800) 424-9300 INTERNATIONAL: (703) 527-3887

Date Prepared: 04/16/2009 Replaces: 03/13/2007

Emergency Contact

CHEMTREC should only be contacted in the event of transportation related chemical emergencies involving a spill, leak, fire, exposure, or accident.

2. HAZARDS IDENTIFICATION Hazards Overview WARNING: Irritating to eyes and skin.

Potential Health Hazards Skin: Eyes: Ingestion: Irritating to skin. Prolonged contact may cause dermatitis. Irritating to eyes. May cause redness, swelling, and burns. May cause abdominal discomfort, nausea, and vomiting.

Inhalation: Low volatility makes vapor inhalation unlikely. Aerosol or mist may be irritating to the respiratory tract. Listed Carcinogens: This product contains no known or suspected human carcinogens by OSHA/IARC/ACGIH. 3. COMPOSITION AND INFORMATION ON INGREDIENTS Component Sodium silicate Potassium carbonate Anionic surfactant 4. FIRST AID MEASURES Skin: Remove contaminated clothing. Thoroughly rinse affected area with water. Seek medical attention if irritation persists. Thoroughly flush eyes with water for 15 20 minutes. Immediate medical attention is required. CAS Number 1344-09-8 584-08-7 proprietary Weight % < 5% < 5% 10 20%

Eyes:

Inhalation: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Seek medical attention if symptoms of overexposure develop. Ingestion: DO NOT induce vomiting. Give one or two glasses of water to conscious victim. Seek medical attention. Page 1 of 3

CleansSafe is a trademark of Petroferm Inc.

CleanSafe 787C
5. FIRE FIGHTING MEASURES Extinguishing Media: Special Fire Fighting Procedures:

04/16/2009

Dry chemical, chemical foam, carbon dioxide. Class BC, ABC fire extinguisher. Self-contained positive pressure breathing apparatus and protective clothing should be worn in fighting fires involving chemicals.

Unusual Fire Hazards: Exercise care when disposing of rags contaminated with this product. Use normal precautions appropriate for oily rags. 6. ACCIDENTAL RELEASE MEASURES Do not allow product to enter drains or waterways. Remove all ignition sources from affected area. Absorb small spills with inert material, then place in chemical waste container. For large spills, dike affected area to prevent spreading. Observe government regulations. 7. HANDLING AND STORAGE Store in original container with compatible materials, preferably in a cool, ventilated, fire-resistant building. Avoid overheating or freezing. Avoid open flames and sparks. 8. EXPOSURE CONTROLS - PERSONAL PROTECTION Exposure Guidelines OSHA PEL ACGIH TLV Engineering Controls/PPE Respiratory: Ventilation:

Not Established for the constituents of this product Not Established for the constituents of this product Use NIOSH/MSHA approved respirator if ventilation is not sufficient and if mists are generated. Use with adequate local or general ventilation. Wear a NIOSH approved full face respirator with the proper cartridge if vapors cannot be controlled with ventilation. Chemically resistant gloves and safety glasses must be worn while handling this material. An apron and splash shield should be worn if transfer or use of the material presents a splash hazard. A safety shower should be provided in the work area. Safety glasses/goggles must be worn while handling this product. A splash shield should be worn if transfer or use of this product presents a splash hazard. Provide an eye bath in the work area.

Clothing/Glove:

Eye Protection:

9. PHYSICAL AND CHEMICAL DATA 12 pH >210F (99C) Boiling Point(760 mm Hg): Not determined VOC Content: Specific Gravity (H2O =1): 1.08 at 77F (25C) Not determined Vapor Pressure(20C): None to boiling (ASTM 93-85) Flash Point: Not determined Vapor Density (Air = 1): Evaporation Rate (BUAC = 1): Not determined Completely soluble Solubility in Water: Clear liquid Appearance : Mild Odor: Page 2 of 3

CleanSafe 787C
10. STABILITY AND REACTIVITY Stability: Conditions to Avoid: Incompatibility: Hazardous Decomposition Products: Hazardous Polymerization:

04/16/2009

This product is stable under recommended storage conditions. Direct sunlight, sparks, and open flames. Strong mineral acids and strong oxidizing agents. None, other than normal products of combustion. Will not occur.

11. TOXICOLOGICAL INFORMATION No data available for this mixture. 12. ECOLOGICAL INFORMATION No data available for this mixture. 13. DISPOSAL CONSIDERATIONS Do not dispose into drains, sewers, or surface water. Dispose of used material in compliance with all applicable government regulations. 14. TRANSPORT INFORMATION US DOT/IATA/IMO Not Regulated for Shipping. 15. REGULATORY INFORMATION USA TSCA: All components listed or exempt. USA SARA 313: No listed components USA EPCRA 311/312: Acute health hazard

16. OTHER INFORMATION NFPA Codes: Health: 2 Fire: 1 Reactivity: 0

This information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any other process. Such information is to the best of the company's knowledge and believed accurate and reliable as of the date indicated. However, no representation, warranty or guarantee of any kind, express or implied, is made as to its accuracy, reliability or completeness and we assume no responsibility for any loss, damage or expense, direct or consequential, arising out of use. It is the user's responsibility to satisfy himself as to the suitableness and completeness of such information for his own particular use.

Page 3 of 3

You might also like