You are on page 1of 408

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24 Generator Room (East) PE 24

Defect Remove fixing on wall Install door threshold plates to three (3) external double doors Make good to external wall (internal face) where fuel pipes pass through (2 No.) Insert pipe sleeves where fuel pipes pass through external wall (2 No.) Apply anti-corrosive paint to manifold exhaust brackets (4 No.) suspended from ceiling Take out eight (8) bolt assemblies in soffit of ceiling slab and make good Power wire with unfixed end to be connected or removed (East Side) Seal holes around cable trays at high level to Mains Power Room (2 No) Make good at wall and floor junction around the room and repair as required Make good around grille (West side) high level where cables etc pass through wall and seal Make good to underside of down stand beam near doors and repaint Insert pipe sleeves to 2 No manifold exhaust pipes where they pass through the external wall Resolve location of UPS system near external doors and protect from adverse weather No fire extinguishers Fix Door stop to internal door Fix Door Stop to all external doors No 1 Fix Door Stop to all external doors No 2 Fix Door Stop to all external doors No 3 Fire Fighting Equipment is missing Door signage

Rating Classif. C B C B C C A A C B C B A A B B B B A B

Date Rectified

Date Checked

Comments

Water and Snow can penetrate

W4A to advise

4/10/2013

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14 Main Switch Room (East) PW 14

Defect Rubber mats 6mm (tested to 11,000 volt) in front of main switch cabinets (1 m wide) Tidy up cables on wall near door Remove empty cable spool Seal holes around cable trays at high level to Generator Power Room (2 No) Install door threshold plates to external double doors Remove loose wire Digital Power Factor Control Box is not lockable (2 doors) Digital Power Factor Control Box seal and make good to power entry slot in base of unit (2 No) Digital Power Factor Control Box (left) remove loose item in base Make good at wall and floor junction around the room and repair as required Remove cable connection to rear of Main Switch Cabinets supply power to Containers No fire extinguishers Fix door stop to Internal Door Fix door stop to External Doors Door signage

Rating Classif. A C C A B C C B A C A A B B B

Date Rectified

Date Checked

Comments

Water and snow can penetrate

Cable is NOT SWRA W4A to advise

4/10/2013

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Location Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16 Security Room East PE16

Defect Fitment approval and its poor ergonomical design and is also VERY unstable Make good floor covering that is short at door to Docking Bay Remove wires coming out of ceiling or reroute and tidy up Remove unconnected cables in ceiling or connect as required Complete suspended ceiling Floor seal joint (left of fitment) to be repaired Bolt fixings piercing intumescent strip of door to Docking Bay to be reviewed and resolved Hole in intumescent strip head frame of door to Docking Bay to be repaired Remove protection film still remaining on door External Window to be screened Cover Plate required to two (2) boxes in the UPS Unit near the entry door Ivorine Labels required to all boxes in Security Room in Romanian (& English if possible) Make good skirting to RH of entry door Make good to uncompleted box conduit cover to LH of door above box unit Remove general rubbish behind the fitment unit Tidy up ALL wires behind the fitment unit Paint pipe to radiator Make good paint finish to radiator where damaged Replace damaged ceiling tile (1 No) Replace stained ceiling tiles (water damaged) 3 No Make good poor cutting of ceiling tiles around heating pipes Redo pipe holdfasts on wall (2 No) Repair pipework that is distorted for radiator Clean window of labels and written identification numbers etc. Reset light fitting (left) LH switch plate upper (LH of entry door) is loose and is to be refixed Repair wall between upper and lower LH switch plates to the LH of entry door Incombustible Fire Plan No fire extinguishers Fix Door stop to door Door Signage Refix skirting fixed with panel pins and refix with adhesive or clip-on system complete Provide fire seal threshold strip to door Remove paint from window frames and make good

Rating Classif. A B B A B C A A C B A B B B B B B B B B B B B B B B B A A B B B A B

Date Rectified

Date Checked

Comments W4A to review and advise

W4A to advise

4/10/2013

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Location Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17 Security Room Toilet (East)PE17

Defect Complete suspended ceiling Clean up WHB Clean up WC Clean floor tiles Tidy up pipe holdfasts to radiator Review protruding screw fixing within door frame rebates Make good poor cutting of ceiling tiles around heating pipes Pipes to radiator cross over and need to be redone so that they are tidy Make good hole in wall below water heater Insert sleeves to water heater pipes going through wall Make good to wall around pipes to water heater in wall Paint pipe to radiator Repair walls where damaged and repaint Clean mirror of identification marks Remove sellotape on mirror Touch up door paintwork where chipped and damaged Regrout to wall tiles to RH of door Make good to uneven grouting to wall tiles and remove laitance and excess grout deposits Mage good to ceiling edge trim (West Wall) Replace 1 damaged ceiling tile Identification Schedule for CCTV Cameras Door Signage Refix skirting fixed with panel pins and refix with adhesive or clip-on system complete

Rating Classif. B B B B B C B B B B B B B C B C B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Location Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15

Defect Handrails required to stair steps Skirting to wall at stair steps has been done but badly Repaint black and yellow strip to rear of docking bay Make good PVC skirting at two (2) corners PVC Skirting to rear of docking bay undulates and needs to be reset Make good and seal wall on East Wall near grille to Generator Room Roller Shutter door does not function Install door threshold plates to external door Make good to two (2) holes in wall Remove loose wire on north wall Reset light fitting at rear of Docking Bay LH side looking south Make good wall (West) at high level and finish off and paint Complete wall finish including paint and detail to roller shutter door on west wall Remove loose black PVC above roller shutter doors Remove large concrete snot on area in front of Security Room Repair pavement/trottoir to Security Room threshold Make good to edge of pavement in front of Security and Garbage Room Make good to wall base at junction with floor (west) Make good to wall base at junction with floor (east) Remove assembly instruction door label on Security Room door Repair/replace chipped stair treads (terrazzo) to East side Install missing cover plate to junction box at high level in rear of Docking Bay Remove or connect two unconnected wires at high level in the rear of the Docking Bay Make good poor insulation to HVAC pipe at the rear of the Docking Bay (Right looking South) Fill in missing blockwork on South Wall at the rear of the docking bay at high level Make good wall finish and paint at high level at the rear of the Docking Bay Replace damaged light fitting in rear of Docking Bay (LH looking South) Running Man Sign to RH of Roller Shutter Door is not properly fixed Complete grille etc above side door to Roller Shutter Approval Certificate for Roller Shutter Door (Authorities and W4A) Fix door stop to external door Hand over keys for Docking Bay Roller Shutter doors Hydro-Insulation to floor is required as there is also the presence of a floor drain gulley Provide ISCIR/Fire Authority approval for Roller Shutter Doors

Rating Classif. A B B B C B B B B C B B B C B B B B B C B A A B B B B A B B B B A B

Date Rectified

Date Checked

Comments

W4A to advise W4A to advise

4/10/2013

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61

Location Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15 Docking Bay Area (East)PE15

Defect Skirting to Docking Bay on East Wall is poor and badly done Skirting to Docking Bay on West Wall is poor and badly done Replace five (5) chipped steps to stair Paint docking bay floor at ground level Make good floor around floor gulley Remove obsolete conduit to LH side of Roller shutter door including fixings and make good to wall Fire Fighting equipment is not available Refix skirting fixed with panel pins and refix with adhesive or clip-on system complete (South Wall) Refix black/yellow edge angle to docking bay which is not level or matched to the floor Make good edge of concrete landing at head of steps which is very rough Side door does not close properly Intruder Alarm Contacts do not align properly Door controls to Roller Shutter door do not seem to work Make good to hole in upper part of Open frame to side door Make good to four (4) holes in Hinge frame to side door Install door stop to Side Door Remove paint splashes etc on door surfaces and make good Remove key set and fix blanking piece Make good to hole in wall plasterboard below Running Man Sign and repaint Why are there two (2) CCTV cameras operating in the Docking Bay Area ? Provide housing for Pneumatic Safety Edge control and coiled wire cable LH end of floor rubber edging to Roller Shutter Door is damaged and requires to be renewed Rubber seal to bottom edge of Roller Shutter Door is damaged and to be replaced Check pressure regulator at LH Bottom end of roller shutter door that appears to have burnt out Docking Bay Door Fire Officer Approval is required Install angle at step area in Docking Bay marked with diagonal black and yellow stripes near Security Room and Garbage Room Replace small gulley with proper gulley as in Docking Bay West

Rating Classif. B B B B B B A B B B B B A B B B B A B B A B B A A A A

Date Rectified

Date Checked

Comments

W4A to advise

W4A to advise

4/10/2013

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10

Defect Water leak in northwest corner to be remedied Car Park Exhaust Duct system to be relocated or enclosed in a fireproof enclosure Remove four (4) loose metal plates on west wall Remove two (2) temporary cables suspended at ceiling level Remove or connect electric wires not connected Repaint floor (north wall) where drain inserted Make good hole in wall near ABB Cabinet Fill in open plates spaces within ABB control box on Northeast wall Clean surface of ABB Control box on northeast wall of paint and green stains Refix conduit on northeast wall Remove reinforcement rod on northeast wall Remove obsolete angle bracket on northeast wall Remove cable to watchman's hut that is improperly wired into a plug outlet with another cable Repaint metal platform to Water purifier Tidy up (South) general rubbish behind pipework etc. Remove identification marks on glazing and profiles to blast wall Remove identification marks on entry door Make good to door finish at edges Make good to aperture in entry door head frame Make good to damaged arris at LH return to entry door reveal Install the remainder of MEP Labels Make good to the 'hotchpotch' assembly at the floor gulley Fuel pipe to LH Boiler (looking north) needs to be properly fixed in position and protected Make good to boiler bases upstands Make good to hole in floor southeast corner Make good to hole in wall in southeast corner near ceiling Pipe flange ES TAVC PO8 is under stress and requires to be reset or replace Pipe label E-AC-TO3 is temporary and to be replaced Repair Pipe label EST AC PO6 Install pipe label to EST AC PO7 Remove loose wire (south wall) Clean out cable tray south wall of MEP fixtures, timber and general debris Seal wall hole (West-South) where pipes pass through

Rating Classif. B A C A A C B B C B C C A C B C C C C C B B A C C C A B B B C C B

Date Rectified

Date Checked

Comments

Cable should be SWRA

4/10/2013

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10 Boiler Room (East) S1 E10

Defect Fill in opening for tap unit in sink unit with blanking piece Tidy up under skirts at rear of both boilers Remove film covering to both boiler control panels (upper) Remove protective covering to profiles of blast wall Repair sealant cover to head frame of blast wall Seal opening to LH Upper of Blast wall where a duct and cable tray pass through Provide Methane Gas detector Provide electrical power emergency isolation switch Plant and Equipment Diagram No fire fighting equipment Fix Door stops to Boiler Room Double Doors Fix Door stops to Boiler Room Blast Double Doors No 1 Fix Door stops to Boiler Room Blast Double Doors No 2 Fire Fighting Equipment is missing including sand box etc. Door Signage Fire seal threshold required to Boiler entry door Fire Alarm required

Rating Classif. C B C C B A A A A A B B B A B A A

Date Rectified

Date Checked

Comments

W4A to advise

W4A to advise

4/10/2013

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL

Defect Repaint kerb on BRD wall with black and yellow markings Repaint Kerb on LH of East access road with black and yellow markings Provide Gas Pipe enclosure and remove fibreglass insulation Change five (5) plastic labels on fire hydrant entry points on division wall to incombustible Repaint edge (top) of divider wall between access road and ramp (East) with black and yellow markings Finish top of divider wall between access road and East ramp Reset checker plate access cover on Access Road near BRD and at front Repair top edge (BRD side) of divider wall to East Ramp where fibre mat and metal edging is exposed Remove four (4) broken kerb and timber plank in access road near East Ramp Car Park Barrier Rest post is not stable and to be fixed properly Car Park Barrier Arm Box is not stable and requires to be fixed properly Repair top edge (AH side) of divider wall to East Ramp where fibre mat and metal edging is exposed Make good paint finish to East ramp wall at the base on the west side where repaired Make good and seal around gas pipe entry Reset Vehicle Height sign to 2.13m for complete length as LH side is only 2.08 metres Road gulley drain at base of East Ramp is short by 280mm and requires to be completed Make good defective concrete on both sides of the East Ramp road gully at the base of the ramp Make good to East Ramp Wall on west side above the gas supply pipe which is unfinished Remove reinforcement bar protruding from ceiling in the East Ramp entrance and make good Clean ramp surface finish Reset cover plate at top of East ramp that is distorted and a potential hazard to vehicles Replace eight (8) missing pavior tiles at East Elevation Reset pavior tiles on west side of Retail Entrance (East) Remove cable near East Boiler flues LH side Clean East boiler flues of concrete etc at base Re-execute pavior tiles around East Boiler flues Re-level paviors near East Boiler flues that are uneven Make good joint between building and paviors on East Elevation Install tiles skirtings to ALL external columns Make good joint between building and paviors on South Elevation Make good joint between building and paviors on West Elevation Re-level paviors just left of East Entrance that are uneven Re-level paviors to west of West Entrance that are uneven

Rating Classif. B B A A B B B B B B B B B B A B B B B C B B B A B B B B B B B B B

Date Rectified

Date Checked

Comments

W4A design awaited

W4A to advise on this

Plasty Prod operation

4/10/2013

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL

Defect Re-level paviors to third column from the West Entrance near BCR Bank that are uneven Make good defective recessed skirting to glass walled column near BCR Bank (West) Replace thirty (30) cracked paviors Provide Gas Pipe enclosure West Tidy up edge of paviors near Dr Felix Str and edging reveals Complete grassed areas to South Elevation Complete grassed areas to West Elevation Make good tiling on top and down stands to railing to English Courtyard on all three sides Touch up paintwork to metal railing to English Courtyard which is stained with cement slurry and unfinished Complete remaining landscaping in West Elevation Kerbing to West grassed area is really edging and not sufficient and damaged - to be redone Access toby box to fuel tank to be installed Make good to road kerbs at West Road access near north boundary at the return Fuel Tank (West) vent pipe seems undersized and the open end is not protected from debris etc. Seal joint between PVC pipe sleeve and fuel POL line (West) Make good to two cover plates in the West Access Road near the boiler flues Bollard Protection to West Boiler Flues is incomplete Corner of Building (northwest) is not protected from impact collision damage Clean up road generally Clean out road gully on West Access Road Bollard Protection to West Generator Exhausts is incomplete Bollard Protection to East Generator Exhausts is incomplete Bollards are fitted with reinforcement rods and slotted into holes drilled in concrete which is not acceptable Complete landscaped areas on north boundary Small Bollards appear loose, two are missing and two bollards are lying on the ground - bollards to be fixed Remove containers to northeast corner Finish parking areas to northeast corner including car park bays marking lines and numbers Make good to concrete road surfacing which undulates in the northeast area Make good to concrete road surfacing where do paw marks are visible (East Rear) Make good to concrete road surfacing where excavation repair has been made and also near the paviors Complete the grille work to the gas trench (East) which has a large gap at the upper end Tidy up paintwork to road grille (Gas Trench) East Rear Fuel Tank cover (East) upper frame is loose

Rating Classif. B B B A B B B B B B B B B B B B B B B B B B B B B B B B B B A B

Date Rectified

Date Checked

Comments

W4A design is awaited

W4A to advise on kerbing required

East Rear

4/10/2013

10

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 67 68 69 70 71 72 73 74 75 76 77 78 79

Location EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL EXTERNAL

Defect Fuel Tank cover (East) to be painted with high quality corundum paint Make good to lower cover inside Fuel Tank Box (East) which is badly distorted, rusty and damaged Remove rubbish and water that has collected inside the lower cover of the fuel tank covering equipment Label required for Fuel Pipe fill line on West Label required for Fuel Pipe fill line on East Fuel Tank (East) vent pipe seems undersized and the open end is not protected from debris etc. Seal joint between PVC pipe sleeve and fuel POL line (East) Directional arrows on access roads Car Park Barrier East to have arm adjusted so that it fits properly in the cradle 'U' Install proper manhole to access to Water Tanks in access road (present cover and frame is substandard and damaged) Install proper manhole access and frame to water tanks at top of ramp (present cover is substandard and damaged) Install access ladder to water tanks Clean out general debris in water tanks and timber

Rating Classif. B B B B B B B B B A A A B

Date Rectified

Date Checked

Comments

4/10/2013

11

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01

Defect Replace damaged floor tile (West Rear) near door to docking bay Floor tile finish has many uneven edges throughout that need to be taken up and re-laid Reception Desk LH Fin return is loose and unstable Reception Desk RH Fin return is loose and unstable Make good uneven tiles at rear wall behind Reception Desk Heating to Reception Area is under designed and insufficient Tiling to Lift Lobby with 50mm strip tile is of poor quality and requires to be redone There are marked colour variations in the glass panel wall lining generally Remove protective remnants at head frame to three lifts Clean down stainless steel returns and above lift doors to all three lifts Make good skirting to ALL lift returns that do not fit cleanly Remove paint on ceiling fixtures to Lift Lobby suspended light fittings (6 No) Make good seal between glass wall panels and floor base Clean down excess grout still on tiled wall on both east and west elevations Make good vertical joint between glass panelled wall and render near LH Door Rear Make good joint at glass wall angle near LH Door Rear Glass Wall Joint LH next to Lift Lobby is standing proud of the wall and to be adjusted Make good joint at glass wall angle LH next to Lift Lobby Refix loose section of Reception Desk top in the middle Make good seal between glazing and floor finish on both sides of the Main Entrance Door Replace defective tile in floor finish on the right of the Main Entrance Door near the front window Reset uneven wall tiles near window on east side of the Reception Area Reset uneven wall tiles near window on west side of the Reception Area Make good between gap between glazed fin and wall east side near front window Make good between gap between glazed fin and wall west side near front window Make good to seal at all glass fins to the front window and the floor finish Hose reel lock defective and to be repaired or replaced Clean out debris etc. in Hose reel Enclosure Break Glass box for key to replace unlocked key box Seal hole in base of Hose reel Enclosure Remove wooden batten to RH side of door to Hose reel enclosure and make good Fit nozzles (2 No) to hose reels Remove unused flexible conduit in Hose reel enclosure LH side

Rating Classif. B B B B B B B C B C B B B C B B B B C B B B B B B B B B B A B A C

Date Rectified

Date Checked

Comments

W4A input is required

4/10/2013

12

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01 Reception (East) PE01

Defect Make good to blockwork to RH side of Hose reel enclosure Remove reinforcement rod sticking out of block wall and make good Make good hole towards Glass Panelled wall LH Side in Hose reel Enclosure Make good blockwork to LH side of Hose reel Enclosure as there is presently a gap Make good blockwork to south side of Hose reel Enclosure at upper level Small diameter pipe to RH side of Hose reel Enclosure to be fixed properly to wall Small diameter pipe to RH side of Hose reel Enclosure to be labelled Glass in Hose reel Enclosure Door is not set in a gasket and shakes Make good surface to ceiling in rear recessed ceiling light trough (east) Reset two glass wall panels in the rear wall of the Reception Area behind the desk as out of line Repair wall hole in rear wall above glass panels Fill in hole in light trough (East) Fill in hole in light trough LH side of Reception Desk Tidy up wires in light trough LH side of Reception Desk Fill in hole in light trough (west) Reset uneven wall tiles near window on east side of the Reception Area Make good vertical joint between glass wall panelling and render (East) Remove paint smears from HVAC ceiling grilles (6 No) Remove paint smears from the Running Man sign Sprinkler heads to be set flush with ceiling finish (2 No) Screws to Entrance Wind Fang (8 No) are silvery and are to be replaced with black headed screws Floor finish indicates that several tiles are 'bossed' and require to be refixed and set properly The Door to the rear and Docking Bay is not fire rated Remove remaining polythene protective cover from LH rear door Remove paint stains on door and make good as required Clean paint off floor tiles at LH Door Rear threshold Touch up ceiling at joint to south front Fire Alarm point has no instructions for use in Romanian and English Intruder alarm on door (black) is white coloured. Why are they not compatible with the frame of the door ? Fix Door Stop to (LH) Door to Docking Bay Fix Door Stop to (RH) Door to Rear Passage

Rating Classif. B C A A A B B A B B B B B B B B B C C C B B A B B B B A C B B

Date Rectified

Date Checked

Comments

W4A to comment

W4A to advise

4/10/2013

13

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

Location Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A Reception East Entrance PE01A

Defect Make good to damage (2 No) to recess box on RH side of the enclosure Make good damage to the two ceiling frames Take out the four shims between the inner ceiling frame and the glass cover ceiling Remove protective covering at end (RH) of both ceiling frames Clean glass cover ceiling from paint marks, mastic etc. Make good to floor tiles at all four corners as workmanship is poor Make good joint between floor tiles and walls to both sides of entry enclosure LH Inner leaf door to be reset to allow keepers to operate properly Refix loose seal to LH inner leaf door near frame bottom Make good to top of left hand inner leaf door at top of pull handle both sides Make good to base of LH frame (right of door near the floor) Remove green sticker on glass ceiling above inner door Remove concrete slurry on door handle outer door Re-level floor tiles at threshold to inner door leaves Reset keeper plate set at angle to LH Outer door leaf Bottom keeper to LH outer door leaf is loose and to be tightened Outer leaves of doors to realigned as they are uneven and the gap between them varies in the vertical The frame bases LH and RH to inner door to be finished Relevel mat well as at rear Maxwell is below the surrounding tile edge Refix door handle to Inner Door leaf (RH) south which is loose at top frame fixing Make good to chipped hole in northwest corner of Reception East Entrance and seal completely

Rating Classif. B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

14

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01

Defect Joint Plate between East and West buildings is partially distorted Floor tiles are generally uneven, not aligned and 'bossed' or debonded in many places Cills of Profiles at floor level are stained with tile grout and require to be cleaned Metallic ceiling panels - replace distorted, stained etc. panels Metallic ceiling panels - clean down ceiling panels with oily stain marks etc. Joint Plate between East and West buildings is not continuous at columns Repair crack in ceiling plasterboard ceiling at East/West building joint Make good to large 'X' scratch on middle cill profile on 2nd bay from East/West Buildings joint Reset sprinkler heads that have excessive projection from the ceiling (5 No) Remove paint from sprinkler heads (4 No) Paint white cable box conduit for fire alarm installation (West) on column to match column gray colour Fire alarm push alarm (West) has no written instruction for use Remove grout from glass seals and floor finish to all shopfronts generally Door West Stair : the fixing screws again protrude as driven at an angle Intumescent strip around Door to West Stair is not continuous Door West Stair : the intumescent strip is not provided to the door threshold and bases of frames Repair skirting at Door to West Stair bases and make good all round Remove paint on 'Running Man' sign to corridor to West Stair Clean off paint to top seal to all glazed shopfronts generally Remove all labels, written pane identifications, adhesive from removed labels to shop front glazing generally Re-align metal edge trims to metallic ceiling generally Re-align shopfront glass at LH corner of corridor to East Staircase and redo joint 14mm wide which is substandard Clean paint off shopfront glass at corridor to East Stair LH side near door Intumescent strip around Door to East Stair is not continuous Door East Stair : the intumescent strip is not provided to the door threshold and bases of door frames Repair skirting at Door to East Stair bases and make good all round Remove protective tape to top seal of shop front along RH of East Stair corridor Make good at base of all columns where they join the floor finish Paint white cable box conduit for fire alarm installation (East) on column to match column gray colour Fire alarm push alarm (East) has no written instruction for use Remove are 2 No wooden pegs contraptions that penetrate the joint seal to the shop fronts on East and make good Remove all glue, mastic pointing excess to all glazed shopfronts and faade glazing generally Refix two portion of loose ceiling edge strip in Eastern half of the East Building corridor

Rating Classif. C B C B B A B B B C C A C C A A B C C B B C C A A B C C C A B B B

Date Rectified

Date Checked

Comments W4A to advise on acceptability

W4A to advise on tiles in joint W4A to advise on acceptability

4/10/2013

15

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41

Location Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01 Level One Corridor (East) E1 E01

Defect On north side of eastern part of main corridor the seal is missing between the shop fronts and the floor tiling Eastern part of corridor the return to the steel handrail is still a potential hazard and could catch clothes Eastern part of corridor there are seven (7) missing light fittings to be installed Eastern part of corridor corrugated steel wall lining : install bolt head covers that are missing There are some different types of bolt covers to the corrugated sheet wall lining and to be changed to match Closure of angle eastern corridor is unsatisfactory and needs to be reviewed Fire seal to threshold to Door East Stair is required Fire seal to threshold to Door West Stair is required

Rating Classif. B A B B B C A A

Date Rectified

Date Checked

Comments

W4A to review and advise

4/10/2013

16

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25

Defect Clean paint and plaster smears on 3 No ceiling grilles Remove all labels and written identification marks on glazing throughout area Remove all protective covering to profiles throughout area Remove paint on window profiles at ceiling level on West Elevation Four (4) ceiling lights do not appear to be working : replace Clean black paint from balustrade off terrazzo stairs Replace four (4) chilled stair treads or make good Remove concrete grout on stair riser Remove all builders marks required to align and place metal balustrade rails to steps Corrugated sheet wall lining requires alignment and repair generally on the splay wall Metal skirting to splay wall requires to be fixed properly, aligned and cleaned Fire alarm push alarm has no written instruction for use Joint of splay wall and eastern door needs to be made good and aligned Protective covering at joint to splay wall and eastern door required to be removed Joint of splay wall and eastern door needs at ceiling level requires to be completed Intruder Alarm not installed on East Door Remove unconnected wire There are several 'bossed' or debonded tiles in the floor that requires to be refixed Two (2) FCU controls to be properly fixed Trim to ceiling finish is missing above west side door Replace ceiling trim to bulkhead on south elevation Repaint ceiling are on bulkhead on south elevation as marked Clean up ceiling trim around column heads of paint marks There is no finish under stair is this correct Clean mastic, grout etc stain to profiles throughout facades in this area Floor tiles at Main Entrance (south) require to be re-laid and aligned Door closed missing on main door leaf (RH) Lower stair handrail is not stable and may require further support How do you stop adventurous children crawling under stair (lower) ? Holes in East Main Entrance door frame to be closed Door closer both missing to Main Entrance Door Main Entrance door require to be adjusted and re-aligned Repair skirting to northeast corner of column

Rating Classif. C B B B B B B B C B B A B C B B A B B B B C C A C B B A A B B B B

Date Rectified

Date Checked

Comments

These have never worked

W4A to advise

W4A to advise W4A to advise

4/10/2013

17

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39

Location East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25 East Entrance (Mall) PE25

Defect Remove paint on south faade head frames on complete length Realign trim to ceiling finish at south faade head frame Make good to exposed wires to door intruder contact Install door close to outer leaf of Entrance Door Remove bolt fixing in stringer of stair upper flihgt and make good Repair hole to bulkhead near East Mall Entrance and make good all round

Rating Classif. B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

18

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08

Defect Remove pen writing on door surfaces Make good wall above main outer door where pipes etc pass into car park and remove reinforcement rod Clean cement stains on door frames Make good poor rendering above outer door especially at joint to ceiling Repaint wall where wall has been repaired (3 No) Make good to wall to LH side of outer door Remove all protective coverings to doors (Outer) Paint floor Refix intumescent strip to head frame of outer door Repair hole in head frame of outer door Make good to gap between wall and door frame on RH of outer door Reset facing to LH of outer door Door frame fixing screws protrude - refix Intumescent strip is broken to side frame due to outer door security prong Inner leaf (RH) does not open - refix Install threshold plate and seal to outer door Remove manufacturer's label on Outer door Repair damaged insulation to pipes above outer door (3 No) Make good to door fames on both sides and head frame to door North Seal hole in wall to Boiler Room where cable tray passes through Seal hole in wall to Car Park Area where cable tray passes through Make good to RH side of door frame to outer door (Car Park) Reset inner leaf of double door to Boiler Room which does not open Repair wall to RH side of door to Boiler Room Remove protective covering to Boiler Room Door Remove cement stains from head frame to Boiler Room Door Complete insulation to pipe returns at high level on East Wall (Boiler Room) Install missing pipe sleeves (5 No) Make good protruding sealant to single door on South Wall Remove manufacturer's label on door (South) Seal hole in South Wall near floor level Seal hole in wall at ceiling level on South wall where pipes pass through and repaint wall Remove measurement writing on walls

Rating Classif. B A B B B B B B A B B B B A A A B B B A A B A B B B B B B B B A B

Date Rectified

Date Checked

Comments

4/10/2013

19

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52

Location Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08 Vest. to Boiler Room East SE1.08

Defect Make good joint between floor and wall generally Remove red paint marks on wall to Car Park Install threshold plate and seal to Boiler Room Door Make good to threshold to Car Park Exhaust Room (North Wall) Make good to threshold to Storage Room (South Wall) Make good to intumescent strip where damaged to Boiler Room Door Intumescent strip is broken to side frame due to Boiler Room door security prong Make good to area above door to boiler room where it has been patched up with a door frame larger than the door Make good wall crack to LH of Boiler Room Door on East Wall to column Refix loose junction box on North Wall Clean concrete snots on ceiling Make good to joint between wall and ceiling to Boiler Room Wall Make good to joint between wall and ceiling to Car Park Wall Refix flexible conduit at Light Fitting near West Wall (South) Install door stops to double door to Car Park Area Install door stop to door to Car Park Exhaust Room (North) Install door stop to door to Storage Room (South) Fire threshold strip required to entry door to car park Warning Notice required for boiler flue pipes horizontal with clearance height of 1.68 to 1.73 metres

Rating Classif. B B A B B A A B B B C A A B B B B A A

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

20

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11 English Courtyard S1E.11

Defect Floor to have Tiles as F.02 Remove protective cover from Profiles on Glazed wall to Boiler Room Renew grille grating to street level in accordance with W4A revised drawing Seal Wall (Glazed) where cable tray passes through and make good Paint Walls Refix loose ladder access to street level (Ladder has steel reinforcement bar rungs - back street manufacture) Paint ladder to street level Paint grille and frame to street level Remove cement/concrete on pipe hangers on wall to Pump Room Remove and connect loose wire above door to pump room Intumescent strip to Pump Room is damage and requires to be fixed Remove manufacturer's labels on door to Pump Room Make good several repair patches to walls generally Make good to joint between walls and floor generally Refix loose coupling to ceiling conduit (East) Make good conduit connections to door alarm contacts Refix seal to door in Blast Wall that is loose Rehang inner leaf of Blast Room Door that 'grinds' along the concrete floor Remove steel reinforcement to RH of opening in pavement slab and make good Fire seal threshold is required to Fire Pump Room Door

Rating Classif. B B A A B A B B B A A B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

21

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25

Location Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12 Fire Pump Room -1 S1E.12

Defect Paint Floor Paint Walls Make good seal around door frame which is protruding Remove manufacturer's labels on door Install Pump Room Wall Diagram Remove or connect loose wire on North Wall Tidy up hotch potch of loose wires in control boxes (2 No) on North Wall and remove insulating tape repairs Make good to North wall at ceiling Install pipe sleeves (12 No) Make good to flexible conduit connection to pump motor near North Wall Remove two protruding reinforcement rods in North Wall and make good Make good to North East Corner wall at top Provide statutory protection to stair hole access in floor Make good holes in East Wall at floor level Repair water leaks from tanks ? Make good to hole in floor slab on South Wall Seal hole in floor slab near water tanks Remove Paper "Danger' label to Electrical Distribution Board and provide proper signage Seal hole in floor slab at southwest corner Make good and seal to West Wall near door (LH) at ceiling level where pipes etc pass through Paint floor drain grille and frame Install Door stop to single door Door Signage Fire Fighting equipment is missing Fire Alarm to be installed

Rating Classif. B B B B B A A B B B B B A B B B B A B A B B B A A

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

22

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space

Defect Window No 1 North Repair defective seal at corner and refix seal to opening window Window No 2 North Repair defective seal at corner and refix seal to opening window Window No 3 North Repair defective seal at corner and refix seal to opening window Window No 4 North Repair defective seal at corner and refix seal to opening window Window No 5 North Repair defective seal at corner and refix seal to opening window Window No 6 North Repair defective seal at corner and refix seal to opening window Window No 7 North Repair defective seal at corner and refix seal to opening window Window No 8North Repair defective seal at corner and refix seal to opening window Window No 9 North Repair defective seal at corner and refix seal to opening window Window No 10 North Repair defective seal at corner and refix seal to opening window Window No 11 North Repair defective seal at corner and refix seal to opening window Window No 12 North Repair defective seal at corner and refix seal to opening window Window No 13 North Repair defective seal at corner and refix seal to opening window Window No 1 East Repair defective seal at corner and refix seal to opening window Window No 2 East Repair defective seal at corner and refix seal to opening window Window No 3 East Repair defective seal at corner and refix seal to opening window Window No 4 East Repair defective seal at corner and refix seal to opening window Window No 5 East Repair defective seal at corner and refix seal to opening window Window No 6 East Repair defective seal at corner and refix seal to opening window Window Fan No 1 East Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 1 South Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 2 South Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 2 South Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 4 South Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 5 South Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 6 South Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 7 South Repair seal broken at top both ends and remove excess mastic sealant Make good to joint between flexible building floor joint and faade wall Finish joint on South faade between two buildings Make good at head of vertical South faade joint and ceiling finish Remove protective tape to profiles at South Faade joint Clean down excess mastic to windows at southeast corner internally Make good by removing concrete snots to Column A 20

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B C

Date Rectified

Date Checked

Comments

4/10/2013

23

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space

Defect Make good by removing concrete snots to Column A19 Make good by removing concrete snots to Column A18 Make good by removing concrete snots to Column A17 Make good by removing concrete snots to Column A16 Make good by removing concrete snots to Column A15 Make good by removing concrete snots to Column A14 Make good by removing concrete snots to Column B20 Make good by removing concrete snots to Column B19 Make good by removing concrete snots to Column C20 Make good by removing concrete snots to Column C19 Make good by removing concrete snots to Column D20 Make good by removing concrete snots to Column D19 Make good by removing concrete snots to Column D18 Make good by removing concrete snots to Column D17 Make good by removing concrete snots to Column D14 Remove steel reinforcement in slab behind columns A 12 & 13 and make good Remove paint smears etc on ceiling grilles South Faade Remove paint smears etc on ceiling grilles North Faade Remove paint smears etc on ceiling grilles East Facade Remove label on door to Stair Corridor Grid 14/15 South Make good around Fire Damper grille to LH of Door to Stair Corridor South Grid B14/15 and realign and install proper lock Operating label required on Fire Alarm South Grid B14/15 Operating label required on Fire Alarm North Grid C14/15 Operating label required on Fire Alarm South Grid B17/18 Operating label required on Fire Alarm North Grid C17/18 Make good around Fire Damper grille to LH of Lift Lobby Grid B16 and realign and install proper lock Wall tiles to Lift Lobby have out of alignment, bossed and not level throughout and to be redone Floor tiles to Lift Lobby are uneven , out of alignment, and bossed generally and to be redone Stainless steel skirtings to be refixed flush with wall returns to lift opening PE7 Stainless steel skirtings to be refixed flush with wall returns to lift opening PE8 Stainless steel skirtings to be refixed flush with wall returns to lift opening PE9 Remove protective covering to head panel of lift openings at head of side frames Lift Opening PE7 Remove protective covering to head panel of lift openings at head of side frames Lift Opening PE8

Rating Classif. C C C C C C C C C C C C C C C B B B B B B A A A A B B B C C C C C

Date Rectified

Date Checked

Comments

4/10/2013

24

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99

Location Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space

Defect Remove Protective covering to head panel of lift openings at head of side framed Lift Opening PE09 Make good to wall tile pointing at Lift PE07 at RH side Make good to wall tile pointing at Lift PE09 at LH side Clean stains on upper lift panels above lift door opening PE07 near ceiling Clean stains on upper lift panels above lift door opening PE08 near ceiling Clean stains on upper lift panels above lift door opening PE09 near ceiling Remove paint stains on air grille in middle of Lift Lobby North Area Grid C D 12/20 Refix ceiling edge trims to suspended ceiling generally that have warped or are out of alignment Replace three (3) damaged ceiling tiles in North Area Grid CD 15/19 Remove labels on all windows generally Reset ceiling grille in northeast corner Make good to wall lining in northeast corner at floor Repoint at window head near Boiler Flue as open Clean general building debris out of runnels to all twenty seven opening sashes Remove excess mastic at window corner to RH side of Boiler Flue internally Replace damaged opening sash window in South East corner with twisted frame Remove excess mastic at window corner facing Boiler Flue internally Remove excess mastic at windows to southeast corner internally Make good scratch to opening window 1 Grid A 19/20 Tighten window handles to opening windows South Faade No 2 Tighten window handles to opening windows South Faade No 3 Tighten window handles to opening windows South Faade No 4 Tighten window handles to opening windows South Faade No 5 Tighten window handles to opening windows South Faade No 6 Tighten window handles to opening windows South Faade No 7 Make good to rough floor at Column A 18 near window faade Make good to rough floor at Column A 17 near window faade Repair damaged joints in expansion joint between the buildings Grid Line 12/13 (3 No) Replace broken window restrainer to opening window sash on Window 5 North Facade Install medium ceiling hatch near Grid Line B/C 18 Install small ceiling hatch near Grid Line B/C 18 Make good around Fire Damper grille to grid C/B18 and realign Make good damaged paint to Fire Hose reel box where damaged B18

Rating Classif. C B B C C C B B B B B B B B B B B B B B B B B B B B B B A B B B C

Date Rectified

Date Checked

Comments

4/10/2013

25

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115

Location Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space Level 3 East Open Space

Defect Glass Key Box to Fire Hose reel box the glass is loose and should be replaced with a Break Glass Key Box B18 Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse B18 Seal hole in floor slab inside Fire Hose reel Cabinet B 18 Seal openings between Fire Hose reel door frame and blockwork all round B18 Clean airbourne dirt around circular ceiling vents in plasterboard 'corridor' ceiling north area C 12/20 Clean airbourne dirt around circular ceiling vents in plasterboard 'corridor' ceiling south area B 12/20 Make good access ceiling hatch Grid B/C 14 Make good around Fire Damper grille to grid C14 and realign and install proper lock Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box C14 Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse C14 Seal openings between Fire Hose reel door frame and blockwork all round C14 Seal holes in wall lining to RH of door opening inside the Fire Hose reel enclosure C 14 Seal hole in ceiling slab of Fire Hose reel Enclosure C 14 Replace stained ceiling tile in Area AB 18/19 Replace damaged ceiling tile on Area AB 18/19 Fire Fighting Equipment is missing

Rating Classif. A A A A B B B B A A A A A B B A

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

26

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Location Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25 Electrical Closet Grd. East PW25

Defect Repaint wall as substandard Make good 'messy' joint between floor and wall finish all round Seal opening on south wall at high level (@ No.) and make good Cabinet TEG-E make good to panel internally where badly cut for flexible conduit Cabinet TEG-E replace damaged/chipped panel RH second down Remove protective covering from TESra 2GE Make good eleven (11) drill holes on south wall and repaint Make good to render around wall door returns which are poorly executed and repaint Clean rust marks on floor paint and repaint Clean off concrete grout and snots on door frames amend repaint as required Reset protruding door screws to frame fixing all round Install door stop Intumescent strip is missing on RH side of door frame needs to be replaced Intumescent strip to head frame is covered in cement grout and needs to be cleaned or replaced Intumescent strip to both sides of frame is not complete at the heads and required to be replaced Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Apply paint to threshold plate as rusting Door Signage Fire seal threshold required to door to Closet

Rating Classif. B C B B B C C B B B B B A A A A B B A

Date Rectified

Date Checked

Comments

4/10/2013

27

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Location Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area Level 6 Open Area

Defect Window No 1 North Repair defective seal at corner and refix seal to opening window Window No 2 North Repair defective seal at corner and refix seal to opening window Window No 3 North Repair defective seal at corner and refix seal to opening window Window No 4 North Repair defective seal at corner and refix seal to opening window Window No 5 North Repair defective seal at corner and refix seal to opening window Window No 6 North Repair defective seal at corner and refix seal to opening window Window No 7 North Repair defective seal at corner and refix seal to opening window Window No 8 North Repair defective seal at corner and refix seal to opening window Window No 10 North Repair defective seal at corner and refix seal to opening window Window No 11 North Repair defective seal at corner and refix seal to opening window Window No 12 North Repair defective seal at corner and refix seal to opening window Window No 13 North Repair defective seal at corner and refix seal to opening window Window No 1 East Repair defective seal at corner and refix seal to opening window Window No 2 East Repair defective seal at corner and refix seal to opening window Window No 3 East Repair defective seal at corner and refix seal to opening window Window No 4 East Repair defective seal at corner and refix seal to opening window Window No 5 East Repair defective seal at corner and refix seal to opening window Window No 6 East Repair defective seal at corner and refix seal to opening window Window Fan No 1 East Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 1 South Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 2 South Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 2 South Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 4 South Repair seal broken at top both ends and remove excess mastic sealant and tighten handle Window Fan No 5 South Repair seal broken at top both ends and remove excess mastic sealant and remove wire in stay Window Fan No 6 South Repair seal broken at top both ends and remove excess mastic sealant Window Fan No 7 South Repair seal broken at top both ends and remove excess mastic sealant and protective tape to profile Remove paint smears to ceiling grilles South Faade and realign as required Remove paint smears to ceiling grilles East Faade and realign as required Make good around Fire Damper grille to grid C14 and realign and install proper lock fastening Remove paint/cement splashes to internal surface of glass to FHE C14 Door Clean airbourne dirt around circular ceiling vents in plasterboard 'corridor' ceiling north area C 12/20 Clean airbourne dirt around circular ceiling vents in plasterboard 'corridor' ceiling south area B 12/20 Fire Fighting equipment is missing Remove paint smears to ceiling grilles North Faade and realign

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B A B

Date Rectified

Date Checked

Comments

4/10/2013

28

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14

Location Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01) Corridor North C14/18 (E6E.01)

Defect Install operator signage to Fire Alarm Button at South Wall near door to Stair Vestibule E4E.03 Make good round Fire Damper Grille panel (Low) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Lower) near Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall near Lift Lobby Install operator signage to Fire Alarm Button at South Wall RH of Service Elevator Vestibule Install operator signage to Door Release Button at South Wall to RH of Service Elevator Vestibule Install break glass to Emergency Door Release Button on South Wall to RH of Service Elevator Vestibule Remove paint from Running Man Sign above door to Stair Vestibule E4E.16 Make good round Fire Damper Grille panel (Upper C 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper C 16) near Lift Lobby Provide proper locking device to Upper (C/16) Fire Damper Grille on South Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on South Wall near to RH side of Service Elevator Lobby Clean paint off grille to Fire Damper panel (Lower) to RH side of Service Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall to RH side of Service Lift Lobby

Rating Classif. A B B B A A A B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

29

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01) Corridor West B/C 14 (E6E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory Make good round Fire Damper Grille panel C14 East Wall near Fire Hose reel Enclosure (FHE) Clean paint off grille to Fire Damper panel C14 near FHE Provide proper locking device to C14 Fire Damper Grille on East Wall near FHE Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hose reel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork and make good Divider Wall to LH to be sealed full length to back wall Seal wall at RH side of enclosure for waste pipe and make good Seal two holes in ceiling slab within FHE and make good Seal around conduit to RH side of FHE internally near concrete beam Fit two (2) nozzles to hosereels Seal wall RH side to drain pipe and make good Remove large open cable in floor slab and make good Remove small cable left in FHE and make good at floor and ceiling slabs when removed Make good hole in wall below FHE externally and repaint Remove hardboard shim on LH side frame of FH Enclosure

Rating Classif. B B B B B B B B B B B B A A A A A A B B

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

30

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18

Defect Prepare for and paint ceiling Remove paint on Access Card Reader Remove paint stains on floor covering generally Fill in hole to door head frame Remove paint splashes etc on doors Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip on inner hinge frame is broken and short at base and prong receiver and to be replaced Intumescent strip on hinge frame of outer door leaf is short at base and to be replaced Install door stops to Doors Clean paint off Door Frames Door Signage Fire/Smoke Threshold seal is required to door Install closer with selector on doors Remove all remaining parts of the protective covering to doors Install rubber seal to door Intumescent strip to meeting style is not continuous and missing at door lock Realign door intruder alarm contacts Inner leaf of door has too much play when closed and to be adjusted Tidy up wiring to door intruder contact Screw missing form door locking plate Connect door closer to outer door leaf Touch up to damaged paintwork to door frames generally Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Relay floor covering that is distorted and 'bubbled' and prepare floor screed below Replace missing external angle corner piece to LH side of lift entrance return Replace missing skirting and external angle corner piece to RH side of lift entrance return Install edging between floor covering and lift threshold Paint sprinkler pipework Tidy up joint at sprinkler head and elbow joints including removing excess joint hemp fibres on sprinkler pipework Replace screws at grille to LH side with white headed screws as elsewhere Seal and make good to conduit at ceiling level (North Wall) Seal and make good to large hole with two (2) conduits at northeast corner at ceiling level

Rating Classif. B B B B B B B A A B B B A A B B A B A B B A B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

31

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 33 34 35 36 37 38 39

Location Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18 Service Elevator Vestibule E6E.18

Defect Seal and make good to one (1) sprinkler pipe in northeast corner at near ceiling level Remove paint on Arrow Lift Indicator and make good Remove remaining parts of protective covering to Lift frames Clean off paint splashes on Lift Door and frames Make good to floor finishes etc at base of LH frame of door Make good to floor finishes etc at base of RH frame of door and fill in sinking to screed Complete conduit to ceiling smoke detector

Rating Classif. B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

32

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16)

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to hinge frame at head and bases of Door South : to be replaced Intumescent strip is not complete to base and head of open frame of Door South and is also loose : to be replaced Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to head frame is missing Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Install door closer to Door South Why are there locks on Stair Egress Doors operated with Card Reader Access and Release Push button ? Terrazzo tile floor is uneven and needs to be levelled, polished and resealed Terrazzo Skirting at LH wall return to doors to have rounded or pencil arrissed corner to Stair Egress Door Provide operation label to Door Push Button in Romanian and English Remove paint etc. from top edge of skirting on all walls Reset double power socket outlet near Door North on East wall to be level Reset double power socket outlet near Door South on East wall to be level Clean paint etc from two (2) light fittings Screw missing from door lock plate on Door North Clean paint off door frame to Door North Touch up chipped paintwork to door frames Intumescent strip is not complete to open frame being short at base and missing in top section of Door North : to be replaced Intumescent strip to hinge frame is missing at top and short to base to Door North : to be replaced Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Remove all remaining parts of protective covering to door Terrazzo Skirting at RH wall return to doors to have rounded or pencil arrissed corner to Stair Egress Door

Rating Classif. B B A A B B A A B A B A A B B A B B B B B B B A A B B A B B A B B

Date Rectified

Date Checked

Comments

W4A to advise

This push button is disabled

4/10/2013

33

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51

Location Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16) Stair Vestibule Level 6 (E6E.16)

Defect Make good to floor terrazzo tiling that finished short at Door North Set Running Man Sign straight at ceiling Remove all remaining parts of protective covering to door North Remove paint to three (3) sprinkler head in ceiling and make good Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Make good to skirting to LH of Door South as missing Make good to skirting to LH of Door North as missing Make good to skirting to RH of Door North Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required Remove paint from Running Man Sign and make good Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internally around Dry Riser Access Panel and make good Fill in gaps around Upper Fire Damper on West Wall and make good all round

Rating Classif. B B B C B B B B B B B B B A B A A B

Date Rectified

Date Checked

Comments

4/10/2013

34

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Location Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15 Handicapped Toilet E6E.15

Defect No floor gulley installed Clean excess grouting to tiles generally Replace door grill screws (Internal) with white headed screws Make good to floor finish at LH Base Frame of door Make good to floor finish at RH Base Frame of door Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Clean fan outlet in ceiling of dirt/dust etc. WHB tap is loose and to be reset properly Install plug Install rubber seal around door Install Door stop Clean general dirt etc in floor pointing and make good Repoint to wall tiling where short or insufficient Make good to tiled floor finish to door frame bases LH Make good to tiled floor finish to door frame bases RH Make good to wall tiling at north east corner Make good to wall tiling at northwest corner where missing Make good to joint between wall and floor tiling on South Wall Make good to door dent at lock plate

Rating Classif. A B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

35

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05)

Defect Remove paint to three sprinkler heads Make good to floor and finish at frames bases of Door South Remove paint to South Door Frames Fit rubber seal all round door South Intumnescent strip is not installed to side or head frames Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Install door closer to Door South Install edging and recut floor covering to door South threshold Clean paint off door frame to Door North Intumescent strip is installed to side or head frames of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Install door closer to Door North Remove all remaining parts of protective covering to door Screw missing in lock plate to door North Replace missing external angle corner to skirting to LH of door to Handicapped Toilet E6E.15 Replace missing external angle corner to skirting to RH of door to Toilet E6E.14 Replace missing external angle corner to skirting to RH of door to Pantry Replace missing external angle corner to skirting to LH of door to Pantry Replace missing skirting between Pantry and Vestibule E6E.08 Refix all skirting as attached with panel pins with adhesive or clip-on system Reset double socket outlet near Door South and make level Reset double socket outlet near Door North and make level

Rating Classif. B B B B A B B A B B A B A B B A B B A B B A B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

36

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38

Location Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05) Vestibule Level 6 (E6E.05)

Defect Install edging strip between PVC floor covering and tile floor finish to Handicapped Toilet E4E.11 Install edging strip between PVC floor covering and tile floor finish to Toilet E4E.12 Install edging strip between PVC floor covering and tile floor finish to Toilet E4E.13 Install edging strip between PVC floor covering and tile floor finish to Toilet E4E.14 Install edging strip between PVC floor covering and tile floor finish to Handicapped Toilet E4E.15

Rating Classif. B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

37

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12

Location Vestibule E6\4E.08 Vestibule E6\4E.08 Vestibule E6\4E.08 Vestibule E6\4E.08 Vestibule E6\4E.08 Vestibule E6\4E.08 Vestibule E6\4E.08 Vestibule E6\4E.08 Vestibule E6\4E.08 Vestibule E6\4E.08 Vestibule E6\4E.08 Vestibule E6\4E.08

Defect Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Make good to floor finishes at door frame bases Clean light of dirt and paint stains Touch up chipped paint on door frames Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Refix all skirting as attached with panel pins with adhesive or clip-on system

Rating Classif. B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

38

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13

Location Data Room Level 6 E6E.10 Data Room Level 6 E6E.10 Data Room Level 6 E6E.10 Data Room Level 6 E6E.10 Data Room Level 6 E6E.10 Data Room Level 6 E6E.10 Data Room Level 6 E6E.10 Data Room Level 6 E6E.10 Data Room Level 6 E6E.10 Data Room Level 6 E6E.10 Data Room Level 6 E6E.10 Data Room Level 6 E6E.10 Data Room Level 6 E6E.10

Defect Paint Ceiling and beams Seal hole at north wall where sprinkler pipe enters Clean out light fitting Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Seal North wall to two (2) HVAC pipes and make good all round Seal conduit at ceiling level on South Wall Refix all skirting as attached with panel pins with adhesive or clip-on system

Rating Classif. B B B B B B B B B B A A B

Date Rectified

Date Checked

Comments

4/10/2013

39

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09

Defect Paint ceiling Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Make good to floor level on South Wall near door and refix floor covering Install skirting to South Wall as missing Skirting missing at return on East Wall Skirting loose on northern side of East Wall Skirting is missing on West wall (North) Make good to north wall next floor sinking and refix floor covering complete Infill large hole in southeast of room (fire stopping) Hole at present is a safety issue Skirting missing at North wall Remove manufacturer's labels from door and make good Paint walls Make good to door plasterboard ingoings to both door frames and head frame Remove paint to Door Frames Fit rubber seal all round door Intumescent strip is short to hinge frame at base of door and to be replaced Intumescent strip is short to open frame at base and to be replaced Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to Door h Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to door Remove remaining protective covering to door Install fire/smoke seal threshold plate to door Two (2) screw missing in lock plate to door Door frames are 8mm above finished floor level and to be reset Install door closer Realign intruder alarm door contacts Door sign Make good to wall base at return to East wall in middle and repaint Tighten up thirteen (13) screws to the five control boxes to RH of SBS 10E Screw in the seven (7) missing screws to the five (5) control boxes to RH of SBS-10E Install missing skirting to LH return to door with and including external corner angle piece Make good to floor slab and finish at LH door frame base

Rating Classif. B B B B B B B B A B B B B B B A A B B A B B A B B A B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

40

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42

Location Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09 Electrical Closet E6E 09

Defect Replace label to cabinet SBS 10E which is plastic with paper printed sign and install ivorine label Clean paint from two (2) ceiling lights and make good Make good to plasterboard at wall return near Bus Bars on East Wall and paint Reconnect or remove to three (3) wires at beam level above SBS-10E Reconnect or remove to three (3) wires to Box 3 above SBS-10E Reconnect or remove to five (5) wires to Box 3 above SBS-10E Electrical Cabinet TCT-6E : reset upper panel internally Clean out internal of Electrical Cabinet TL6E Clean out internal of Electrical Cabinet TUPS-6E

Rating Classif. B B B A A A A C C

Date Rectified

Date Checked

Comments

4/10/2013

41

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area

Defect Make good wall at corner A22 including underside of slab Remove concrete dropping to SVP pipe and generally clean up A22 Provide impact Protection to SVP Pipe A22 Provide impact protection to SVP Pipe A20 Provide impact protection to SVP Pipe A18 Provide impact protection to SVP Pipe A16 Provide impact protection to SVP Pipe A14 Provide impact protection to SVP Pipe D14 Provide impact protection to SVP Pipe D16 Provide impact protection to SVP Pipe D18 Provide impact protection to SVP Pipe D20 Provide impact protection to SVP Pipe at C21 near ALA Entrance Provide impact protection to car exhaust extracts A22 LH Provide impact protection to car exhaust extracts A21 RH Provide impact protection to car exhaust extracts A21 LH Provide impact protection to car exhaust extracts A20 RH Provide impact protection to car exhaust extracts A20 LH Provide impact protection to car exhaust extracts A19 RH Provide impact protection to car exhaust extracts A19 LH Provide impact protection to car exhaust extracts A18 RH Provide impact protection to car exhaust extracts A18 LH Provide impact protection to car exhaust extracts A17 RH Provide impact protection to car exhaust extracts A17 LH Provide impact protection to car exhaust extracts A16 RH Provide impact protection to car exhaust extracts A16 LH Provide impact protection to car exhaust extracts A16 LH Provide impact protection to car exhaust extracts A15 RH Provide impact protection to car exhaust extracts A15 LH Provide impact protection to car exhaust extracts A14 RH Provide impact protection to car exhaust extracts A14 LH Provide impact protection to car exhaust extracts A13 LH Provide impact protection for car exhaust extract Column B19 Provide impact protection for car exhaust extract Column B13

Rating Classif. B C A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A

Date Rectified

Date Checked

Comments

W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise

4/10/2013

42

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area

Defect Provide impact protection to water supply pipe Column A 20 Provide impact protection to water supply pipe Column A 18 Provide impact protection to water supply pipe Column A 16 Provide impact protection to water supply pipe Column A 14 Provide impact protection to water supply pipe Column D 20 Provide impact protection to water supply pipe Column D 18 Provide impact protection to water supply pipe Column D 16 Provide impact protection to water supply pipe Column D 14 Clean out void between Column Walls A 12 and 13 Clean out void between Column Walls D 12 and 13 Provide impact Protection to CO Warning Sign A 12 Provide impact Protection to CO Warning Sign D 12 Provide impact Protection to CO Warning Sign A 17 Provide impact Protection to CO Warning Sign D 17 Clean out floor drain near D20 as blocked and also remove blue plastic bedding Paint floor drain grating near D 20 Clean out floor drain near D18 Paint floor drain grating near D 18 Clean out floor drain near D16 Paint floor drain grating near D 16 Clean out floor drain near D14 Paint floor drain grating near D 14 Clean out floor drain near A20 Paint floor drain grating near A 20 Clean out floor drain near A18 which needs also to be aligned as place squint Paint floor drain grating near A 18 Clean out floor drain near A16 Paint floor drain grating near A 16 Clean out floor drain near A14 as blocked Paint floor drain grating near A 14 Clean concrete group to SVP Pipe at Column D 20 Clean concrete group to SVP Pipe at Column D 14 including masking tape Cover plates to sewer pump are not fixed permanently and of 'backstreet' quality To be replace and recessed

Rating Classif. A A A A A A A A B B A A A A B B B B B B B B B B B B B B B B B B A

Date Rectified

Date Checked

Comments W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise

W4A to advise W4A to advise W4A to advise W4A to advise Drain not in position as drawing Drain not in position as drawing Drain not in position as drawing Drain not in position as drawing Drain not in position as drawing Drain not in position as drawing Drain not in position as drawing Drain not in position as drawing

4/10/2013

43

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99

Location Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area

Defect South east corner of cover plate to Sewage Pumping Station is curling and will cause tyre problems. Replace as 66 above Cover plate and frame for rear part of Sewage Pumping Station not yet installed Paint support metalwork to Sewage Pumping Station to prevent rust etc. D19 : take down cable tray support left in and make good Make good to back kerb to outer wall between D19 and D20 Seal hole in wall upper to RH of Column D 19 Make good and seal four holes in wall to ALA D21 Remove timber packer plate at wall head above ALA entrance and make good Provide finishing ventilation plates to three (3) ventilation opening to ALA above entrance door to ALA Provide impact protection to wall mounted ventilation unit near Column D20 Provide impact protection to Running Man Sign on column C 20 Provide impact protection to Running Man Sign on column B 20 Provide impact protection to Running Man Sign on wall C18 Provide impact protection to Running Man Sign on wall B18 Provide impact protection to Running Man Sign on wall B15 Provide impact protection to Running Man Sign on wall C14 Make good leak between A16 and A17 and repaint wall Make good two (2) leaks between A15 and A16 and repaint wall Make good large leak between A14 and A15 and repaint wall Make good leak between A13 and A14 and repaint wall Make good leak between at column D15 and repaint wall and column Make good leak between D 15 and D16 and repaint wall Make good leak between D17 and D18 and repaint wall Make good leak between D18 and D19 and repaint wall Make good leak between D19 and D20 and repaint wall Repair sprinkler pipe installation between D 13 and D14 as out of line and level and suspended holdfasts are squint Provide impact protection to wall mounted ventilation unit near Column D14 Realign sprinkler pipe installation between D16 and D17 Make good to wall external to RH of Wall Column D16 and repaint Remove 60mm plastic water pipe protruding over 1 m from ceiling and seal hole and make good at Column D18 Install operator signage to Fire Alarm Button at wall C17 and remove paint Install operator signage to Fire Alarm Button at wall B17 Install operator signage to Fire Alarm Button at wall B14

Rating Classif. A A B B B B B B B A A A A A A A B B B B B B B B B B B B B B A A A

Date Rectified

Date Checked

Comments

W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise

4/10/2013

44

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132

Location Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area

Defect Install operator signage to Fire Alarm Button at Wall D15 Take out temporary electrical cabinet and supply wire including making good to slab soffit when removed at Wall BC 14 Remove timber packer at wall head and make good Wall BC 14 Make good to vertical runnel (LH) to concrete Wall BC 14 and repaint Remove steel rod in wall BC 14 to the left of the HVAC/Plumbing Shafts and make good Remove concrete snotting and splatter to LH side of door to Corridor C 14/15 Make good formwork rod hole to Wall C14/15 on RH side of Door to Corridor Seal pipes passing through to Service Lift Vestibule Wall C14/15 Make good to honeycombed wall B 14/15 and repaint Make good hole in ceiling slab at D14 Remove 100mm diameter cupped plate on Wall B17/18 and make good Make good to honeycombed wall B 18 and repaint Make good to wide vertical wall runnel on Wall B/C 18 and repaint Make good botched ceiling slab repair near Wall B/C 18 Seal two (2) holes near slab at HVAC/Plumbing Ducts on Wall B/C 18 Make good to four (4) holes near slab Make good seven (7) formwork rod holes on LH of Wall C 17/18 Make good four (4) formwork rod holes on RH of Wall C 17/18 Make good honeycombed wall to RH of Wall C 17/18 and repaint Seal two (2) pipes that pass through wall above door to Elevator Lobby on Wall C 17/18 Make good to arrises of plasterboard lined duct in middle of wall (East) to Elevator Lobby Remove pipe between A17/18 in external wall kerb and seal Repair water leaks in AREA B/C 21 and 22 and make good to finishes Remove wire in wall to ALA to LH side of emergency exit to ALA Remove timber packing to wall to ALA C21 to B22 and make good Repair hole in slab ceiling between A 21/22 and B21/22 Seal off cable tray as it passes through wall between Car Park Area and Annex Room S3E.9 Seal conduit as it passes through wall above door to Service Corridor S3E .8 Warning notice needed in Car Park Area B/C 21 as clearance height is 1.83 metres Warning notice needed in Car Park Area A/B 22 at sprinkler pipe as clearance height is 2.01metres Warning notice needed in Car Park Area A/B 22 along wall under large dia. exhaust pipe as clearance height is 2.07metres Make good wall leak between A 20 and 21 and repaint wall Carbon Monoxide signs to also have warning in English

Rating Classif. A B B B B B B B B B B B B B A C C C B A B B B B B B A A A A A B A

Date Rectified

Date Checked

Comments

W4A to advise W4A to advise W4A to advise W4A to advise

4/10/2013

45

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165

Location Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area Basement -3 East General Area

Defect Make good flexible conduit connections to CCTV Camera A21 Make good flexible conduit connections to CCTV Camera B18 Make good flexible conduit connections to CCTV Camera B14 Make good flexible conduit connections to CCTV Camera A12 Make good flexible conduit connections to CCTV Camera D12 Make good flexible conduit connections to CCTV Camera C14 Make good flexible conduit connections to CCTV Camera C18 Make good to white water pipe at ceiling D18 Complete conduit connection to CO Warning Sign A 12 Complete conduit connection to CO Warning Sign D 12 Complete conduit connection to CO Warning Sign A 17 Complete conduit connection to CO Warning Sign D 17 Make good painting to black and yellow threshold strip Service Elevator Vestibule. Make good painting to black and yellow threshold strip Corridor B14/15 South. Make good painting to black and yellow threshold strip Corridor C14/15 North Make good painting to black and yellow threshold strip Corridor B17/15 South. Make good painting to black and yellow threshold strip Corridor C17/18 North Tidy conduit connections to control panel for Sewage Pumping Station D17/18 Paint floor after leak repaired between A 13/14 Make good to wall paint near six gang wall switch where missing to LH of Door to Corridor S3E.06 South side Paint to missing area at six gang light switch on North Wall C 17/18 Fire fighting equipment is missing

Rating Classif. B B B B B B B B B B B B B B B B B B B B B A

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

46

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04 Stair S3E.04

Defect Replace three (3) chipped steps Repair skirting that is debonding at mid landing Clean light fitting on landing that is covered in paint etc. Landing tiles are uneven and need to be levelled and repolished Stair are badly stained and need deep cleaned and repolished Floor tiling at -3 is uneven and needs levelled and repolished Make good to wall where black conduit passes through wall Remove paint on Running Man sign Remove paint on wall grille Fix handles to doors and make good Remove masking tape to door frames Intumescent strip is not complete to both frame bases Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop Install door closer Remove paint stains to top edges of skirting to landing and stairs throughout Door Signage Fire /Smoke seal threshold required to Door

Rating Classif. B B B B B B B B C A B A B B A B A B B A

Date Rectified

Date Checked

Comments

Why is conduit flexible and black ?

4/10/2013

47

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03

Defect Remove paint to South Door and Frames Fix handles to door South and make good Intumescent strip is not complete to both frame bases of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Install door closer to Door South Paint ceiling Seal two (2) holes in wall through which pipes/conduit pass (South) Refix steel conduit with proper fixings to Light Switch near Door South Remove paint from conduit near Door South Make good to two (2) holes near Door South Running Man sign obstructs the sprinkler head in operation mode and needs to be reviewed Carbon Monoxide Warning sign obstructs the operation of the sprinkler head and requires to be relocated Carbon Monoxide sign to have English Warning Clean paint etc from two (2) light fittings Remove red paint stains from wall generally Make good round Fire Damper Grille panel (Lower) Make good round Fire Damper Grille panel (Upper) Provide proper locking device to Lower Fire Damper Grille Provide proper locking device to Upper Fire Damper Grille Make good ceiling at northeast corner of corridor Refix steel conduit with proper fixings to Light Switch near Door North Remove paint from conduit near Door North Remove labels from Door North Fix handles to door North and make good Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Install door closer to Door North

Rating Classif. B A A B B A B A B B A B B A A A B B B B B B B A B B A A B B A B A

Date Rectified

Date Checked

Comments

Door South

Door North

4/10/2013

48

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53

Location Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03 Corridor Vestibule S3E.03

Defect Seal wall where small pipe passes through North Wall both sides Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal openings between Fire Hose reel (FHE) door frame and blockwork all round Remove masking tape to FHE Door panel frames Remove paint on door to FHE Make good door cill inside FHE Seal pipe holes Two (2) in ceiling slab Inside this duct the two walls to the HVAC shafts have not been installed and require to be executed Wall to LH side of FHE is not complete at the upper level and needs to be completed Tidy up blockwork above door and generally Remove timber and wood around HVAC vent shaft Install access cover and frame to Dry Riser Outlet Provide Type C connection to Dry Riser Seal in FHE to vent HVAC at slab level ceiling Remove paint to top edges of skirting throughout Provide angle steel threshold step to Door South and paint with black and yellow diagonal stripes Provide angle steel threshold step to Door North and paint with black and yellow diagonal stripes Fire/Smoke threshold seal required to Door North Fire/Smoke threshold seal required to Door South

Rating Classif. B B B A B B B A A A B B A A A B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

49

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Location Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05 Service Lift Vestibule S3E.05

Defect Replace damaged door frame Fit door handles Tidy up door seal to LH side of door Fill in hole to door head frame Seal hole to door bulkhead where pipes pass through Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Remove red paint daubs on walls Inner leaf of door is binding on the head frame and does not close properly and requires adjustment Outer leaf of door is binding on the head frame and requires to be adjusted Skirting is fixed with panel pins and requires to fixed with adhesive or better Paint ceiling Make good paint work to LH side of Service Lift Frames Install door stops to Doors Clean paint off Service Lift Door Frames Clean paint off service lift call and indicator wall panels Remove all protective covering from Lift Doors Replace light diffuser as not standard Seal conduit hole at ceiling level Provide angle steel threshold step to Door North and paint with black and yellow diagonal stripes Door Signage Fire/Smoke threshold seal required to entry door

Rating Classif. B A B B B B B A B A A B B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

50

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Location Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13 Telephone Closet S3E.13

Defect Prepare floor to be level Paint floor Seal wall hole (East Upper) where conduit tray passes through into Car Park Area Seal wall hole (West Upper) where conduit tray passes through into Car Park Area Align four (4) control boxes on west wall Clean all paint and cement grout of conduits Generally tidy up wires in cable trays Clean light fitting Make good joint between wall and floor Remove concrete snots etc to wall and paint Remove labels to door Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is not complete to both frame bases of Door Intumescent strip is not complete to door head frame Install door handles Install door stop Install door closer Clean threshold plate and paint Paint ceiling Door Signage Fire/Smoke threshold seal required to entry door

Rating Classif. B B A A C C B B C C B B B A A A A B A B B B A

Date Rectified

Date Checked

Comments

4/10/2013

51

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

Location Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14 Electrical Closet S3E.14

Defect Prepare floor to level Paint floor Remove labels to door Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is not complete to both frame bases of Door Intumescent strip is not complete to door head frame Install permanent door handles Install door stop Install door closer Clean threshold plate and paint Remove wire in door jamb Seal wall hole above entry door where pipes and cables pass through Remove two (2) pieces of HVAC ducting Clean paint etc off light fitting Make good wall to external to RH side of entry door and repaint Remove concrete stains and grout to door frames Make good and seal to West Upper Wall at cable tray Make good and seal to East Upper Wall at cable tray Seal wall at East wall at junction to ceiling slab Make good joint between wall and floor throughout Make good to wall returns at entry door and repaint Remove paint on conduits Remove three (3) bolt fixings in West wall and make good Electrical Cabinet TLB3-E door to be refitted as it does not close properly Door signage Fire/Smoke threshold seal required to entry door

Rating Classif. B B B B B A A A B B A B B A B B B B A A A B B B B A B A

Date Rectified

Date Checked

Comments

4/10/2013

52

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01

Defect Socket Outlet externally on Wall C16/17 has unconnected wires to LH of Door Fixing screws to frame protrude and are to be refixed to Double Door South Cover four (4) protruding screw ends in angle plate to top corners to Double Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is not complete to both frame bases of Door jambs Intumescent strip is not complete to door head frame Install permanent door handles Door South Install door stops to Double Door South Install door closers and selector to Door South Clean threshold plate and paint Door South Remove all protective covering to Double Door South Intumescent strip to meeting stile is damaged and to be replaced to Door South Remove red paint stain on Door Frame (South) Make good to rectangular hole in head frame Door South Fixing screws to frame protrude and are to be refixed to Double Door North Cover four (4) protruding screw ends in angle plate to top corners to Double Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is not complete to RH frame of Door North There is no intumescent strip to LH Door Frame of Door North Intumescent strip is not complete to door head frame Install permanent door handles on Double Door North Install door stops to Double Door North Install door closers and selector to Double Door North Clean threshold plate and paint to Double Door North Remove all protective covering to Door North Intumescent strip to meeting stile is missing and to be replaced to Door North Outer North Door leaf (LH) scrapes along the floor surface and requires to be reset Make good to rectangular hole in head frame Door North Finish floor covering paint around door jamb bases at Double Door North Refix skirting with proper fixing system and remove panel pins throughout Fix missing skirting to North and East walls with proper system Paint ceiling Make good to conduit near ceiling on South Wall

Rating Classif. A B B A A A B B A B B A B B B B A A A A B B A B B A B B B B B B B

Date Rectified

Date Checked

Comments

Door South

Door North

4/10/2013

53

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65

Location Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01 Lift Lobby S3E.01

Defect Make good to ceiling where rebar reinforcement is exposed Remove piece of timber formwork still attached to the ceiling soffit and make good Seal two (2) holes in wall at northwest corner for small dia. Pipes Seal one (1) hole in southwest corner wall for small dia pipe Firm up supports of sprinkler pipes within this area Clean two (2) light fittings of paint and dirt inside Make good to wall returns and arrises to both sides of door to store and repaint Make good to hole in ceiling in northwest corner for conduit Make good hole in North wall above door for conduit Finish floor paint finish along East Wall where not completed Remove protective covering from Lift Doors and Frames Clean out water in base of Lift Shaft PE 7 and effect repair Remove paint to frames of lift shaft doors Remove all builder's debris in base of Lift Shaft PE7 Carbon Monoxide Warning to also be in English Make good hole in ceiling in Southwest area Clean grill on West Wall of paint etc. Tidy up conduit on north side to light fitting conduits to both sides Provide angle steel threshold step to Door North and paint with black and yellow diagonal stripes Provide angle steel threshold step to Door South and paint with black and yellow diagonal stripes Door Signage South Door Signage North Fire/Smoke threshold seal required to entry door South Fire/Smoke threshold seal required to entry door North

Rating Classif. B B B B A B B B B B B B B B A B B B B B B B A A

Date Rectified

Date Checked

Comments

Door South

Door North

4/10/2013

54

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location

Defect

Rating Classif. B A A B B A B A B A A B A A A B B B B B B B B A B B A A B B A B A

Date Rectified

Date Checked

Comments

Corridor Vestibule B/C 18/19 S3E.06 Remove paint and cement to South Door and Frames Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Fix handles to door South and make good Intumescent strip is not complete to both frame bases of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Install door closer to Door South Paint ceiling Seal two (2) holes in wall through which pipes/conduit pass (South) Refix steel conduit with proper fixings to Light Switch near Door South Remove paint from conduit near Door South Make good to two (2) holes above Door South Running Man sign obstructs the sprinkler head in operation mode and needs to be reviewed Carbon Monoxide sign to have English Warning Remove labels from Door South Clean paint etc from two (2) light fittings Remove red paint stains from wall generally Make good round Fire Damper Grille panel (Lower) Make good round Fire Damper Grille panel (Upper) Provide proper locking device to Lower Fire Damper Grille Provide proper locking device to Upper Fire Damper Grille Remove paint from door and frames North Refix steel conduit with proper fixings to Light Switch near Door North Remove paint from conduit near Door North Remove labels from Door North Fix handles to door North and make good Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Install door closer to Door North

4/10/2013

55

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64

Location

Defect

Rating Classif. A B B A B B A A A A B A A A B A B B A B B B B B B B B B B

Date Rectified

Date Checked

Comments

Corridor Vestibule B/C 18/19 S3E.06 Seal wall where small pipe passes through North Wall both sides Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Corridor Vestib B/C 18/19 S3E.06 Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal openings between Fire Hose reel (FHE) door frame and blockwork all round Remove masking tape to FHE Door panel frames Remove paint on door to FHE Make good door cill inside FHE Seal pipe holes Two (2) in ceiling slab Inside this duct the two wall to the HVAC shafts have not been installed and require to be executed Wall to RH side of FHE is not complete at the upper level and needs to be completed Clean out building debris and remove Seal to HVAC vent at slab Install access cover and frame to Dry Riser Outlet Provide Type C connection to Dry Riser Floor tiling is uneven and needs to be levelled and repolished Seal wall to South Wall where small pipes passes through Make good skirting to RH side of Door South Make good hole above Upper Fire Damper Grille Fire Damper Door Upper fouls the Running Man sign and RMS to be relocated Clean paint stains on Fire Damper Upper Grille Make good hole above Lower Fire Damper Grille Refit grille door to Lower Fire Damper Panel Make good hole at conduit above Fire Damper and at Light Fitting on ceiling Make good skirting to LH side of Door North Make good skirting to RH side of Door North Make good at slab ceiling near Door North for conduit entry to light switch Remove paint from skirting top edges throughout Provide angle steel threshold step to Door North and paint with black and yellow diagonal stripes Provide angle steel threshold step to Door South and paint with black and yellow diagonal stripes Fire/Smoke threshold seal required to entry door South Fire/Smoke threshold seal required to entry door North

4/10/2013

56

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Location Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17 Storage Area S3E.17

Defect Prepare and paint ceiling Prepare and paint walls Prepare and paint floor Install fluorescent light with light switch and conduit Install smoke detector with cable etc. Install skirting Make good formwork fixing holes twenty four (24) to concrete walls Repair temporary bulkhead lining above entry door and seal Remove paint and cement to Door and Frames Outer handle is loose and needs to be replaced with permanent handle Inner handle is damaged and to be replaced Intumescent strip is not complete to RH door jamb frame and to be replaced Intumescent strip to LH door jamb is missing and to be installed Intumescent strip to head frame is missing and to be installed Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door Install door closer to Door Door does not close properly and to be reset Install sprinkler with pipework etc. Door signage Fire/Smoke seal threshold required to entry door

Rating Classif. B B B A A B B B B B B A A A B B A B A B A B A

Date Rectified

Date Checked

Comments

4/10/2013

57

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

Location Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07 Egress Stair S3E.07

Defect Replace one (1) chipped stair step Clean down steps of dirt marks, concrete etc complete Floor tiling to mid landing is uneven and to be levelled and resealed/polished Floor tiling to stair floor is uneven and to be levelled and resealed/polished and insert missing grout between some tiles Clean light to mid landing and make good to three (3) loose plastic fixing lugs Change one of the fluorescent tubes as they are different colours Make good to damaged wall at mid landing to stair divider wall Make good debonded skirting at mid landing to stair at divider wall Make good holes in wall to RH of lower stair flight at sixth (6th) step Insert Stair Pressurization Grille etc. to Base landing Remove paint from Running Man Sign Clean Light Fitting at Base Level Make good to wall at conduit above entry base door Remove paint to Base Entry Door and Frames Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to LH and RH door jambs is not complete at bases and to be replaced Intumescent strip to head frame is missing and to be installed Remove all protective covering that remains Fix missing strike plate to open door jamb Fix missing door handles Install door stop to Door Install door closer to Door Remove manufacturer's labels on door surface Door signage Remove paint from top edge of skirting to floor, landings and stairs Fire/Smoke seal threshold required to entry door

Rating Classif. B B B B B B B B B A B B B B B B A A A B B B B A B B B

Date Rectified

Date Checked

Comments

4/10/2013

58

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Location ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11 ALA Vestibule S3E.11

Defect Prepare and paint floor Remove general cement grout from all conduits Insert proper support holdfasts to sprinkler pipe installation Make good to conduit on wall near entry door that has been flattened by the application of another conduit Electrical junction box has two references deleted and is not identified Running Man Sign is squint and to be levelled Remove timber formwork to entry door soffit and make good Fill in wall hole to LH of West Wall Paint wall where repairs carried out Floor wet - investigate and resolve source Remove four (4) nails in wall above entry door and make good Paint wall in two areas behind and around wall fixed conduits Remove all loose tape from ceiling soffit Paint ceiling Electrical Cabinet TACA-E install missing cover plates internally Make good wall above door to Main ALA Room Make good to three (3) holes in wall to Main ALA Seal conduit holes two (2) no to LH side of door to Main ALA

Rating Classif. B B A B B B B B B B B B B B A B B B

Date Rectified

Date Checked

Comments

4/10/2013

59

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Location ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12 ALA SHELTER S3E.12

Defect Make good to two (2) areas of honeycombed wall to RH of Main Entry Door and repaint Clean up conduit generally of cementitious grout ALA Vent. Machinery is sitting on a 'bodged up' pile of timber cross sticks and needs a proper concrete or metal base Paint floor under ALA vent machinery it metal trestle support is provided Running Man sign is squint and to be levelled Make good to hole above Running Man Sign Paint Wall between A-C 23 Make good to honeycombed wall on Wall D 21/22 North and repaint Clean out debris in wall holes to vestibule Make good to formwork fixing holes (5 No) on wall D21 - C22 and repaint Paint floor throughout Remove red paint stains on walls On first fin wall remove hole stuffed with paper make good and repaint Remove timber packer at wall head on fin walls No 4 and make good Make good to hole at high level above third opening in finwall and repaint Remove loose tape on ceiling Make good hole in centre of main ALA ceiling and repaint Make good to small pipe passing through wall above entry door of Main ALA Make good door jamb returns all round to Main ALA entry door and repaint

Rating Classif. B B A B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

60

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10

Defect Water leaks as water all over the space - investigate and dry out Remove all MET and builder's debris Change labels to Electrical control box to RH of entry door on West Wall as wrongly applied Make good to three (3) holes on West wall including one conduit pipe and repaint Make good to three (3) pipes hole in ceiling next to West Wall and repaint Make good to three (3) formwork fixtures holes in west wall and repaint Make good to ten (1) formwork holes in North Wall and repaint Remove steel rod in northwest corner near floor and make good Clean out central drain gully Paint gulley drain grating Connect or remove two wires that are unconnected near pump motors on North Wall Install all equipment and flow labels throughout Make good to ceiling slab at sprinkler pipe main supply Make good hole in southwest corner to conduit and cables and repaint Make good hole in southwest corner to SVP pipe and repaint Clean dirt and debris in Electrical Unit TPI9E Provide handrail to steel stair to level above Make good to North Wall where SVP pipes passes through towards East Wall Paint Floor Paint ceiling Connect or remove loose wire on north wall that is unconnected Remove six (6) nails to northeast corner and make good Provide the fixing screws to eight (8) control boxes on North Wall Complete conduit cable connections on North Wall Paint rusting baseplate to pumps on east side of room Make good around ceiling opening to access ladder Remove two (2) nails at access ladder ceiling opening and make good Remove steel fixing plate at access ladder opening and make good Make good concrete mound at southwest corner which is an eyesore Remove highspot in floor slab to RH of Entry Door and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected

Rating Classif. A B A B B B B B B B A A B A B B A B B B A C B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

61

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50

Location Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10 Fire Pump Room S3E.10

Defect Intumescent strip to LH and RH door jambs is not complete at bases and to be replaced Clean out frames at door base Remove all protective covering that remains Fix missing strike plate to open door jamb Fix missing door handles Install door stop to Door Install door closer to Door Remove manufacturer's labels on door surface Make good threshold concrete to room as uneven and rough Seal door frame all round Make good to small hole in wall to the right hand side of the door entry Make good to rough door lintol soffit at RH side Remove paint on door and frames Fire Fighting equipment is missing Door Signage Fire/Smoke seal threshold required to entry door Fire Alarm to be installed

Rating Classif. A B B A A B B A B B C B B A B A A

Date Rectified

Date Checked

Comments

W4A to advise W4A to advise

4/10/2013

62

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

Location Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08 Service Corridor SE3.08

Defect Remove two pieces of wire above door to Fire Pump Room and make good Remove paint and cement to conduit to left and above door to Fire Pump Room Remove timber formwork left in hole formed in southeast corner at ceiling level and make good Seal duct hole at ceiling level in southeast corner and make good both sides Remove six (6) nails left in ceiling slab near entry to Fire Pump Room and make good Paint ceiling Seal large hole in wall to southwest corner with extract duct and tray and make good Make good hole to LH side of entry door to Fire Pump Room at high level Make good to wall where flexible conduit passes through and repaint Remove paint on black flexible conduit at high level on splay wall B22 to A23 Make good to wall to LH side of entry door to Fire Pump Room and repaint Remove paint on conduit at entry door RH to Car Park Area and along ceiling Remove cement and paint on conduit at high level running along wall to Annex Room S3E.09 Clean all three (3) lights fixed as bulkheads to wall Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to LH and RH door jambs is not complete at bases and to be replaced Clean out frames at door base Remove all protective covering that remains Remove metal shim between frame and sub-frame near door strike plate Fix missing door handles Install door stop to Door Install door closer to Door Remove manufacturer's labels on door surface Seal door frame all round Remove paint on door and frames Door Signage Fire/Smoke seal threshold required to entry door Fire Alarm to be installed

Rating Classif. B B B A B B A B B B B B B B B B A A B B B A B A B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

63

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Location Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09 Annex S3E.09

Defect Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to LH and RH door jambs is not complete at bases and to be replaced Clean out frames at door base Remove all protective covering that remains Intumescent strip is loose on head frame and to be refixed Fix missing door handles Install door stop to Door Install door closer to Door Remove manufacturer's labels on door surface Replace damaged strike plate Remove cement and paint on door and frames Intumescent strip is short on head frame to hinge jambs Remove four (4) nails in ceiling near south wall and make good Seal rectangular hole in West wall at high level Complete paint to wall near cable trunking on West Wall Make good to hole at high level on West wall near cable tray Paint West wall where timber plate removed Remove three nails on East Wall and make good Tidy up seal to small pipe at East Wall above where timber batten removed Remove red paint daubs to walls Finish paint missing at various parts of the ceiling Generally touch up walls where paint poor or missing Repaint wall and ceiling at wall/ceiling junction the proper colours Seal rectangular hole in East wall at high level in south east corner of room Make good to wall where conduit and light switch box has been relocated to RH of entry door and repaint Make good to six (6) formwork fixtures holes and repaint Clean Two (2) ceiling lights Make good to ceiling above entry door and repaint Remove paint etc to conduits to Rah side of entry door including the switch boxes and plates Refix conduit black flexible to Fire Detector as 'wavy' Door signage Fire/Smoke seal threshold required to entry door

Rating Classif. B B A A B B A A B A B A B A B B B B B B B B B B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

64

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area

Defect Make good ceiling around SVP at corner A22 including underside of slab Remove concrete dropping to SVP pipe and generally clean up A22 Provide impact Protection to SVP Pipe A22 Provide impact protection to SVP Pipe A20 Provide impact protection to SVP Pipe A18 Provide impact protection to SVP Pipe A16 Provide impact protection to SVP Pipe A14 Provide impact protection to SVP Pipe D14 Provide impact protection to SVP Pipe D16 Provide impact protection to SVP Pipe D18 Provide impact protection to SVP Pipe D20 Provide impact protection to car exhaust extracts A22 LH Provide impact protection to car exhaust extracts A21 RH Provide impact protection to car exhaust extracts A21 LH Provide impact protection to car exhaust extracts A20 RH Provide impact protection to car exhaust extracts A20 LH Provide impact protection to car exhaust extracts A19 RH Provide impact protection to car exhaust extracts A19 LH Provide impact protection to car exhaust extracts A18 RH Provide impact protection to car exhaust extracts A18 LH Provide impact protection to car exhaust extracts A17 RH Provide impact protection to car exhaust extracts A17 LH Provide impact protection to car exhaust extracts A16 RH Provide impact protection to car exhaust extracts A16 LH Provide impact protection to car exhaust extracts A16 LH Provide impact protection to car exhaust extracts A15 RH Provide impact protection to car exhaust extracts A15 LH Provide impact protection to car exhaust extracts A14 RH Provide impact protection to car exhaust extracts A14 LH Provide impact protection to car exhaust extracts A13 LH Provide impact protection to car exhaust extracts Column C19 Provide impact protection for car exhaust extract Column B19 Provide impact protection for car exhaust extract Column B13

Rating Classif. B C A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A

Date Rectified

Date Checked

Comments

W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise

4/10/2013

65

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area

Defect Provide impact protection to water supply pipe Column A 20 Provide impact protection to water supply pipe Column A 18 Provide impact protection to water supply pipe Column A 16 Provide impact protection to water supply pipe Column A 14 Provide impact protection to water supply pipe Column D 20 Provide impact protection to water supply pipe Column D 18 Provide impact protection to water supply pipe Column D 16 Provide impact protection to water supply pipe Column D 14 Clean out void between Column Walls A 12 and 13 Clean out void between Column Walls D 12 and 13 Provide impact Protection to CO Warning Sign A 12 Provide impact Protection to CO Warning Sign D 12 Provide impact Protection to CO Warning Sign A 17 Provide impact Protection to CO Warning Sign D 17 Clean out floor drain near D20 Paint floor drain grating near D 20 Clean out floor drain near D18 Paint floor drain grating near D 18 Clean out floor drain near D16 Paint floor drain grating near D 16 Clean out floor drain near D14 Paint floor drain grating near D 14 Clean out floor drain near A20 as blocked with water inside Paint floor drain grating near A 20 Clean out floor drain near A18 Paint floor drain grating near A 18 Clean out floor drain near A16 Paint floor drain grating near A 16 Clean out floor drain near A14 Paint floor drain grating near A 14 Clean concrete group to SVP Pipe at Column A18 Seal hole in ceiling slab at SVP pipe at Column A18 Provide proper support to car exhaust duct which is unstable at A22

Rating Classif. A A A A A A A A B B A A A A B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise

W4A to advise W4A to advise W4A to advise W4A to advise

4/10/2013

66

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99

Location Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area

Defect Provide impact protection to wall mounted ventilation unit near Column D14 Provide pipe sleeve to SVP pipe at Wall A/B 22 and make good Seal Wall A/B 22 where three (3) conduits pass through wall at high level and make good Seal opening above door to Corridor S2E.08 and make good to both sides Seal around conduits on Wall A/B 22 to RH of door to Service Corridor S2E.08 Make good insulation to several pipes that have been damaged and repaired with black tape in A/B 21/22 Area Clean off red paint marks on grille to Car Exhaust ducting in B21/22 Clean Floor of stain and paint in A/C 21/22 Ducts not built in C21 but shown on drawings Provide impact protection to wall mounted ventilation unit near Column D20 Provide impact protection to Running Man Sign on column D 20 Provide impact protection to Running Man Sign on column B 20 Provide impact protection to Running Man Sign on wall C18 Provide impact protection to Running Man Sign on wall B18 Provide impact protection to Running Man Sign on wall B15 Provide impact protection to Running Man Sign on wall C14 Make good leak between A21 and A22 and repaint wall Make good leak at D 12/13 and repaint wall Make good to hole in slab around SVP between A 21/22 Make good to small hole in splay wall between C21 and B22 Make good to splay wall C21/B22 around SVP pipe entry Make good hole to several pipes between B/C 21/22 and remove acrow props that have no warning sign on a main access At C21 make good hole in slab ceiling for Fire Sprinkler supply pipe Realign sprinkler pipes in Area A 20/21 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column A20 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column A16 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column A14 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column D16 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column D18 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column D20 Install operator signage to Fire Alarm Button at wall C17 and remove paint Install operator signage to Fire Alarm Button at wall B17 Install operator signage to Fire Alarm Button at wall B14

Rating Classif. A B B A B B B B A A A A A A A A B B B B B A B B B B B B B B A A A

Date Rectified

Date Checked

Comments W4A to advise

W4A to comment and advise W4A to comment and advise Should this sign be on C20 ? W4A to comment and advise W4A to comment and advise W4A to comment and advise W4A to comment and advise W4A to comment and advise

W4A to advise

4/10/2013

67

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132

Location Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area

Defect Install operator signage to Fire Alarm Button at Wall D15 Take out temporary electrical supply wire including making good to slab soffit and floor when removed at Wall BC 14 Make good to ceiling slab at water pipe at Column A 18 Realign sprinkler pipework in Area A 17/18 as not level or straight Replace twisted or distorted hangers to sprinkler installation in Area A 17/18 Carbon Monoxide System Warning sign on Column A 17 to be placed vertical Make good to low floor area with water 'ponding' near Area A/B 14/15 Make good to base of column A14 Make good to wall at previous leak between A 13/14 Make good to low floor area with water 'ponding' near Area C/D 13/14 Make good to low floor area with water 'ponding C/D 17/18 Sprinkler handles in D 13/14 are accessible to the General Public and need to be protected Sprinkler pipework in Area D 13/14 to be levelled and realigned properly Remove 150mm piece of timber in wall head at D 14 and make good all round Make good hole in ceiling at water pipe at Column D14 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column D14 Make good conduit connection to Car Exhaust Grille near Column D14 which is not complete Paint floor between Electrical Closet S2E.17 and Telephone Closet S2E.16 Make good to base of column D 14 and repaint as required to floor Make good around SVP pipe at ceiling slab and floor at Column D16 Make good to low area to RH of Column Wall D17 with water 'ponding" Make good to ceiling slab around white water feed pipe to Sewage Pump Station Level -3 Clean down cement stains on SVP pipe at Column D18 Remove 60mm Black pipe and make good holes to floor and ceiling slab etc. at Column D18 Realign and level sprinkler pipe installation between D 19/20 Warning notice required in area near Column A22 as the clearance height is 1.92 metres Warning Notice needed in Car Park Area B 21/22 as pipes are set at a clearance height of 2.07 metres Warning Notice needed in Car Park Area B/C 21 where pipes are at a clearance height on an access street of 2.07 metres Warning notice needed in Car Park Area B/C 21 as clearance height is 1.87 metres Warning notice needed in Car Park Area A/B 22 at pipe as clearance height is 1.90metres Warning notice needed in Car Park Area B 21/22 as two pipe supports have a clearance height of 1.97metres Make good wall leak between A 20 and 21 and repaint wall Carbon Monoxide signs (4 No) to also have warning in English

Rating Classif. A B B B B B B B B B B A B B B B A B B B B B B B B A A A A A A B A

Date Rectified

Date Checked

Comments

W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise

4/10/2013

68

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165

Location Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area

Defect Make good flexible conduit connections to CCTV Camera A21 Make good flexible conduit connections to CCTV Camera B18 Make good flexible conduit connections to CCTV Camera B14 Make good flexible conduit connections to CCTV Camera A12 Make good flexible conduit connections to CCTV Camera D12 Make good flexible conduit connections to CCTV Camera C14 Make good flexible conduit connections to CCTV Camera C18 Make good to white water pipe at ceiling D18 Complete conduit connection to CO Warning Sign A 12 Complete conduit connection to CO Warning Sign D 12 Complete conduit connection to CO Warning Sign A 17 Complete conduit connection to CO Warning Sign D 17 Make good painting to black and yellow threshold strip Service Elevator Vestib. Make good painting to black and yellow threshold strip Corridor B14/15 South. Make good painting to black and yellow threshold strip Corridor C14/15 North Make good painting to black and yellow threshold strip Corridor B17/15 South. Make good painting to black and yellow threshold strip Corridor C17/18 North Tidy conduit connections to control panel for Sewage Pumping Station D17/18 Make good large rectangular hole in ceiling slab to LH of Column D 19 Make good to wall paint near six gang wall switch where missing to LH of Door to Corridor S2E.03 South side Remove red paint stains to wall at duct next to Column D 19 Make good to slot hole at high level to RH of Wall Column D 19 Seal water pipe at floor level to Column D20 and make good to floor paint Seal holes around three pipes at high level on external wall between D20/21 Make good wall paint to RH of Wall Column D 21 on external wall Make good to all door jamb return to Storage Vestibule S2E.14 Seal holes to four (4) conduits at wall head to Storage Vestibule S2E.14 Make good to formwork fixing holes three (3) no on wall to Storage Vestibule S2E.12 Make good to formwork fixing holes four (4) no on wall return C21 near Storage Vestibule S2E.12 Make good honeycombing to wall return C21 near Storage Vestibule S2E.12 and repaint Make good to bulkhead panel above door to Storage Vestibule S2E.12 Seal wall at high level on wall to Storage Vestibule S2E.12 to pipes and conduits complete Make good to small hole at C14 North (Stair) and repaint

Rating Classif. B B B B B B B B B B B B B B B B B B A B B B B B B B B B B B A A B

Date Rectified

Date Checked

Comments

4/10/2013

69

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198

Location Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area Basement -2 General Area

Defect Make good to two (2) pipes at high level to LH of wall B/C 14 Seal pipe on Wall B 14/15 at high level to LH of Door to Stair Vestibule S2E.03 Seal holes to conduit and pipes above Door to Stair Vestibule S2E.03 on Wall B14/15 Make good joint with floor around Column A14 and repaint as required Seal hole at high level on Wall B 14/15 to RH of door to Stair Vestibule S2E.03 Remove paint on conduit near door to Stair Vestibule S2E.03 on Wall B 14/15 Provide impact protection to Car Exhaust duct between B/C 15 Make good around four pipes and conduits at high level on Wall B/C 15 Remove Steel rod above Door to Stair Vestibule S2E.03 on Wall C 14/15 Make good around two conduits on Wall C 14.15 at high level to LH of door to Stair Vestibule S2E.03 Seal pipe at high level to Service Elevator Enclosure LH of door on Wall C 14/15 Clean conduit to Fire Alarm near C18 Make good to four (4) small holes in ceiling slab at Corner C 18 Make good to three (3) formwork fixing holes to Wall C17/18 Make good to wall head on Wall C 17/18 Clean conduit of paint and cement stains in the area around the Door to Stair Vestibule S2E.06 Seal conduit hole on Wall C17/18 to RH of door to Stair Vestibule S2E.06 Seal two (2) formwork fixing holes on Wall C17/18 to right of Stair Vestibule S2E.06 door Seal wall at two (2) conduits and two (2) pipes above door to Elevator Lobby S2E.01 on Wall C 16/17 Make good to edges and joint to ceiling and floor to duct lining at wall B/C 16/17 to Elevator Lobby S2E.01 Make good and seal to pipe at high level to Wall to Elevator Lobby S2E.01 Wall B/C 16/17 Make good and seal at high level to two (2) conduits to Wall B 14/15 to Stair S2E.04 Fire Fighting equipment is missing Remove red paint on wall near floor B 16/17 and repaint Realign socket outlet on Wall B16/17 Make good to wall and floor at floor level to left of South Door to Elevator Room S2E.01 and repaint Parking Bay lines missing to Bay A 21/22 Parking Bay lines missing to Bay A 20/21 Parking Bay lines missing to Bay A 19/20 Seal hole in Wall BC 21 and make good Clean paint of conduit on RH of Wall BC 21 Wall B 17/18 Remove paint on six gang wall light switch Remove HVAC ducting near Store Area S2E.15

Rating Classif. B B B B B B A B B B B B B B B B B B B B B B A B B B B B B B B B B

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

70

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

Location Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04 Egress Stair S2E.04

Defect Clean light at Landing -2 Paint divider wall where defaced with graffiti Clean light fitting on landing that is covered in paint etc. Landing tiles are uneven and need to be levelled and repolished Stair are badly stained and need deep cleaned and repolished Floor tiling at -2 is uneven and needs levelled and repolished Fix conduit to Fire Detector which is improperly fixed Remove paint on Running Man sign Remove paint from door and frames Fix permanent handles to doors and make good Remove protective covering that remains on door Intumescent strip is not complete to hinge frame base and loose in some areas Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop Install door closer Remove paint stains to top edges of skirting to landing and stairs throughout Intumescent strip is not complete to lock frame base and loose in some areas Door Signage Fire/Smoke Threshold seal is required to door

Rating Classif. B B B B B B B B B B B A B B A B A B A B A

Date Rectified

Date Checked

Comments

4/10/2013

71

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03

Defect Remove paint to South Door and Frames Fix permanent handles to door South and make good Intumescent strip is not complete to both frame bases of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Install door closer to Door South Replace damaged door prong receiver in door frame Seal two (2) holes in wall through which pipes/conduit pass (South) Refix steel conduit with proper fixings to Light Switch near Door South Install switch plate to light switch South as currently the wires are unprotected Clean conduit to light switch (south) of paint etc Running Man sign obstructs the sprinkler head in operation mode and needs to be reviewed Carbon Monoxide Warning sign obstructs the operation of the sprinkler head and requires to be relocated Carbon Monoxide sign to have English Warning Clean paint etc from two (2) light fittings Clean paint of grille to Fire Damper Grille (Upper) Clean paint of grille to Fire Damper Grille (Lower) Make good round Fire Damper Grille panel (Lower) Make good round Fire Damper Grille panel (Upper) Provide proper locking device to Lower Fire Damper Grille Provide proper locking device to Upper Fire Damper Grille Refix switch plate to light switch near North Door Refix steel conduit with proper fixings to Light Switch near Door North Remove paint from conduit near Door North Fix permanent handles to door North and make good Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Install door closer to Door North

Rating Classif. B B A B B A B A B B A A B A A A B B B B B B B A A B B A B B A B A

Date Rectified

Date Checked

Comments

South Door

Door North

4/10/2013

72

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67

Location Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03 Stair Vestibule S2E.03

Defect Clean paint of door fames to Door North Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal openings between Fire Hose reel (FHE) door frame and blockwork all round Remove masking tape to FHE Door panel frames Remove paint on door to FHE Make good door cill inside FHE Seal pipe holes Two (2) in ceiling slab Inside this duct the two walls to the HVAC shafts have not been installed and require to be executed Wall to LH side of FHE is not complete at the upper level and needs to be completed Tidy up blockwork above door and generally Make good hole and remove two screws above Fire Hose reel Enclosure and repaint Install access cover and frame to Dry Riser Outlet Provide Type C connection to Dry Riser Seal in FHE to vent HVAC at slab level ceiling Remove paint to top edges of skirting throughout Paint ceiling Screw in fixing screws to Carbon Monoxide sign that protrude Door pivot screws to head and cill of Fire Hose reel Door to be fully driven Make good at threshold to North Door Repaint black/yellow threshold plate to South Door and remove masking tape Refix black/yellow threshold plate to South Door as not even Repaint black/yellow threshold plate to North Door and remove masking tape Refix black/yellow threshold plate to North Door as not even Floor tiling is uneven and requires to be levelled and resealed and repolished Fix skirting to LH of Door South Seal wall at ceiling level for conduit in Southeast corner Seal Conduit on East Wall Make good to holes in ceiling at southwest corner Make good to hole in ceiling for light switch conduit (south) Make good to hole in ceiling for light switch conduit (north) Make good holes for conduit and sprinkler pipe above and RH of North Door Fire/Smoke Threshold seal is required to door North Fire/Smoke Threshold seal is required to door South

Rating Classif. B B B A B B B A A A B B A A A B B B B B B B B B B B B B B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

73

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05 Service Elevator Vestibule SE2.05

Defect Paint ceiling Fit permanent door handles Intumescent strip is short at bases to both jambs and requires to be replaced Fill in hole to door head frame Seal hole to door bulkhead where pipes pass through Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Remove red paint daubs on walls Intumescent strip to meeting style of doors is not the full length and requires to be replaced Seal conduit hole above Door North Seal hole for sprinkler pipe above Door North Skirting is fixed with panel pins and requires to fixed with adhesive or better Make good paint work to LH side of Service Lift Frames Install door stops to Doors Clean paint off Service Lift Door Frames Clean paint off service lift call and indicator wall panels Remove all protective covering from Lift Doors Clean light fitting of paint and dirt inside Seal conduit hole at ceiling level Install selector and door closers Remove paint to door frames Relocate sprinkler head at abutting to the soffit of the ceiling which will reduce its effectiveness in the area Seal conduit at high level on East Wall Remove paint to Arrow Indicator Lift panel Make good to floor subsidence near duct to LH side of North Door and repaint etc. Fix dome covers to four (4) screws to grille in duct to northwest corner Carbon monoxide signage to also be in English Refix black/yellow threshold angle Repaint black/yellow threshold angle Remove masking tape on floor near threshold angle Door Signage Fire/Smoke Threshold seal is required to door North

Rating Classif. B B A B B B B A B A B B B B B B B B B B A B A B B B B A B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

74

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32

Location Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16 Telephone Closet S2E.16

Defect Prepare floor to be level Paint floor Seal wall hole (East Upper) where conduit tray passes through into Car Park Area Seal wall hole (West Upper) where conduit tray passes through into Car Park Area Provide and install closure screws to four (4) control boxes on west wall Clean all paint and cement grout of conduits Connect or remove two (2) unconnected wires in Lower box in southwest corner Clean light fitting Make good joint between wall and floor Remove concrete snots etc to wall and paint completely Remove writing on door Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is not complete to open jamb with much missing Intumescent strip is loose on the hinge jamb and short at base and pivot guard Install permanent door handles Install door stop Install door closer Clean threshold plate and paint Paint ceiling Door Signage Remove cement and paint on door frames and intumescent strip Remove all protective covering to door Make good to bodged up cable duct at high level in southwest corner Make good to outlet box to RH of door outside Tighten up screws to grey box on North wall Replace broken lock turn on Electrical Cabinet TFIC-E Seal off opening in bottom panel inside Electrical Cabinet TFIC-E Replace top panel due to badly cut opening for flexible conduit in Electrical Cabinet TFIC-E Remove reinforcement rod to upper RH side of door and make good Fire/Smoke Threshold seal is required to door

Rating Classif. B B A A C C A B C C B B B A A A B B A B B B B B B A B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

75

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31

Location Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17 Electrical Closet S2E.17

Defect Prepare floor to level Paint floor Clean door frames of paint and cement droppings etc. Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is not complete to hinge frame of door Intumescent strip is not complete to door head frame and loose Install permanent door handles Install door stop Install door closer Clean threshold plate and paint Clean out cement etc at door frame bases Clean paint and cement on door Intumescent strip to open jamb of door is incomplete Remove all remaining protective covering to door Make good and seal to West Upper Wall at cable tray Make good and seal to East Upper Wall at cable tray above door Clean paint etc off light fitting Make good wall to external to RH side of entry door and repaint Clean conduits to light switch and IT point and at high level on east wall Remove red paint on light switch Prepare wall and paint Paint ceiling Make good joint between wall and floor throughout Door to Electrical Panel SBS-2E is squint and to be re-aligned Investigate water leak at wall below Cabinet SBS-2E and make good including any repainting Electrical Cabinet TLB2-E make better fixing of flexible conduit internally. Electrical Cabinet TLB2-E door to be refitted as it does not close properly due to protrusion internally Door signage Fire/Smoke Threshold seal is required to door

Rating Classif. B B B B B A A A B B A B B B A B A A B B B C B B B B A B A B A

Date Rectified

Date Checked

Comments

4/10/2013

76

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01

Defect Socket Outlet externally on Wall B16/17 to LH of door south has unconnected wires and no plate Fixing screws to frame protrude and are to be refixed to Double Door South Cover four (4) protruding screw ends in angle plate to top corners to Double Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is not complete to both frame bases of Door jambs Replace keeper to slip bolt to inner door leaf in head frame as damaged Install permanent door handles Door South Install door stops to Double Door South Install door closers and selector to Door South Inner door of leaf has a play when closed and requires to be adjusted Remove all protective covering to Double Door South Clean up lock plate on door south Remove paint stains on Door Frame (South) Make good to rectangular hole in head frame Door South Fixing screws to frame protrude and are to be refixed to Double Door North Cover four (4) protruding screw ends in angle plate to top corners to Double Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Adjust inner leaf door as there is play in the closed position Remove red paint stains on North door and frames Remove wall paint on North door frames Install permanent door handles on Double Door North Install door stops to Double Door North Install door closers and selector to Double Door North Remove red paint on floor finish near Door South Remove all remaining protective covering to Door North Intumescent strip to meeting stile to Door North is incomplete at lock striking plate Make good to rectangular hole in head frame Door North Replace damaged skirting on East wall Replace damaged skirting to North Wall Refix skirting with proper fixing system and remove panel pins throughout Fix missing skirting on both sides of door to Storage Room S2E.20 Paint ceiling Realign socket outlet on South wall

Rating Classif. A B B A A A B B A B B B B B B B A B B B B B A B B A B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

77

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65

Location Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01 Elevator Lobby S2E.01

Defect Make good to ceiling where rebar reinforcement is exposed and seal completely near Door South Make good to two large ducts on upper LH side of Wall B16/17 Seal to conduit on Wall B16/17 near ceiling to RH of door Seal to pipe above Door South on Wall B16/17 Sprinkler pipe installation to be tidied up and holders set straight Clean two (2) light fittings of paint and dirt inside Make good square hole in ceiling near south wall Remove nail in ceiling and make good Remove two wires in ceiling near south door and make good Make good to ceiling to RH side of North Wall C 16/17 at ceiling Seal wall at conduit in North Wall on LH side C 16/17 Seal North Wall above door where two sprinkler pipes pass through and repaint Remove paint to frames of lift shaft doors Clean lift shaft threshold plate from cement and paint stains etc Carbon Monoxide Warning to also be in English Tighten up all loose screws to Carbon Monoxide sign Seal West Wall at ceiling level where conduit passes through on LH side Seal West Wall at ceiling level where conduit passes through on RH side Angle steel threshold step to Door North to be refixed and painted with black and yellow diagonal stripes Angle steel threshold step to Door South to be refixed and painted with black and yellow diagonal stripes Door Signage South Door Signage North Remove paint stains on Door South Make good and adjust to door leaf outer on Door South as its is scraping along the floor Seal West Wall at where small pipe passes through on RH side Make good subsidence/damage to wall/floor on West Wall and repaint as required Clean paint of both lift panels call and indicator to RH side Infill sinking to storage area door and repaint floor Make good to dent in Door South on Car Park side Fire/Smoke Threshold seal is required to door North Fire/Smoke Threshold seal is required to door South Replace broken light fitting

Rating Classif. B B B B B B B B B B B A B B A B B B B B B B B B B B B B B A A B

Date Rectified

Date Checked

Comments

4/10/2013

78

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Location Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07 Egress Stair SE2.07

Defect Remove paint conduit to fire detector Clean down steps of dirt marks, concrete etc complete Floor tiling to mid landing is uneven and to be levelled and resealed/polished Floor tiling to stair floor at -2 is uneven and to be levelled and resealed/polished and insert missing grout between some tiles Clean red paint daubs on stairs Replace four (4) chipped steps Clean light fitting at mid landing Remove paint from Running Man Sign Clean Light Fitting at Base Level Remove paint to Base Entry Door and Frames Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to LH and RH door jambs is not complete at bases and to be replaced Remove remaining protective covering to doors Fix missing strike plate to open door jamb Install permanent door handles Install door stop to Door Install door closer to Door Remove manufacturer's labels on door surface Door signage Fire/Smoke Threshold seal is required to door Remove paint on top edge of skirting throughout including steps

Rating Classif. B B B B B B B B B B B B A A B A B B A B B A B

Date Rectified

Date Checked

Comments

4/10/2013

79

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06

Defect Remove paint and cement to South Door Frames Fix permanent handles to door South and make good Intumescent strip is not complete to both frame bases of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Install door closer to Door South Remove remaining parts of the protective covering to door South Remove red paint on door South Paint ceiling Remove red paint stain on floor tiling near Door North Running man sign is set at an angle and requires to be relocated Running Man sign obstructs the sprinkler head in operation mode and needs to be reviewed Carbon Monoxide sign to have English Warning Remove paint from skirting Clean paint etc from two (2) light fittings Remove red paint stains from wall generally Make good round Fire Damper Grille panel (Lower) Make good round Fire Damper Grille panel (Upper) Provide proper locking device to Lower Fire Damper Grille Provide proper locking device to Upper Fire Damper Grille Clean paint off grille to Fire Damper panel (Lower) Clean paint off grille to Fire Damper panel (Upper) Replace missing Hydrant Cover Light sign Clean paint and cement off door Frame to Door North Fix permanent handles to door North and make good Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Install door closer to Door North

Rating Classif. B A A B B A B A B B B B B A A B B B B B B B B B A B B A B B A B A

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

80

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06

Defect Remove remaining parts of the protective covering to Door North Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hose reel (FHE) door frame and blockwork Remove masking tape to FHE Door panel frames Tidy up and seal blockwork to head of door frame and make good Make good door cill inside FHE Seal pipe holes Two (2) in ceiling slab Inside this duct the two walls to the HVAC shafts have not been installed and require to be executed Seal wall to LH side of FHE is not complete at the upper level and needs to be completed Replace faulty lock to FHE Door Seal to HVAC vent at slab Install access cover and frame to Dry Riser Outlet Provide Type C connection to Dry Riser Floor tiling is uneven and needs to be levelled and repolished Lower fire hose reel valve is fouled by the threshold of the door and needs to be relocated Upper hosereel is fouled by the door head and requires to be relocated Fit pivot lower screw into the frame properly Seal hole above door South and repaint Seal hole in southeast corner and repaint Seal hole to South Wall where conduit passes through wall and repaint Seal hole in South wall where sprinkler pipe passes through and repaint Seal on West wall at southwest corner at ceiling level and repaint Make good rough joint between wall and ceiling on East wall and repaint Replace broken light switch box near Door South Clean paint on conduit near South Door Remove paint from skirting top edges throughout Provide angle steel threshold step to Door North and paint with black and yellow diagonal stripes Provide angle steel threshold step to Door South and paint with black and yellow diagonal stripes Make good to external concrete step at Door North Install threshold plate to Door South Install threshold plate to Door North Remove tape to angle threshold frame outside Door South

Rating Classif. B B B A B B A A A A A A A A B A A B B B B B B B A B B B B B A A B

Date Rectified

Date Checked

Comments

4/10/2013

81

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 67 68 69 70 71 72 73 74 75 76 77 78 79

Location Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06 Stair Vestibule SE2.06

Defect Remove tape to angle threshold frame outside Door North Make good to concrete step at Car Park Door South and repaint Make good at ceiling on West Wall near South door and repaint Make good at ceiling on West Wall near North door and repaint Make good on West Wall near ceiling at mid point where two (2) conduits pass through and repaint Make good to West wall where sprinkler pipe passes through and repaint Provide more support hangers to sprinkler pipework in space and tidy up generally Make good hole in ceiling in northeast corner for conduit and repaint Repaint area of repair above Door North Make good skirting to LH of Door North Make good to skirting to RH of Door South Fire/Smoke Threshold seal is required to door North Fire/Smoke Threshold seal is required to door South

Rating Classif. B B B B B B B B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

82

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29

Location Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25 Storage S2E.25

Defect Ceiling light to be installed and light switch Fire Detector to be installed Sprinkler installation required Paint walls Paint ceiling Prepare, level and paint floor Make good joint between floor and walls all round Remove temporary broken light and wires on East Wall Make good to two (2) formwork fixtures holes on East Wall Make good to eight (8) formwork fixtures holes on North Wall Make good to eight (8) formwork fixtures holes on West Wall Make good to six (6) formwork fixtures holes on South Wall Remove steel reinforcement rods on South Wall near ceiling and make good Seal to small dia. Pipe on West Wall to RH of door Repair temporary bulkhead lining above entry door and seal Remove paint and cement to Door and Frames Replace with permanent handle Remove remaining protective covering to door Intumescent strip is not complete to LH hinge door jamb frame and to be replaced Intumescent strip to head frame is short and to be replaced Intumescent strip to head frame is missing and to be installed Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door Install door closer to Door Clean out at base of door frames with cement etc Door signage Fire/Smoke seal threshold required to entry door

Rating Classif. A A A B B B B A B B B B B B A B B B A A A B B A B A B B A

Date Rectified

Date Checked

Comments W4A to advise W4A to advise W4A to advise

4/10/2013

83

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

Location Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08 Service Corridor S2E.08

Defect Complete wall painting in areas missed Remove red paint daubs on wall generally Clean red paint off Running Man sign Low headroom on Northeast side of corridor Clean paint and cement off conduit at ceiling level to southwest side of corridor on Wall to Annex S2E.09 Make good to wall head 300mm high on southwest wall to Annex S2E.09 Seal large void above door to Car Park Area Make good to hole at upper wall level near LH of door to Fire Pump Room S2E.10 Clean conduit to RH of Door to Fire Pump Room S2E.10 Clean paint etc. conduit on South Wall of Corridor and West Wall beside it Make good hole above door with six (6) pipes to Fire Pump Room S2E.10 and seal and repaint to both sides Remove paint on conduit at entry door RH to Car Park Area and along ceiling Make god and seal rectangular hole in southeast corner of corridor at ceiling level Clean all three (3) lights fixed as bulkheads to wall Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to LH door jamb is not complete at bases, loose and to be replaced Intumescent strip to RH door jamb is not complete at bases and to be replaced Clean out frames at door base Remove all protective covering that remains Remove paint and cement on door frames and make good Fix permanent missing door handles Install door stop to Door Install door closer to Door Remove cement on Intumescent strip to head frame Remove paint spills to door and make good Door Signage Make good and seal around ventilation duct on West Wall at southern end of corridor and repaint Make good and seal around conduit on West Wall at southern end of corridor and repaint Install Fire Alarm Make good to joint between wall and floor and repaint as required Make good to concrete step at door to Car Park Area Make good to wall returns at door to Car Park Area on external side Fire/Smoke Threshold seal is required to door South

Rating Classif. B B B A B B A A A B A B A B B B A A A B B B B B A A B B A A A B B B A

Date Rectified

Date Checked

Comments

W4A to advise on legal requires.

4/10/2013

84

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13

Defect Fixing screws to frame protrude and are to be refixed to door Service Corridor Cover four (4) protruding screw ends in angle plate to top corner to door Service Corridor Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to LH and RH door jambs is not complete at bases and to be replaced on door Service Corridor Fire/Smoke seal threshold required to entry door Service Corridor Remove all protective covering that remains Make good to door seal frame all round on Service Corridor side Fix permanent door handles Install door stop to Door Install door closer to Door Remove 4 steel rods to LH of Door to Service Corridor on Corridor side LH and make good Door signage to door to Service Corridor Wall missing between S2E.11 and S2E.13 Make good joint between wall and floor all round and repaint as required Clean tape off light fitting Generally remove paint on conduit throughout Repair water leak to northwest corner under main East Entry Ramp Make good pipe encasure to drain to car park ramp all round Paint Southwest wall at northern end Clean conduit down on southwest wall of paint Clean conduit near Door to Service Corridor Make good to bulkhead over door to corridor and fire seal Make good and seal to flexible conduit to RH of door to service corridor and touch up wall paint Seal wall at ceiling to vestibule in northwest corner Seal large rectangular hole to LH at ceiling of wall to vestibule Seal around three (3) conduits in wall to Vestibule and repaint Make good paint to LH side lower of Door to Vestibule Repair wall in northeast corner of Annex Storage near ceiling and repaint Seal wall head on return wall to Vestibule in northwest and repaint Seal return wall to Vestibule in northwest corner at floor level and repaint Make good around and seal to flexible conduit on north wall to Annex Storage area Repaint ceiling at northern end of Annex Storage Area Remove paint on ceiling fixed conduits generally

Rating Classif. B B A A A B B B B A B B B B B B A B B B B A B A A B B B B B B B B

Date Rectified

Date Checked

Comments

Door to Service Corridor

4/10/2013

85

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46

Location Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13 Annex Storage S2E .11 and .13

Defect Fixing screws to frame protrude and are to be refixed to door Vestibule Cover four (4) protruding screw ends in angle plate to top corner to door Vestibule Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to LH and RH door jambs is not complete at bases and to be replaced on door Vestibule Fire/Smoke seal threshold required to entry door Vestibule Remove all protective covering that remains door to Vestibule Seal returns of door all round on Vestibule side of Door to Vestibule Fix permanent door handles Install door stop to Door to Vestibule Install door closer to Door to Vestibule Remove cement and paint on door and frames to Vestibule Door signage Wall ABC 23 remove four (4) steel rods behind ducting and make good

Rating Classif. B B A A A B B B B A B B B

Date Rectified

Date Checked

Comments

Door to Vestibule

4/10/2013

86

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

Location Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12 Vestibule S2E.12

Defect Fixing screws to frame protrude and are to be refixed to door Vestibule Cover four (4) protruding screw ends in angle plate to top corner to door Vestibule Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to LH and RH door jambs is not complete at bases and to be replaced on door Vestibule Fire/Smoke seal threshold required to entry door Vestibule Remove all protective covering that remains door to Vestibule Seal returns of door all round on Vestibule side of Door to Vestibule Fix permanent door handles Install door stop to Door to Vestibule Install door closer to Door to Vestibule Remove cement and paint on door and frames to Vestibule Door signage Remove paint on conduit on wall near door Provide light and switch etc. to Vestibule Make good damaged wall to LH Lower side of Door to Car Park Area including loose plaster boarding Remove damaged paint floor and repaint0 Seal gap to wall at joint to ceiling all round Make good to rectangular duct hole in South wall and repaint Make good to door bulkhead and fire seal Repaint walls as required but especially RH side of door to Annex Storage Room Remove paint on light switch Remove paint on Running Man Sign Running Man Sign is not easily visible when vacating in a hurry and to be resited Seal gap between wall and ceiling to wall side return to Annex Storage Area S2E.13

Rating Classif. B B A A A B B B B A B B B A B B A A A B B B A A

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

87

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Location Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09 Annex Storage Room S2E.09

Defect Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to Hinge door jamb is not complete at bases and to be replaced and also loose Clean out frames at door base Remove all protective covering that remains Intumescent strip is loose on head frame and to be refixed Fix missing door handles and lock Install door stop to Door Install door closer to Door Remove paint stains on door Make good to threshold plate and tidy up metal steel rod fixings Remove paint and cement on door frames Fire/Smoke seal threshold required to entry door Door signage Clean floor of rust stains etc Touch up wall painting near floor on all four walls Repaint ceiling as work substandard Relocate conduit drop and junction box sunk into wall and make good to wall and refix the assembly properly near door RH Remove all paint and cement to conduits to RH of door to Service Corridor Remove paint on all ceiling mounted conduits throughout Touch up paintwork to wall where missing throughout Sprinkler pipe install ion required Clear out general rubbish in the room Seal two (2) pipes in ceiling at southwest corner of room Seal two (2) pipes at floor at southwest corner of room Make good to ceiling at SVP Pipe entry Make good to one (1) formwork fixtures hole on west wall and repaint Clean three (3) ceiling lights Make good and seal to conduit entry near ceiling on East wall Make good and seal to twp (2) conduit entries near ceiling on West wall Reconnect plastic tube for pressure testing and fix with clip Make good and seal to SVP Pipe entry near ceiling on West wall Paint upper part of wall near middle on West wall

Rating Classif. B B A A B B A A B A B B B A B B B B B B B B A B A A B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

88

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10

Defect Remove red paint from IT plug in point Remove red paint on light switch Remove copious red paint on Running Man Sign Repair Running Man Sign as panel has fallen and needs to be realigned Form protective railing to ladder hole in floor as somebody could easily fall Remove red daubs on West, East and South Walls Complete insulation to pipes at ceiling level on West Wall Tidy up pipes in northwest corner and remove all the cement and concrete etc and repaint as required Clean out central drain gully Paint gulley drain grating Seal three(3) SVP pipes that enter at ceiling Install all equipment and flow labels throughout Remove red paint daubs on ceiling Paint North Wall and short return on East Wall Seal off duct in South West Corner at ceiling to SVP and cable tray etc Remove loose tying wires on South Wall and make good (LH) Remove timer formwork piece on ceiling at South Wall, seal to six (6) pipes and make good Seal SVP pipe to floor on North Wall LH Paint Floor Paint ceiling Seal drain at floor level on West Wall Seal duct hole in southwest corner for SVP and Cables and make good Provide closure screws to four (4)\control boxes to LH side of entry door Redo bodged up cable tray box under the four (4) control boxes to LH of entry door Remove paint on conduits to LH side of entry door Make good duct entry to upper LH side of entry door and repaint as required Make good to five (5) formwork fixture holes on West Wall Seal wall to RH of entry door for two insulated pipes and make good Seal wall for three pipes to RH of entry door and make good all round Paint area in Northwest upper area of West Wall Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected

Rating Classif. B B B B A B B B B B B A B B A B A A B B A A B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

89

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53

Location Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10 Fire Pump Room S2E.10

Defect Intumescent strip to Hinge door jamb is not complete at bases and to be replaced and also loose Remove paint on door and frames Remove all protective covering that remains Fix missing strike plate to open door jamb Fix missing door handles Install door stop to Door as when opening the door is hitting the Fire Pump Installation equipment Install door closer to Door Replace missing prong receiver Make good threshold concrete to room as uneven and rough Seal door frame all round in Service Corridor Fire Fighting equipment is missing Door Signage Fire/Smoke seal threshold required to entry door Intumescent strip to open door jamb is not complete at bases and to be replaced Intumescent strip to head frame is short and to be replaced Seal bulkhead above door where six pipes pass through Make good to slab at opening to -1 at access ladder and remove exposed steel reinforcement Make good all round to floor opening at 02 floor level Provide handrail to access ladder Install Fire Alarm

Rating Classif. A B A A A B B B B A B A A A A B B A A

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

90

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson) Storage S2E. 15 (Ericsson)

Defect Fixing screws to frame protrude and are to be refixed to door Vestibule Cover four (4) protruding screw ends in angle plate to top corner to door Vestibule Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to LH and RH door jambs is not complete at bases and to be replaced on door Vestibule Fire/Smoke seal threshold required to entry door Vestibule Remove all protective covering that remains door to Vestibule Make good and seal returns of door all round on Vestibule side of Door to Vestibule Fix permanent door handles Install door stop to Door to Vestibule Install door closer to Door to Vestibule Remove cement and paint on door frames to Vestibule Door signage Remove paint on door surfaces Intumescent strip to head frame is loose and needs to be refixed Intumescent strip to open jamb frame is loose and to be refixed Repair wall leak on Wall C 23 and repaint Make good on Wall C23 at joint to ceiling and repaint Seal and make good around duct extract Apply paint to sprinkler pipe installation Stabilise sprinkler pipe installation as it is NOT stable Paint floor Paint all walls Paint ceiling Clean three (3) light fitting that are dirty inside Clean up wall head along southwest wall and make good Make good to three (3) formwork fixture holes Install Fire Detector in south part of area Make good to taped joint to flexible conduit to Fire Detector Make good and seal off to conduit near ceiling on LH of northwest wall Make good and seal to sprinkler pipe to upper LH of door to vestibule Seal wall at junction with ceiling to both walls to vestibule Seal wall at junction with floor to both walls to vestibule Seal wall to vestibule at ceiling level for two (2) conduits

Rating Classif. B B A A A B B B B A B B B A A A B B B A B B B B B B A B B B A A B

Date Rectified

Date Checked

Comments

4/10/2013

91

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

Location Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson) Vestibule S2E.14 (Ericsson)

Defect Fixing screws to frame protrude and are to be refixed to door Vestibule Cover four (4) protruding screw ends in angle plate to top corner to door Vestibule Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to LH and RH door jambs is not complete at bases and to be replaced on door to Car Park and also loose Fire/Smoke seal threshold required to entry door Vestibule Remove all protective covering that remains door to Vestibule Seal returns of door all round on Vestibule side of Door to Vestibule Fix permanent door handles Install door stop to Door to Car Park Install door closer to Door to Car Park Remove cement and paint on door frames to Car Park Door signage Clean out frames at bases of dirt and concrete etc. Provide light and switch etc. to Vestibule Remove paint stains on door Paint floor Seal gap to wall at joint to ceiling all round Paint ceiling Make good to door bulkhead and fire seal Make good and seal small pipe to North Wall Remove paint on light switch Make good and seal small pipe to South Wall Running Man Sign is not easily visible when vacating in a hurry and to be resited Seal gap between wall and ceiling to wall side return to Annex Storage Area S2E.15 Make good and seal to three (3) conduits at ceiling level in walls and repaint as required Ease lock that is stiff to turn Make good plasterboard return to door all round on Car Park side of door Make good to wall at pipe to RH side of entry door to vestibule

Rating Classif. B B A A A B B B B A B B B A B B A A A B B B A A B B A B

Date Rectified

Date Checked

Comments

4/10/2013

92

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen.

Defect Make good and seal wall at high level at C 21 for cable tray passing through wall Make good and seal wall at high level at C 21 for small pipe passing through wall Make good and seal wall at high level at C 21 for sprinkler pipe passing through wall Make good and seal hole at high level at C21 in wall Make good and seal wall at high level for small pipe passing through wall to S1E.13 Car Exhaust Remove large cable end in wall to Room S1E.13 Car Exhaust Make good and seal to steel plate with orifice in ceiling between C/B 20/21 Relocate four sprinkler head placed very close to wall to Rooms S1E.13 Car Exhaust and Corridor Vestib S1E.08 Make good and seal round flue ducts as they pass through wall to Room S1E.08 Make good and seal large hole for pipes passing above door to S1E.08 and cover up exposed steel reinforcement Provide impact protection to SVP Pipe D16 Make good and seal wall at high level A/B 21 for small pipe passing through wall to S1E.08 Make good and seal wall at high level A/B 21 for small pipe and conduit passing through wall to S1E.08 Make good and seal wall at high level at A 20/21 for sprinkler pipe passing through wall to S1E.09 Make good and seal wall at high level A 20/21 for two (2) small pipes passing through wall to S1E.09 Provide impact protection to car exhaust extracts A20 LH Provide impact protection to car exhaust extracts A19 RH Provide impact protection to car exhaust extracts A19 LH Provide impact protection to car exhaust extracts A18 RH Provide impact protection to car exhaust extracts A18 LH Provide impact protection to car exhaust extracts A17 RH Provide impact protection to car exhaust extracts A17 LH Provide impact protection to car exhaust extracts A16 RH Provide impact protection to car exhaust extracts A16 LH Provide impact protection to car exhaust extracts A16 LH Provide impact protection to car exhaust extracts A15 RH Provide impact protection to car exhaust extracts A15 LH Provide impact protection to car exhaust extracts A14 RH Provide impact protection to car exhaust extracts A14 LH Provide impact protection to car exhaust extracts A13 LH Provide impact protection to car exhaust extracts Column C19 Provide impact protection for car exhaust extract Column B19 Provide impact protection for car exhaust extract wall corner B15

Rating Classif. A B B A B A A A B A A B B B B A A A A A A A A A A A A A A A A A A

Date Rectified

Date Checked

Comments

W4A to advise

W4A to advise

W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise

4/10/2013

93

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen.

Defect Provide impact protection to water supply pipe Column A 20 Provide impact protection to water supply pipe Column A 18 Provide impact protection to water supply pipe Column A 16 Provide impact protection to water supply pipe Column A 14 Provide impact protection to water supply pipe Column D 20 Provide impact protection to water supply pipe Column D 18 Provide impact protection to water supply pipe Column D 16 Provide impact protection to water supply pipe Column D 14 Clean out void between Column Walls A 12 and 13 Clean out void between Column Walls D 12 and 13 Provide impact Protection to CO Warning Sign A 12 Provide impact Protection to CO Warning Sign D 12 Provide impact Protection to CO Warning Sign A 17 Provide impact Protection to CO Warning Sign D 17 Clean out floor drain near D20 Paint floor drain grating near D 20 Clean out floor drain near D18 Paint floor drain grating near D 18 Clean out floor drain near D16 Paint floor drain grating near D 16 Clean out floor drain near D14 Paint floor drain grating near D 14 Clean out floor drain near A20 Paint floor drain grating near A 20 Clean out floor drain near A18 Paint floor drain grating near A 18 Clean out floor drain near A16 Paint floor drain grating near A 16 Clean out floor drain near A14 Replace missing floor drain grating near A 14 Clean out floor drain at bottom of car park entry ramp C22 Paint floor drain grating at bottom of car park ramp C22 Paint grille to longitudinal drain at bottom of ramp to Car Park

Rating Classif. A A A A A A A A B B A A A A B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise

W4A to advise W4A to advise W4A to advise W4A to advise

4/10/2013

94

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99

Location Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen.

Defect Provide impact protection to wall mounted ventilation unit near Column D20 Provide impact protection to Running Man Sign on column D 20 Provide impact protection to Running Man Sign on column B 20 Provide impact protection to Running Man Sign on wall C17 Provide impact protection to Running Man Sign on wall B18 Provide impact protection to Running Man Sign on wall B15 Provide impact protection to Running Man Sign on wall C14 Provide impact protection to wall mounted ventilation unit near Column D14 Make good flexible conduit connections to CCTV Camera B18 Make good flexible conduit connections to CCTV Camera B15 Make good flexible conduit connections to CCTV Camera D14 Make good flexible conduit connections to CCTV Camera C17 Make good flexible conduit connections to CCTV Camera A 19 Make good and seal at white water pipe at floor D18 Complete conduit connection to CO Warning Sign A 12 Complete conduit connection to CO Warning Sign D 12 Complete conduit connection to CO Warning Sign A 17 Complete conduit connection to CO Warning Sign D 20 Make good painting to black and yellow threshold strip Service Elevator Vestib. Make good painting to black and yellow threshold strip Corridor B14/15 South. Make good painting to black and yellow threshold strip Corridor C14/15 North Make good painting to black and yellow threshold strip Corridor B17/15 South. Make good painting to black and yellow threshold strip Corridor C17/18 North Make good painting to black and yellow threshold strip Elevator Vest. B17 South. Make good painting to black and yellow threshold strip Elevator Vest. C17 North. Remove red paint on walls to S1E.13 at Car Park Area Sprinkler pipe to be made more stable in area A 18/19 Remove key at sprinkler pipe installation A 18/19 and hand over to Facilities Management Seal enclosure fire rated to Main Electrical Cable in Area A 18/19 Seal enclosure fire rated to Main Electrical Cable in Area AB 18/19 where angle support are protruding both sides Seal enclosure fire rated to Main Electrical Cable in Area A/B 18/19 as not sealed when an exhaust duct passes underneath Seal enclosure fire rated to Main Electrical Cable in Area A 18/19 as unsealed where seven (7) pipes pass Seal enclosure fire rated to Main Electrical Cables in Area C/D 18/19 as open area both sides at steel box enclosure

Rating Classif. A A A A A A A A B B B B B B B B B B B B B B B B B B A A A A A A A

Date Rectified

Date Checked

Comments W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise

W4A to advise on practicality

4/10/2013

95

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132

Location Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen.

Defect Remove reinforcing rod to Water Pipe sleeve and make good all round at Column A18 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column A16 Make good and seal water Pipe sleeve at Column A14 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column D14 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column D16 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column D18 Remove reinforcing rod to Water Pipe sleeve and make good all round at Column D20 Install operator signage to Fire Alarm Button at wall C17 Install operator signage to Fire Alarm Button at wall B18 Install operator signage to Fire Alarm Button at wall B14 Install operator signage to Fire Alarm Button at wall D15 Warning notice required in area near Column A20 as the clearance height is 1.90 metres Warning Notice needed in Car Park Area A 12/13 for a two meter length as pipes are set at a clearance height of 1.96 metres Warning Notice needed in Car Park Area C 21 where pipes are at a clearance height on an access street of 2.06 metres Warning notice needed in Car Park Area B 20/ 21 Boiler Flue as clearance height is 1.42 metres Warning notice needed in Car Park Area B 20/21 as boiler flue pipes (Horizontal) clearance height is 1.70 to 1.87metres Warning notice needed in Car Park Area A/B 20/21 as two pipe supports have a clearance height of 1.98metres Carbon Monoxide signs ( 4 No) to also have warning in English Refix loose sprinkler holder in A/B 17/18 Remove red paint daubs on soffit of ceiling slab in Area A/B 17/18 Suspended Running Man sign near door south to Stair Vestib S1E.06 is showing opposite flow to RMS on wall B18 Make good and seal at wall head B 17/18 Make good and seal to sprinkler pipe on Wall head B 17/18 Make good and seal around three (3) conduits to wall head B 17/18 Remove red paint daubs to Wall B 17 Remove paint on Six Gang wall switch to LH of Door South on Wall B 17/18 Remove paint on flexible conduit to Fire Alarm Button on Wall B 17/18 to LH of door Make good and seal at high level on Wall C/B 18 for five pipes entering duct in the middle Remove plastic cover to Car Park Exhaust at A 13 Clean out in area between wall columns A12 and A13 Refix supply conduit to Carbon Monoxide Sign on Column A 12 Remove suspension rod in ceiling near Column A13 and make good Remove reinforcing rod in area between A12 and 13 and make good

Rating Classif. B B B B B B B A A A A A A A A A A A A C A A B B B B B A B B B B B

Date Rectified

Date Checked

Comments

W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise W4A to advise

W4A to advise

4/10/2013

96

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165

Location Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen.

Defect Make good and seal wall to two (2) sprinkler pipes above door south to Elevator Lobby on Wall B 16/17 Duct B16/17 at southwest area of Elevator Lobby (external) has not been constructed Seal wall head to South Wall of Elevator Lobby B 16/17 and make good Remove timber formwork at ceiling near B16/17 on West Wall to Elevator Lobby and seal to pipe and make good Complete insulation to two (2) pipes passing through to Elevator Lobby West Wall Seal wall where two pipes pass through Elevator Lobby West Wall RH of central duct and make good Seal Wall where one pipe passes through Elevator Lobby West Wall RH of central duct and make good Seal Wall where one pipe passes through Elevator Lobby West Wall LH of central duct and make good Seal Wall C 17/18 to four (4) conduits pass into Elevator Lobby to LH of door at wall head and make good Seal Wall above door north to Elevator Lobby for sprinkler pipe and make good C 16/17 Remove red paint on Wall C 17/18 near sprinkler pipe Seal Wall C 17/18 to two (2) conduits pass into Elevator Lobby to RH of door at wall head and make good Running Man Sign (suspended) opposite Door to Stair Vestibule S1E.06 North is very loose and needs to be properly fixed Running Man Sign (suspended) opposite Door to Stair Vestibule S1E.06 North is in conflict with RMS on Wall C 17 Seal hole in ceiling at C17 and make good Remove paint to six gang switch on RH of Door North to Stair Vestibule S1E.06 Seal wall head on C17/18 at Stair Vestibule S1E.06 Remove timber formwork at wall head to Wall C 17/18 and make good including repainting Seal to four (4) conduits and one sprinkler pipe above door north to Stair Vestibule S1E.06 and make good C 17/18 Seal to four (4) conduits and one pipe above door north to Stair Vestibule S1E.06 and make good C 17/18 Seal to two (2) conduits above door north RH to Stair Vestibule S1E.06 and make good C 17/18 Make good to wall C 17/18 LH side near ceiling Remove paint on flexible conduit to Fire Alarm Button on Wall C 17/18 to LH of door Clean out area between Wall columns D12 and D13 Fill in twenty six abortive drilled hole in column D12 Fix loose conduit supply to Carbon Monoxide sign on Column D12 Make good around three (3) large pipes on North Wall at D 13 and seal Make good to kerb along North Wall between D13 and 14 Make good electrical connection to exhaust box near D 14/15 and tidy up Repair and make good to area of crazed plaster render on duct wall at D 14 Make good to wall and column at D 15 and repaint Seal hole for supply condensor pipe to Split A/C at D 15 and make good all round Make good floor near D 14 including fixing piece and repaint

Rating Classif. B B A B B B B B B B C B A A A B A B A A A B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

W4A to advise

W4A to advise

4/10/2013

97

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198

Location Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen.

Defect Seal to four (4) conduits and one pipe above door north to Stair Vestibule S1E.03 and make good C14/15 Seal to three (3) SVP pipes in ceiling slab in Area C/D 14/15 and make good all round Make good to Wall C14/15 where conduit and outlet box removed to heater to RH of door to Stair Vestibule S1E.03 Provide impact protection to ceiling mounted heater unit near Wall C 14 Seal to two (2) conduits near door north LH to Stair Vestibule S1E.03 and make good C 14/15 Seal to one (1) conduits near door north LH to Stair Vestibule S1E.03 and make good C 14/15 Seal to two (2) SVP pipes near door north RH to Stair Vestibule S1E.03 and make good C 14/15 Make good to wall near C 14 and repaint Remove paint on flexible conduit to Fire Alarm Button on Wall C 14/15 to LH of door Seal large hole in ceiling slab near C 15 and make good all round Seal to three (3) conduits and one (1) small pipe at ceiling near door north LH to Stair Vestibule S1E.03 and make good C 14/15 Remove large cable end in West Wall BC 14 Make good and seal to five (5) large pipes entering shaft on West Wall to Stair BC 14 and repaint Stabilise sprinkler pipework in area BC 13/14 as loose Repaint wall at high level near B14 on west wall to stair S1E.04 Remove small pipe protruding from wall BC 14 Seal to three (3) conduits and one (1) small pipe above door south LH to Stair Vestibule S1E.03 and make good B 14/15 Remove paint on flexible conduit to Fire Alarm Button on Wall B 14/15 to LH of door Remove paint on Six Gang wall switch to RH of Door South on Wall B 14/15 Make good electrical connection to exhaust box near D 20 and tidy up Remove temporary water pipe near D18 etc and make good hole and seal Seal water pipe at floor in corner RH of wall column D 18 Seal water pipe at floor in corner LH of wall column D 18 Remove cement render that is defective and redo near pipes to LH of Wall Column D 18 Make good around four (4) pipes entering north wall to LH of D18 and seal Make good and seal at wall head to North Wall to LH of Wall Column D 18 Provide impact protection for four (4) large pipes in North Wall to LH of Wall Column D18 Provide impact protection for three (3) large pipes in North Wall to LH of Wall Column D13 Make good hole at high level in Wall Column D 19 Make good to Wall D 19/20 where conduit and outlet box removed to heater Provide impact protection to ceiling mounted heater unit near Wall D 19 Seal hole in ceiling slab to LH of Wall Column D 20 and make good Change SVP pipe grey to Orange pipe to match all other such pipe insulations between D 20 and 21

Rating Classif. B B B A B B B B B A A A A A B B A B B B A B B B B B A A B B A A C

Date Rectified

Date Checked

Comments

4/10/2013

98

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 199 200 201 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220 221 222 223 224 225 226 227 228 229 230 231

Location Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen. Basement Car Park Level -1 Gen.

Defect Make good at wall head to North Wall between D 20/21 and repaint Paint area approx 1m2 of slab with floor paint at base of Car Park Ramp Make good to two (2) formwork fixture hole in Wall Column D 21 and seal Seal and make good to SVP at ceiling level near D21 Make good flexible conduit connections to CCTV Camera D21 at base of Ramp Works related to Valve Room S1E.14 have not been done Works related to Vestibule Room S1E.15 have not been done Works related to Storage Area S1E.16 have not been done yet Works related to Area under Car Park Ramp have not been done yet Remove two hanger rods in ceiling of Area S1E.16 Storage and make good Make good and seal wall head to splay wall D21/C23 Refix loose ceiling conduits in Area Storage S1E.16 Fire Fighting Equipment is missing

Rating Classif. B B B B B B B B B B B B A

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

99

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

Location Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04 Egress Stair S1E.04

Defect Clean light at Landing -1 Remove paint stains to top edges of skirting to landing and stairs throughout Clean light fitting on mid-landing that is covered in paint etc. Landing tiles are uneven and need to be levelled and repolished Stair are badly stained and need deep cleaned and repolished Floor tiling at -2 is uneven and needs levelled and repolished Replace one (1) chipped step Replace tile at base on divider wall -1 level which has been formed in two parts and not one Make good skirting to bases of door Remove paint on Running Man sign Remove paint from door and frames Fix permanent handles to doors and make good Remove protective covering that remains on door Intumescent strip is not complete to hinge and open frame bases Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop Install door closer Door Signage Fire/Smoke Threshold seal is required to door Door to be adjusted as it has squeak and does not close properly Remove paint on flexible conduit to Fire Detector Seal hole at ceiling level to southeast corner and make good

Rating Classif. B B B B B B B B B B B B B A B B A B A B A A B B

Date Rectified

Date Checked

Comments

4/10/2013

100

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03

Defect Remove paint and cement to South Door frames Fix permanent handles to door South and make good Intumescent strip is not complete to both frame bases of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Install door closer to Door South Remove cement render on door south head frame and make good Clean paint on floor tiles at Door South Fire/Smoke Threshold seal is required to door South Remove red paint on floor tiling near Door South Clean conduit to light switch (south) of paint etc Running Man sign obstructs the sprinkler head in operation mode and needs to be reviewed Carbon Monoxide sign to have English Warning Clean paint etc from two (2) light fittings Clean paint of grille to Fire Damper Grille (Upper) Clean paint of grille to Fire Damper Grille (Lower) Make good round Fire Damper Grille panel (Lower) Make good round Fire Damper Grille panel (Upper) Provide proper locking device to Lower Fire Damper Grille Provide proper locking device to Upper Fire Damper Grille Make good to wall on LH side of Door North Make good to wall on RH side of Door North Remove remaining protective covering on door North Fix permanent handles to door North and make good Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Install door closer to Door North

Rating Classif. B B A B B A B A B B A B B A A B B B B B B B B B B B A B B A B A

Date Rectified

Date Checked

Comments

Carbon Monoxide Warning sign obstructs the sighting of the RMS sign when coming from the North Door & should be relocated or redesigned A

4/10/2013

101

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03

Defect Remove paint and cement render off door fames to Door North and make good Glass Key Box to Fire Hosereel box the glass is missing and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hosereel box in neoprene gasket to prevent rattle and worse Seal openings between Fire Hosereel (FHE) door frame and blockwork all round Seal Sprinkler pipe at ceiling slab level and make good Upper hosereel to be relocated as fouls the door to the FHE Make good door cill inside FHE which is 200mm too low Seal pipe holes Two (2) in floor slab Inside this duct the two walls to the HVAC shafts (RH) have not been installed and require to be executed Ventilation duct protrudes into the FHE and requires to be fire rated Tidy up blockwork above door and generally and make good Wall to LH is missing on the top courses and needs to be completed and sealed Lower hosereel feed valve to be relocated as below the door cill and difficult to operate Provide Type C connection to Dry Riser Remove red paint on floor near Fire Hosereel Enclosure (FHE) Remove paint to top edges of skirting throughout Paint ceiling Screw in fixing screws to Carbon Monoxide sign that protrude Door pivot screws to head and cill of Fire Hosereel Door to be fully driven Make good at threshold to North Door as floor tiling is not completed Repaint black/yellow threshold plate to South Door and remove masking tape Refix black/yellow threshold plate to South Door as not even Repaint black/yellow threshold plate to North Door and remove masking tape Refix black/yellow threshold plate to North Door as not even Floor tiling is uneven and requires to be levelled and resealed and repolished Fix skirting to LH of Door South Fix skirting to RH of Door South Make good skirting to LH of Door North Make good skirting to RH of Door North Make good skirting on West Wall South at conduit to light switch Make good skirting on West Wall North at conduit to light switch Remove red paint on floor tiling near Door North Fire/Smoke Threshold seal is required to door North

Rating Classif. B B B A A A B A A A B A A A B B B B B B B B B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

102

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81

Location Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03 Stair Vestibule S1E.03

Defect Remove plaster on skirting near Door South LH and make good Seal hole ceiling (South) and make good Seal hole in ceiling (Mid) and make good Seal wall for four (4) conduits on West Wall to LH of door to Stair and make good including repainting Refix conduit at ceiling level on west wall which is poorly installed Repaint wall West at northern end near door Seal void in West Wall at northwest corner, make good and repaint Relocate junction box on south wall LH that is partially in wall and not accessible and thereafter make good all round Make good to render repair above Door South and repaint Seal wall for four (4) conduits and one (1) small pipe on North Wall above door to Stair and make good including repainting Seal wall for two (2) conduits on North Wall to LH of door and make good including repainting Seal wall for one (1) conduit on East Wall to at ceiling level and make good including repainting Seal wall for one (1) sprinkler pipe on East Wall near ceiling level (Mid) and make good including repainting Seal wall for one (1) sprinkler pipe on East Wall near ceiling level (South) and make good including repainting Make good at bulkhead in southeast corner and repaint

Rating Classif. B B B B B B B A B A B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

103

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05

Defect Paint ceiling Fit permanent door handles Door frame at bases is 8mm above floor finish and requires to be adjusted Fill in hole to door head frame Adjust inner leaf of door as it is still loose when closed Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Remove remaining protective covering to doors Door outer leaf requires adjustment to close properly Seal and make good conduit hole above Door North Seal and make good to hole for sprinkler pipe above Door North and remove red paint on wall Skirting is fixed with panel pins and requires to fixed with adhesive or better Replace missing skirting corner at RH of Lift Entry Install door stops to Doors Clean paint off Service Lift Door Frames Clean paint off service lift call and indicator wall panels Seal wall head to North Wall and make good Clean light fitting of paint and dirt inside Seal conduit hole at ceiling level Install selector and door closers Remove paint to door frames Remove red paint daubs on walls Seal wall head to West Wall and make good Seal wall head to East Wall and make good Make good to floor subsidence near duct to LH side of North Door and repaint etc. Fix dome covers to four (4) screws to grille in duct to northwest corner or change to white headed screws as elsewhere Carbon monoxide signage to also be in English Refix black/yellow threshold angle Repaint black/yellow threshold angle Seal wall head to South Wall and make good Door Signage Fire/Smoke Threshold seal is required to door North

Rating Classif. B B A B A B B A B A B B B B B B B B B B A B A B B B B A B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

104

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37

Location Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05 Service Elevator Vestibule S1E.05

Defect Carbon Monoxide Sign is very high and cannot be readily seen and requires to be relocated Sprinkler pipework is not stable and requires to be properly fixed Make good to floor tiling finish at lift entry Make good to damaged wall edging LH of Lift Entry

Rating Classif. A A B B

Date Rectified

Date Checked

Comments W4A to advise

4/10/2013

105

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17

Defect Prepare floor to be level and relay floor covering properly Install skirting to walls all round Seal wall hole (East Upper) where conduit tray passes through into Car Park Area Seal wall hole (West Upper) where conduit tray passes through into Car Park Area Provide and install closure screws to four (4) control boxes on west wall above four control units Clean all paint and cement grout of conduits Connect or remove two (2) unconnected wires in Lower box in southwest corner Paint walls Make good joint between wall and floor Remove manufacture's labels on door Remove writing on face of door Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is not complete to open jamb Intumescent strip is shirt at base on the hinge jamb and to be replaced Install permanent door handles Install door stop Install door closer Clean threshold plate and paint and also make good to reinforcing rod anchors Paint ceiling Door Signage Remove cement and paint on door frames and intumescent strip Remove all remaining protective covering to door Make good to bodged up cable duct at high level in west wall above door Remove paint on power outlet to RH of door externally Tighten up screws to grey box on North wall Make good wall to LH side of door externally and repaint Make good pointing and seal around door externally to jambs and head frames Make good to two (2) holes to RH of door externally and seal Clean cement on door contact (head frame) Fire/Smoke Threshold seal is required to door Align Door intruder contacts which are squiffy

Rating Classif. B B A A B B A B B B B B B A A A B B A B B B B B B B B B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

106

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38

Location Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17 Telephone Closet S1E.17

Defect Make good wiring to door intruder contacts as very untidy Seal wall (West) on RH side near north wall to RH of door and make good including repainting Make good to conduits near four control boxes on West Wall Make good to several drilled abortive holes on West Wall to RH of four control boxes Make good to several drilled abortive holes on South Wall

Rating Classif. A B B B B

Date Rectified

Date Checked

Comments

4/10/2013

107

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18

Defect Prepare floor to level and relay floor covering Install plastic skirting after floor covering re-laid Clean door frames of paint and cement droppings etc. Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is not complete to hinge frame of door Intumescent strip is not complete to door open jamb frame Install permanent door handles Install door stop Install door closer Clean threshold plate and paint and also make good to reinforcing rod anchors Clean out cement etc at door frame bases Clean paint and cement on door Remove writing and graffiti on door Remove all remaining protective covering to door Make good and seal to West Upper Wall at cable tray Make good and seal to East Upper Wall at cable tray above door and remove protruding piece of blockwork Clean paint etc off light fitting Make good wiring to door intruder contacts as very untidy Align Door intruder contacts which are squiffy Make good to door side and head frame on external side including polystyrene filler and repaint as required Prepare wall and paint Paint ceiling completely Make good joint between wall and floor throughout Electrical Cabinet TLSB-E replace mid panel internally as cracked in two places Electrical Cabinet TLSB-E make good to bottom panel where there are openings in the middle Electrical Cabinet TLB1-E replace damaged panel where flexible conduit is connected badly Electrical Cabinet TLB1-E make better fixing of flexible conduit internally. Electrical Cabinet TLB1-E door to be refitted as it does not close properly due to protrusion internally Door signage Fire/Smoke Threshold seal is required to door Make good at wall head on South wall and repaint as required

Rating Classif. B B B B B A A A B B A B B B B B A A B B A B B B B A A A B A B A B

Date Rectified

Date Checked

Comments

4/10/2013

108

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36

Location Electrical Closet S1E.18 Electrical Closet S1E.18 Electrical Closet S1E.18

Defect Make good to sixteen (16) abortive holes on south wall and repaint Make good at wall head on West wall and repaint as required make good at wall near ceiling around conduit and seal etc.

Rating Classif. B B B

Date Rectified

Date Checked

Comments

4/10/2013

109

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01

Defect Remove floor steel plate to RH of Door North to Elevator Lobby externally and make good all round Fixing screws to frame protrude and are to be refixed to Double Door South Cover four (4) protruding screw ends in angle plate to top corners to Double Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install permanent door handles Door South Install door stops to Double Door South Install door closers and selector to Door South Inner door of leaf has a play when closed and requires to be adjusted Remove red paint splashes on door frames Remove all protective covering to Double Door South Make good to rectangular hole in head frame Door South Remove masking tape to threshold plate Remove general paint to door frames at sides and head all round Clean threshold plate to Lift/Elevator Fixing screws to frame protrude and are to be refixed to Double Door North Cover four (4) protruding screw ends in angle plate to top corners to Double Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Make good to wall lining joints in recess and repaint completely Refix conduit at ceiling level on East Wall as currently poorly installed Remove wall paint on North door frames Install permanent door handles on Double Door North Install door stops to Double Door North Install door closers and selector to Double Door North Remove paint on call and arrow indicator panels to Lift on East Wall Remove all remaining protective covering to Door North Remove manufacture's labels on door and make good Make good to rectangular hole in head frame Door North Clean two (2) light fittings Remove paint to lift stainless steel frames all round Refix skirting with proper fixing system and remove panel pins throughout Fix missing skirting corners on both sides of door to Lift Entry Paint ceiling Seal and make good to two (2) conduits on South Wall near ceiling LH

Rating Classif. B B B A B B A B B B B B B B B B A B B B B B A B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

110

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01 Elevator Lobby S1E.01

Defect Seal and make good hole near ceiling on South wall to RH above door Seal and make good hole near ceiling on South wall to LH above door Seal and make good to two (2) sprinkler pipes above Door South Seal and make good to one (1) sprinkler pipes on West Wall and remove red paint daubs nearby Clean paint stains on radiator on West Wall Seal and make good to two (2) conduits on North Wall near ceiling RH Seal and make good to three (3) conduits on North Wall near ceiling LH Seal and make good to two (2) sprinkler pipes above door on North Wall Finish wall paint externally to Elevator Lobby North at floor level to RH of North Door Remove masking tape to threshold plate to North Door Remove paint on outlet socket to North Wall externally the LH side of North Door to Elevator Lobby Remove red paint above door to North Wall externally Finish wall paint to left of Wall Socket on LH side of Door North externally Carbon Monoxide Warning to also be in English Tighten up all loose screws to Carbon Monoxide sign Seal West Wall at ceiling level where conduit passes through on LH side and make good Seal West Wall where conduit sprinkler pipe passes through on RH side and make good Angle steel threshold step to Door North to be refixed and painted with black and yellow diagonal stripes Angle steel threshold step to Door South to be refixed and painted with black and yellow diagonal stripes Door Signage South Door Signage North Remove floor paint above skirting on West Wall Seal West Wall at where small pipe passes through on RH side Make good subsidence/damage to wall/floor on West Wall and repaint as required Clean paint of both lift panels call and indicator to RH side Infill sinking to storage area door and repaint floor Make good to dent in Door South on Car Park side Fire/Smoke Threshold seal is required to door North Fire/Smoke Threshold seal is required to door South Make good floor in recess on East wall and paint floor and down stand complete

Rating Classif. B B B B B B B B B B B A B A B B B B B B B B B B B B B A A B

Date Rectified

Date Checked

Comments

4/10/2013

111

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07 Egress Stair S1E.07

Defect Remove tape on steps used fro temporary protection in this area Clean down steps of dirt marks, concrete etc complete Floor tiling to mid landing is uneven and to be levelled and resealed/polished Floor tiling to stair floor at -2 is uneven and to be levelled and resealed/polished and insert missing grout between some tiles Make good to damaged skirting at upper flight on first step LH Replace one (1) chipped step Clean light fitting at mid landing Remove paint from Running Man Sign Clean Light Fitting at Base Level Remove paint to Base Entry Door and Frames including red paint Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to LH and RH door jambs is not complete at bases and to be replaced Remove remaining protective covering to doors Fix missing strike plate to open door jamb Install permanent door handles (temporary handle broken on inner side) Install door stop to Door Install door closer to Door Make good tiles skirting to LH side of door Door signage Fire/Smoke Threshold seal is required to door Remove paint on top edge of skirting throughout including steps Clean paint on flexible conduit to Fire Detector

Rating Classif. B B B B B B B B B B B B A A B A A B A B B A B B

Date Rectified

Date Checked

Comments

4/10/2013

112

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06

Defect Remove paint and cement to South Door Frames Fix permanent handles to door South and make good Intumescent strip is not complete to both frame bases of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Install door closer to Door South Remove remaining parts of the protective covering to door South Screw missing in lock plate to door South Paint ceiling Remove paint on floor Remove paint on frames of Fire Hosereel Enclosure (FHE) Running Man sign obstructs the sprinkler head in operation mode and needs to be reviewed Carbon Monoxide sign to have English Warning Remove paint from top edge of skirting Clean paint etc from two (2) light fittings Remove red paint stains from wall generally Make good round Fire Damper Grille panel (Lower) Make good round Fire Damper Grille panel (Upper) Provide proper locking device to Lower Fire Damper Grille Provide proper locking device to Upper Fire Damper Grille Clean paint off grille to Fire Damper panel (Lower) Clean paint off grille to Fire Damper panel (Upper) Screw missing in lock plate to door North Clean paint and cement off door Frame to Door North Fix permanent handles to door North and make good Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Install door closer to Door North

Rating Classif. B A A B B A B A B B B B B A A B B B B B B B B B B B B A B B A B A

Date Rectified

Date Checked

Comments

4/10/2013

113

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06

Defect Remove remaining parts of the protective covering to Door North Glass Key Box to Fire Hosereel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hosereel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hosereel (FHE) door frame and blockwork Remove masking tape to FHE Door panel frames Seal to head of door frame with blockwork and make good Make good door cill inside FHE Seal pipe hole on RH to wall and make good Inside this duct the two walls to the HVAC shafts have not been installed and require to be executed Fire proofing required to ventilation shaft in Fire Hosereel enclosure or relocated Seal and make good to floor slab for supply pipe Seal to HVAC vent at slab Clean out builder's debris in FHE Provide Type C connection to Dry Riser Floor tiling is uneven and needs to be levelled and repolished Take off label to FHE door Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Remove paint on conduit on East Wall near Door South and make good Make proper connection between conduit and light switch near Door South Remove paint on conduit on East Wall near Door North and make good Make proper connection between conduit and light switch near Door North Complete paintwork to Northern parts of East Wall Seal and make good to wall head of West wall Seal and make good to one (1) sprinkler pipe in North wall above North Door Seal and make good to five (5) conduits to RH side of North Door near ceiling Seal and make good to four (4) conduits to LH side of North Door near ceiling Remove paint from skirting top edges throughout Provide angle steel threshold step to Door North and paint with black and yellow diagonal stripes Provide angle steel threshold step to Door South and paint with black and yellow diagonal stripes Make good to skirting to RH of Door North Install threshold plate to Door South Install threshold plate to Door North Remove tape to angle threshold frame outside Door North

Rating Classif. B B B A B B A A A A A A B A B B A B B B B B B B A B B B B B A A B

Date Rectified

Date Checked

Comments

4/10/2013

114

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 67 68 69 70 71 72 73

Location Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06 Stair Vestibule S1E.06

Defect Seal and make good to one (1) small dia pipe in North wall above North Door Seal and make good to one (1) sprinkler pipe in South wall to RH side of South Door near ceiling Seal and make good to five (5) conduits to RH side of North Door near ceiling Seal and make good to two (2) conduits to LH side of North Door near ceiling Make good to hole above South Door near ceiling and repaint Fire/Smoke Threshold seal is required to door North Fire/Smoke Threshold seal is required to door South

Rating Classif. B B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

115

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13

Defect Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door jamb is not complete at bases and to be replaced Clean out frames at door base Remove all protective covering that remains Remove manufacturer's labels on door and make good Fix permanent door handles Install door stop to Door Install door closer to Door Remove paint stains on door Make good and seal to threshold plate and tidy up metal steel rod fixings Remove paint and cement on door frames Fire/Smoke seal threshold required to entry door Door signage Remove wood piece at RH door frame base Make good and seal to door side and head frames all round on Vestibule side and repaint Make good crack on south wall and repaint Make good to wall and floor joint all around the room Make good floor near threshold and repaint as required to floor Paint wall where repair carried out on North Wall LH Seal and make good the rectangular hole top RH in North Wall and all around cable tray Seal and make good to pipe on south wall LH near floor Seal and make good to pipe on south wall RH above door Clean two (2) light fittings that are dirty inside Remove wire fixing in ceiling and make good to northern end and repaint Make good and seal where conduit passes though west wall at ceiling level Make good to ceiling at several abortive holes to RH side of room and repaint Seal and make good the rectangular hole top RH in East Wall and all around cable tray Seal and make good around large Car Exhaust System duct Make good to six (6) formwork fixing holes on East Wall Cut back two (2) duct fixings that protrude and could cause physical injury (room centre) Cut back one (1) duct fixings that protrudes and could cause physical injury West Wall

Rating Classif. B B A A B B B A B A B B B A B B B B B B B A B B B B B B A A B A A

Date Rectified

Date Checked

Comments

4/10/2013

116

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36

Location Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13 Mechanical Room (CEX) S1E.13

Defect Make good paint to wall on West Wall where repair executed on LH side Generally tidy up walls and touch up Seal pipe at low level RH side of East Wall and make good all round

Rating Classif. B B B

Date Rectified

Date Checked

Comments

4/10/2013

117

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09

Defect Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door jamb is not complete at bases and to be replaced Clean out frames at door base Remove all protective covering that remains Remove manufacturer's labels on door and make good Fix permanent door handles Install door stop to Door Install door closer to Door Remove paint stains on door Make good and seal to threshold plate and tidy up metal steel rod fixings Remove paint and cement on door frames Fire/Smoke seal threshold required to entry door Door signage Replace missing screw in lock plate to door Make good and seal to door side and head frames all round on Vestibule side and repaint Make good to dent in door and if required replace Adjust door to close tightly as there is play in the door at the moment Seal door to side and head frames in vestibule and make good all round Make good to hole at LH side of entry door in the Vestibule Room S1E.08 Relocate one of the sprinkler pipe hangers that fouls itself on one of the heating pipes Stabilise the sprinkler pipe installation as loose Make good joint between wall and floor and repaint as required Clean two (2) light fittings that are dirty inside Seal large hole in top LH side of West Wall around circular exhaust duct and make good all round Remove steel rod on RH side top of West wall and make good Paint West Wall Make good to two (2) formwork fixing holes and repaint as required Fit ventilation plat where hole covered with paper and string on South wall RH Paint South Wall Paint ceiling Fill in gap to wall on North Wall LH near pipe and make good including painting

Rating Classif. B B A A B B B A B A B B B A B B B B B B B B A B B B B B B A B B B

Date Rectified

Date Checked

Comments

4/10/2013

118

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46

Location Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09 Storage S1E.09

Defect Tidy up pipe in wall including cleaning concrete stain and align and fix properly Seal open branch on pipe in wall in northwest corner Seal square hole on North wall and make good to LH side of door Make good and seal to duct opening above entry door and seal all round to six pipes Seal and make good to one sprinkler pipe above entry door and repaint Seal wall head above entry door and make good including repainting Make good to hole on North wall at floor level currently filled with insulation material and repaint LH Make good to hole on North wall at floor level near Entry door Seal and make good to duct hole for seven (7) pipes passing into Boiler Room on East Wall and repaint as required Seal and make good to square hole in top RH corner of East Wall and paint Paint patch repair on LH side of East Wall Remove steel rod near floor and make good to finishes Make good to six (6) formwork fixtures holes and repaint as required

Rating Classif. B A A A B A B B A A B B B

Date Rectified

Date Checked

Comments

4/10/2013

119

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02 Storage Area PE.02

Defect Make good uneven ceiling edge trim to suspended ceiling all round and remove curled edges Replace one (1) damaged ceiling tile Replace on stained ceiling tile near HVAC leak Plastic skirting to be installed as missing completely Trim missing to suspended ceiling around column B16 to be installed Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door jamb is not complete at bases and to be replaced Fit proper extended lock to inner face Remove all protective covering that remains Remove manufacturer's labels on door and make good Screw fixing missing to lock plate on door Install door stop to Door Install door closer to Door Remove paint stains on door Make good to gap between mitred joint of frames at both heads Remove paint on door frames Fire/Smoke seal threshold required to entry door Door signage

Rating Classif. B B B B B B B A A B B B B B A B A B A B

Date Rectified

Date Checked

Comments

4/10/2013

120

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18

Defect Paint sprinkler pipe installation to 2 sprinklers Clean paint off light switch plate Paint floor Seal joint gap between floor and wall (this place is sluiced out regularly) and install skirting North Wall Seal joint gap between floor and wall (this place is sluiced out regularly) and install skirting South Wall Seal joint gap between floor and wall (this place is sluiced out regularly) and install skirting East Wall Seal joint gap between floor and wall (this place is sluiced out regularly) and install skirting West Wall Seal wall head to top of East Wall and make good to ceiling suffix and wall Seal East wall to conduit at ceiling level and make good Seal wall head to top of South Wall and make good to ceiling soffit and wall Seal Wall around beam on South Wall on Grid Line C/D 15 Seal South Wall for two small pipes and make good all round Seal around large duct on South Wall and make good all round Seal South Wall at cable tray and make good all round Seal wall head to top of West Wall and make good to ceiling soffit and wall Seal West Wall for two (2) conduits and make good all round Seal wall head to top of North Wall and make good to ceiling soffit and wall Seal North Wall at cable tray and make good all round Seal North wall for sprinkler pipes (2 No) and make good all round Seal North wall at square duct and make good all round Seal North Wall to large duct with large void above and make good all round for 2 hour fire rating Seal Wall around beam on North Wall on Grid Line C/D 15 Repaint walls that have been damaged by dirty water Clean the two (2) light fittings that are dirty inside Make good to concrete threshold which is of poor construction Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door jamb is not complete at bases and to be replaced Fit proper extended lock to inner face Remove all protective covering that remains Remove manufacturer's labels on door and make good Screw fixing missing to lock plate on door

Rating Classif. B B B B B B B A B A A B A A A B A A B A A A B B B B B A A B B B B

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

121

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43

Location Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18 Garbage Room PE.18

Defect Install door stop to Door Install door closer to Door Remove paint stains on door Make good to gap between mitred joint of frames at both heads Remove paint and rust on door frames Fire/Smoke seal threshold required to entry door Door signage Adjust door to prevent 'play' when closed Make good to wall where damaged by the fixing of the door intruder alarm contact Fire Fighting Equipment is missing

Rating Classif. B A B A B A B B B A

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

122

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Location Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05 Storage Area PE.05

Defect Make good uneven ceiling edge trim to suspended ceiling all round and remove curled edges Plastic skirting to be installed as missing completely Clean wall stain and repaint on West Wall due to HVAC failure to RH of door Make good wall to LH side of door on West Wall Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door jamb is not complete at bases and to be replaced Fit proper extended lock to inner face Remove all protective covering that remains Clean out at bases of frames at floor level and make good Screw fixing missing to lock plate on door Install door stop to Door Install door closer to Door Make good to gap between mitred joint of frames at both heads Remove paint on door frames Fire/Smoke seal threshold required to entry door Door signage

Rating Classif. B B B B B B A A B B B B B A A B A B

Date Rectified

Date Checked

Comments

4/10/2013

123

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04)

Defect Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door jambs and head frame is not provided Strike plate is missing and requires to be replaced Remove all protective covering that remains Clean out at bases of frames at floor level and make good Screw fixing missing to lock plate on door Install door stop to Door Install door closer to Door Make good to gap between mitred joint of frames at both heads Remove paint on door frames Fire/Smoke seal threshold required to entry door Door signage Fixing screw in hinge frame is missing Adjust door as hinges are binding and door resists closure Adjust door as there is play in the leaf when the door is shut Make good to concrete floor where it joins the tiles floor to Reception Area Skirting fixed with panel pins and to be fixed with adhesive or clip-o system Make good to bottom of lowest step and floor finish as there is a large gap Replace bottom step as chipped Make good joints at side to all steps Clean paint and dirt marks off all steps Repair tile capping on LH side going up as uneven Realign suspended ceiling light Clean ceiling light Reconnect open ended wire or remove at ceiling level Reconnect or remove black cable in ceiling space area Make good to cable with taped joint which is not acceptable and any proposed spicing is subject to Elec. Eng's approval Paint sprinkler installation South sprinkler head is fouled by duct and requires to be relocated North sprinkler head is fouled by cable tray and requires to be relocated Make good on South Wall the unfinished wall at RH Top and render 2 Hour Fire Rating complete

Rating Classif. B B A A B B B B B A A B A B A A A B B B B B B B B B A A A B A A A

Date Rectified

Date Checked

Comments

W4A to advise if FIRE DOOR reqd

W4A to review and advise

4/10/2013

124

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55

Location Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04) Corridor Area BC 16 (PW.04)

Defect Make good around large duct on South Wall and seal all round including gap to RH side at top corner Seal around beam at north end of East Wall in top corner and make good Seal around cable tray near ceiling at North end of East Wall and make good Seal around smaller cable tray near ceiling at North end of East Wall and make good Seal around four (4) pipes near ceiling on East Wall and make good all round Seal around cable tray near ceiling at midway of East Wall and make good Seal around duct towards south end of East wall and make good Seal hole at South end of East Wall and make good Seal wall head along most of East wall to ceiling and make good Make good to gap between skirting and floor at upper level north end of East Wall Make good to poor jointing of skirting at base of steps on East Wall Refix all skirting that has been panel pinned and not installed with adhesive or clip-on system as specified Skirting missing to door return LH to PE.05 Skirting missing to door return RH to PE.02 Paint wall in south top corner of West Wall Seal around cable tray near ceiling at South end of West Wall and make good Seal around four (4) pipes near ceiling on West Wall and make good all round Seal around beam at north end of West Wall in top corner and make good Seal wall head along most of West wall to ceiling and make good Skirting broken between door to Reception Lobby and steps and to be replaced Make good to poor jointing of skirting at base of steps on West Wall Skirting to West wall at top of steps has been done in bits and pieces and not acceptable and must be replaced

Rating Classif. A A A A A A A A A B B B B B C A A A A B B B

Date Rectified

Date Checked

Comments 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL

2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL

4/10/2013

125

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04)

Defect Refix skirting fixed with panel pins throughout with adhesive or clip-on system Replace broken skirting at west end of North wall on return to Docking Bay Replace missing corner piece at west end of North Wall near Docking Bay Replace missing end to skirting at RH of Door to Generator Room PE.24 Replace missing end to skirting at RH of Door to Main Electrical Switchroom PE.14 Refix loose skirting at eastern end of North Wall Replace missing corner piece at west end of South near Docking Bay Tidy up skirting at LH of Column C16 Skirting on South Wall between C16 and C17 is loose and to be refixed All five (5) suspended ceiling lights to be set level and in line Sprinkler installation is above major pipe runs and its effectiveness is very much reduced and to be relocated Seal around four (4) pipes at eastern end of South Wall C18/19 and make good Seal wall head at C18/19 on South Wall and make good to ceiling Tidy up loose wires in C18/19 South Wall in ceiling area Install operator signage to Fire Alarm Button at South wall C18 Seal wall head along most of South wall to ceiling between C16/18 and make good Seal South wall above opening to stair corridor for eleven (11) conduits and one (1) pipe and make good all round Seal South Wall around circular duct pipe and make good Seal South Wall around small cable tray and make good at western end Seal South Wall around cable tray and make good at western end Seal wall around large pipe at western end of South Wall and make good all round Remove wall paint on fan Realign grille plate to level Seal all round grille and make good Seal wall head where there is a substantial gap to the ceiling (MAJOR Fire Escape Corridor) and make good all round Remove paint on Running Man Sign on North Wall Install fixing screws to eleven (11) control boxes on North Wall Refix switch plate to RH of Door to Electrical Closet PW 25 Seal opening at wall head on east side of corridor ingoing at C18 near open duct and make good all round Finish open duct at wall head on east side of corridor ingoing at C17 Finish wall head to eastern wall at corridor ingoing at C18 and seal to ceiling Finish wall head to southern wall at corridor ingoing at C18 and seal to ceiling Finish wall head to western wall at corridor ingoing at C18 and seal to ceiling

Rating Classif. B B B B B B B B B B A A A B A A A A A A A B B B A B B A A A A A A

Date Rectified

Date Checked

Comments

W4A to review and advise 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL

2 HOUR FIRE RATED WALL

2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL

4/10/2013

126

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49

Location Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04) Corridor C16 to 19 (PW.04)

Defect Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door jambs is short at base and to be replaced Fit proper locking set on door Remove all protective covering that remains Tidy up wiring to upper contact for intruder alarm Screw fixing missing to lock plate on door Install door stop to Door Install door closer to Door Remove paint on door and make good Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Fix upper door contact for intruder alarm properly Realign door contacts for intruder alarm system

Rating Classif. B B A A B B B A B A B B A B B B

Date Rectified

Date Checked

Comments Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert Door to Shop Unit Mobexpert

4/10/2013

127

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04) Corridor C/D 18/19 (PW.04)

Defect Paint sprinkler Pipe installation throughout Rehang light fitting as not level Sprinkler installation is placed right under duct and 150mm from west wall and not central for more effectiveness Fire Escape External Door is lockable (locked at present) How do people escape !!!???? Install threshold plate and seal to External Door Provide missing skirting to wall return to RH side of External Door Provide missing skirting to wall return to LH side of External Door Refix skirting fixed with panel pins with adhesive or clip-on system throughout Redo contact wiring to External Door Intruder alarm which is poorly executed Make good hole in floor to RH side of External door and repaint Make good hole in floor to LH side of External door and repaint Make good floor near External door which is very rough and unacceptable Seal East wall at north end to Beam all round and make good near ceiling Paint area of wall to North end of East Wall near ceiling Reconnect or remove loose wire near duct at northern end of East Wall Reconnect or remove loose green wire near duct at northern end of West Wall Seal around conduit near ceiling at northern end of East Wall and make good Seal wall at southern end of East Wall including bulkhead formation to duct and make good to two hour fire rating Seal East wall to conduit below duct at southern end of East Wall and make good Seal East wall to pipe below duct at southern end of East Wall and make good Remove paint from Running Man Sign Reset twin power outlet in East wall that is squint Seal West Wall at high level along the full length to obtain 2 hour fire rating including any required bulkhead and make good Seal West wall at high level to beam at northern end and make good all round Seal four (4) holes created for duct supports and make good all round on upper West wall Install threshold plate to external door Door open width is only 690mm which is not in accordance with the drawings or requirements 900mm

Rating Classif. B B A A B B B B B B B B A C A A B A A A B B A A A A A

Date Rectified

Date Checked

Comments

W4A to review and advise W4A to review and advise

2 HOUR FIRE RATED WALL

2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL

2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL

4/10/2013

128

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04)

Defect Reinstall skirting fixed with panel pins and refix with adhesive or clip-on system Refix loose skirting properly to East Wall which has been screwed Reset twin power outlet in West wall that is squint Make good to wall at floor level on East Wall at southern end Realign ceiling light that is squint Remove ceiling paint to ceiling light Remove ceiling paint to two (2) sprinkler heads Make good floor at Door to Stair Egress PE.06 Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door jambs is short at base and to be replaced and also loose Fit proper locking set on door Remove all protective covering that remains Make good tiled floor at RH door frame base Make good tiled floor at LH door frame base Screw fixing missing to lock plate on door Install door stop to Door Install door closer to Door Remove paint on door and make good Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Realign door contacts for intruder alarm system Refix skirting to LH of door which is poorly fitted Glass Key Box to Fire Hosereel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hosereel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hosereel (FHE) door frame and blockwork Seal to head of door frame with blockwork and make good Make good door cill inside FHE Remove hardboard packer on LH side in frame area Remove paint on FHE frames all round and make good Remove paint on glass panel to FHE Door

Rating Classif. B B B B B B B B B B A A B B B A A B A B B A B B B B B A B A B B B

Date Rectified

Date Checked

Comments

Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07 Door to Egress Stair PE.06/07

4/10/2013

129

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43

Location Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04) Corridor B/C 17/18 (PW.04)

Defect Make good to 'snowman' blockwork to RH side Four divider wall in duct are missing on RH side of FHE and are to be installed Divider wall to LH side of FHE is not complete at the top and requires to be installed Dry Riser outlet box to be formed in wall and make good all round Provide Type C connection to Dry Riser Relocate operating valve to lower hosereel to more accessible position Seal holes to ceiling slab above and make good all round Clean out builder's debris in FHE Seal hole in floor slab for pipes (2 No) and make good Make good to holes etc. below H Light on West Wall and repaint

Rating Classif. A A A A A A A B A B

Date Rectified

Date Checked

Comments

4/10/2013

130

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04)

Defect Reinstall skirting fixed with panel pins and refix with adhesive or clip-on system Replace missing corner piece to skirting at corridor LH side to Stair PE.21 Make good to poorly installed skirting at step base to North Wall Make good to poorly installed skirting at step base to South Wall Remove or fix loose large conduit or pipe on North Wall at ceiling level Refix light (West) that is out of alignment and set level Refix light (East) that is out of alignment and set level Seal North wall along full length at ceiling level as corridor is a Major Fire Escape Route and make good including bulkhead Seal North Wall at pipe (square hole) and make good all round, at upper level Seal North Wall at cable tray and make good all round, at upper level Seal North Wall at rectangular duct and make good all round Seal North Wall to pipe on RH side of rectangular duct and make good Seal North Wall to two (2) small pipes near ceiling and make good Seal opening at eastern end of North Wall and make good all round near Docking Bay Area Seal South Wall at SVP Pipe at eastern end and make good Seal South Wall at four (4) conduits and one (1) small pipe at eastern end and make good Seal South wall along full length at ceiling level as corridor is a Major Fire Escape Route and make good including bulkhead Seal South Wall at seven (7) conduits and one (1) small pipe above corridor to Stair PE21 and make good Seal South wall to one (1) small pipe at eastern end and make good Seal South Wall at three (3) conduits to RH of corridor to Stair PE21 and make good Remove or reconnect loose open wire in ceiling area at western end of South Wall Relocate sprinkler head fouled by many pipes etc in ceiling void area to restore effectiveness Install operator signage to Fire Alarm Button at South wall C14/15 Clearance height is 2.00 metres to Corridor (Fire Escape Route) to PE.21 and requires to be adjusted Seal West Wall to corridor which is a large void for 2 hour fire rating and make good all round Replace four (4) chipped steps Seal gap between bottom step and floor Redo floor which is very rough at door to west wall and make good to finishes all round Make good rough floor at top of steps and repaint Make good wall finish to LH side of head frame to door where door intruder contact has been installed Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected

Rating Classif. B B B B A B B A A A A A A A A A A A A A A A A A A B B B B B B B A

Date Rectified

Date Checked

Comments

2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL 2 HOUR FIRE RATED WALL W4A to review and advise W4A to review and advise 2 HOUR FIRE RATED WALL

4/10/2013

131

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44

Location Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04) Corridor C 14/15 (PW.04)

Defect Intumescent strip to both door jambs is short at base and to be replaced and also loose Fit proper locking set on door Remove all protective covering that remains Screw fixing missing to lock plate on door Install door stop to Door Install door closer to Door Remove paint on door and make good Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Realign door contacts for intruder alarm system

Rating Classif. A B B B B A B B A B B

Date Rectified

Date Checked

Comments

4/10/2013

132

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29

Location Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04) Corridor B/C 14/15 (PW.04)

Defect Provide skirting to steps Reinstall skirting fixed with panel pins and refix with adhesive or clip-on system Remove paint on duct at top of stairs on LH side Clean paint marks etc on steps throughout Remove paint to two (2) sprinkler heads in ceiling Remove paint on light fitting Make good to gap between stair bottom step and floor Reset Running Man sign level on wall Remove wall paint on Running Man sign Remove wall paint on H sign Glass Key Box to Fire Hosereel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hosereel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hosereel (FHE) door frame and blockwork Seal to head of door frame with blockwork and make good Make good door cill inside FHE Renew lock to FHE Door panel Remove paint on FHE frames all round and make good Remove paint on glass panel to FHE Door Wall to LH side of enclosure is missing and to be installed Wall to RH side of enclosure is missing and to be installed Ventilation duct in FHE enclosure requires to be enclosed in fire rated plasterboard etc. and made good Dry Riser outlet box to be formed in wall and make good all round Provide Type C connection to Dry Riser Upper Fire hosereel needs to be relocated as fouls door Lower Fire hosereel needs to be relocated as fouls door Clean out builder's debris in FHE Seal hole in floor slab for pipes (2 No) and make good Make good blockwork to head of FHE Box Seal ceiling slab for two(2) pipes and make good

Rating Classif. B B B B B B B B B B B B A A A A B B A A A A A A A B A A A

Date Rectified

Date Checked

Comments

4/10/2013

133

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25

Location Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08 Corridor PE.08

Defect Reinstall skirting fixed with panel pins and refix with adhesive or clip-on system Make good to wall above skirting with wall paint East Wall Make good to wall above skirting with wall paint West Wall Make good to wall above skirting with wall paint South Wall Make good to wall above skirting with wall paint North Wall No sprinkler installation provided Remove paint on light fitting Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door and head jambs is missing Make good at frame bases at floor level Remove all protective covering that remains Screw fixing missing to lock plate on door Install door stop to Door Install door closer to Door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Realign door contacts for intruder alarm system Redo skirting on South Wall as workmanship is very poor Remove paint on frames to South Door and make good Remove paint on door frames and make good to South Door Fire/Smoke seal threshold required to entry door South

Rating Classif. B B B B B A B B B A A B B A B A B A B B B B B A

Date Rectified

Date Checked

Comments

W4A to review and advise North Door North Door North Door North Door : W4A to review/ advise North Door North Door North Door North Door North Door North Door North Door North Door North Door South Door South Door South Door

4/10/2013

134

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

Location Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower Egress Stair PE.22 Lower

Defect Remove paint etc to top edge of skirting throughout and make good Clean light fitting of paint stains etc. Seal wall with sloping camb ceiling LH side Reset Running Man Sign level Remove masking tape and paint on Running Man Sign Tiled Ground floor uneven and dirty and to be reset, polished and sealed Seal South wall above door entry to ceiling and make good Seal and make good 'patchwork' plasterboard at grille above entry door and repaint all round Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door jambs is short and to be replaced Make good at frame bases at floor level Remove all protective covering that remains Screw fixing missing to lock plate on door Install door stop to Door Install door closer to Door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Replace lock set that is short in escutcheon of door Remove manufacturer's labels and make good

Rating Classif. B B B B B B B B B B A A B B B B A B A B B B

Date Rectified

Date Checked

Comments

Door to Basement Stairs

4/10/2013

135

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22)

Defect Remove paint etc to top edge of skirting throughout and make good Clean light fitting of paint stains etc. Make good to skirting that is showing signs of distress on West Wall Reset Running Man Sign level Remove masking tape and paint on Running Man Sign Tiled floor (Ground Level) is uneven and dirty and to be reset, polished and sealed Seal East wall above door entry to ceiling and make good Remove paint stains etc to stair to Level 1 Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short and loose and to be replaced Intumescent strip to hinge door jamb is missing and to be replaced Remove all protective covering that remains Screw fixing missing to lock plate on door Install door stop to Door Install door closer to Door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Replace lock set that is short in escutcheon of door Adjust door and eliminate 'play' Reset Loudspeaker on wall which is squint Make good to 600 x 500mm hole above entry door and seal all round and repaint Make good hole under wall light fitting and repaint Remove wall paint on pressurization system grille Clean at bases of door frames and make good to finishes Door strike plate is missing and to be replaced Remove plaster to skirting and steps Replace broken mid landing wall light Make good end of divider wall at mid-landing and repaint Replace two (2) chipped stair treads Redo skirting to steps as workmanship is poor

Rating Classif. B B B B B B B B B B A A B B B B A B A B B B B A B B B A B A B B B

Date Rectified

Date Checked

Comments

4/10/2013

136

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37

Location Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22) Egress Stair Upper (PE.22)

Defect Tiling floor to mid landing is uneven and dirty and to be relaid, polished and sealed Make good to upper part of divider wall to upper stair flight and repaint Make good skirting to RH side of Door at Ground Floor Make good skirting to LH side of Door at Ground Floor

Rating Classif. B B B B

Date Rectified

Date Checked

Comments

4/10/2013

137

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25

Location Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23 Service Elevator Vestib. PE.23

Defect Prepare for and paint ceiling Paint sprinkler pipe Door frame at bases is 5mm above floor finish and requires to be adjusted Fill in hole to door head frame Adjust inner leaf of door as it is still loose when closed Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is short on both side frames and requires to be replaced Install door stops to Doors Clean paint off Door Frames Door Signage Fire/Smoke Threshold seal is required to door North Install closers with selector on doors Remove all remaining parts of the protective covering to doors Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Skirting broken at LH side of door return to corridor Skirting loose at RH side of door return to corridor Skirting corner piece missing on RH side of return to corridor Make god to damage arris on LH side of door returns to corridor Skirting missing at wall returns to lift door Seal and make good to three conduits at North Wall near ceiling Seal and make good to sprinkler pipe at North Wall above door Seal and make good to one (1) conduit on South Wall near ceiling Seal and make good to hole in wall plasterboard lining on South Wall RH side of lift door

Rating Classif. B B A B A B B A A A B B A A B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

138

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper) Egress Stair PE 07 (Upper)

Defect Remove paint etc to top edge of skirting throughout and make good Clean light fitting of paint stains etc. Remove paint on Fire Key Box and make good Remove paint on Wall Light in Lower landing Remove paint on Running Man Sign and make good Tiled floor (Ground Level) is uneven and dirty and to be reset, polished and sealed Seal East wall above door entry to ceiling and make good Remove paint stains etc to stair to Level 1 Make good joint to ceiling above door at Eastern Wall and repaint Make good to distressed tile skirting to RH side of entry Door from Corridor PE.06 Make good to distressed tile skirting to South Wall Remove builder's marks for handrail etc on lower flight steps and make good Clean paint marks etc on both stair flights Remove paint to skirting on stair flights to Level 1 Replace five (5) chipped steps on stair flights to Level 1 Replace broken mid landing wall light Remove plaster to skirting and steps Redo skirting to steps as workmanship is poor Tiling floor to mid landing is uneven and dirty and to be relaid, polished and sealed Make good to chipped edges to divider wall at mid landing and up to level 1 and repaint

Rating Classif. B B B B B B B B A B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

139

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32

Location Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07) Egress Stair Lower (PE.07)

Defect Remove paint etc to top edge of skirting throughout and make good Clean light fitting of paint stains etc. Seal wall with sloping camb ceiling LH side Reset Running Man Sign level Remove masking tape and paint on Running Man Sign Tiled Ground floor uneven and dirty and to be reset, polished and sealed Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door jambs is short and to be replaced Seal joint between door frame and wall finishes Remove all protective covering that remains Screw fixing missing to lock plate on door Install door stop to Door Install door closer to Door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Replace lock set that is short in escutcheon of door Adjust door as it does not close properly Make good around Fire Damper grille and seal at upper level Provide proper locking device to Fire Damper Grille at upper level Remove paint to Fire Damper Grille at upper level Seal and make good to rectangular hole at high level on East Wall and repaint Make good to defective skirting on eastern wall (Ground) Make good cracked/distressed wall joint at southeast corner for lower part of wall and repaint Skirting to RH of Door is missing and to be replaced Skirting to LH of door is of poor workmanship and to be redone

Rating B B B B B B B B A A B B B B A B A B B A B B B B B B B B

Date

Date

Comments

4/10/2013

140

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Location Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex) Retail Area PE.09 (Mobex)

Defect Seal West Wall at south end at high level for two (2) pipes and make good Seal West Wall at south end at high level for one (1) pipes and make good Reconnect or remove two loose unconnected cables on West Wall (South) Seal and make good to duct opening on West wall Seal to cable tray opening on West wall at high level and make good all round Reconnect or remove one loose unconnected cable on West Wall (South) near circular duct Seal rectangular opening on West Wall (South) and make good all round Seal West Wall at near return end at high level for one (1) pipes and make good Seal and make good on return wall drainage pipe that is half buried in wall Seal and make good to rectangular duct opening to West Wall (North) LH Seal and make good to one (1) pipe near ceiling on West Wall (North) Seal and Make good to rectangular duct opening to West Wall (North) RH Seal and make good to rectangular duct on West Wall (North) at the right end above door Seal and make good the length of West Wall at ceiling Remove timber formwork to door step Seal and make good to upper part of West Wall CD 19 to ceiling including missing wall infill Install threshold plate to Double Entrance door on East Faade Seal and make good to LH of North Wall at ceiling level rectangular opening Seal and make good to three (3) rectangular openings for ducts all around Seal and make good at ceiling level on North Wall around beam Seal and make good to upper part of North Wall D 18/20 to ceiling including missing wall infill Sprinkler pipe to eastern side of Retail Area is inadequately supported and needs more holders Install threshold plate to Double Entrance door on South Faade Make good rubber seals to door where under distress at meeting style Adjust doors so that they are level at the head frames of doors Fire dampers to Duct 1 on West Wall Fire dampers to Duct 2 on West Wall Fire dampers to Duct 3 on West Wall Fire dampers to Duct 4 on West Wall Seal West Wall above door around beam and make good Seal and make good around cable tray at north return wall near door Seal wall head to ceiling and make good to North return wall Seal to hole with four (4) pipes and make good on North return wall Seal North return wall around beam at eastern end and make good

Rating Classif. A A A A A A A A A A A A A A B A B A A A A A B B B A A A A A A A A A

Date Rectified

Date Checked

Comments 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall

W4A to review and advise W4A to review and advise W4A to review and advise W4A to review and advise 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall

4/10/2013

141

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27

Location Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote) Retail Space PE.20 (Cosmote)

Defect Glass Key Box to Fire Hosereel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hosereel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hosereel (FHE) door frame and blockwork Seal to head of door frame with blockwork and make good Make good door cill inside FHE Divider wall RH is not completed in FHE Enclosure Divider wall LH is not completed in FHE Enclosure Remove heavy electrical cable in FHE Clean out builder's debris in FHE Seal hole in floor slab for pipes (2 No) and make good Make good blockwork to head of FHE Box Seal ceiling slab for two(2) pipes and make good Seal east wall at large pipe and make good all round near ceiling Seal opening with cable tray and four (4) pipes and make good on East wall Seal on West Wall for small pipe at south end and make good all round Seal on West Wall for small cable tray near ceiling at south end and make good all round Seal on West Wall for duct pipe and make good all round Seal on West wall near ceiling for two conduits and make good all round Seal for small sprinkler pipe on West Wall and make good Seal for SVP pipe in West Wall and make good Seal for two (2) conduits toward the northern end of West wall and make good Seal up large opening on north wall to RH of Column D14 and make good all round Install threshold plate to Shopfront entrance door Tidy up wiring to door intruder contacts Door closers with selector required Drop bolt keepers to lower end of door not there Sprinkler pipe in area needs a general touching up to prevent further rusting etc.

Rating Classif. B B A A A A A A B A A A A A A A A A A A A A B B A B B

Date Rectified

Date Checked

Comments

2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall

4/10/2013

142

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

Location Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon) Retail Space PE.20 (Cocoon)

Defect Install threshold plate to Shopfront entrance door Seal West Wall (South) for pipe at high level and make good Seal wall head to West wall AB 15 and make good Seal wall missing at wall head on return wall to West B15 and make good all round Seal hole in West Wall (South) around four (4) pipes and cable tray and make good Seal hole to pipe at high level RH side of West Wall (South) and make good Install operator signage to Fire Alarm Button at West return wall Seal wall missing at wall head on West Wall (North) BC 15 and make good all round Seal wall to pipe at RH end of West Wall (North) and make good Seal wall missing at wall head of North Wall C 15/16 and make good to six (6) pipes, cable tray and beam Fill in missing blockwork to North Wall RH at top Seal East Wall (North) around four (4) pipes and make good Seal East Wall (North) around cable tray and make good Seal East Wall (Mid) around one (1) pipe and make good Seal East Wall to irregular hole with four (4) pipes and cable tray and make good all round Seal East Wall (South) to two (2) pipes at high level and make good all round

Rating Classif. B A A A A A A A A A A A A A A A

Date Rectified

Date Checked

Comments

2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall 2 HOUR Fire Rated Wall

4/10/2013

143

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8

Location Retail Space PE.20 (Musette) Retail Space PE.20 (Musette) Retail Space PE.20 (Musette) Retail Space PE.20 (Musette) Retail Space PE.20 (Musette) Retail Space PE.20 (Musette) Retail Space PE.20 (Musette) Retail Space PE.20 (Musette)

Defect Install threshold plate to Shopfront entrance door Seal West Wall for pipe at high level RH side and make good Seal West Wall around hole for four (4) pipes and make good all round Seal wall head to West Wall and make good Seal East Wall around large opening for four (4) pipes and cable tray and make good all round Seal North Wall along complete length at top where unfinished and make good all round including duct Fire Damper required on duct Seal wall head to East Wall and make good

Rating Classif. B A A A A A A

Date Rectified

Date Checked

Comments

W4A to review and advise

4/10/2013

144

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29

Location Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13 Egress Stair E1E.13

Defect Remove paint etc to top edge of skirting throughout and make good Clean light fitting of paint stains etc. Reset Light fitting as not level Reset Running Man Sign level as not level Replace five (5) chipped steps to Level 2 Tiled First floor uneven and dirty and to be reset, polished and sealed Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to both door jambs is short and to be replaced Refix head rubber filling to door head which is loose Remove all protective covering that remains Two (2) screws fixing missing to lock plate on door Install door stop to Door Door is binding on hinges and is difficult to close and will not fully close on closer Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be realigned Remove paint on access card reader and make good Remove paint stains etc on both flights of stairs between Levels 1 and 2 and make good Seal off end of tubular hand rail at bottom Level 1 Make good to door arris to RH side of door Mid landing : replace L shaped tile at handrail and make good Mid landing tiles are uneven at bottom of upper flight including 'bossed' tiles Stair Handrail is not stable between Levels 1 and 2 and requires to be reset Clean light fitting of paint stains etc. at mid landing Reset Light fitting as not level at mid landing Replace cracked terrazzo floor tile near door

Rating Classif. B B B B B B B B A A B B B B A B A B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

145

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12

Defect Remove paint to South Door Frames Fit rubber seal all round door Intumescent strip is not complete to both frame bases of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Clean out at bases of door frames and make good Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Make good to arris on RH side of door to stair and repaint Tile floor is uneven and needs to be levelled, polished and resealed Remove paint on Blue Door Push button and make good Provide operation label to Door Push Button in Romanian and English Remove paint on Running Man sign and make good Remove paint from top edge of skirting on all walls Make good to wall paint just above skirting where stained by tiler's bad workmanship Provide rubber seal all round to door Make good round Fire Damper Grille panel (Lower) Make good round Fire Damper Grille panel (Upper) Provide proper locking device to Lower Fire Damper Grille Provide proper locking device to Upper Fire Damper Grille Clean paint off grille to Fire Damper panel (Lower) Clean paint off grille to Fire Damper panel (Upper) Screw missing in lock plate to door North Clean paint off door frame to Door North Replace prong point keeper that has been damaged Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Remove all remaining parts of protective covering to door

Rating Classif. B B A B B A B B A B B B B A B B B B B B B B B B B B B A B B A B B

Date Rectified

Date Checked

Comments

4/10/2013

146

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55

Location Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12 Stair Vestibule E1E.12

Defect Remove paint to three (3) sprinkler head in ceiling Glass Key Box to Fire Hosereel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hosereel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hosereel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork (loose block ready to fall) and make good Divider Wall to LH to be sealed full length to back wall Divider Wall to LH to be completed in upper part of FH enclosure (1.35 linear metres missing) Divider Wall to RH to be completed in upper part of FH enclosure Divider wall to RH to be sealed to front and back wall where unsealed Seal and make good to floor slab for supply pipe Seal two holes in floor slab within FHE and make good Seal two holes in ceiling slab within FHE and make good Seal blockwork around opening panel to Dry Riser Outlet and make good Remove timber inside Dry Riser Enclosure Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Divider wall on LH side of Dry Riser Enclosure is missing Replace missing skirting to RH of North door Make good to floor covering at North Door which is very untidy Make good to skirting to RH of Door South Make good to skirting to LH of Door South Fire/Smoke Threshold seal is required to door North

Rating Classif. C B B A A A A A A A A A A B B A A B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

147

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25

Location Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08 Egress Stair E1E.08

Defect Remove paint etc to top edge of skirting throughout and make good Clean light fitting of paint stains etc. Reset Light fitting as not level Skirting at lower stair divide wall is of poor workmanship and requires to be redone Replace two (2) chipped steps to Level 2 Tiled First floor requires to be polished and sealed and repaired where poor workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short and to be replaced Intumescent strip to hinge door jamb is short and missing at upper part and to be replaced Strike plate insert damaged and require to be replaced Install door stop to Door Door is binding on hinges and squeaks and requires adjustment as door does not close properly Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be realigned Make good between door frame and plaster jambs to door sides Remove paint stains etc on both flights of stairs between Levels 1 and 2 and make good Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Clean light fitting of paint stains etc. at mid landing Reset Light fitting as not level at mid landing Repair tile skirting to LH side of door Make good damage to lower divider wall to stair

Rating Classif. B B B B B B B B A A A A B A B A B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

148

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to both frame bases of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Clean two (2) light fittings Tile floor is uneven and needs to be levelled, polished and resealed Reset sprinkler head in ceiling that is protruding Provide operation label to Door Push Button in Romanian and English Remove paint on Running Man sign and make good Remove paint from top edge of skirting on all walls Make good to wall paint just above skirting where stained by tiler's bad workmanship Reset double power outlet in wall that is not level Make good round Fire Damper Grille panel (Lower) Make good round Fire Damper Grille panel (Upper) Provide proper locking device to Lower Fire Damper Grille Provide proper locking device to Upper Fire Damper Grille Clean paint off grille to Fire Damper panel (Lower) Clean paint off grille to Fire Damper panel (Upper) Screw missing in lock plate to door North Clean paint off door frame to Door North Adjust door as squeaks and binds on hinges Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Remove all remaining parts of protective covering to door

Rating Classif. B B A B B A B B A B B B B A B B B B B B B B B B B B A A B B A B B

Date Rectified

Date Checked

Comments

4/10/2013

149

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61

Location Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07 Stair Vestibule E1E 07

Defect Remove paint to three (3) sprinkler head in ceiling Glass Key Box to Fire Hosereel box the glass is loose and should re replaced with a Break Glass Key Box as key is missing Bed Glazing to Fire Hosereel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hosereel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork and make good Divider Wall to LH to be sealed full length to back wall Divider Wall to LH to be completed in upper part of FH enclosure (1.35 linear metres missing) Divider wall to RH to be sealed to front and back wall where unsealed Seal LH Divider wall to pipe at high level Seal RH divider wall to pipe at high level Seal two holes in floor slab within FHE and make good Install access panel cover for Dry Riser which is missing Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Divider wall on LH side of Dry Riser Enclosure is missing Clean out general rubbish in Dry Riser Enclosure Reset H sign as not level Replace missing skirting to RH of North door Make good to floor covering at North Door which is very untidy Make good to skirting to RH of Door South Make good to skirting to LH of Door South Fire/Smoke Threshold seal is required to door North Make good to floor at South Door LH Make good to floor at South Door RH Make good arris to LH return to Stair Door and repaint Make good to tile skirting to LH side of North Door Make good to tile skirting to RH side of North Door Remove reinforcement in wall to LH side of north door and make good to wall including stains made when cutting rod

Rating Classif. C A B A A A A A A A A A A A A B B B B B B A B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

150

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29

Location Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09 Service Elevator Vestib. E1E.09

Defect Prepare for and paint ceiling Paint sprinkler pipe Door frame at bases is 5mm above floor finish and requires to be adjusted Fill in hole to door head frame Adjust inner leaf of door as it is still loose when closed Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is short on both side frames and requires to be replaced Install door stops to Doors Clean paint off Door Frames Door Signage Fire/Smoke Threshold seal is required to door North Install closers with selector on doors Remove all remaining parts of the protective covering to doors Install rubber seal to door Intumescent strip to meeting style is not continuous and missing at door lock Realign door intruder alarm contacts Refix loose skirting to LH side of lift door Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Remove paint on light switch to LH side of Lift Door and make good Remove paint on both indicator panels to RJ side of lift door and make good Seal and make good to sprinkler pipe at North Wall above door Fit and fix floor covering Make good to concrete threshold to lift door and fit floor covering including edging piece to lift door Remove paint on Access Card Reader and make good Check lift reprogrammed to stop at Level 1 Remove paint on lift door frames and make good Repair cracked arris at RH side of Lift Door

Rating Classif. B B B B A B B A A B B B A A B B A B B B B B B B B B A B B

Date Rectified

Date Checked

Comments

4/10/2013

151

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03)

Defect Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Skirting loose on East wall of corridor Fit and fix floor coverings Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is not installed and is required to sides and head frames Install permanent door handles Screw missing at lock plate Install door stop to Door Install rubber seal to Door all round Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Install door closer Remove manufacturer's labels on door and make good Make good to floor covering at door threshold including edging piece Seal East Wall at conduit at ceiling level at north end and make good all round Seal East Wall at cable tray near ceiling level at north end and make good all round Seal East wall at AHU metal support and make good all round Seal East Wall at sprinkler pipe near ceiling level at north end and make good all round Refix loose plasterboard behind AHU on East Wall Remove paint on Light Fitting on East Wall and make good Seal wall to hole on East Wall with four (4) pipes and make good all round Install operator signage to Fire Alarm Button at East Wall Seal at East Wall (South) near ceiling level a large sprinkler pipe and make good all round Install final layer of plasterboard in top RH side of East Wall above door which is missing and make good all round Install plasterboard to large full length gap to South Wall above door and seal to duct, sprinkler pipe and two (2) conduits Rest Running Man Sign which is not level Make good to South wall where damaged on RH side of door at low level Seal at West Wall (South) to large sprinkler supply pipe and make good all round Seal at West to cable tray at high level (South) and make good all round Seal at West wall to hole with four (4) pipes and make good all round

Rating Classif. B B B B B A A B B B B B A B A B B A A A A A B A A A A A B B A A A

Date Rectified

Date Checked

Comments

Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02 Door to Retail Area E1E.02

4/10/2013

152

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43

Location Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03) Corridor C/D 17/18 (E1E.03)

Defect Seal at West Wall to rectangular horizontal hole with two (2) pipes and make good all round Seal at West Wall to rectangular vertical hole with two (2) pipes and make good all round Seal West wall at AHU metal support and make good all round Seal at West Wall and make good to one (1) conduit at ceiling level (mid) and make good all round Seal at West Wall and make good to one (1) conduit at ceiling level (North) and make good all round Seal at West Wall (North) to pipe and make good all round Seal at West wall to cable tray near ceiling at northern end and make good all round Seal wall head to East Wall and make good all round Seal wall head to West Wall and make good all round Prepare and paint ceiling

Rating Classif. A A A A A A A A A B

Date Rectified

Date Checked

Comments

4/10/2013

153

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03)

Defect Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Fit and fix floor coverings Prepare and paint ceiling Seal South Wall to one (1) sprinkler pipe A and make good all round Seal South Wall to one (1) sprinkler pipe B and make good all round Seal South Wall to one (1) sprinkler pipe C and make good all round Seal South Wall to one (1) sprinkler pipe D and make good all round Seal South Wall to one (1) sprinkler pipe E and make good all round Seal South Wall to one (1) sprinkler pipe F and make good all round Seal at Wall head to South wall for full length and make good as paint is missing on RH side of wall at cable tray Make good to wall above skirting where paintwork is fouled Seal at South Wall at cable tray near ceiling (East) and make good all round Refix loose skirting on South wall Seal and make good to SVP pipe at East End on ceiling Seal and make good to SVP pipe at Mid part of ceiling Seal and make good to SVP pipe at West End on ceiling Reconnect or remove loose wire in cable tray Seal and make good to electrical cable at southwest part of ceiling and make good Repair insulation to SVP pipe in west part of ceiling Seal Wall return to South Wall (West) around bean and make good all round Seal wall near ceiling to wall return to South wall (West) and make good around large cable tray and four (4) pipes Refix skirting to column D15 and make good Complete sealing of North wall D15/18 at wall head and make good including two (2) conduits Remove wall paint from five (5) lights and make good Fill in hole to North Wall and seal (LH) Fill in hole to North Wall and seal (RH) Complete painting of North wall as not finished Complete sealing of West wall D15 at wall head and make good Complete sealing of North wall D14/15 at wall head and make good including two (2) conduits Seal North Wall D14/15 at wall head and make good all round Seal North Wall at D15 around beam and make good Seal North Wall D14/15 to ventilation duct and make good all round Seal South Wall D15 at wall head and make good all round

Rating Classif. B B B A A A A A A A B A B A A A A A A A A B A B A A B A A A A A A

Date Rectified

Date Checked

Comments

What are electrical conduits ? What are electrical conduits ?

4/10/2013

154

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53

Location Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03) Corridor D 14 to 18 (E1E.03)

Defect Seal South Wall D 15 to sprinkler pipe (LH) near ceiling and make good all round Seal South Wall D 15 to SVP pipe (LH) near ceiling and make good all round Repair insulation to SVP pipe to LH side of South Wall D 15 Seal South Wall D15 to beam at ceiling level and make good all round Seal South wall to sprinkler pipe (RH) near ceiling level and make good all round Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is short at base of both door frames and to be replaced Intumescent strip is short to top frame of door and to be replaced Screw missing at lock plate Install door stop to Door Install rubber seal to Door all round Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Install door closer Remove manufacturer's labels on door and make good Make good to floor covering at door threshold including edging piece Remove paint on door and make good

Rating Classif. A A A A A B B A A A B B B B A B A B B B

Date Rectified

Date Checked

Comments

Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall) Door to Retail Space (South Wall)

4/10/2013

155

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03)

Defect Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Fit and fix floor coverings Prepare and paint ceiling Replace missing skirting corner at wall return north (Elec. Enclosure) Repair and make good LH arris to wall return at Electrical Enclosure Refix skirting to LH of Electrical Enclosure that have become loose Refix skirting to RH of Electrical Enclosure that have become loose Refix loose corner piece of skirting at LH of Electrical Enclosure Repair skirting to both wall ingoings to Door to Female Toilet E1E.05 Make good floor covering to Door to Retail Unit including edging piece (E1E.04) (North) Make good floor covering to Door to Female Toilet including edging piece (E1E.05) Make good floor covering to Door to Male Toilet including edging piece (E1E.06) Repair skirting to both wall ingoings to Door to Male Toilet E1E.06 Make good floor coverings including threshold edging strip to Stair Door (E1E.07) Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is not installed and is required to sides and head frames Install permanent door handles Screw missing at lock plate Install door stop to Door Install rubber seal to Door all round Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Install door closer Remove manufacturer's labels on door and make good Remove all remaining protective covering to door Clean to two (2) light fittings Seal East Wall (Electrical Enclosure) at wall head and make good all round Seal East Wall (Electrical Enclosure) at small pipe and make good all round Seal East Wall (Electrical Enclosure) at cable tray and make good all round Seal East Wall (Electrical Enclosure) at RH side to pipe and make good all round

Rating Classif. B B B B B B B B B B B B B B B B A A B B B B B A B A B B B A A A A

Date Rectified

Date Checked

Comments

Door to Retail Unit E1E.04 North

4/10/2013

156

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48

Location Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03) Corridor C/D 14/15 (E1E.03)

Defect Install fixing screws to two control boxes on East Wall to Electrical Enclosure Make good to floor concrete, relevel and prepare for floor covering at door to Retail Area E1E.03 (North) Seal West Wall (LH) near ceiling to two (2) large pipes and make good all round Seal West Wall (LH) near ceiling to cable tray and make good all round Seal West Wall (LH) near ceiling to one (1) small pipe and make good all round Seal West Wall (LH) near ceiling to one (1) large pipe and make good all round Seal West Wall (LH) near ceiling to one (1) large circular duct pipe and make good all round Seal West Wall near ceiling (Mid) to one (1) conduit and make good all round Seal wall head to West wall and make good to full length Seal West Wall (RH) at hole in wall and make good all round Seal West Wall (RH) at hole in wall to four (4) pipes and make good all round Seal West Wall (RH) at cable tray near ceiling and make good all round Seal West Wall (RH) at one (1) sprinkler pipe near ceiling and make good all round Seal West Wall (LH) side for one (1) pipe below two large pipes and make good all round Seal West Wall at beam D 14/15 and make good all round

Rating Classif. B B A A A A A A A A A A A A A

Date Rectified

Date Checked

Comments

NOTE : Electrical Cabinets with locks were NOT inspected

4/10/2013

157

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03) Corridor C 14/15 (E1E.03)

Defect Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Fit and fix floor coverings Prepare and paint ceiling Relocate sprinkler heads that are fouled up by other MEP equipment and reduced in effectiveness Clean light fitting Rest Running Man Sign that is not level Remove wall paint from Running Man Sign and make good Install operator signage to Fire Alarm Button at South Wall Install operator signage to Door Release Button at South Wall Install break glass to Emergency Door Release Button on South Wall Complete plasterboard to South Wall at ceiling level yet to be executed and make good to duct and four (4) pipes Seal at South Wall around beam C/D 15 and make good Seal at wall head on East Wall and make good full length Seal East Wall (LH) to small pipe and make good Seal East Wall near ceiling to cable tray and make good Seal East Wall (RH) to large pipe and make good Seal East Wall (RH) to small pipe and make good Seal at wall head on North Wall and make good full length Seal North wall around beam C/D 15 and make good all round Seal North wall near ceiling to one (1) sprinkler pipe and make good all round Seal North Wall at western end where hole next to ceiling and make good to two (2) conduits complete Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip is not installed and requires to be on both side frames and head frame Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Make good to floor covering at door threshold including edging piece Screw missing at lock plate Install door stop to Door Install rubber seal to Door all round Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Install door closer

Rating Classif. B B B A B B B A A A A A A A A A A A A A A B B A A B B B B B A B A

Date Rectified

Date Checked

Comments

W4A to review and advise

4/10/2013

158

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

Location Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05 Female Toilet E1E.05

Defect Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Remove paint on door frames and make good Replace wrong lockset Tidy up floor covering at door threshold and provide edging strip to floor tiles Replace screws to inner door grille to match grille as outside No water supply to sink taps Tap LH is loose and to be tightened Tap RH is loose and to be tightened Install plug Light switch plate is not level Reset and make good around floor gulley Remove and tidy up mortar grouting to wall Wall tiling is of mediocre standard and excess mortar to be removed Clean up grout between tiles to floors Clean dirt/dust in and around the two (2) ceiling ventilators Running Man sign is not level and to be aligned Remove wall paint to Running Man sign and make good Make good to rough pointing and join between wall tiling and mosaic on RH leg support Make good and repair to rough patch to mosaic covering to RH of sink on vanity surface Tiling below sink is of poor quality and to be re-executed Mosaic to Vanitory Unit is generally sub-standard and should be redone Make good joint between wall tiling and floor below Vanitory Unit Make good joint between mosaic and wall tiling at top surface of Vanitory Unit and seal

Rating Classif. B B B B B B A B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

159

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27

Location Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06 Male Toilet (E1E.06

Defect Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Remove paint on door frames and make good Replace wrong lockset Tidy up floor covering at door threshold and provide edging strip to floor tiles Replace screws to inner door grille to match grille as outside No water supply to sink taps Tap LH is loose and to be tightened Tap RH is loose and to be tightened Install plug Light switch plate is not level Reset and make good around floor gulley Box in water meter and provide access panel Remove tape at mirror and make good Wall tiling is generally substandard and excess grout is to be removed Make good substandard mosaic to top of Vanitory Unit on RH side Make good to joint between mirror and wall and mosaic tiles at top of Vanitory Unit Wall tiling below Vanitory Unit to be re-executed including replacing broken tiles Wall tiles to LH of door are not level and to be redone Wall tiling very substandard in WC cubicle and requires to be redone Clean grouting to floor tiles as very dirty Replace cracked floor tile on South Wall base Clean dirt/dust at and around the two (2) ceiling ventilators and make good Mosaic work to Vanitory unit is generally substandard Modesty screen to Urinal requires to be more firmly fixed Make good joint to LH side of Vanitory unit between mosaic and wall tiling Clean out relieving bead between wall tiling and plaster frieze on East Wall

Rating Classif. B B B B B B A B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

160

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7

Location Retail Area (Togo) E1E.04 Retail Area (Togo) E1E.04 Retail Area (Togo) E1E.04 Retail Area (Togo) E1E.04 Retail Area (Togo) E1E.04 Retail Area (Togo) E1E.04 Retail Area (Togo) E1E.04

Defect Seal North Wall at Wall head and make good for full length Seal Wall near ceiling to West Wall around cable tray (North) and make good Seal West Wall at wall head and make good for full length Seal East Wall 450mm at wall head and make good for full length Seal South Wall above bulkhead and make good for full length Seal East wall for group of four (4) pipes and make good all round Seal East wall for cable tray (North) and make good all round

Rating Classif. A A A A A A A

Date Rectified

Date Checked

Comments

4/10/2013

161

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Location Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10) Retail Area A/C 15/17 (E1E.10)

Defect Seal North Wall around four (4) pipes and make good all round Seal at ceiling level missing wall boarding to North Wall and make good Seal West Mid BC 16 Wall around four (4) HVAC pipes and make good all round Seal at ceiling level missing wall boarding to Wes Mid BC 16 Wall and make good Seal West Mid BC 16 Wall for one (1) sprinkler pipes and make good all round Seal West Wall AB 15 where wall boarding is missing at upper level to ceiling slab and make good all round Seal North return wall to West Wall where wall boarding is missing at upper level to ceiling slab and make good all round Seal West Wall (North) CD/15 where wall boarding is missing at upper level to ceiling slab and make good all round Seal North Wall around one small pipe and make good all round Seal North Wall D15/17 where wall boarding is missing at upper level to ceiling slab and make good all round Seal South Wall A 15/17 for full length above bulkhead and make good all round Seal wall board missing at upper level to B 17/18 North and make good all round Seal East Wall above bulkhead A/B 17/18 and make good all round and seal to four (4) HVAC pipes Seal South Wall A 18/21 for full length above bulkhead and make good all round Seal wall board missing at upper level to B 18 North and make good all round Seal East Wall above bulkhead A/B 18 and make good all round Seal East wall at A/B 18 to four (4) HVAC pipes and make good all round Seal West above bulkhead A/B 18 and make good all round

Rating Classif. A A A A A A A A A A A A A A A A A A

Date Rectified

Date Checked

Comments

4/10/2013

162

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Location Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02) Retail Area A/D 18/21 (E1E.02)

Defect Seal wall board missing at upper level to B 18 North and make good all round Seal East Wall above bulkhead A/B 18 and make good all round Seal East wall at A/B 18 to four (4) HVAC pipes and make good all round Seal West above bulkhead A/B 18 and make good all round Seal East Wall around Beam B 18/19 and make good all round Seal East wall around Beam C 18/19 and make good all round Relocate sprinkler heads near East Wall (Ozer) Seal East wall at wall head for full length A/D 19 and make good all round Seal West Wall to wall head for full length and make good all round A/D 18 Seal West wall (RH) to four (4) HVAC pipes and make good all round Seal West Wall around Beam B 18/19 and make good all round Seal West wall around Beam C 18/19 and make good all round Seal West Wall (RH) to one (1) small pipe and make good Seal West Wall (RH) to one (1) sprinkler small pipe and make good Seal West Wall (LH) to one (1) sprinkler small pipe and make good Seal West Wall (LH) to one (1) small pipe and make good Seal West wall (LH) to four (4) HVAC pipes and make good all round Complete wall boarding to West Wall at upper level and make good all round

Rating Classif. A A A A A A A A A A A A A A A A A A

Date Rectified

Date Checked

Comments

4/10/2013

163

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

Location Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01) Lift Lobby Level 2 (E2E.01)

Defect Tiling to floor is uneven and not aligned and requires to be re-executed Wall Tiling to West Wall is debonding, uneven, not aligned and requires to be re-executed Wall Tiling to East (Lift) Wall is uneven, not aligned and requires to be re-executed Remove paint on loudspeaker in ceiling and make good Readjust two (2) small downlighters that are not properly aligned and make good Remove paint on ventilation grille near lifts Seal pointing between tiling and lift panelling to PE 09 at head RH Seal pointing between tiling and lift panelling to PE 08 at head both sides Seal pointing between tiling and lift panelling to PE 07 at head both sides Refit stainless steel skirting to Lift PE 09 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 08 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 07 that show gaps between the skirting and wall panelling both sides Clean threshold of Lift PE 07 Clean threshold of Lift PE 08 Clean threshold of Lift PE 07 Make good to floor covering at RH of lift door frame PE7 Make good to floor covering at LH of lift door frame PE7 Make good to floor covering at RH of lift door frame PE8 Make good to floor covering at LH of lift door frame PE8 Make good to floor covering at RH of lift door frame PE9 Make good to floor covering at LH of lift door frame PE9

Rating Classif. B B B C B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

164

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01) Corridor C 14/18 Level 2 (E2E.01)

Defect Clean up ventilated dirt deposits on painted ceiling finish to eight (8) air inlets and make good Skirting not yet installed Floor covering not yet installed Remove tape and paint stain on Fire Alarm to South Wall near door to Stair Vestibule E2E.03 Install operator signage to Fire Alarm Button at South Wall near door to Stair Vestibule E2E.03 Make good round Fire Damper Grille panel (Low) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Lower) near Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall near Lift Lobby Tiling to wall at C17 South Wall is uneven and not aligned and requires to be re-executed Tiling to wall at C16 South Wall is uneven and not aligned and requires to be re-executed Install operator signage to Fire Alarm Button at South Wall RH of Service Elevator Vestibule Install operator signage to Door Release Button at South Wall to RH of Service Elevator Vestibule Install break glass to Emergency Door Release Button on South Wall to RH of Service Elevator Vestibule Complete paintwork in ceiling recess bulkhead (light trough) along South Wall Make good round Fire Damper Grille panel (Upper C 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper C 16) near Lift Lobby Provide proper locking device to Upper (C/16) Fire Damper Grille on South Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on South Wall near to RH side of Service Elevator Lobby Clean paint off grille to Fire Damper panel (Lower) to RH side of Service Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall to RH side of Service Lift Lobby

Rating Classif. B B B B A B B B B B A A A B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

165

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

Location Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01) Corridor Level 2 B/C 14 (E2E.01)

Defect Install access panel No 1 and frame to ceiling Install access panel No 2 and make good to frame to ceiling Glass Key Box to Fire Hosereel box the glass is loose and should re replaced with a Break Glass Key Box as key is missing Bed Glazing to Fire Hosereel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hosereel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork and make good Divider Wall to LH to be sealed full length to back wall Seal wall at RH side of enclosure for waste pipe and make good Seal two holes in ceiling slab within FHE and make good Remove cable and make good to ceiling and floor slab when removed Make good round Fire Damper Grille panel (Upper C 14) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper C 14) near Lift Lobby Provide proper locking device to Upper (C/14) Fire Damper Grille on South Wall near Lift Lobby Skirting not yet installed Floor covering not yet installed

Rating Classif. A A A B A A A A A A A B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

166

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Location Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01) Corridor Level 2 B 14/18 (E2E.01)

Defect Clean up ventilated dirt deposits on painted ceiling finish to eight (8) air inlets and make good Skirting not yet installed Floor covering not yet installed Make good to gap between Low Fire Damper Grille on North Wall and tiling finish Install operator signage to Fire Alarm Button at North Wall near door to Stair Vestibule E2E.03 Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E2E.03 Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E2E.03 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E2E.03 Tiling to wall at C17 North Wall is uneven and not aligned and requires to be re-executed Tiling to wall at C16 North Wall is uneven and not aligned and requires to be re-executed Install operator signage to Fire Alarm Button at North Wall LH of Stair Vestibule E2E.17 Complete paintwork in ceiling recess bulkhead (light trough) along North Wall Make good round Fire Damper Grille panel (Upper C 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper C 16) near Lift Lobby Provide proper locking device to Upper (C/16) Fire Damper Grille on North Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E2E.17 LH Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E2E.17 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E2E.17 LH Make good to chipped arris to LH of door to Stair Vestibule E2E.03

Rating Classif. B B B B A B B B B B A B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

167

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26

Location Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18 Egress Stair E2E.18

Defect Remove paint etc to top edge of skirting throughout and make good Clean light fitting of paint stains etc. Reset Light fitting as not level Reset Running Man Sign light as not level Tiled Level 2 floor requires to be polished and sealed and repaired where poor workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short and to be replaced Intumescent strip to hinge door jamb is short and to be replaced Rubber infill strip to door is loose at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be realigned Clean out and make good to floor at frame bases to door Door Access Closer was operational but could be opened by a strong push and needs to be reset Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Clean light fitting of paint stains etc. at mid landing Reset Light fitting as not level at mid landing Make good tiling at mid landing at stair turn as of poor workmanship Lower flight top stair tread moves on strong shaking of the handrail and requires all to be refixed firmly Seal gap between lower flight to step and mid landing Clean two (2) stair flights between Levels 2 and 3 of paint and mortar stains complete

Rating Classif. B B B B B B B A A A B B B B A B B B A B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

168

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to both frame bases of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Intumescent strip is missing on the head frame Install door closer Adjust door to remove squeak and binding Tile floor is uneven and needs to be levelled, polished and resealed Make good to wall around Dry Riser including the removal twelve (12) black headed screws Provide operation label to Door Push Button in Romanian and English Remove paint on Running Man sign and make good Remove paint from top edge of skirting on all walls Make good to wall paint just above skirting where stained by tiler's bad workmanship Reset double power outlet in wall that is not level Clean two (2) light fittings Clean paint and masking tape off door frame to Door North Intumescent strip to hinge frame is short at upper prong on Door North Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Install door closer to Door North Screw missing in lock plate to door North Remove all remaining parts of protective covering to door

Rating Classif. B B A B B A B B A B A A A B B A B B B B B B A A B B A B B A B B B

Date Rectified

Date Checked

Comments

4/10/2013

169

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43

Location Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17 Stair Vestibule Level 2 E2E.17

Defect Remove paint to three (3) sprinkler head in ceiling Remove masking tape to two (2) Sprinkler heads Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internal around Dry Riser Access Panel and make good Make good to skirting to RH of Door South Make good to skirting to LH of Door South Make good to floor at South Door RH

Rating Classif. C A B B B A B B B B

Date Rectified

Date Checked

Comments

4/10/2013

170

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26

Location Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05 Vestibule E2E.05

Defect Make good to south sprinkler head and rest Clean up stains on ceiling loudspeaker Make good to bossed tiles near corridor to Electrical Closet and Data Room Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to both frame bases of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Install door closer to Door South Install permanent handles etc. to door South Clean paint off door frame to Door North Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Install door closer to Door North Remove all remaining parts of protective covering to door Install missing lock and door handles to North Door

Rating Classif. B B B B B A B B A B B A B A B B A B B A B B A B B A

Date Rectified

Date Checked

Comments

4/10/2013

171

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Location Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06 Handicapped Toilet E2E.06

Defect Make good to floor tiling around floor gulley and regrout Clean grouting to tiles generally Replace door grill screws (Internal) with white headed screws Tidy up floor at LH Base Frame of door Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Reset WC seat and make firm WHB tap is loose and to be reset properly Replace damage collar washer to WHB tap Install plug Install missing chromium insert to overflow to WHB Install Door stop Install rubber seal around door Generally clean off excess grouting on wall tiles No hot water available

Rating Classif. B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

172

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Location Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07 Toilet E2E 07

Defect Make good to floor tiling at RH side on door Make good to floor tiling at LH side on door Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally Tidy up joint between wall and floor tiling on South Wall Remove paint on mirror and make good WHB tap is loose and to be reset properly Install plug No hot water available Replace door grill screws (Internal) with white headed screws WC Toilet Flushing mechanism is not working

Rating Classif. B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

173

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Location Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08 Toilet E2E 08

Defect Make good to floor tiling at joint with wall tiling at RH side on door Make good to floor tiling at joint with wall tiling along South Wall Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally Tidy up joint between wall and floor tiling on South Wall Install overflow chromium insert WHB tap is loose and to be reset properly Install plug No hot water available Replace door grill screws (Internal) with white headed screws Door to be eased as 'loud squeak' Remove paint splashes on wall tiling

Rating Classif. B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

174

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Location Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09 Toilet E2E.09

Defect Make good tile grouting etc around floor gulley Make good to lower RH Door frame where paint has peeled and frame rusted Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally Install missing chromium insert to overflow to WHB Remove paint on mirror and make good WHB tap is loose and to be reset properly Install plug No hot water available Replace door grill screws (Internal) with white headed screws

Rating Classif. B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments Floor hydro-insulated ??

4/10/2013

175

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10 Handicapped Toilet E2E.10

Defect Make good to floor tiling around floor gulley and regrout Clean excess grouting to tiles generally Replace door grill screws (Internal) with white headed screws Tidy up floor at LH Base Frame of door Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Clean fan outlet in ceiling of dirt/dust etc. WHB tap is loose and to be reset properly Make good joint between wall tiling and floor tiling on West wall Install plug Install missing chromium insert to overflow to WHB Install Door stop Install rubber seal around door Replace door grill screws (Internal) with white headed screws No hot water available Install rubber seal around door Clean out at bases to door frames and make good to floor finish

Rating Classif. B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

176

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12 Janitor Closet E2E.12

Defect Fix correct lock set to door Replace door grill screws (Internal) with white headed screws Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Remove all remaining parts of protective covering to door Remove paint on door frames and make good Remove wall paint on trims to suspended ceilings and make good Redo angle edge to vertical corner to LH of door and make good Redo angle edge to vertical corner southeast and make good Make good to joint between wall and floor tiling on South Wall Make good to joint between wall and floor tiling on West Wall Replace broken suspended ceiling tile Replace badly water stained suspended ceiling tile LH tap in wall is loose and requires to be fixed properly Tile around LH tap is broken and to be replaced RH tap in wall is loose and requires to be fixed properly Make good wall to pipe and seal Make good suspended ceiling tile around supply pipe in northeast corner Install door stop Install trough

Rating Classif. B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

177

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26

Location Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11 Pantry E2E.11

Defect Wall tiling is generally poor workmanship Make good joint between wall and floor tiling on North Wall Clean off excess grouting throughout Make good to large void on South Wall below units and generally tidy up and if required install access panel Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Replace door grill screws (Internal) with white headed screws Install rubber seal to door all round Make good to base of RH door frame that is damaged Make good joint to ceiling on East Wall to Janitor Closet Redo angle piece on wall tiling at external angle to LH of door to Janitor Closet Redo angle piece on wall tiling at external angle to RH of door to Janitor Closet Door frames are set above floor finish by 10/12mm and require to be reset Reset RH door to upper cabinet on South Wall Reset LH door to upper wall cabinets on East Wall No hot water available Install plug Seal floor cabinet units between wall and units LH side and make good Seal floor cabinet units between wall and units RH side and make good Replace broken suspended ceiling tile Make good untidy joint between wall tiling and suspended ceiling on North Wall Install door stop Are suspended ceiling tiles water resistant (pantry has boiling kettles etc.) Double bowel sink shown on drawings - Who authorised the change to a single bowel sink

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

178

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Location Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13 Vestibule E2E.13

Defect Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Skirting loose on North Wall Replace missing external corner piece to LH of door to Data Room Replace missing external corner piece to RH of door to Data Room Replace missing internal corner piece to LH of door to Electrical Closet Floor at entry to Main Vestibule requires to be levelled and floor covering resealed Edging strip required at door to main vestibule for joint between tiles floor and PVC Floor covering Clean light of dirt and paint stains Frames of door to Main Vestibule are set some 10mm above floor finish and require to be reset Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Remove labels on door and make good

Rating Classif. B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

179

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Location Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15 Data Room E2E.15

Defect Paint ceiling Paint wall including columns and beams Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Seal hole in South wall and make good Seal around conduit pipe in South wall and make good Frames of door to Main Vestibule are set some 10mm above floor finish and require to be reset Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Provide threshold plate to door Complete conduit to smoke detector Seal North wall to two (2) HVAC pipes and make good all round Make good joint between plasterboard wall finish and column on RH side of North wall Seal to conduit on East wall and make good

Rating Classif. B B B B B B B B B B B B B B B A B B

Date Rectified

Date Checked

Comments

4/10/2013

180

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37

Location Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14 Electrical Closet E2E.14

Defect Paint ceiling Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Make good to all ingoing of wall around door to frames and head Complete plasterboard wall lining on East wall Remove fixing wire set in wall (East) and make good Make good to floor level on South Wall near door and refix floor covering Skirting on South wall is not complete Replace missing external corner piece to RH of door to Vestibule Infill large hole in southeast of room from which Level 1 is very visible Infill large hole on East Wall from which Level 1 is very visible Refix loose skirting on East wall Make good to north wall next floor sinking and refix floor covering complete Skirting missing at North wall Remove paint to Door Frames Fit rubber seal all round door Intumescent strip is not complete to both frame bases of door Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to door Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Tidy up door intruder alarm contact wiring Install door closer Realign intruder alarm door contacts Door sign Frame bases of door are set 15 to 25mm above floor finish and require to be reset properly Make good to taped jointed wire to Smoke Detector Make good to three (3) taped jointed wires in cable trays at ceiling level Fit sealing screws to five (5) control boxes Replace label to cabinet SBS 6E which is plastic with paper printed sign stuck on with sellotape and install ivorine label Reconnect loose wire or remove in electrical box above control boxes Cabinet TUPS2-E refix panel to top internally Cabinet TL2-E refix three (3) panels at top Re-adjust cabinet TL2-E inner door as difficult to close and fasten Realign doors to Cabinet TL2-E as not level

Rating Classif. B B B B B B B B A A B B B B B A B B A B B A B B A B B B A A B B A A A B B

Date Rectified

Date Checked

Comments

4/10/2013

181

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

Location Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16 Service Elevator Vestibule E2E.16

Defect Prepare for and paint ceiling Access Car Reader is not level and to be reset Door frame at bases is 5mm above floor finish and requires to be adjusted Fill in hole to door head frame Adjust inner leaf of door as it is still loose when closed Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to Door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is short on both side frames and requires to be replaced Install door stops to Doors Clean paint off Door Frames Door Signage Fire/Smoke Threshold seal is required to door North Install closers with selector on doors Remove all remaining parts of the protective covering to doors Install rubber seal to door Intumescent strip to meeting style is not continuous and missing at door lock Realign door intruder alarm contacts Fit permanent handles and lock to doors Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Replace missing external corners to skirting to LH of Lift Door Replace missing external corners to skirting to RH of Lift Door Relay floor covering that is distorted and 'bubbled' and prepare floor screed below Install floor covering to entrance recess to Service Elevator Vestibule Make good to concrete threshold to lift door and fit floor covering including edging piece to lift door Install PVC Skirting to entrance recess to Service Elevator Vestibule Make good scratches to door surface Repair damaged wall at LH side of Lift Door in ingoing to lift Repair damaged wall at LH side of Lift Door Paint sprinkler pipework Tidy up elbow joint on sprinkler pipework Replace screws at grille to LH side with white headed screws as elsewhere Seal and make good to conduit at ceiling level (West Wall) Seal and make good to two (2) conduits at northeast corner at ceiling level Seal and make good to one (1) sprinkler pipe in northeast corner at near ceiling level

Rating Classif. B B B B A B B A A B B B A A B B A B B B B B B B B B B B B B B B A A A

Date Rectified

Date Checked

Comments

4/10/2013

182

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

Location Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04 Egress Stair E2E.04

Defect Remove paint etc to top edge of skirting throughout and make good Clean light fitting of paint stains etc. Reset Light fitting as not level Reset Running Man Sign light as not level Tiled Level 2 floor requires to be polished and sealed and repaired where poor workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short and to be replaced Intumescent strip to hinge door jamb is short and to be replaced Rubber infill strip to door is loose at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts ARE MISSING Screw in head frame to be removed and make good to frame Remove all remaining protective covering to door Remove plaster daubs on door and make good Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Clean light fitting of paint stains etc. at mid landing Remove tile set in two pieces in mid landing and make good Make good tiling at mid landing at stair turn as of poor workmanship Stair handrail not stable enough and to be strengthened Clean two (2) stair flights between Levels 2 and 3 of paint and mortar stains complete Repair damaged skirting to RH of door at Level 2 Remove paint to Door Access Closer Remove paint to Access Card reader and make good Remove paint on smoke detector and make good

Rating Classif. B B B B B B B A A A B B B B A B B B A B B B B B A B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

183

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to both frame bases of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Intumescent strip is missing on the head frame Install door closer Make good to floor at North and extend terrazzo floor tiling up to door threshold Tile floor is uneven and needs to be levelled, polished and resealed Make good to wall around Dry Riser including the removal twelve (12) black headed screws Provide operation label to Door Push Button in Romanian and English Remove paint on Running Man sign and make good Remove paint from top edge of skirting on all walls Make good to chipped arris to wall return to Stair Door LH Make good to chipped arris to wall return to Stair Door RH Clean paint etc from two (2) light fittings Clean paint off door frame to Door North Intumescent strip to hinge frame is loose above upper prong on Door North Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Intumescent strip is short on open frame top and also loose and is to be replaced Clean up at frame bases and make good Remove all remaining parts of protective covering to door

Rating Classif. B B A B B A B B A B A A A B B A B B B B B B A A B B A B B A A B B

Date Rectified

Date Checked

Comments

4/10/2013

184

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46

Location Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03 Stair Vestibule E2E.03

Defect Remove paint to three (3) sprinkler head in ceiling Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internal around Dry Riser Access Panel and make good Make good to skirting to RH of Door North Make good to skirting to LH of Door North Fit new plastic door to Dry Riser as missing Make good to plasterboard to LH side of Dry Riser inlet and repaint

Rating Classif. C B B B B B B A B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

185

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29

Location Terrace : South Terrace : South Terrace : South Terrace : South Terrace : South Terrace : South Terrace : South Terrace : South Terrace : South Terrace : South Terrace : South Terrace : East Terrace : East Terrace : East Terrace : East Terrace : East Terrace : East Terrace : East Terrace : North Terrace : North Terrace : North Terrace : North Terrace : North Terrace : North Terrace : North Terrace : Generally Terrace : Generally Terrace : Generally Terrace : Generally

Defect Finish terrace slabs to Area A23 approx 3/4m2 Make good to metal plate/slab level at Area A22 where metal plate is 15.20mm above and is untidy at corner Generally remove mortar stains on window profiles and glass along South Faade A13 to A21 Seal and make good joint between terrace paving and base profile to windows along South Faade A13 to A 21 Many of the base profile plates to the parapet faade are not level and there are level discrepancies with the terrace paving Seal & make good joint between terrace paving and parapet base profiles including replacing ill cut paviors from A13 to A23 Make good seal at top of parapet faade at A13 Remove mortar and cement splashes etc. on the base profile to the parapet faade from A13 to A23 Make good joint between base parapet faade profile and paviors at A13 Remove all mortar/concrete deposits on base profile junction with vertical profiles (7 No.) and make good Remove remaining parts of profile protective covering to base profile of windows to Westfourth/Euroest on South Faade Generally remove mortar stains on window profiles and glass along East Faade A/D 20/21 Seal and make good joint between terrace paviors and base profile to windows along East Faade A/D 20/21 Remove remaining parts of profile protective covering to base profile of windows to Euroest on East Faade Repair damage to Boiler Flue pipes (damage done in 2005) Remove two (2) badly cut paviors next to Faade Glazing on East Faade Seal & make good joint between terrace paving and parapet base profiles including replacing ill cut paviors A/D 20/21 Make good to broken pavior and replace near C 21 Finish terrace slabs to Area D 15/16 approx 10/12m2 Generally remove mortar stains on window profiles and glass along North Faade D 15/21 Seal and make good joint between terrace paviors and base profile to windows along North Faade D 15/21 Remove remaining parts of profile protective covering to base profile of windows to Nippon/Euroest on North Faade D 15/21 Replace two (2) badly chipped tile paviors on North Faade Remove concrete snots on paviors Seal & make good joint between terrace paving and parapet base profiles including replacing ill cut paviors D 15/21 Plastic spacers some are left in and some have been removed which is the correct position ? Water is gathering at A23 area of terrace and there is no gulley in the area Remove mortar stains on inner face of parapet to North Terrace Remove mortar stains on inner face of parapet to East Terrace

Rating Classif. B B B B B B B B B B B B B B B B B A B B B B B B B B A B B

Date Rectified

Date Checked

Comments

W4A to advise

4/10/2013

186

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2

Location Westfourth Area E2E.02B Westfourth Area E2E.02B

Defect Refix internal door pull properly to Door No 2 to terrace which came off at the base when opening the door Remove remaining protective covering to profiles to LH side of Door No 2

Rating Classif. A B

Date Rectified

Date Checked

Comments Door Terrace near D 16 Door Terrace near D 16

4/10/2013

187

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Location Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C Nippon Area E2E.02C

Defect Make good to hole in concrete column D 13 Remove reinforcement rod in floor near Column D 13 near Faade and make good Remove cable and open wiring in floor screed between Columns D13/14 and make good Make good to screed infill along North Faade windows D13 to D18 Remove remaining protective covering to profiles around door Remove paint to door profiles Repair damaged seal at base of door internal face Tighten up door handle (inner) as not firm Remove mortar dropping on threshold plate of door Readjust door as it is not a tight fit especially at the head of the door Remove mortar on base profiles to North Faade D13 to D18 Remove ceiling paint to HVAC diffusers on plasterboard edge ceiling near faade Remove mortar dropping on threshold plate of door Readjust door as it is not a tight fit especially at the head of the door Remove paint to door profiles Remove remaining protective covering to profiles around door Remove remaining protective covering to base profiles along faade D13 to D 18 Make good gap between floor screed and base profile to faade between D17/18 Remove the many labels on windows including the adhesive

Rating Classif. B B A B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

Door Terrace near D16 Door Terrace near D16 Door Terrace near D16 Door Terrace near D16 Door Terrace near D16 Door Terrace near D16

Door Terrace near D 17

4/10/2013

188

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7

Location Euroest Invest E2E.02A Euroest Invest E2E.02A Euroest Invest E2E.02A Euroest Invest E2E.02A Euroest Invest E2E.02A Euroest Invest E2E.02A Euroest Invest E2E.02A

Defect Euroest stated that rooms on South Faade are very hot but to be checked again once the HVAC Cooling System is balanced Remove labels on glazing on North, East and South facades including adhesive Terrace door near Column D 18 to be adjusted as it is very stiff to open Clean threshold plate to Terrace Door near D18 of mortar stains etc. and make good Terrace door near Column D 19 to be adjusted as it is very stiff to open and the frame catches on the frame profile Terrace Door near Column B 20 to be adjusted as it is very stiff Terrace door near Column C 20 to be adjusted as it is very stiff to open and the frame catches on the frame profile

Rating Classif. B B B B B B B

Date Rectified

Date Checked

Comments W4A to review and advise

4/10/2013

189

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

Location Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01 Level 3 Lift Lobby E3E.01

Defect Tiling to floor is uneven and not aligned and requires to be re-executed Wall Tiling to West Wall is debonding, uneven, not aligned, pointing is distressed and requires to be re-executed Wall Tiling to East (Lift) Wall is uneven, not aligned, pointing is distressed and requires to be re-executed Remove paint on loudspeaker in ceiling and make good Readjust two (2) small downlighters (North and South) that are not properly aligned and make good Remove paint on ventilation grille large (South) Seal pointing between tiling and lift panelling to PE 09 at head both sides Seal pointing between tiling and lift panelling to PE 08 at head both sides Seal pointing between tiling and lift panelling to PE 07 at head both sides Refit stainless steel skirting to Lift PE 09 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 08 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 07 that show gaps between the skirting and wall panelling both sides Clean threshold of Lift PE 09 Clean threshold of Lift PE 08 Clean threshold of Lift PE 07 Make good to floor covering at RH of lift door frame PE7 Make good to floor covering at LH of lift door frame PE7 Make good to floor covering at RH of lift door frame PE8 Make good to floor covering at LH of lift door frame PE8 Make good to floor covering at RH of lift door frame PE9 Make good to floor covering at LH of lift door frame PE9 Clean all stainless steel skirting to lifts PE07 and PE08 Make good pointing between wall tiling and lift panels to LH side of Lift PE09 Make good pointing between wall tiling and lift panels to RH side of Lift PE09 Make good pointing between wall tiling and lift panels to LH side of Lift PE08 Make good pointing between wall tiling and lift panels to LH side of Lift PE07 Make good pointing between wall tiling and lift panels to RH side of Lift PE07 Remove protective covering to lift door frame head LH of Lift PE07 Clean stainless steel panel near ceiling on Lift PE09 Clean stainless steel panel near ceiling on Lift PE08 Clean stainless steel panel near ceiling on Lift PE07 Remove paint on three (3) small ceiling downlighters and make good Set HVAC controller on West Wall level Remove paint on seven (7) sprinkler heads in ceiling Remove paint on smaller grille to North and make good

Rating Classif. B B B C B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

190

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

Location Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01) Corridor North Level 3 (E3E.01)

Defect Clean up ventilated dirt deposits on painted ceiling finish to fourteen (14) air inlets and make good Install operator signage to Fire Alarm Button at South Wall near door to Stair Vestibule E3E.03 Make good round Fire Damper Grille panel (Low) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Lower) near Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall near Lift Lobby Tiling to return at C17 South Wall is rapidly debonding and needs to be redone Remove paint splashes on wall tiling at D17 to RH of door to Stair Vestibule E3E.03 Remove paint on Running Man Sigh to Stair Vestibule E3E.03 Make good crack in ceiling at Running Man Sign to Stair Vestibule E3E.03 Tiling to wall at C17 South Wall is uneven, debonding, and not aligned and requires to be re-executed Tiling to wall at C16 South Wall is uneven, debonding and not aligned and requires to be re-executed Install operator signage to Fire Alarm Button at South Wall RH of Service Elevator Vestibule Install operator signage to Door Release Button at South Wall to RH of Service Elevator Vestibule Install break glass to Emergency Door Release Button on South Wall to RH of Service Elevator Vestibule Make good large gap above Fire Damper to RH side of Lift Lobby above frame head including the poor wall tiling work Make good round Fire Damper Grille panel (Upper C 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper C 16) near Lift Lobby Provide proper locking device to Upper (C/16) Fire Damper Grille on South Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on South Wall near to RH side of Service Elevator Lobby Clean paint off grille to Fire Damper panel (Lower) to RH side of Service Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall to RH side of Service Lift Lobby

Rating Classif. B A B B B B B B B B B A A A B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

191

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2

Location Corridor Level 3 East (E3E.01) Corridor Level 3 East (E3E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory

Rating Classif. B B

Date Rectified

Date Checked

Comments

4/10/2013

192

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2

Location Corridor Level 3 West (E3E.01) Corridor Level 3 West (E3E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory

Rating Classif. B B

Date Rectified

Date Checked

Comments

4/10/2013

193

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Location Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01) Corridor Level 3 South (E3E.01)

Defect Clean up ventilated dirt deposits on painted ceiling finish to fourteen (14) air inlets and make good Install operator signage to Fire Alarm Button at North Wall near door to Stair Vestibule E3E.03 Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E3E.16 Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E3E.16 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E3E.16 Install operator signage to Fire Alarm Button at North Wall LH of Stair Vestibule E3E.16 Tiling to wall at C17 North Wall is uneven, debonding and not aligned and requires to be re-executed Tiling to wall at C16 North Wall is uneven, debonding and not aligned and requires to be re-executed Remove ceiling paint to Running Man Sign and make good Make good poor tiling above Fire Damper Grille B16 near lift lobby Clear tiling at base near Fire Damper Grille to LH side of door to Stair Vestibule E3E.03 Make good to large gap between Low Fire Damper Grille and tiling finish on North Wall LH to Stair Vestibule Door E3E.03 Make good round Fire Damper Grille panel (Upper B 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper B 16) near Lift Lobby Provide proper locking device to Upper (B 16) Fire Damper Grille on North Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E3E.03 LH Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E3E.03 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E3E.03 LH

Rating Classif. B A B B B A B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

194

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to both frame bases and frame heads of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South South door frames are 4mm above the finished floor level and to be reset South door does not fully close on the door closer and requires to be adjusted for this and the 'squeak' as it moves Remove paint splashes etc on door surfaces and make good Make good to pin and burn mark on door lock plate Tile floor is uneven and needs to be levelled, polished and resealed Terrazzo Skirting at wall return to doors to have rounded or pencil arrissed corners to Stair Egress Door Provide operation label to Door Push Button in Romanian and English Remove paint on Running Man sign and make good Remove paint from top edge of skirting on all walls Reset double power socket outlet near Door North on West wall to be level Reset double power socket outlet near Door South on West wall to be level Clean paint etc from two (2) light fittings Clean paint off door frame to Door North Remove masking tape to door frames and make good and marks Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Clean up at frame bases and make good Remove manufacturer's label on door and adhesive and make good

Rating Classif. B B A B B A B B A B B A B B B B A B B B B B B B A B B A B B A B B

Date Rectified

Date Checked

Comments

4/10/2013

195

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52

Location Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03 Stair Vestibule E3E 03

Defect Fix lock and handles to door North Make good to floor at North and extend terrazzo floor tiling up to door threshold North door frames are 6mm above the finished floor level and to be reset Remove all remaining parts of protective covering to door Remove paint to three (3) sprinkler head in ceiling Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internal around Dry Riser Access Panel and make good Make good to skirting to RH of Door North Reset H sign above Dry Riser box to be level and make good Remove timber batten in Dry Riser box that is obstructing the efficient usage of the Type C Hose Connection Terrazzo Skirting is irregular on East Wall and requires to be redone terrazzo Skirting is irregular on West Wall and requires to be redone Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required

Rating Classif. A B B B C B B B B B B A B B B A B B A

Date Rectified

Date Checked

Comments

W4A to review and advise

4/10/2013

196

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27

Location Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04 Egress Stair E3E.04

Defect Remove paint etc to top edge of skirting throughout and make good Remove paint from Running Man Sign and make good Remove paint from Access Car Reader and make good Remove paint etc. from ceiling Smoke Detector and make good Tiled Level 3 floor requires to be polished and sealed and repaired where poor workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short and to be replaced Intumescent strip to hinge door jamb is short and to be replaced Rubber infill strip to door is loose at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be aligned Door intruder alarm contact wiring to be tidied up Remove all remaining protective covering to door Replace key sets with correct set Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Clean light fitting of paint stains etc. at mid landing Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface Clean two (2) stair flights between Levels 3 and 4 of black paint and mortar stains complete Tighten up door hold contact plate

Rating Classif. B B B B B B B A A A B B B B A B B B A B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

197

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to both frame base and frame head on hinge side of Door South Intumescent strip is not complete to base of open frame of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Tidy up at base of door frames and make good to floor finishes Why are there locks on Stair Egress Doors operated with Card Reader Access and Release Push button ? Terrazzo tile skirting at southwest corner is uneven and requires to be redone Terrazzo tile floor is uneven and needs to be levelled, polished and resealed Terrazzo Skirting at wall return to doors to have rounded or pencil arrissed corners to Stair Egress Door Provide operation label to Door Push Button in Romanian and English Remove paint on Running Man sign and make good Remove paint etc. from top edge of skirting on all walls Reset double power socket outlet near Door South on West wall to be level Clean paint etc from two (2) light fittings Screw missing from door lock plate Clean paint off door frame to Door North Touch up chipped paintwork to door frames Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Clean up at frame bases and make good to terrazzo floor finish Make good to damaged LH door return arris to Egress Stair door and paint

Rating Classif. B B A A B B A B B A B B A B B B A B B B B B B B A B B A B B A B B

Date Rectified

Date Checked

Comments

W4A to review and advise

4/10/2013

198

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49

Location Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16 Stair Vestibule E3E.16

Defect Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internal around Dry Riser Access Panel and make good Reset H sign above Dry Riser box to be level and make good Remove all remaining parts of protective covering to door Remove masking tape and paint to three (3) sprinkler head in ceiling Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Make good to skirting to LH of Door North Make good to skirting to RH of Door South Make good around Dry Riser Box with six (6) black screws and repaint Make good to wall base to LH side of Door North Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required

Rating Classif. A B B B C B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

199

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

Location Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17 Egress Stair E3E.17

Defect Remove paint etc to top edge of skirting throughout and make good Reset Running Man Sign to be level Remove paint from Access Car Reader and make good Replace strikeplate to door as in distress and damaged Tiled Level 3 floor requires to be polished and sealed and repaired where poor workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short at base and to be replaced Intumescent strip to hinge door jamb is short at base and head and to be replaced Rubber infill strip to door is missing at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be aligned Remove paint etc from door frames to door Remove all remaining protective covering to door Tidy up contact wires to Intruder Alarm at door head Door frames are set 11mm above the finished floor level and require to be reset Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Reset mid Landing light fitting level Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface Clean two (2) stair flights between Levels 3 and 4 of black paint and mortar stains complete Replace four (4) chipped stairs to upper flight 3/4 Replace two (2) chipped stairs to lower flight 3/4 Wall light switch to be reset level Make good to ceiling around smoke detector and repaint Terrazzo skirting at south wall is in distress and to be re-executed including pointing at top Make good to LH arris to door which is damage and repaint Re-execute skirting to LH side of door as poor workmanship Re-execute skirting to RH side of door as poor workmanship

Rating Classif. B B B B B B B A A A B B B B A B B B A B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

200

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

Location Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05 Vestibule E3E.05

Defect Remove paint to sprinkler head (south) Clean up stains on ceiling loudspeaker Remove paint on loudspeaker in ceiling and make good Remove paint to South Door Frames Fit rubber seal all round door South Intumnescent strip is not installed to side or head frames Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Install door closer to Door South Install edging and recut floor covering to door South threshold Clean paint off door frame to Door North Intumescent strip is installed to side or head frames of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Install door closer to Door North Remove all remaining parts of protective covering to door Screw missing in lock plate to door North Remove paint to light fitting (north) and make good Replace missing external skirting corner piece to LH of Door to Toilet E3E.14 Replace missing external skirting corner piece to LH of Door to Toilet E3E.11 Replace missing external skirting corner piece to RH of Door to Toilet E3E.11 Remove paint on skirting to LH side of Door North Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Refix loose skirting and external skirting corner piece to LH of door to Pantry E3E.06 Refix loose skirting and external skirting corner piece to RH of door to Pantry E3E.06 Refix loose skirting and external skirting corner piece to LH of door to Vestibule E3E.08

Rating Classif. B B B B B A B B A B B A B A B B A B B A B B A B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

201

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31

Location Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15 Handicapped Toilet E3E.15

Defect Make good to floor tiling around floor gulley and regrout Clean excess grouting to tiles generally Replace door grill screws (Internal) with white headed screws Make good to floor finish at LH Base Frame of door Make good to floor finish at RH Base Frame of door Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Clean fan outlet in ceiling of dirt/dust etc. WHB tap is loose and to be reset properly Install plug Overhaul flush to WC as not working properly Install Door stop Install rubber seal around door Replace external grille at door base external as broken No hot water available Install rubber seal around door Clean out at bases to door frames and make good to floor finish Light bulb missing in downlighter and to be replaced Compete activity related to open hole in ceiling with unconnected wires etc. Reconnect open wires or remove from ceiling space Remove masking tape from downlighter in ceiling Repair upper hinge to door that has 'dropped' and make good Install edging strip to PVC floor covering where it abuts the floor tiles in the toilet Wall tiling to be redone on southeast corner of wall near door Remove black screw in South wall and make good Clean general dirt etc in floor pointing and make good Repoint to wall tiling where short or insufficient Remove excess grout on wall tiling

Rating Classif. B B B B B B B B B B B B B B B B B B B B A B A B A B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

202

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Location Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14 Toilet E3E.14

Defect Make good tile grouting etc around floor gulley Make good to RH door frame (open) where dented at lock strike plate Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug No hot water available Install edging strip to PVC floor covering where it abuts the ceramic tile floor finish in toilet Make good to water leak stain to centre and edges of suspended ceiling and repaint Light (2 No.) bulbs are missing and to be replaced

Rating Classif. B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

203

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25

Location Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13 Toilet E3E.13

Defect Make good tile grouting etc around floor gulley Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug No hot water available Install edging strip to PVC floor covering where it abuts the ceramic tile floor finish in toilet Touch up missing parts of grouting to wall tiling generally Remove masking tape to ceiling downlighter Clean out at bases of door frames and make good floor finished complete Flushing mechanism to WC to be overhauled as it is not working properly Fit missing soap dispenser to RH of WHB Reinstall missing light bulb to downlighter Plate to WC Flushing mechanism is loose and to be refixed Make good at joint between wall tiling and floor tiling on south wall Make good at joint between wall tiling and floor tiling on west wall

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

204

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12 Toilet E3E.12

Defect Make good tile grouting etc around floor gulley Make good to RH door frame (open) where dented at lock strike plate Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug No hot water available Install edging strip to PVC floor covering where it abuts the ceramic tile floor finish in toilet Make good to water leak stain to centre and edges of suspended ceiling and repaint Light (2 No.) bulbs are missing and to be replaced

Rating Classif. B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

205

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26

Location Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11 Handicapped Toilet E3E.11

Defect Make good to floor tiling around floor gulley and regrout Clean excess grouting to tiles generally Replace door grill screws (Internal) with white headed screws Replace distressed strikeplate in open frame Touch up chipped paintwork to door frames Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Clean fan outlet in ceiling of dirt/dust etc. WHB tap is loose and to be reset properly Install plug No hot water available Install Door stop Install rubber seal around door Clean out at bases to door frames and make good to floor finish Light bulb missing in downlighter and to be replaced Compete activity related to open hole in ceiling or repair. Fit downlighter in ceiling properly Install edging strip to PVC floor covering where it abuts the floor tiles in the toilet Clean general dirt etc in floor pointing and make good Repoint to wall tiling where short or insufficient Remove excess grout on wall tiling Make good to edge of door damaged near lock plate Make good to joint between wall tiling and floor tiling at North wall

Rating Classif. B B B B B B B B B B B B B B B B B A B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

206

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18

Defect Prepare for and paint ceiling Remove paint from Arrow lift indicator and make good Door frame at bases is 6mm above floor finish and requires to be adjusted Fill in hole to door head frame Adjust inner leaf of door as scrapes the floor as it is closing Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is short on both side frames and requires to be replaced Install door stops to Doors Clean paint off Door Frames Door Signage Fire/Smoke Threshold seal is required to door Install closers with selector on doors (currently door closer on outer leaf is disconnected) Remove all remaining parts of the protective covering to doors Install rubber seal to door Intumescent strip to meeting style is not continuous and missing at door lock Realign door intruder alarm contacts Inner leaf of door head frame slip bolt is defective and inner leaf cannot be placed in the locked position Tidy up wiring to door intruder contact Screws (2 No) missing form door locking plate Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Relay floor covering that is distorted and 'bubbled' and prepare floor screed below Install floor covering to entrance recess to Service Elevator Vestibule Make good to concrete threshold to lift door and fit floor covering including edging piece to lift door Install PVC Skirting to entrance recess to Service Elevator Vestibule both sides Make good to wall at joint with door frame on LH side and repaint Repair damaged wall at northwest corner and make good Paint sprinkler pipework Tidy up joint at sprinkler head including removing excess joint hemp fibres on sprinkler pipework Replace screws at grille to LH side with white headed screws as elsewhere Seal and make good to conduit at ceiling level (South Wall) Seal and make good to large hole with three (3) conduits at northeast corner at ceiling level

Rating Classif. B B B B A B B A A B B B A A B B A B A B B B B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

207

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41

Location Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18 Service Elevator Vestibule E3E.18

Defect Seal and make good to one (1) sprinkler pipe in northeast corner at near ceiling level Refix loose plastic skirting to LH side of lift return Refix loose plastic skirting to RH side of lift return Remove paint on skirting in northeast corner of North Wall Make good to wall at northwest corner and repaint Complete conduit to ceiling smoke detector Light is squint and requires to be aligned and refixed Remove red paint stain on North Wall

Rating Classif. B B B B B B C B

Date Rectified

Date Checked

Comments

4/10/2013

208

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14

Location Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08 Vestibule E3E.08

Defect Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Skirting loose on North Wall at LH return to door to Data Room Make good to floor finishes at door frame bases Seal hole in hinge door frame at top or fix screw fixing Clean light of dirt and paint stains Touch up chipped paint on door frames Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Remove labels on door and make good

Rating Classif. B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

209

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

Location Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10 Data Room E3E.10

Defect Paint ceiling and beams Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Skirting missing around Column C16 including external angle skirting corner Remove conduit holdfast at ceiling level on South wall and make good Make good to floor finish at base of LH Door frame Frames of door to Main Vestibule are set some 8mm above floor finish and require to be reset Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Remove labels on door surface and make good Complete conduit to smoke detector Seal North wall to two (2) HVAC pipes and make good all round Seal to conduit on East wall and make good Connect up exposed wires in light switch and refix light switch plate near door RH side Connect up double socket outlet with exposed wires on West wall and fit cover plate Remove two (2) screw fixings on North Wall and make good Remove one (1) screw fixing on South Wall and make good Remove six (6) hook fixings on West wall and make good

Rating Classif. B B B B B B B B B B B B B B B A B A A B B B

Date Rectified

Date Checked

Comments

4/10/2013

210

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

Location Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09 Electrical Closet E3E.09

Defect Paint ceiling Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Make good to floor level on South Wall near door and refix floor covering Install skirting to South Wall as missing Skirting missing at return on East Wall Skirting loose on northern side of East Wall Skirting is missing on West wall (North) Make good to north wall next floor sinking and refix floor covering complete Infill large hole in southeast of room (fire stopping) Hole at present is a safety issue Skirting missing at North wall Skirting under Electrical Cabinet TUPS-3E on West wall is short and to be replaced Paint walls Connect up exposed wires in light switch and refix light switch plate near door RH side Remove paint to Door Frames Fit rubber seal all round door Intumescent strip is not complete to hinge frame at base of door and to be replaced Intumescent strip is not complete to open frame at base and head of door and also loose to be replaced Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to door Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Door frames are 5mm above finished floor level and to be reset Install door closer Realign intruder alarm door contacts Door sign Make good to wall base at return to East wall in middle and repaint Electrical Cabinet TCT-31 replace damaged top panel cover internally Screw in the fifteen (15) loose screws to the five (5) control boxes to RH of SBS-7E Fit sealing screws to five missing screws to the (5) control boxes to RH of SBS-7E Replace label to cabinet SBS 6E which is plastic with paper printed sign and install ivorine label Reconnect loose wire or remove in electrical box above control boxes No 4 above SBS-7E Reconnect loose wire or remove in electrical box above control boxes No 3 above SBS-7E

Rating Classif. B B B B B B B B A B B B A B B A B B A B B A B B A B B B A B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

211

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

Location Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07 Janitor Closet E3E.07

Defect Install protection to water pipe with meter Replace door grill screws (Internal) with white headed screws Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Remove all remaining parts of protective covering to door Remove paint on door frames and make good Remove wall paint on trims to suspended ceilings and make good Redo angle edge to vertical corner to LH of door and make good Redo angle edge to vertical corner southeast and make good Make good to joint between wall and floor tiling on South Wall Make good to joint between wall and floor tiling on West Wall Replace light bulbs in downlighter Replace badly water stained suspended ceiling tile LH tap in wall is loose and requires to be fixed properly Tidy up loose layout of pipework connected with boiler RH tap in wall is loose and requires to be fixed properly Make good untidy suspended ceiling around Column B16 Make good grouting etc to floor gulley Install door stop Repair defective wall tiling above door head external Make good to floor finish (ceramic tiles to RH door frame Install trough

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments W4A to review and advise

4/10/2013

212

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06 Pantry E3E.06

Defect Wall tiling is generally poor workmanship Make good joint between wall and floor tiling on North Wall Clean off excess grouting throughout Seal East wall below sink where pipes pass through and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Replace door grill screws (Internal) with white headed screws Install rubber seal to door all round Touch up chipped paintwork to door frames Replace damaged strike plate in open frame Redo angle piece on wall tiling at external angle to LH of door to Janitor Closet Redo angle piece on wall tiling at external angle to RH of door to Janitor Closet Door frames are set above floor finish by 10/12mm and require to be reset Reset RH door to upper cabinet on South Wall Mixer tap unit is loose and to be refixed No hot water available Install plug Seal floor cabinet units between wall and units LH side and make good (East Wall) Seal floor cabinet units between wall and units RH side and make good (East Wall) Replace broken suspended ceiling tile Make good untidy joint between wall tiling and suspended ceiling on North Wall Install door stop Install edging to PVC floor covering at door entrance Make good to floor finishes at base of RH door frame to Vestibule Adjust door as there is a large gap between door surface and frame when closed Reset to level position for power socket outlet (double) at floor level on North Wall Remove masking tape to door frames Remove masking tape to downlighter Are suspended ceiling tiles water resistant (pantry has boiling kettles etc.) Seal floor cabinet units between wall and units LH side and make good (South Wall) Double bowel sink is shown on drawings - Who authorised change to single bowel sink ?

Rating Classif. B B B A B B B B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

W4A to review and advise W4A to advise

4/10/2013

213

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Location Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01 Level 4 Lift Lobby E4E.01

Defect Tiling to floor is uneven and not aligned and requires to be re-executed Wall Tiling to West Wall is debonding, uneven, not aligned, pointing is distressed and requires to be re-executed Wall Tiling to East (Lift) Wall is uneven, not aligned, pointing is distressed and requires to be re-executed Readjust two (2) small downlighters (Middle and South) that are not properly aligned and make good Remove paint on ventilation grille large (South) Seal pointing between lift panelling and ceiling PE 09 Refit stainless steel skirting to Lift PE 09 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 08 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 07 that show gaps between the skirting and wall panelling both sides Clean threshold of Lift PE 09 Clean threshold of Lift PE 08 Clean threshold of Lift PE 07 Make good to floor covering at RH of lift door frame PE7 Make good to floor covering at LH of lift door frame PE7 Make good to floor covering at RH of lift door frame PE8 Make good to floor covering at LH of lift door frame PE8 Make good to floor covering at RH of lift door frame PE9 Make good to floor covering at LH of lift door frame PE9 Make good pointing between wall tiling and lift panelling to LH side of PE09 Make good pointing between wall tiling and lift panelling to RH side of PE07 Remove protective covering from base of RH frame to Lift PE08 Remove protective covering from base of LH frame to Lift PE09 Remove protective covering from base of LH frame to Lift PE08 Remove protective covering to lift door frame head LH of Lift PE09 Remove protective covering to lift door frame head LH of Lift PE08 Remove protective covering to lift door frame head LH of Lift PE07 Clean masking tape off stainless steel panel near ceiling on Lift PE09 Clean masking tape off stainless steel panel near ceiling on Lift PE08 Clean masking tape stainless steel panel near ceiling on Lift PE07 Remove paint on three (3) small ceiling downlighters and make good Set HVAC controller on West Wall level Remove paint on five (5) sprinkler heads in ceiling Remove paint on smaller grille to North and make good

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

214

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Location Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01) Corridor North C14/18 (E4E.01)

Defect Remove paint on Fire Alarm LH of door to Stair Vestibule E4E.03 Install operator signage to Fire Alarm Button at South Wall near door to Stair Vestibule E4E.03 Make good round Fire Damper Grille panel (Low) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Lower) near Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall near Lift Lobby Tiling to wall at C17 South Wall is uneven, debonding, and not aligned and requires to be re-executed Tiling to wall at C16 South Wall is uneven, debonding and not aligned and requires to be re-executed Install operator signage to Fire Alarm Button at South Wall RH of Service Elevator Vestibule Install operator signage to Door Release Button at South Wall to RH of Service Elevator Vestibule Install break glass to Emergency Door Release Button on South Wall to RH of Service Elevator Vestibule Remove paint from Running Man Sign above door to Stair Vestibule E4E.16 Make good round Fire Damper Grille panel (Upper C 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper C 16) near Lift Lobby Provide proper locking device to Upper (C/16) Fire Damper Grille on South Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on South Wall near to RH side of Service Elevator Lobby Clean paint off grille to Fire Damper panel (Lower) to RH side of Service Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall to RH side of Service Lift Lobby

Rating Classif. B A B B B B B A A A B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

215

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14

Location Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01) Corridor East B/C 18(4E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory Make good round Fire Damper Grille panel C14 East Wall near Fire Hose reel Enclosure (FHE) Clean paint off grille to Fire Damper panel C14 near FHE Provide proper locking device to C14 Fire Damper Grille on East Wall near FHE Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hose reel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork and make good Divider Wall to LH to be sealed full length to back wall Seal wall at RH side of enclosure for waste pipe and make good Seal two holes in ceiling slab within FHE and make good Seal around conduit to RH side of FHE internally near concrete beam

Rating Classif. B B B B B B B B B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

216

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

Location Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01) Corridor West B/C 14 (E4E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory Make good round Fire Damper Grille panel B18 East Wall near Fire Hose reel Enclosure (FHE) Clean paint off grille to Fire Damper panel B19 near FHE Provide proper locking device to B18 Fire Damper Grille on East Wall near FHE Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box as key is missing Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hose reel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork and make good Divider Wall to LH to be sealed full length to back wall Remove three electrical cables (used by Ozer during construction) and make good to all holes Seal two holes in ceiling slab within FHE and make good Seal around hole to RH side of FHE internally near concrete beam Make good slab inside FHE as concrete deposits and debris etc.. Seal around two (2) pipes in the floor slab and make good

Rating Classif. B B B B B B B B B B B A A A B A

Date Rectified

Date Checked

Comments

4/10/2013

217

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

Location Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01) Corridor South B14/18 (E4E.01)

Defect Make good poor tiling above Fire Damper Grille B16 near lift lobby Install operator signage to Fire Alarm Button at North Wall near door to Stair Vestibule E4E.03 Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E4E.16 Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E4E.16 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E4E.16 Install operator signage to Fire Alarm Button at North Wall LH of Stair Vestibule E4E.16 Tiling to wall at C17 North Wall is uneven, debonding and not aligned and requires to be re-executed Tiling to wall at C16 North Wall is uneven, debonding and not aligned and requires to be re-executed Make good to large gap between Low Fire Damper Grille and tiling finish on North Wall LH to Stair Vestibule Door E4E.03 Make good round Fire Damper Grille panel (Upper B 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper B 16) near Lift Lobby Provide proper locking device to Upper (B 16) Fire Damper Grille on North Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E4E.03 LH Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E4E.03 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E4E.03 LH

Rating Classif. B A B B B A B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

218

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03)

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to open frame and short at base and loose at top and near strike plate to Door South : replace Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Intumescent strip is not complete to hinge frame as short at base to Door South and to be replaced Intumescent strip on head frame is loose and to be refixed properly of South Door Remove paint splashes etc on South door surfaces and make good Install door closer to South Door South door frames are 4mm above the finished floor level and to be reset Remove labels on South Door and make good Provide operation label to Door Push Button in Romanian and English Finish render to wall to LH side of Door North Remove paint from top edge of skirting on all walls North door frames are 6mm above the finished floor level and to be reset Clean paint etc from two (2) light fittings Clean paint off door frame to Door North Clean paint splashes etc on surfaces of Door North Intumescent strip is short to head frame and requires to be replaced Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Remove remaining protective covering to Door North Remove manufacturer's label on door and adhesive and make good

Rating Classif. B B A B B A B B A B A A B A B B A B B B B B B A A B B A B B A B B

Date Rectified

Date Checked

Comments

This button has been disabled

4/10/2013

219

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53

Location Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03) Stair Vestibule Level 4 (E4E.03)

Defect Screw missing in lock plate to door North North door frames are 6mm above the finished floor level and to be reset Make good to terrazzo skirting to RH side of Door South Rest light switch (south) that is not level Remove paint to three (3) sprinkler head in ceiling Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internally around Dry Riser Access Panel and make good Remove timber batten in Dry Riser box that is obstructing the efficient usage of the Type C Hose Connection Form rounded external corner to terrazzo skirting to LH of door to Egress Stair Form rounded external corner to terrazzo skirting to RH of door to Egress Stair Fill in gap all round the Upper Fire Damper on the West Wall North Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required Tile floor is uneven and needs to be levelled, polished and resealed Terrazzo Skirting at wall return to doors to have rounded or pencil arrissed corners to Stair Egress Door

Rating Classif. B B B B C B B B B B B A B A B B B A B B

Date Rectified

Date Checked

Comments

4/10/2013

220

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29

Location Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04) Egress Stair Level 4 (E4E.04)

Defect Remove paint etc to top edge of skirting throughout and make good Remove paint from Running Man Sign and make good Remove paint from Access Car Reader and make good Remove paint etc. from ceiling Smoke Detector and make good Tiled Level 4 floor requires to be levelled, polished and sealed and repaired including workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short and to be replaced Intumescent strip to hinge door jamb is short and to be replaced Rubber infill strip to door is loose at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be aligned Door intruder alarm contact wiring to be tidied up Remove all remaining protective covering to door Replace key sets with correct set Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Clean light fitting of paint stains etc. at mid landing Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface Clean two (2) stair flights between Levels 3 and 4 of black paint and mortar stains complete Clean terrazzo tile at mid landing around the two (2) balustrade supports Reset light fitting at mid landing to level position Clean main landing light of paint splashes etc

Rating Classif. B B B B B B B A A A B B B B A B B B A B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

221

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16)

Defect Remove paint and masking tape to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to both frame base and prong receiver on hinge side and loose of Door South : replace Intumescent strip is not complete to base of open frame of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Install door closer to Door South Why are there locks on Stair Egress Doors operated with Card Reader Access and Release Push button ? Terrazzo tile floor is uneven and needs to be levelled, polished and resealed Terrazzo Skirting at both wall returns to doors to have rounded or pencil arrissed corners to Stair Egress Door Provide operation label to Door Push Button in Romanian and English Remove paint etc. from top edge of skirting on all walls Reset double power socket outlet near Door North on East wall to be level Reset double power socket outlet near Door South on East wall to be level Clean paint etc from two (2) light fittings Screw missing from door lock plate on Door North Clean paint off door frame to Door North Touch up chipped paintwork to door frames Intumescent strip is not complete to both frame bases of Door North Intumescent strip is loose at the prong receiver on the hinge frame and to be re-installed to Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Remove all remaining parts of protective covering to door Install closer to Door North

Rating Classif. B B A A B B A B B A B A A B B A B B B B B B B A A B B A B B A B B

Date Rectified

Date Checked

Comments

W4A to advise

This push button is disabled

4/10/2013

222

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54

Location Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16) Stair Vestibule Level 4 (E4E.16)

Defect Reset Door North that has broken out of its frame position and make good Replace damaged strikeplate to open frame of Door North Make good to hole to LH side of Door north and make good to floor finish complete Remove all remaining parts of protective covering to door North Remove paint to three (3) sprinkler head in ceiling and make good Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Make good to skirting to LH of Door South Make good to skirting to RH of Door South Make good to skirting to LH of Door North Make good to skirting to RH of Door North Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required Remove paint from Running Man Sign and make good Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internally around Dry Riser Access Panel and make good Fill in gaps around Lower Fire Damper on West Wall and make good all round Fill in gaps around Upper Fire Damper on West Wall and make good all round

Rating Classif. B B B B C B B B B B B B B B B A B A A B B

Date Rectified

Date Checked

Comments

4/10/2013

223

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17) Egress Stair Level 4 (E4E.17)

Defect Remove paint etc to top edge of skirting throughout and make good Remove paint from Running Man Sign and make good Remove paint from Access Car Reader and make good Remove paint on Smoke Detector and make good Tiled Level 4 floor requires to be polished and sealed and repaired where poor workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short at base and to be replaced Intumescent strip to hinge door jamb is short at base and head and to be replaced Intumescent strip is missing from head frame and requires to be replaced Rubber infill strip to door is missing at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be aligned Remove all remaining protective covering to door Tidy up contact wires to door intruder alarm Align contacts of door intruder alarm Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface Clean two (2) stair flights between Levels 3 and 4 of black paint and mortar stains complete Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Adjust door closer to enable door to close onto the lock and not ajar Make good to wall finish at LH side of door and repaint Repoint between wall finish and RH side of door and repaint Clean paint from mid landing light Make good to LH arris to door which is damage and repaint Re-execute skirting to LH side of door as poor workmanship with rounded corners Re-execute skirting to RH side of door as poor workmanship with rounded corners

Rating Classif. B B B B B B B A A A A B B B B A B B B B B B B B B B A B B B B B B

Date Rectified

Date Checked

Comments

Why are these required ?

4/10/2013

224

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05)

Defect Remove paint to three sprinkler heads Make good to floor and finish at frames bases of Door North Remove paint to South Door Frames Fit rubber seal all round door South Intumnescent strip is not installed to side or head frames Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Install door closer to Door South Install edging and recut floor covering to door South threshold Clean paint off door frame to Door North Intumescent strip is installed to side or head frames of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Install door closer to Door North Remove all remaining parts of protective covering to door Screw missing in lock plate to door North Replace missing skirting to RH side of Door South Replace missing skirting to RH of Door to Handicapped Toilet E4E.15 Replace missing external angle skirting corner piece and skirting to LH of Door to Handicapped Toilet E3E.15 Replace missing external angle skirting corner piece and skirting to RH of Door to Handicapped Toilet E3E.15 Replace missing skirting between Handicapped Toilet E4E.15 and Toilet E4E.14 Replace missing external skirting corner angle piece to LH side of door to Toilet E4E.14 Replace missing external angle skirting corner piece and skirting to RH of Door to Toilet E3E.14 Replace missing external angle skirting corner piece and skirting to RH of Door to Handicapped Toilet E3E.11

Rating Classif. B B B B A B B A B B A B A B B A B B A B B A B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

225

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43

Location Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05) Vestibule Level 4 (E4E.05)

Defect Make good to missing floor covering to RH side of Door South Make good to hole in wall to RH side of Door to Handicapped Toilet E4E.11 and make good and repaint Reset double socket outlet near Door South and make level Reset double socket outlet near Door North and make level Install edging strip between PVC floor covering and tile floor finish to Handicapped Toilet E4E.11 Install edging strip between PVC floor covering and tile floor finish to Toilet E4E.12 Install edging strip between PVC floor covering and tile floor finish to Toilet E4E.13 Install edging strip between PVC floor covering and tile floor finish to Toilet E4E.14 Install edging strip between PVC floor covering and tile floor finish to Handicapped Toilet E4E.15 Refix all skirting as attached with panel pins with adhesive or clip-on system

Rating Classif. B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

226

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Location Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15 Handicapped Toilet E4E.15

Defect Make good to floor tiling around floor gulley and regrout Clean excess grouting to tiles generally Replace door grill screws (Internal) with white headed screws Make good to floor finish at LH Base Frame of door Make good to floor finish at RH Base Frame of door Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Clean fan outlet in ceiling of dirt/dust etc. WHB tap is loose and to be reset properly Install plug Install rubber seal around door Install Door stop Install rubber seal around door Clean general dirt etc in floor pointing and make good Repoint to wall tiling where short or insufficient Make good to tiled floor finish to door frame bases LH Make good to tiled floor finish to door frame bases RH Make good to wall tiling at north east corner Make good to wall tiling at northwest corner where missing Make good to joint between wall and floor tiling on South Wall

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

227

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Location Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14 Toilet E4E.14

Defect Make good the very poor tile grouting etc around floor gulley Make good to base of RH door frames to floor finish Make good to base of LH door frames to floor finish Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug Make good to joint between wall and floor tiling finish in northwestern corner

Rating Classif. B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

228

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

Location Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13 Toilet E4E.13

Defect Make good tile grouting etc around floor gulley Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug Replace broken web sink complete Install edging strip to PVC floor covering where it abuts the ceramic tile floor finish in toilet Touch up missing parts of grouting to wall tiling generally Make good to defective wall tiling in South West Corner Make good to defective wall tiling in South East Corner Clean out at bases of door frames and make good floor finished complete Make good at joint between wall tiling and floor tiling on south wall Make good at joint between wall tiling and floor tiling on west wall

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

229

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12 Toilet E4E.12

Defect Make good tile grouting etc around floor gulley Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug Clean out at bases of door frames and make good floor finished complete Repoint to wall tiling to LH side of door frame for the full length Repoint wall tiling above hand towel dispenser Adjust door as it squeaks Make good at joint between wall tiling and floor tiling on North wall Make good at joint between wall tiling and floor tiling on West wall

Rating Classif. B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

230

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

Location Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11 Handicapped Toilet E4E.11

Defect Make good to floor tiling around floor gulley and regrout Clean excess grouting to tiles generally Replace door grill screws (Internal) with white headed screws Repoint to LH side of door frame Touch up chipped paintwork to door frames Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Clean fan outlet in ceiling of dirt/dust etc. WHB tap is loose and to be reset properly Install plug Replace defective collar seal to WHB tap Install Door stop Install rubber seal around door Clean out at bases to door frames and make good to floor finish Clean general dirt etc in floor pointing and make good Repoint to wall tiling where short or insufficient Make good to joint between wall tiling and floor tiling at North wall Make good to joint between wall tiling and floor tiling at South wall Make good to joint between wall tiling and floor tiling at West wall

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

231

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18)

Defect Prepare for and paint ceiling Remove paint on Access Card Reader Remove paint stains on floor covering generally Fill in hole to door head frame Remove paint splashes etc on doors Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is short on both side frames and requires to be replaced Install door stops to Doors Clean paint off Door Frames Door Signage Fire/Smoke Threshold seal is required to door Install closers with selector on doors Remove all remaining parts of the protective covering to doors Install rubber seal to door Intumescent strip to meeting style is not continuous and missing at door lock Realign door intruder alarm contacts and fix head frame contact which is loose Inner leaf of door has too much play when closed and to be adjusted Tidy up wiring to door intruder contact Screw missing form door locking plate Intumescent strip is short at the prong receiver on the RH door frame Touch up to damaged paintwork to door frames generally Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Relay floor covering that is distorted and 'bubbled' and prepare floor screed below Replace missing skirting and external angle corner piece to LH side of lift entrance return Replace missing skirting and external angle corner piece to RH side of lift entrance return Replace missing skirting to RH of Lift entrance Paint sprinkler pipework Tidy up joint at sprinkler head and elbow joints including removing excess joint hemp fibres on sprinkler pipework Replace screws at grille to LH side with white headed screws as elsewhere Seal and make good to conduit at ceiling level (West Wall) Seal and make good to large hole with two (2) conduits at northeast corner at ceiling level

Rating Classif. B B B B B B B A A B B B A A B B A B A B B A B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

232

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41

Location Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18) Service Elevator Vestibule (E4E.18)

Defect Seal and make good to one (1) sprinkler pipe in northeast corner at near ceiling level Replace broken skirting on West Wall Remove remaining parts of protective covering to Lift frames Clean off paint splashes on Lift Door and frames Make good to floor finishes etc at base of LH frame of door Make good to floor finishes etc at base of RH frame of door and fill in sinking to screed Complete conduit to ceiling smoke detector Remove red paint stain on North Wall

Rating Classif. B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

233

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13

Location Vestibule E4E.08 Vestibule E4E.08 Vestibule E4E.08 Vestibule E4E.08 Vestibule E4E.08 Vestibule E4E.08 Vestibule E4E.08 Vestibule E4E.08 Vestibule E4E.08 Vestibule E4E.08 Vestibule E4E.08 Vestibule E4E.08 Vestibule E4E.08

Defect Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Skirting loose on North Wall at LH return to door to Data Room Make good to floor finishes at door frame bases Reset light switch plate to level position Clean light of dirt and paint stains Touch up chipped paint on door frames Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop

Rating Classif. B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

234

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8

Location Data Room E4E.10 Data Room E4E.10 Data Room E4E.10 Data Room E4E.10 Data Room E4E.10 Data Room E4E.10 Data Room E4E.10 Data Room E4E.10

Defect Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Seal North wall to two (2) HVAC pipes and make good all round

Rating Classif. B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

235

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36

Location Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09 Electrical Closet E4E.09

Defect Paint ceiling Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Make good to floor level on South Wall near door and refix floor covering Install skirting to South Wall as missing Skirting missing at return on East Wall Skirting loose on northern side of East Wall Skirting is missing on West wall (North) Make good to north wall next floor sinking and refix floor covering complete Infill large hole in southeast of room (fire stopping) Hole at present is a safety issue Skirting missing at North wall Skirting under Electrical Cabinet TUPS-3E on West wall is short and to be replaced Paint walls Make good to door plasterboard ingoings to both door frames and head frame Remove paint to Door Frames Fit rubber seal all round door Intumescent strip is short to hinge frame at base of door and to be replaced Intumescent strip is short to open frame at base and to be replaced Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to door Remove remaining protective covering to door Install fire/smoke seal threshold plate to door Screw missing in lock plate to door Door frames are 5mm above finished floor level and to be reset Install door closer Realign intruder alarm door contacts Door sign Make good to wall base at return to East wall in middle and repaint Replace missing skirting to LH side of door Screw in the twenty (20) missing screws to the five (5) control boxes to RH of SBS-7E Install missing skirting to LH return to door with and including external corner angle piece Install missing skirting to RH return to door with and including external corner angle piece Make good to floor slab and finish at LH door frame base Replace label to cabinet SBS 6E which is plastic with paper printed sign and install ivorine label Clean paint from two (2) ceiling lights and make good

Rating Classif. B B B B B B B B A B B B B B B A A B B A B B A B B A B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

236

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07 Janitor Closet E4E.07

Defect Install protection to water pipe with meter Replace door grill screws (Internal) with white headed screws Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Remove all remaining parts of protective covering to door Remove paint on door frames and make good Remove wall paint on trims to suspended ceilings and make good Redo angle edge to vertical corner to LH of door and make good Redo angle edge to vertical corner southeast and make good Make good to joint between wall and floor tiling on South Wall Make good to joint between wall and floor tiling on West Wall Make good ceiling trim at Column B16 Install trough LH tap in wall is loose and requires to be fixed properly Tidy up loose layout of pipework connected with boiler RH tap in wall is loose and requires to be fixed properly Make good untidy suspended ceiling around Column B16 Make good grouting etc to floor gulley Install door stop Make good to floor finish (ceramic tiles) to RH door frame

Rating Classif. B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments W4A to review and advise

4/10/2013

237

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

Location Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06 Pantry E4E.06

Defect Wall tiling is generally poor workmanship Make good joint between wall and floor tiling on North Wall Clean off excess grouting throughout Repair boiler leak and install proper safety valve Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Replace door grill screws (Internal) with white headed screws Install rubber seal to door all round Touch up chipped paintwork to door frames Redo angle piece on wall tiling at head of door to Janitor Closet Redo angle piece on wall tiling at external angle to LH of door to Janitor Closet Redo angle piece on wall tiling at external angle to RH of door to Janitor Closet Door frames are set above floor finish by 6mm and require to be reset Reset RH door to upper cabinet on South Wall Repair damaged floor base unit (RH) damaged by leaking boiler Replace damaged suspended ceiling tile Install plug Seal floor cabinet units between wall and units LH side and make good (East Wall) Seal floor cabinet units between wall and units RH side and make good (East Wall) Make good untidy joint between wall tiling and suspended ceiling on North Wall Install door stop Install edging to PVC floor covering at door entrance Make good to floor finishes at base of LH door frame to Vestibule Make good to floor finishes at base of RH door frame to Vestibule Reset to level position for power socket outlet (double) at floor level on North Wall Are suspended ceiling tiles water resistant (pantry has boiling kettles etc.) Seal floor cabinet units between wall and units LH side and make good (South Wall) Double bowel sink is shown on drawings - Who authorized change to single bowel sink

Rating Classif. B B B A B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

W4A to review and advise W4A to advise

4/10/2013

238

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36

Location Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01 Level 5 Lift Lobby E5E.01

Defect Tiling to floor is uneven and not aligned and requires to be re-executed Wall Tiling to West Wall is debonding, uneven, not aligned, pointing is distressed and requires to be re-executed Wall Tiling to East (Lift) Wall is uneven, not aligned, pointing is distressed and requires to be re-executed Readjust three (3) small downlighters that are not properly aligned and make good Remove paint on ventilation grille large (South) Seal pointing between lift panelling and ceiling PE 09 Seal pointing between lift panelling and ceiling PE 07 Refit stainless steel skirting to Lift PE 09 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 08 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 07 that show gaps between the skirting and wall panelling both sides Clean threshold of Lift PE 09 Clean threshold of Lift PE 08 Clean threshold of Lift PE 07 Make good to floor covering at RH of lift door frame PE7 Make good to floor covering at LH of lift door frame PE7 Make good to floor covering at RH of lift door frame PE8 Make good to floor covering at LH of lift door frame PE8 Make good to floor covering at RH of lift door frame PE9 Make good to floor covering at LH of lift door frame PE9 Make good pointing between wall tiling and lift panelling to LH side of PE09 Make good pointing between wall tiling and lift panelling to LH side of PE07 Remove protective covering from base of RH frame to Lift PE08 Remove protective covering from base of LH frame to Lift PE09 Remove protective covering from base of LH frame to Lift PE08 Remove protective covering to lift door frame head LH of Lift PE09 Remove protective covering to lift door frame head RH of Lift PE09 Remove protective covering to lift door frame head LH of Lift PE08 Remove protective covering to lift door frame head LH of Lift PE07 Clean masking tape off stainless steel panel near ceiling on Lift PE09 Reset warped top panel near ceiling on Lift PE08 Make good joint at West Wall south end where tiling meets render Reset warped top panel near ceiling on Lift PE07 Remove paint on one (1) small ceiling downlighters and make good Set HVAC controller on West Wall level Remove paint on eight (8) sprinkler heads in ceiling Remove paint on smaller grille to North and make good

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

239

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

Location Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01) Corridor North C14/18 (E5E.01)

Defect Install operator signage to Fire Alarm Button at South Wall near door to Stair Vestibule E5E.03 Make good round Fire Damper Grille panel (Low) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Lower) near Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall near Lift Lobby Tiling to wall at C17 South Wall is uneven, debonding, and not aligned and requires to be re-executed Tiling to wall at C16 South Wall is uneven, debonding and not aligned and requires to be re-executed Install operator signage to Fire Alarm Button at South Wall RH of Service Elevator Vestibule Install operator signage to Door Release Button at South Wall to RH of Service Elevator Vestibule Remove paint from Running Man Sign above door to Stair Vestibule E4E.16 Make good round Fire Damper Grille panel (Upper C 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper C 16) near Lift Lobby Provide proper locking device to Upper (C/16) Fire Damper Grille on South Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on South Wall near to RH side of Service Elevator Lobby Clean paint off grille to Fire Damper panel (Lower) to RH side of Service Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall to RH side of Service Lift Lobby

Rating Classif. A B B B B B A A B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

240

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2

Location Corridor East B/C 18(5E.01) Corridor East B/C 18(5E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory

Rating Classif. B B

Date Rectified

Date Checked

Comments

4/10/2013

241

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14

Location Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01) Corridor West B/C 14 (E5E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory Make good round Fire Damper Grille panel B18 East Wall near Fire Hose reel Enclosure (FHE) Clean paint off grille to Fire Damper panel B19 near FHE Provide proper locking device to B18 Fire Damper Grille on East Wall near FHE Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box as key is missing Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hose reel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork and make good Divider Wall to LH to be sealed full length to back wall Remove one electrical cable (used by Ozer during construction) and make good to holes Seal two holes in ceiling slab within FHE and make good Seal around two (2) pipes in the floor slab and make good

Rating Classif. B B B B B B B B B B B A A A

Date Rectified

Date Checked

Comments

4/10/2013

242

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Location Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01) Corridor South B14/18 (E5E.01)

Defect Make good poor tiling above Fire Damper Grille B16 near lift lobby Install operator signage to Fire Alarm Button at North Wall near door to Stair Vestibule E5E.03 Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E5E.16 Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E5E.16 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E5E.16 Install operator signage to Fire Alarm Button at North Wall LH of Stair Vestibule E5E.16 Tiling to wall at C17 North Wall is uneven, debonding and not aligned and requires to be re-executed Tiling to wall at C16 North Wall is uneven, debonding and not aligned and requires to be re-executed Make good to large gap between Low Fire Damper Grille and tiling finish on North Wall LH to Stair Vestibule Door E5E.03 Make good round Fire Damper Grille panel (Upper B 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper B 16) near Lift Lobby Provide proper locking device to Upper (B 16) Fire Damper Grille on North Wall near Lift Lobby Infill to large gap LH side to wall at Fire Damper on North Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E5E.03 LH Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E5E.03 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E5E.03 LH Infill to large gap LH side to wall at Fire Damper on North Wall near Stair Vestibule E5E.03

Rating Classif. B A B B B A B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

243

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03)

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to open frame and short at base and head and loose at top to Door South : replace Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Intumescent strip is not complete at prong receiver to hinge frame and short at base to Door South and to be replaced Lockset is missing and to be fixed Door signage South door frames are 8mm above the finished floor level and to be reset Provide operation label to Door Push Button in Romanian and English Make good to skirting that is broken near RH of door to Egress Stair Remove paint from top edge of skirting on all walls North door frames are 10mm above the finished floor level and to be reset Clean paint etc from two (2) light fittings Clean paint off door frame to Door North Intumescent strip is short to head frame and requires to be replaced Intumescent strip is not complete to both frame bases of Door North and to be replaced Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Remove remaining protective covering to Door North Remove manufacturer's label on door and adhesive and make good Screw missing in lock plate to door North Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required Tile floor is uneven and needs to be levelled, polished and resealed

Rating Classif. B B A B B A B B A B A A B B A B B B B B A A B B A B B A B B B A B

Date Rectified

Date Checked

Comments

This button has been disabled

4/10/2013

244

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45

Location Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03) Stair Vestibule Level 5 (E5E.03)

Defect Make good to terrazzo skirting to RH side of Door North Remove paint to three (3) sprinkler head in ceiling Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internal around Dry Riser Access Panel and make good Form rounded external corner to terrazzo skirting to LH of door to Egress Stair Form rounded external corner to terrazzo skirting to RH of door to Egress Stair

Rating Classif. B C B B B B B B A B B B

Date Rectified

Date Checked

Comments

4/10/2013

245

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

Location Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04) Egress Stair Level 5 (E5E.04)

Defect Remove paint etc to top edge of skirting throughout and make good Remove paint from Running Man Sign and make good Reset light fitting on Level 5 Landing wall which is squint Remove paint etc. from ceiling Smoke Detector and make good Tiled Level 3 floor requires to be levelled, polished and sealed and repaired including workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short and to be replaced Intumescent strip to hinge door jamb is short and to be replaced Rubber infill strip to door is loose at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be aligned Make good to wall painting where stained by repairs to terrazzo skirting Remove all remaining protective covering to door Replace key sets with correct set Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Clean light fitting of paint stains etc. at mid landing Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface and done in bits and pieces Clean two (2) stair flights between Levels 3 and 4 of black paint and mortar stains complete Clean terrazzo tile at mid landing around the two (2) balustrade supports Provide rounded edges to terrazzo skirting to LH of door base Provide rounded edges to terrazzo skirting to RH of door base Replace two (2) chipped steps

Rating Classif. B B B B B B B A A A B B B B A B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

246

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16)

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to both frame base and prong receiver both sides on hinge side of Door South : replace Intumescent strip is not complete to base of open frame of Door South and also loose Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Intumescent strip is loose and distorted on head frame and to be replaced Why are there locks on Stair Egress Doors operated with Card Reader Access and Release Push button ? Terrazzo tile floor is uneven and needs to be levelled, polished and resealed Terrazzo Skirting at RH wall returns to door to have rounded or pencil arrissed corners to Stair Egress Provide operation label to Door Push Button in Romanian and English Remove paint etc. from top edge of skirting on all walls Reset double power socket outlet near Door North on East wall to be level Reset double power socket outlet near Door South on East wall to be level Clean paint etc from two (2) light fittings Screw missing from door lock plate on Door North Clean paint off door frame to Door North Touch up chipped paintwork to door frames Intumescent strip is short to base of open frame of Door North and to be replaced Intumescent strip is short at head and base on the hinge frame and to be re-installed to Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Remove all remaining parts of protective covering to door Terrazzo Skirting at LH wall returns to door to have rounded or pencil arrissed corners to Stair Egress

Rating Classif. B B A A B B A B B A B A A B B A B B B B B B B A A B B A B B A B B

Date Rectified

Date Checked

Comments

W4A to advise

This push button is disabled

4/10/2013

247

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50

Location Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16) Stair Vestibule Level 5 (E5E.16)

Defect Remove all remaining parts of protective covering to door North Remove paint to three (3) sprinkler head in ceiling and make good Reset sprinkler head South which is proud of ceiling surface Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Make good to skirting to LH of Door South Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required Remove paint from Running Man Sign and make good Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internally around Dry Riser Access Panel and make good Remove piece of timber formwork within Dry Riser enclosure that is obstructing access to Dry Riser coupling Remove pencil mark on terrazzo skirting RH return to Door to Stair Egress Make good to skirting terrazzo to East Wall near south end that is in distress

Rating Classif. B B B B B B B B B B A B A A A B B

Date Rectified

Date Checked

Comments

4/10/2013

248

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17) Egress Stair Level 5 (E5E.17)

Defect Remove paint etc to top edge of skirting throughout and make good Remove paint from Running Man Sign and make good Tiled Level 4 floor requires to be levelled, polished and sealed and repaired where poor workmanship near divide wall to stair Intumescent strip is missing from head and frame and requires to be installed Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short at base and to be replaced Intumescent strip to hinge door jamb is short at base and head and to be replaced Intumescent strip is missing from head frame and requires to be replaced Rubber infill strip to door is partly missing at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be aligned Remove all remaining protective covering to door Tidy up contact wires to door intruder alarm Clean paint etc from Landing 5 light and make good Make good at joint with wall and ceiling above door Landing 5 and repaint Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface Clean two (2) stair flights between Levels 5 and 6 of black paint and mortar stains complete Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Make good to wall above Door to Landing 5 LH side Replace one (1) chipped stair tread Repoint between wall finish and RH side of door and repaint Clean paint etc from mid landing light Seal joint between tiled floor and terrazzo tile skirting on north wall at mid landing Re-execute skirting to LH side of door as poor workmanship with rounded corners Re-execute skirting to RH side of door as poor workmanship with rounded corners

Rating Classif. B B B A B B A A A A B B B B A B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

Why are these required ?

4/10/2013

249

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31

Location Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18) Service Elevator Vestibule (E5E.18)

Defect Remove paint stains on floor covering generally Fill in hole to door head frame Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is short on both side frames and requires to be replaced Install door stops to Doors Clean paint off Door Frames Door Signage Fire/Smoke Threshold seal is required to door Install closer on inner leaf of doors with selector on doors Remove all remaining parts of the protective covering to doors Install rubber seal to door Intumescent strip to meeting style is not continuous and missing at door lock Realign door intruder alarm contacts and fix head frame contact which is loose Inner leaf of door has too much play when closed and to be adjusted Tidy up wiring to door intruder contact Screw missing form door locking plate Intumescent strip is short at the prong receiver on the RH door frame Touch up to damaged paintwork to door frames generally Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Relay floor covering that is distorted and 'bubbled' and prepare floor screed below Paint sprinkler pipework Tidy up joint at sprinkler head and elbow joints including removing excess joint hemp fibres on sprinkler pipework Replace screws at grille to LH side with white headed screws as elsewhere Seal and make good to conduit at ceiling level (West Wall) Seal and make good to one (1) sprinkler pipe in northeast corner at near ceiling level Clean off paint splashes on Lift Door and frames Make good to floor finishes etc at base of LH frame of door Make good to floor finishes etc at base of RH frame of door and fill in sinking to screed Repair door catch on Inner Door leaf that operate the upper door bolt

Rating Classif. B B B B A A B B B A A B B A B A B B A B B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

250

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Location Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09 Electrical Closet E5E.09

Defect Fix skirting to complete room which is missing Make good to floor level on South Wall near door and refix floor covering Make good wall plasterboard on East Wall near bus bar assembly (RH) Remove paint splashed on door surfaces Make good to short floor covering on East side of room Make good to north wall next floor sinking and refix floor covering complete Infill large hole in southeast of room (fire stopping) Hole at present is a safety issue Install door closer Intumescent strip is not provided to head frame of door and to be installed Intumescent strip is not provided to open frame of door and to be installed Remove paint to Door Frames Fit rubber seal all round door Intumescent strip is not provided to hinge frame of door and to be installed Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be accounted Install door stop to door Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Door frames are 5mm above finished floor level and to be reset Install door closer Intruder alarm door contacts to be fitted Door sign Screw in the fifteen (6) loose screws to the five (5) control boxes to RH of SBS-7E Fit sealing screws to fourteen (14) missing screws to the (5) control boxes to RH of SBS-7E Replace label to cabinet SBS 9E which is plastic with paper printed sign and install ivorine label Reconnect three (3) loose wires or remove in electrical box above control boxes No 2 above SBS-7E Reconnect seven (7) loose wires or remove in electrical box above control boxes No 4 above SBS-7E Clean dust inside TLE-5E Clean dust inside TUPS-5E Clean dust inside TCT-5E Clean dust inside TLS-5E Replace broken panel (lower upper) in Electrical Cabinet TUPS-5E

Rating Classif. B B B B B B A A A A B B A B B A B B A B B A B B B B B A A B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

251

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8

Location Data Room E5E.10 Data Room E5E.10 Data Room E5E.10 Data Room E5E.10 Data Room E5E.10 Data Room E5E.10 Data Room E5E.10 Data Room E5E.10

Defect Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Seal North wall to two (2) HVAC pipes and make good all round

Rating Classif. B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

252

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Location Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space

Defect Window No 1 North Repair tighten window handle Window No 2 North Repair tighten window handle Window No 3 North Repair tighten window handle Window No 4 North Repair tighten window handle Window No 5 North Repair tighten window handle Window No 6 North Repair tighten window handle Window No 7 North Repair tighten window handle Window No 8 Repair defective seal at corner of opening window Window No 9 North Repair defective seal at corner and refix seal to opening window Window No 10 tighten window handle Window No. 11 tighten window handle Window No 12 North install missing window frame seal for full height of opening Window No 13 North refix seal to opening window at base of sash Window No 14 North tighten window handle Window No 3 East Tighten window handle Window No 6 East Repair defective seal at head frame corner and refix seal to opening window Window Fan No 1 East Repair seal at bottom LH that is under stress and remove excess mastic sealant Window Fan No 1 East tighten up window handle Window Fan No 1 East remove all remaining protective covering to window frames etc. Window Fan No 1 South install inner frame seal which is missing and remove excess mastic sealant Window Fan No 1 South tighten window handle Window Fan No 2 South make good to window seal outer and inner at top LH Window Fan No 2 South make good to window seal in distress at RH which is also broken and needs to be replaced Window Fan No 2 South tighten window handle Window Fan No 3 South tighten window handle Window Fan No 4 South tighten window handle Window Fan No 5 South tighten window handle Window Fan No 5 South tighten window handle Window Fan No 7 South tighten window handle Window Fan No 2 South Remove excess mastic and sealant Window Fan No 3 South Remove excess mastic and sealant Window Fan No 4 South Remove excess mastic and sealant Window Fan No 5 South Remove excess mastic and sealant Window Fan No 6 South Remove excess mastic and sealant

Rating Classif. B B B B B B B B B B B B B B B B B B B A B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

253

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 35 36 37 38 39 40 41 42 43 44

Location Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space Level 5 Schlumberger Space

Defect Window Fan No 7 South Remove excess mastic and sealant Window Fan No 3 South replace frame seal that is damaged Window Fan No 3 South replace window frame seal that is damaged Window Fan No 4 South Repair window seal (2 No) to LH of window Window Fan No 5 South repair or replace outer window seal that is distorted at top and damaged at LH end Window Fan No 6 South Repair or replace outer seal to window that is loose and damaged at RH end Window Fan No 7 South Repair or replace outer seal to window that is under stress and distorted Window Fan No 7 South Repair or replace inner seal to window that is damaged at RH end and distorted Remove labels on all windows generally Clean general building debris out of runnels to all twenty eight (28) opening sashes

Rating Classif. B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

254

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

Location Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01 Level 6 Lift Lobby E6E.01

Defect Wall Tiling to East (Lift) Wall is uneven, not aligned, pointing is distressed and requires to be re-executed Readjust two (2) small downlighters (North and South) that are not properly aligned and make good Remove paint on ventilation grille large (South) Seal pointing between lift panelling and ceiling PE 09 Refit stainless steel skirting to Lift PE 09 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 08 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 07 that show gaps between the skirting and wall panelling both sides Clean threshold of Lift PE 09 Clean threshold of Lift PE 08 Clean threshold of Lift PE 07 Make good pointing between wall tiling and lift panelling to LH side of PE09 Make good pointing between wall tiling and lift panelling to RH side of PE09 Make good pointing between wall tiling and lift panelling to LH side of PE08 Make good pointing between wall tiling and lift panelling to RH side of PE08 Make good pointing between wall tiling and lift panelling to LH side of PE07 Make good pointing between wall tiling and lift panelling to RH side of PE07 Remove protective covering from base of RH frame to Lift PE08 Remove protective covering from base of LH frame to Lift PE09 Remove protective covering from base of LH frame to Lift PE08 Remove protective covering to lift door frame head LH of Lift PE09 Remove protective covering to lift door frame head LH of Lift PE08 Remove protective covering to lift door frame head LH of Lift PE07 Make good to warped joints between head lift panel above door and main panel above lift door PE09 Make good to warped joints between head lift panel above door and main panel above lift door PE08 Make good to warped joints between head lift panel above door and main panel above lift door PE07 Remove paint on three (3) small ceiling downlighters and make good Remove paint on eight (8) sprinkler heads in ceiling Remove paint on smaller grille to North and make good

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

255

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

Location Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01) Corridor East B/C 18 (E6E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory Make good round Fire Damper Grille panel B18 East Wall near Fire Hose reel Enclosure (FHE) Clean paint off grille to Fire Damper panel B18 near FHE Provide proper locking device to B18 Fire Damper Grille on East Wall near FHE Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box as key is missing Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hose reel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork and make good Investigate damp stain within FHE at B18 Install two (2) nozzles to hosereels Make good and seal hole in ceiling slab in FHE Seal LH internal divider wall all round at conduit entry Make good slab inside FHE as concrete deposits and debris etc.. Seal around two (2) pipes in the floor slab and make good

Rating Classif. B B B B B B B B B B A A A A B A

Date Rectified

Date Checked

Comments

4/10/2013

256

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

Location Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01) Corridor South B14/18 (E6E.01)

Defect Remove paint from Fire Alarm at Stair Vestibule E6E.16 Install operator signage to Fire Alarm Button at North Wall near door to Stair Vestibule E6E.03 Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E6E.16 Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E6E.16 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E6E.16 Install operator signage to Fire Alarm Button at North Wall LH of Stair Vestibule E6E.16 Make good to large gap between Low Fire Damper Grille and tiling finish on North Wall LH to Stair Vestibule Door E6E.03 Make good round Fire Damper Grille panel (Upper B 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper B 16) near Lift Lobby Provide proper locking device to Upper (B 16) Fire Damper Grille on North Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E6E.03 LH Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E6E.03 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E6E.03 LH Remove paint from Running Man Sign near Stair Vestibule E6E.16 Make good to damaged arris to RH side of Door to Stair Vestibule E6E.16

Rating Classif. A B B B A B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

257

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03)

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is not complete to open frame and short at base and top to Door South : replace Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Intumescent strip is not complete to hinge frame as missing to lower part, loose in the upper and short at head to Door South Intumescent strip on head frame is short at sides of South Door : to be replaced Remove labels on South door and make good Provide operation label to Door Push Button in Romanian and English Remove paint from top edge of skirting on all walls Clean paint etc from two (2) light fittings Clean paint off door frame to Door North Clean paint splashes etc on surfaces of Door North Intumescent strip is short to head frame and requires to be replaced Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Remove remaining protective covering to Door North Remove manufacturer's label on door and adhesive and make good Screw missing in lock plate to door North Make good to terrazzo skirting to RH side of Door South Remove paint to three (3) sprinkler head in ceiling Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper)

Rating Classif. B B A B B A B B A B A A B A B B B B A A B B A B B A B B B B C B B

Date Rectified

Date Checked

Comments

4/10/2013

258

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45

Location Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03) Stair Vestibule Level 6 (E6E.03)

Defect Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internally around Dry Riser Access Panel and make good Remove timber batten in Dry Riser box that is obstructing the efficient usage of the Type C Hose Connection Form rounded external corner to terrazzo skirting to LH of door to Egress Stair Form rounded external corner to terrazzo skirting to RH of door to Egress Stair Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required Tile floor is uneven and needs to be levelled, polished and resealed Make good split joint at arris to LH side of door to Egress Stair and repaint

Rating Classif. B B B B A B A B B A B B

Date Rectified

Date Checked

Comments

4/10/2013

259

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Location Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04) Egress Stair Level 6 (E6E.04)

Defect Remove paint etc to top edge of skirting throughout and make good Remove paint from Running Man Sign and make good Remove paint from Access Car Reader and make good Remove paint etc. from ceiling Smoke Detector and make good Tiled Level 6 Landing floor requires to be levelled, polished and sealed and repair near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short and to be replaced Intumescent strip to hinge door jamb is short and to be replaced Rubber infill strip to door is loose at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door frame set 12mm above finished floor level and to be reset Door intruder alarm contact wiring to be tidied up Remove all remaining protective covering to door Clean paint etc off light at Landing 6 Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Clean light fitting of paint stains etc. at mid landing Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface Clean two (2) stair flights between Levels 3 and 4 of black paint and mortar stains complete Clean terrazzo tile at mid landing around the two (2) balustrade supports Reset light fitting at mid landing to level position Clean main landing light of paint splashes etc Replace one (1) chipped step tread Make good to wall paint where repairs carried out to stair skirting Repoint joint between floor tiles and terrazzo skirting at mid landing East Wall Repoint terrazzo skirting at West Wall for lower stair flight Repoint terrazzo skirting at East Wall for upper stair flight

Rating Classif. B B B B B B B A A A B B B B A B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

260

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17)

Defect Remove paint etc to top edge of skirting throughout and make good Remove paint from Running Man Sign and make good Remove paint from Access Car Reader and make good Remove paint on Smoke Detector and make good Tiled Level 4 floor requires to be polished and sealed and repaired where poor workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short at base and head and to be replaced Intumescent strip to hinge door jamb is short at base and head and to be replaced Intumescent strip is missing from head frame and requires to be replaced Rubber infill strip to door is missing all round Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be aligned Remove all remaining protective covering to door Tidy up contact wires to door intruder alarm Align contacts of door intruder alarm Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface Clean two (2) stair flights between Levels 6 and 7 of black paint and mortar stains complete Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Door lock is not working properly and to be overhauled Make good to wall finish at LH side of door and repaint Reset Mid landing light so that it is level Clean paint from mid landing light Touch up damaged paintwork to door frames Repoint between floor tiling to mid landing and north wall Repoint between floor tiling to mid landing and east wall

Rating Classif. B B B B B B B A A A A B B B B A B B B B B B B B B B A B B B B B B

Date Rectified

Date Checked

Comments

Why are these required ?

4/10/2013

261

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41

Location Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17) Egress Stair Level 6 (E6E.17)

Defect Repoint between floor tiling to mid landing and west wall Clean Landing 6 light of paint etc Re-fix intruder alarm contact to door frame as loose Terrazzo skirting is missing to LH of door and to be replaced Repoint to tiles skirting to Lower Stair flight on West Wall Repoint to tiles skirting to Upper Stair flight on East Wall Re-execute skirting to LH side of door as poor workmanship with rounded corners Re-execute skirting to RH side of door as poor workmanship with rounded corners

Rating Classif. B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

262

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

Location Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14 Toilet E6E.14

Defect Make good the very poor tile grouting etc around floor gulley Make good to base of RH door frames to floor finish Make good to base of LH door frames to floor finish Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug

Rating Classif. B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

263

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Location Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13 Toilet E6E.13

Defect Make good tile grouting etc around floor gulley Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug Touch up missing parts of grouting to wall tiling generally Clean out at bases of door frames and make good floor finished complete Make good at joint between wall tiling and floor tiling on south wall Make good at joint between wall tiling and floor tiling on west wall

Rating Classif. B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

264

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Location Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12 Toilet E6E.12

Defect Make good tile grouting etc around floor gulley Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug Clean out at bases of door frames and make good floor finished complete Make good at joint between wall tiling and floor tiling on North wall Make good at joint between wall tiling and floor tiling on West wall

Rating Classif. B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

265

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

Location Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11 Handicapped Toilet E6E.11

Defect Make good to floor tiling around floor gulley and regrout Clean excess grouting to tiles generally Replace door grill screws (Internal) with white headed screws Touch up chipped paintwork to door frames Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Clean fan outlet in ceiling of dirt/dust etc. WHB tap is loose and to be reset properly Install plug Replace defective collar seal to WHB tap Install Door stop Install rubber seal around door Clean out at bases to door frames and make good to floor finish Clean general dirt etc in floor pointing and make good Repoint to wall tiling where short or insufficient Make good to joint between wall tiling and floor tiling at North wall Make good to joint between wall tiling and floor tiling at South wall Make good to joint between wall tiling and floor tiling at West wall

Rating Classif. B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

266

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Location Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07 Janitor Closet E6E.07

Defect Install protection to water pipe with meter Replace door grill screws (Internal) with white headed screws Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Remove all remaining parts of protective covering to door Remove paint on door frames and make good Remove wall paint on trims to suspended ceilings and make good Redo angle edge to vertical corner to LH of door and make good Redo angle edge to vertical corner southeast and make good Make good to joint between wall and floor tiling on South Wall Make good to joint between wall and floor tiling on West Wall Make good ceiling trim at Column B16 Install trough LH tap in wall is loose and requires to be fixed properly Tidy up loose layout of pipework connected with boiler RH tap in wall is loose and requires to be fixed properly Replace two (2) damaged ceiling tiles Make good grouting etc to floor gulley Install door stop Make good to floor finish (ceramic tiles) to RH door frame Make good to floor finish (ceramic tiles) to LH door frame Make good joint between LH side of door and wall finish Make good joint between RH side of door and wall finish

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments W4A to review and advise

4/10/2013

267

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

Location Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06 Pantry E6E.06

Defect Wall tiling is generally poor workmanship Make good joint between wall and floor tiling on North Wall Clean off excess grouting throughout Repair boiler leak and install proper safety valve Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Replace door grill screws (Internal) with white headed screws Install rubber seal to door all round Touch up chipped paintwork to door frames Redo angle piece on wall tiling at head of door to Janitor Closet Redo angle piece on wall tiling at external angle to LH of door to Janitor Closet Redo angle piece on wall tiling at external angle to RH of door to Janitor Closet Redo angle piece on wall tiling at external angle to soffit of door to Janitor Closet Reset RH door to upper cabinet on South Wall Repair damaged floor base unit (RH) damaged by leaking boiler Replace damaged suspended ceiling tile Install plug to sink Seal floor cabinet units between wall and units LH side and make good (East Wall) Seal floor cabinet units between wall and units RH side and make good (East Wall) Make good untidy joint between wall tiling and suspended ceiling on North Wall Install door stop Install edging to PVC floor covering at door entrance Make good to floor finishes at base of LH door frame to Vestibule Make good to floor finishes at base of RH door frame to Vestibule Reset to level position for power socket outlet (double) at floor level on North Wall Are suspended ceiling tiles water resistant (pantry has boiling kettles etc.) Seal floor cabinet units between wall and units LH side and make good (South Wall) Redo angle piece on wall tiling at external angle between cupboard units in southeast room corner ]Make good to wall at joint with tiling at southeast corner near wall tiling and just above floor cupboard units Double sink shown on plans - Who authorised change to single sink Make good to untidy angle joint at bulkhead to suspended ceiling Make good poor workmanship to relief bead above wall tiling on South Wall Wall Cabinets on South Wall require to be set level

Rating Classif. B B B A B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

W4A to review and advise

W4A to advise

4/10/2013

268

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

Location Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01 Level 7 Lift Lobby E7E.01

Defect Reset Large Grille in ceiling and make good to screw holes etc to the north and repaint Wall Tiling to East (Lift) Wall is uneven, not aligned, pointing is distressed and requires to be re-executed Readjust three (3) small downlighters that are not properly aligned and make good Remove paint on ventilation grille large (South) Seal pointing between lift panelling and ceiling PE 09 Refit stainless steel skirting to Lift PE 09 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 08 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 07 that show gaps between the skirting and wall panelling both sides Clean threshold of Lift PE 09 Clean threshold of Lift PE 08 Clean threshold of Lift PE 07 Make good pointing between wall tiling and lift panelling to LH side of PE09 Make good pointing between wall tiling and lift panelling to RH side of PE09 Make good pointing between wall tiling and lift panelling to LH side of PE08 Make good pointing between wall tiling and lift panelling to RH side of PE08 Make good pointing between wall tiling and lift panelling to LH side of PE07 Make good pointing between wall tiling and lift panelling to LH side of PE09 Make good pointing between wall tiling and lift panelling to RH side of PE07 Remove protective covering from base of RH frame to Lift PE08 Remove protective covering from base of LH frame to Lift PE09 Remove protective covering from base of LH frame to Lift PE08 Remove protective covering to lift door frame head LH of Lift PE09 Remove protective covering to lift door frame head LH of Lift PE08 Remove protective covering to lift door frame head LH of Lift PE07 Remove paint on three (3) small ceiling downlighters and make good Remove paint on eight (8) sprinkler heads in ceiling Infill gap at head of lift panel lining to Lift PE08 Infill gap at head of lift panel lining to Lift PE07

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

269

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

Location Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01) Corridor North C14/18 (E7E.01)

Defect Remove paint on Fire Alarm LH of door to Stair Vestibule E7E.03 Install operator signage to Fire Alarm Button at South Wall near door to Stair Vestibule E7E.03 Make good round Fire Damper Grille panel (Low) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Lower) near Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall near Lift Lobby Install operator signage to Fire Alarm Button at South Wall RH of Service Elevator Vestibule Install operator signage to Door Release Button at South Wall to RH of Service Elevator Vestibule Install break glass to Emergency Door Release Button on South Wall to RH of Service Elevator Vestibule Remove paint from Running Man Sign above door to Stair Vestibule E7E.16 Make good round Fire Damper Grille panel (Upper C 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper C 16) near Lift Lobby Provide proper locking device to Upper (C/16) Fire Damper Grille on South Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on South Wall near to RH side of Service Elevator Lobby Clean paint off grille to Fire Damper panel (Lower) to RH side of Service Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall to RH side of Service Lift Lobby point ceiling finish around Running Man Sign near Stair Vestibule E7E.16

Rating Classif. B A B B B A A A B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

270

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Location Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01) Corridor East B/C 18(E7E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory Make good round Fire Damper Grille panel C14 East Wall near Fire Hose reel Enclosure (FHE) Clean paint off grille to Fire Damper panel C14 near FHE Provide proper locking device to C14 Fire Damper Grille on East Wall near FHE Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hose reel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork and make good Divider Wall to RH to be sealed full length to back wall Seal wall at RH side of enclosure for waste pipe and make good Seal two holes in ceiling slab within FHE and make good Seal around conduit to RH side of FHE internally on LH Divider wall Make good to wall below Fire Damper Grill near Door to Stair Vestibule E7E.03 Renew defective lock to Fire Hose reel Enclosure (FHE) Fit two (2) nozzles to hosereels Remove hardboard shim to LH side of FHE door frame Divider Wall to RH to be sealed at top and made good Seal and make good to void for pipes in ceiling slab Seal and make good to large pipe above FHE Door on RH side inside Seal ends of RH Divider wall in FHE and make good Remove loose frame fixing metal fastener to LH side frame and make good

Rating Classif. B B B B B B B B B B B B A B B B A B A A A A B

Date Rectified

Date Checked

Comments

4/10/2013

271

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

Location Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01) Corridor West B/C 14 (E7E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory Make good round Fire Damper Grille panel B18 East Wall near Fire Hose reel Enclosure (FHE) Clean paint off grille to Fire Damper panel B19 near FHE Provide proper locking device to B18 Fire Damper Grille on East Wall near FHE Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box as key is missing Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hose reel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork and make good Divider Wall to LH to be sealed full length to back wall Remove three electrical cables (used by Ozer during construction) and make good to all holes Seal two holes in ceiling slab within FHE and make good Seal around hole to RH side of FHE internally near concrete beam Make good slab inside FHE as concrete deposits and debris etc.. Seal around two (2) pipes in the floor slab and make good Fit two (2) nozzles to hosereels Remove small electrical cable used by Ozer during construction and make good to floor and ceiling slab when removed Make good to blockwork above door on RH side of front wall Seal sides of RH Divider wall at back and front and make good Seal LH Divider wall at top and make good Make good to wall plaster finish to LH side of external door frames to FHE

Rating Classif. B B B B B B B B B B B A A A B A A A A A A B

Date Rectified

Date Checked

Comments

4/10/2013

272

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13

Location Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01) Corridor South B14/18 (E7E.01)

Defect Install operator signage to Fire Alarm Button at North Wall near door to Stair Vestibule E7E.03 Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E7E.16 Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E7E.16 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E7E.16 Install operator signage to Fire Alarm Button at North Wall LH of Stair Vestibule E7E.16 Install operator signage to Fire Alarm Button at North Wall LH of Stair Vestibule E7E.16 Make good to large gap between Low Fire Damper Grille and tiling finish on North Wall LH to Stair Vestibule Door E7E.03 Make good round Fire Damper Grille panel (Upper B 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper B 16) near Lift Lobby Provide proper locking device to Upper (B 16) Fire Damper Grille on North Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E7E.03 LH Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E7E.03 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E74E.03 LH

Rating Classif. A B B B A A B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

273

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03)

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip to open frame is short to both head and base to Door South : to be replaced Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Intumescent strip is not complete to hinge frame as short at base to Door South and to be replaced Intumescent strip to hinge frame is missing below the prong receiver Change to permanent lockset Tiled floor is uneven and discoloured and required to be levelled, polished and sealed Floor tiling at Door South is incomplete South light is not working and to be repaired Provide operation label to Door Push Button in Romanian and English Remove paint from top edge of skirting on all walls Clean paint etc from two (2) light fittings Clean paint off door frame to Door North Clean paint splashes etc on surfaces of Door North Intumescent strip is short to head frame and requires to be replaced Intumescent strip is not complete to both frame bases of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Remove remaining protective covering to Door North Form rounded external corner to terrazzo skirting to RH of door to Egress Stair Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required Tile floor is uneven and needs to be levelled, polished and resealed

Rating Classif. B B A B B A B B A B A A B B B B A B B B B A A B B A B B A B B A B

Date Rectified

Date Checked

Comments

This button has been disabled

W4A to advise on solution

4/10/2013

274

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48

Location Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03) Stair Vestibule Level 7 (E7E.03)

Defect Screw missing in lock plate to door North Make good to terrazzo skirting to RH side of Door South Remove paint to three (3) sprinkler head in ceiling Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internally around Dry Riser Access Panel and make good Door to Dry Riser hatch is missing and to be replaced Seal internally around Dry Riser Access Panel and make good Form rounded external corner to terrazzo skirting to LH of door to Egress Stair Make good to poor workmanship to terrazzo tiling at RH of North Door

Rating Classif. B B C B B B B B B A B A B B B

Date Rectified

Date Checked

Comments

4/10/2013

275

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32

Location Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04) Egress Stair Level 7 (E7E.04)

Defect Remove paint etc to top edge of skirting throughout and make good Remove paint etc. from ceiling Smoke Detector and make good Tiled Level 3 floor requires to be levelled, polished and sealed and repaired including workmanship near divide wall to stair Door to be adjusted as squeaks badly Closer not really strong enough to close the door Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short at head and base and to be replaced Intumescent strip to hinge door jamb is short at head and base and to be replaced Rubber infill strip to door is loose at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be aligned Door intruder alarm contact wiring to be tidied up Remove all remaining protective covering to door Replace key sets with correct set Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Clean light fitting of paint stains etc. at mid landing Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface Clean two (2) stair flights between Levels 3 and 4 of black paint and mortar stains complete Clean terrazzo tile at mid landing around the two (2) balustrade supports Reset light fitting at mid landing to level position Clean main landing light of paint splashes etc Reset Light to Landing & and make level Make good to hole repair on South wall to LH of Loudspeaker Replace one (1) chipped stair tread

Rating Classif. B B B B A B B A A A B B B B A B B B A B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

276

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16)

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is short to both frame bases to Door South : replace Intumescent strip is not complete to base of open frame of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Install door closer to Door South Why are there locks on Stair Egress Doors operated with Card Reader Access and Release Push button ? Terrazzo tile floor is uneven and needs to be levelled, polished and resealed Make good to LH return of terrazzo skirting at Egress Stair door with rounded external angle Provide operation label to Door Push Button in Romanian and English Remove paint etc. from top edge of skirting on all walls Replace damaged strike plate to Door South Reset double power socket outlet near Door South on East wall to be level Clean paint etc from two (2) light fittings Screw missing from door lock plate on Door North Clean paint off door frame to Door North Touch up chipped paintwork to door frames Door North Intumescent strip is not complete to both frame bases of Door North Intumescent strip is loose at the prong receiver on the hinge frame and to be re-installed to Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Remove all remaining parts of protective covering to door Make good to RH return of terrazzo skirting at Egress Stair door with rounded external angle

Rating Classif. B B A A B B A B B A B A A B B A B B B B B B B A A B B A B B A B B

Date Rectified

Date Checked

Comments

W4A to advise

This push button is disabled

4/10/2013

277

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52

Location Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16) Stair Vestibule Level 7 (E7E.16)

Defect Touch up damaged paintwork to door frames of Door South Make good to floor and finish to LH Side frame of Door South Remove all remaining parts of protective covering to door North Remove paint to three (3) sprinkler head in ceiling and make good Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Make good to skirting to LH of Door South Make good to skirting to LH of Door North Make good to skirting to RH of Door North Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required Remove paint from Running Man Sign and make good Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internally around Dry Riser Access Panel and make good Replace missing hatch door to Dry Riser Make good to damaged skirting to LH side of door to Egress Stair and repaint as required

Rating Classif. B B B C B B B B B B B B B A B A A B B

Date Rectified

Date Checked

Comments

4/10/2013

278

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36

Location Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17) Egress Stair Level 7 (E7E.17)

Defect Remove paint etc to top edge of skirting throughout and make good Remove paint from Running Man Sign and make good Align Access Car Reader level and make good Remove paint on Smoke Detector and make good Tiled Level 7 floor requires to be polished and sealed and repaired and where poor workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short at base and strike plate, also loose and to be replaced Intumescent strip to hinge door jamb is short at base and head and to be replaced Door catches on Egress Stair landing floor : adjust so that it does not catch Rubber infill strip to door is loose at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be aligned Remove all remaining protective covering to door Tidy up contact wires to door intruder alarm Align contacts of door intruder alarm Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface Clean two (2) stair flights between Levels 3 and 4 of black paint and mortar stains complete Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Fix contact plate for Access Control on door to door more tightly Make good to terrazzo skirting damaged to LH side of Door and repaint as required Repoint between wall finish and LH side of door and repaint Clean paint from mid landing light Clean paint from light on Landing 7 Reset light to Landing 7 level Make good to joint between floor and skirting on mid landing East Wall Make good joint on tile skirting to Upper flight on East Wall and make good to painting as required Re-execute skirting to LH side of door as poor workmanship with rounded corners Re-execute skirting to RH side of door as poor workmanship with rounded corners

Rating Classif. B B B B B B B A A A A B B B B A B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

Why are these required ?

4/10/2013

279

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05)

Defect Remove paint to three sprinkler heads Make good to floor and finish at frames bases of Door South Remove paint to South Door Frames Fit rubber seal all round door South Intumnescent strip is not installed to side or head frames Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Install door closer to Door South Install edging and recut floor covering to door South threshold Clean paint off door frame to Door North Intumescent strip is installed to side or head frames of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Install door closer to Door North Remove all remaining parts of protective covering to door Screw missing in lock plate to door North Replace missing external angle skirting corner piece to LH of Door to Handicapped Toilet E7E.15 Replace missing external angle skirting corner piece to LH of Door to Pantry Replace missing external angle skirting corner piece to RH of Door to Pantry Replace missing external angle skirting corner piece to RH of Door to Vestibule E7E.08 Replace missing skirting to LH side return to Pantry Door Refix skirting on East Wall South End Make good to hole in wall to RH side of Door to Handicapped Toilet E4E.11 and make good and repaint Reset double socket outlet near Door South and make level

Rating Classif. B B B B A B B A B B A B A B B A B B A B B A B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

280

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40

Location Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05) Vestibule Level 7 (E7E.05)

Defect Install edging strip between PVC floor covering and tile floor finish to Handicapped Toilet 74E.11 Install edging strip between PVC floor covering and tile floor finish to Toilet E7E.12 Install edging strip between PVC floor covering and tile floor finish to Toilet E7E.13 Install edging strip between PVC floor covering and tile floor finish to Toilet E7E.14 Install edging strip between PVC floor covering and tile floor finish to Handicapped Toilet E7E.15 Refix all skirting as attached with panel pins with adhesive or clip-on system Clean paint and dirt on Smoke Detector

Rating Classif. B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

281

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15 Handicapped Toilet E7E.15

Defect Make good to floor tiling around floor gulley and regrout Clean excess grouting to wall tiles generally Replace door grill screws (Internal) with white headed screws Make good to floor finish at LH Base Frame of door Make good to floor finish at RH Base Frame of door Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Clean fan outlet in ceiling of dirt/dust etc. WHB tap is loose and to be reset properly Install plug Install Door stop Install rubber seal around door Clean general dirt etc in floor pointing and make good Repoint to wall tiling where short or insufficient Make good to tiled floor finish to door frame bases LH Make good to tiled floor finish to door frame bases RH Make good to joint between wall and floor tiling on South Wall

Rating Classif. B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

282

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Location Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14 Toilet E7E.14

Defect Make good the poor tile grouting etc around floor gulley Make good to base of RH door frames to floor finish Make good to base of LH door frames to floor finish Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug Make good to joint between wall and floor tiling finish on West wall

Rating Classif. B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

283

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Location Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13 Toilet E7E.13

Defect Make good tile grouting etc around floor gulley Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug Touch up missing parts of grouting to wall tiling generally Clean out at bases of door frame LH and make good floor finished complete Clean out at bases of door frame RH and make good floor finished complete Make good at joint between wall tiling and floor tiling on south wall Make good at joint between wall tiling and floor tiling on west wall

Rating Classif. B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

284

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Location Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12 Toilet E7E.12

Defect Make good tile grouting etc around floor gulley Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug Clean out at bases of door frame LH and make good floor finished complete Clean out at bases of door frame RH and make good floor finished complete Make good at joint between wall tiling and floor tiling on North wall Make good at joint between wall tiling and floor tiling on South wall

Rating Classif. B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

285

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11 Handicapped Toilet E7E.11

Defect Make good to floor tiling around floor gulley and regrout Clean excess grouting to tiles generally Replace door grill screws (Internal) with white headed screws Touch up chipped paintwork to door frames Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door WHB tap is loose and to be reset properly Install plug to sink Install Door stop Install rubber seal around door Clean out at bases to door frames and make good to floor finish Clean general dirt etc in floor pointing and make good Repoint to wall tiling where short or insufficient Make good to joint between wall tiling and floor tiling at North wall Make good to joint between wall tiling and floor tiling at South wall Make good to joint between wall tiling and floor tiling at West wall Make good to joint between wall tiling and floor tiling at East wall

Rating Classif. B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

286

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18)

Defect Prepare for and paint ceiling Remove paint on Access Card Reader Remove paint stains on floor covering generally Fill in hole to door head frame Remove paint splashes etc on doors Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is short on both side frames and requires to be replaced Install door stops to Doors Clean paint off Door Frames Door Signage Fire/Smoke Threshold seal is required to door Install closers with selector on doors Remove all remaining parts of the protective covering to doors Install rubber seal to door Intumescent strip to meeting style is not continuous and missing at door lock Realign door intruder alarm contacts and fix head frame contact which is loose Inner leaf of door has too much play when closed and to be adjusted Tidy up wiring to door intruder contact Screw missing form door locking plate Reconnect outer leaf door closer Touch up to damaged paintwork to door frames generally Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Relay floor covering that is distorted and 'bubbled' and prepare floor screed below Replace external angle skirting corner piece to LH side of lift entrance return Replace missing skirting and external angle corner piece to RH side of lift entrance return Replace inner leaf bolt insert to head frame that has been damaged by the door operation Paint sprinkler pipework Tidy up joint at sprinkler head and elbow joints including removing excess joint hemp fibres on sprinkler pipework Replace screws at grille to LH side with white headed screws as elsewhere Seal and make good to conduit at ceiling level (West Wall) Seal and make good to large hole with two (2) conduits at northeast corner at ceiling level

Rating Classif. B B B B B B B A A B B B A A B B A B A B B A B B B B B A B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

287

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43

Location Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18) Service Elevator Vestibule (E7E.18)

Defect Seal and make good to one (1) sprinkler pipe in northeast corner at near ceiling level Refix loose skirting on West Wall Remove remaining parts of protective covering to Lift frames and Lift Doors Clean off paint splashes on Lift Door and frames Provide edge strip to Lift threshold for good finish to floor covering Complete conduit to ceiling smoke detector properly and not a bit of black take and flexible conduit Remove red paint stain on North Wall Remove labels etc from door and make good Relocate door contacts for intruder alarm as they interfere with the closure of the outer door leaf Seal and make good to conduit at ceiling level on North Wall (middle)

Rating Classif. B B B B B B B B A B

Date Rectified

Date Checked

Comments

Is the conduit fire proof ?

4/10/2013

288

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14

Location Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08 Vestibule E7E.08

Defect Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Skirting loose on North Wall to Data Room Make good to floor finishes at door frame bases Reset light switch plate to level position Clean light of dirt and paint stains Touch up chipped paint on door frames Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system

Rating Classif. B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

289

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

Location Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10 Data Room E7E.10

Defect Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Seal North wall to two (2) HVAC pipes and make good all round Paint ceiling and beams Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Replace missing skirting to Column C16 including external angle corner piece Remove formwork between beam and floor slab on East Wall and make good all the length Double floor socket on West wall to be set level Seal South wall for conduit at ceiling level and make good Seal West wall for conduit at ceiling level and make good

Rating Classif. B B B B B B B A B B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

290

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36

Location Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09

Defect Paint ceiling Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Make good to floor level on South Wall near door and refix floor covering Install skirting to South Wall as missing Remove two (2) wall fixing on East Wall near Bus Bars and make good Make good to taped wire joint on electrical cable in southeast corner at ceiling level Skirting is missing on West wall (North) Make good to north wall next floor sinking and refix floor covering complete Infill large hole in southeast of room (fire stopping) Hole at present is a safety issue Skirting missing at North wall Skirting under Electrical Cabinet TUPS-3E on West wall is short and to be replaced Paint walls Make good to door plasterboard ingoings to both door frames and head frame Remove paint to Door Frames Fit rubber seal all round door Intumescent strip is short to hinge frame at base of door and to be replaced Intumescent strip is short to open frame at base and head and to be replaced Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to door Remove remaining protective covering to door Install fire/smoke seal threshold plate to door Screw missing in lock plate to door Door frames are 5mm above finished floor level and to be reset Install door closer Realign intruder alarm door contacts Door sign Make good to wall base at return to East wall in middle and repaint Plasterboard lining including repair to return on East Wall near Bus bars and make good Screw in the twenty (20) missing screws to the five (5) control boxes to RH of SB11-7E Install missing skirting to LH return to door with and including external corner angle piece Make good missing skirting to West Wall near door Make good to floor slab and finish at LH door frame base Replace label to cabinet SBS 11E which is plastic with paper printed sign and install ivorine label Clean paint from two (2) ceiling lights and make good

Rating Classif. B B B B B B B B A B B B B B B A A B B A B B A B B A B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

291

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 37 38 39 40 41

Location Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09 Electrical Closet E7E.09

Defect Reconnect or remove two (2) wires in Box 3 above SBS 11E Reconnect or remove five (5) wires in Box 4 above SBS 11E Reinstall five (5) missing internal panels to Electrical Cabinet TL7-E Reinstall two (2) missing internal panels to Electrical Cabinet TLS7-E Refix upper panel firmly to Electrical Cabinet TCT7-E

Rating Classif. A A A A A

Date Rectified

Date Checked

Comments

4/10/2013

292

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

Location Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07 Janitor Closet E7E.07

Defect Install protection to water pipe with meter Replace door grill screws (Internal) with white headed screws Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Remove all remaining parts of protective covering to door Remove paint on door frames and make good Remove wall paint on trims to suspended ceilings and make good Redo angle edge to vertical corner to LH of door and make good Redo angle edge to vertical corner southeast and make good Make good to joint between wall and floor tiling on South Wall Make good to joint between wall and floor tiling on West Wall Make good ceiling trim at Column B16 Install trough LH tap in wall is loose and requires to be fixed properly Tidy up loose layout of pipework connected with boiler RH tap in wall is loose and requires to be fixed properly Make good untidy suspended ceiling around Column B16 Make good grouting etc to floor gulley Install door stop Make good to floor finish (ceramic tiles) to RH door frame Make good to floor finish (ceramic tiles) to he door frame Replace water stained suspended ceiling tile Make good wall tiling around water pipe on East wall which is unsatisfactory Make good poor finish to top of wall tiling at Column B 16

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments W4A to review and advise

4/10/2013

293

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32

Location Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06 Pantry E7E.06

Defect Wall tiling is generally poor workmanship Make good joint between wall and floor tiling on North Wall Clean off excess grouting throughout Repair boiler leak and install proper safety valve Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Replace door grill screws (Internal) with white headed screws Install rubber seal to door all round Touch up chipped paintwork to door frames Redo angle piece on wall tiling at head of door to Janitor Closet Redo angle piece on wall tiling at external angle to LH of door to Janitor Closet Redo angle piece on wall tiling at external angle to RH of door to Janitor Closet Make good to reveal above wall tiling at door to Vestibule and repaint Reset RH door to upper cabinet on South Wall Make good reveal at top of wall tiling along North wall and repaint Replace damaged one (1) suspended ceiling tile Install plug to sink Seal floor cabinet units between wall and units LH side and make good (East Wall) Seal floor cabinet units between wall and units RH side and make good (East Wall) Make good untidy joint between wall tiling and suspended ceiling on North Wall Install door stop Install edging to PVC floor covering at door entrance Make good to floor finishes at base of LH door frame to Vestibule Make good to floor finishes at base of RH door frame to Vestibule Reset to level position for power socket outlet (double) at floor level on North Wall Are suspended ceiling tiles water resistant (pantry has boiling kettles etc.) Seal floor cabinet units between wall and units LH side and make good (South Wall) Redo angle piece on wall tiling at external angle to head of door to Janitor Closet Redo angle near sink/floor cabinets in Southeast corner and make good Double Sink shown on plans - who authorised change ?

Rating Classif. B B B A B B B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

W4A to review and advise

W4a to advise

4/10/2013

294

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Location Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area

Defect Window No 1 North Repair tighten window handle Window No 2 North Repair tighten window handle Window No 3 North Repair tighten window handle Window No 4 North Repair tighten window handle Window No 5 North Repair tighten window handle Window No 6 North Repair tighten window handle Window No 7 North Repair tighten window handle Window No 8 North Repair defective seal at corner of opening window Window No 9 North Repair defective seal at corner and refix seal to opening window Window No 10 North tighten window handle Window No. 11 North tighten window handle Window No 12 North repair defective angle seal at bottom Window No 13 North refix seal to opening window at base of sash Window No 14 North tighten window handle Window No 3 East Tighten window handle Window No 6 East Repair defective seal at head frame corner and refix seal to opening window Window Fan No 1 East Repair seal at top LH and RH that is under stress and remove excess mastic sealant Window Fan No 1 East tighten up window handle and does not make the full 180o turn Window Fan No 1 East remove all remaining protective covering to window frames etc. Window Fan No 1 South Repair seal at LH and RH to top of opening sash frame Window Fan No 1 South tighten window handle Window Fan No 2 South make good to window frame seal which is damaged and distorted Window Fan No 2 South make good to window seal in distress at RH and LH which is also broken and needs to be replaced Window Fan No 2 South tighten window handle Window Fan No 3 South tighten window handle Window Fan No 3 South make good to window seal in distress at RH and LH which is also broken and needs to be replaced Window Fan No 3 South tighten window handle Window Fan No 3 South Make good to frame seal that is damaged and distorted at bottom both ends Window Fan No 1 South Remove excess mastic and sealant Window Fan No 2 South Remove excess mastic and sealant Window Fan No 3 South Remove excess mastic and sealant Window Fan No 4 South Remove excess mastic and sealant Window Fan No 5 South Remove excess mastic and sealant Window Fan No 6 South Remove excess mastic and sealant

Rating Classif. B B B B B B B B B B B B B B B B B B B A B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

295

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61

Location Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area Level 7 S&T General Area

Defect Window Fan No 4 South Make good to outer seal of opening sash where damaged at both ends at top Window Fan No 4 South Make good to inner opening sash seal where damaged at RH top Window Fan No 5 South Make good to outer seal of opening sash where damaged at both ends at top Window Fan No 5 South Make good to inner opening sash seal where damaged at LH top Window Fan No 6 South Repair damaged sole plate to window frame Window Fan No 6 South Make good to outer seal of opening sash where damaged at RH at top Window Fan No 6 South Make good to inner opening sash seal where damaged at LH top Window Fan No 7 South Make good to outer seal of opening sash where damaged at both RH and LH at top Window Fan No 7 South Make good to inner opening sash seal where damaged at LH and RH at top Remove paint in ceiling edge trim throughout Remove paint on ceiling diffusers on North Faade Remove paint on ceiling diffusers on South Faade Remove paint on ceiling diffusers on East Faade Window No 1 North repair to bottom angle seal in frame Window No 2 North repair to bottom angle seal in frame Window No 5 North repair to bottom angle seal in frame Window No 6 North repair to bottom angle seal in frame Window No 7 North repair bottom frame seal as distorted Window No 13 North repair to bottom angle seal in frame Window No 14 North repair bottom frame seal as distorted Window No 1 East repair bottom frame seal as distorted Window No 2 East repair opening sash seal which is in distress Window No 3 East repair opening sash seal which is in distress Window No 3 East repair to bottom angle seal in frame Window No 4 East repair to bottom angle seal in frame Remove labels on all windows generally Clean general building debris out of runnels to all twenty eight (28) opening sashes

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

296

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39

Location Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01 Level 8 Lift Lobby E8E.01

Defect Tiling to floor is uneven and not aligned and requires to be re-executed Wall Tiling to West Wall is debonding, uneven, not aligned, pointing is distressed and requires to be re-executed Wall Tiling to East (Lift) Wall is uneven, not aligned, pointing is distressed and requires to be re-executed Readjust two (2) small downlighters (North and South) that are not properly aligned and make good Grille Large is missing and to be replaced Seal pointing between lift panelling and ceiling PE 09 Refit stainless steel skirting to Lift PE 09 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 08 that show gaps between the skirting and wall panelling both sides Refit stainless steel skirting to Lift PE 07 that show gaps between the skirting and wall panelling both sides Clean threshold of Lift PE 09 Clean threshold of Lift PE 08 Clean threshold of Lift PE 07 Make good to floor covering at RH of lift door frame PE7 Make good to floor covering at LH of lift door frame PE7 Make good to floor covering at RH of lift door frame PE8 Make good to floor covering at LH of lift door frame PE8 Make good to floor covering at RH of lift door frame PE9 Make good to floor covering at LH of lift door frame PE9 Make good pointing between wall tiling and lift panelling to LH side of PE09 Make good pointing between wall tiling and lift panelling to RH side of PE09 Make good pointing between wall tiling and lift panelling to LH side of PE08 Make good pointing between wall tiling and lift panelling to RH side of PE08 Make good pointing between wall tiling and lift panelling to LH side of PE07 Make good pointing between wall tiling and lift panelling to RH side of PE07 Remove paint on ceiling loudspeaker and make good Clean paint off stainless steel skirting to LH side of lift PE08 Clean stainless steel panel above Lift PE09 Clean stainless steel panel above Lift PE08 Clean stainless steel panel above Lift PE07 Remove paint on three (3) small ceiling downlighters and make good Set HVAC controller on West Wall level and clean off excess of adhesive Remove protective covering to lift door frame head LH of Lift PE09 Remove protective covering to lift door frame head LH of Lift PE08 Remove protective covering to lift door frame head LH of Lift PE07 Make good to corner joint LH side of East Lift Wall Remove protective covering from base of LH frame to Lift PE08 Remove paint on eight (8) sprinkler heads in ceiling Remove paint on smaller grille to North and make good Remove paint on smaller grille to North and make good

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B C C C B C B B B

Date Rectified

Date Checked

Comments

4/10/2013

297

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25

Location Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01) Corridor North C14/18 (E8E.01)

Defect Remove paint on Fire Alarm LH of door to Stair Vestibule E8E.03 Install operator signage to Fire Alarm Button at South Wall near door to Stair Vestibule E8E.03 Make good round Fire Damper Grille panel (Low) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Lower) near Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall near Lift Lobby Tiling to wall at C17 South Wall is uneven, debonding, and not aligned and requires to be re-executed Tiling to wall at C16 South Wall is uneven, debonding and not aligned and requires to be re-executed Install operator signage to Fire Alarm Button at South Wall RH of Service Elevator Vestibule Install operator signage to Door Release Button at South Wall to RH of Service Elevator Vestibule Install break glass to Emergency Door Release Button on South Wall to RH of Service Elevator Vestibule Remove paint from Running Man Sign above door to Stair Vestibule E8E.16 Make good round Fire Damper Grille panel (Upper C 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper C 16) near Lift Lobby Provide proper locking device to Upper (C/16) Fire Damper Grille on South Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on South Wall near to RH side of Service Elevator Lobby Clean paint off grille to Fire Damper panel (Lower) to RH side of Service Lift Lobby Provide proper locking device to Low Fire Damper Grille on South Wall to RH side of Service Lift Lobby Refix five (5) sprinkler heads flush with ceiling Make good poor lining above Fire Damper near Lift Lobby on South Wall Straighten Fire Damper and Frame which is out of alignment on South Wall near lift lobby Realign Running Man Sign above door to Stair Vestibule E8E.16 Remove paint on Fire Alarm LH of door to Stair Vestibule E8E.16 Remove paint on wall tiling at wall return near door to Stair Vestibule E8E.03 Make good joint between wall tiling return and plastered wall near door to Stair Vestibule E8E.03 Make good large gap joint between RJ side of Fire Damper near door to Stair Vestibule E8E.03

Rating Classif. B A B B B B B A A A B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

298

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Location Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01) Corridor East B/C 18(E8E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory Make good round Fire Damper Grille panel C14 East Wall near Fire Hose reel Enclosure (FHE) Clean paint off grille to Fire Damper panel C14 near FHE Provide proper locking device to C14 Fire Damper Grille on East Wall near FHE Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hose reel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork and make good Divider Wall to LH to be sealed full length to back wall and front wall Seal wall at RH side of enclosure for two (2) conduits and make good Seal two holes in ceiling slab within FHE and make good Seal around conduit to RH side of FHE internally near concrete beam Seal LH divider wall for two (2) pipes and make good Tidy up loose blockwork to RH divider wall in FHE Seal LH Divider wall at plasterboard joints and edges throughout and make good Refix door as not fitting properly Remove metal and hardboard shims to LH side of door frame

Rating Classif. B B B B B B B B B B B B A A B A A B B

Date Rectified

Date Checked

Comments

4/10/2013

299

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

Location Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01) Corridor West B/C 14 (E8E.01)

Defect Make good edge trim to Ceiling Access Panel (North) as workmanship is unsatisfactory Make good edge trim to Ceiling Access Panel (South) as workmanship is unsatisfactory Make good round Fire Damper Grille panel B18 East Wall near Fire Hose reel Enclosure (FHE) Clean paint off grille to Fire Damper panel B19 near FHE Provide proper locking device to B18 Fire Damper Grille on East Wall near FHE Glass Key Box to Fire Hose reel box the glass is loose and should re replaced with a Break Glass Key Box as key is missing Bed Glazing to Fire Hose reel box in neoprene gasket to prevent rattle and worse Seal LH and RH openings between Fire Hose reel (FHE) door frame and blockwork Build up blockwork below threshold and seal to door Seal to head of door frame with blockwork and make good Divider Wall to LH to be sealed full length to back wall Remove one (1) electrical cable (used by Ozer during construction) and make good to all holes Seal two holes in ceiling slab within FHE and make good Remove paint on H Sign and make good Make good slab inside FHE as concrete deposits and debris etc.. Seal around two (2) pipes in the floor slab and make good Remove metal shim to LH side frame Finish missing parts of RH divider wall and make good Seal RH divider wall for drain pipe and make good Seal RH divider wall for one (1) large diameter pipe and make good Seal RH divider wall for two (2) small diameter pipes and make good Seal RH divider wall for one (1) conduit and make good

Rating Classif. B B B B B B B B B B B A A B B A B A A A A A

Date Rectified

Date Checked

Comments

4/10/2013

300

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Location Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01) Corridor South B14/18 (E8E.01)

Defect Make good poor tiling above Fire Damper Grille B16 near lift lobby Install operator signage to Fire Alarm Button at North Wall near door to Stair Vestibule E8E.03 Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E8E.16 Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E8E.16 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E8E.16 Install operator signage to Fire Alarm Button at North Wall LH of Stair Vestibule E8E.16 Tiling to wall at C17 North Wall is uneven, debonding and not aligned and requires to be re-executed Tiling to wall at C16 North Wall is uneven, debonding and not aligned and requires to be re-executed Make good to large gap between Low Fire Damper Grille and tiling finish on North Wall LH to Stair Vestibule Door E8E.03 Make good round Fire Damper Grille panel (Upper B 16) on South Wall near Lift Lobby Clean paint off grille to Fire Damper panel (Upper B 16) near Lift Lobby Provide proper locking device to Upper (B 16) Fire Damper Grille on North Wall near Lift Lobby Make good round Fire Damper Grille panel (Low) on North Wall near Stair Vestibule E8E.03 LH Clean paint off grille to Fire Damper panel (Low) near Stair Vestibule E8E.03 North Wall Provide proper locking device to Low Fire Damper Grille on North Wall near Stair Vestibule E8E.03 LH Replace broken 'break' glass to Fire Alarm Button at North Wall near to Stair Vestibule E8E.03 Remove paint on Fire Alarm near door to Stair Vestibule E8E.16 Remove paint on Running Man Sign near door to Stair Vestibule E8E.16 Refix loose fire damper frame and door near Lift Lobby on North Wall Remove paint on Running Man Sign near door to Stair Vestibule E8E.03 Make good to large gap between Fire Damper near door to Stair Vestibule E8E.16 at RH side Make good to large gap between Fire Damper near door to Stair Vestibule E8E.036 at LH side Remove paint to Running Man Sign at Lift Lobby

Rating Classif. B A B B B A B B B B B B B B B A B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

301

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03)

Defect Remove paint to South Door Frames Fit rubber seal all round door South Intumescent strip is short to open frame at base to Door South : replace Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Intumescent strip is short to hinge frame at base to Door South and to be replaced Complete terrazzo tiling up to door frames at Door South Make good to terrazzo skirting in northwest corner South door frames are 4mm above the finished floor level and to be reset Provide operation label to Door Push Button in Romanian and English Remove paint from top edge of skirting on all walls North door frames are 6mm above the finished floor level and to be reset Clean paint etc from two (2) light fittings Clean paint off door frame to Door North Intumescent strip is short to open frame at base to Door North : replace Intumescent strip is short to hinge frame at base to Door North and to be replaced Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Remove remaining protective covering to Door North Screw missing in lock plate to door North Make good to terrazzo skirting to RH side of Door South Remove paint to three (3) sprinkler head in ceiling Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper)

Rating Classif. B B A B B A B B A B A B B B A B B B B B A B B A B B A B B B C B B

Date Rectified

Date Checked

Comments

This button has been disabled

4/10/2013

302

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46

Location Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03) Stair Vestibule Level 8 (E8E.03)

Defect Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internally around Dry Riser Access Panel and make good Door to Dry Riser Fire Hatch is missing and to be replaced Divider Wall in Dry Riser RH side is missing and to be installed Form rounded external corner to terrazzo skirting to LH of door to Egress Stair Form rounded external corner to terrazzo skirting to RH of door to Egress Stair Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required Tile floor is uneven and needs to be levelled, polished and resealed Remove paint etc from top edge of skirting all round

Rating Classif. B B B B A B B A B B A B B

Date Rectified

Date Checked

Comments

Who approved this door hatch ?

4/10/2013

303

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31

Location Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04) Egress Stair Level 8 (E8E.04)

Defect Remove paint etc to top edge of skirting throughout and make good Remove paint from Running Man Sign and make good Remove paint from Access Car Reader and make good Remove paint etc. from ceiling Smoke Detector and make good Tiled Level 8 floor requires to be levelled, polished and sealed and repaired including workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short and to be replaced Intumescent strip to hinge door jamb is short and to be replaced Rubber infill strip to door is missing at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be aligned Door intruder alarm contact wiring to be tidied up Remove all remaining protective covering to door Replace key sets with correct set Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Clean light fitting of paint stains etc. at mid landing Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface Clean two (2) stair flights between Levels 3 and 4 of black paint and mortar stains complete Clean terrazzo tile at mid landing around the two (2) balustrade supports Reset light fitting at mid landing to level position Clean main landing light of paint splashes etc Replace one (1) chipped step Touch up damaged paintwork to door frames

Rating Classif. B B B B B B B A A A B B B B A B B B A B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

304

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16)

Defect Remove paint to South Door Frames and make good Fit rubber seal all round door South Intumescent strip is short to open frame base of Door South : replace Intumescent strip is not complete to base of open frame of Door South Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Intumescent strip is short to hinge frame base of Door South : replace Why are there locks on Stair Egress Doors operated with Card Reader Access and Release Push button ? Terrazzo tile floor is uneven and needs to be levelled, polished and resealed Terrazzo Skirting at both wall returns to doors to have rounded or pencil arrissed corners to Stair Egress Door Provide operation label to Door Push Button in Romanian and English Remove paint etc. from top edge of skirting on all walls Reset double power socket outlet near Door North on East wall to be level Reset double power socket outlet near Door South on East wall to be level Clean paint etc from two (2) light fittings Screw missing from door lock plate on Door North Clean paint off door frame to Door North Touch up chipped paintwork to door frames (north) Intumescent strip is not complete to base of open frame of Door North Intumescent strip is short to hinge frame base of Door North : replace Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Remove all remaining parts of protective covering to door North Install closer to Door North

Rating Classif. B B A A B B A B B A B A A B B A B B B B B B B A A B B A B B A B B

Date Rectified

Date Checked

Comments

W4A to advise

This push button is disabled

4/10/2013

305

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55

Location Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16) Stair Vestibule Level 8 (E8E.16)

Defect Touch up damaged paintwork to frames of Door South Make good to damaged skirting to LH of Stair door Make good skirting broken at door reveal LH of Stair Door Remove all remaining parts of protective covering to door North Remove paint to three (3) sprinkler head in ceiling and make good Make good round Fire Damper Grille panel (Upper) Clean paint off grille to Fire Damper panel (Upper) Provide proper locking device to Upper Fire Damper Grille (Upper) Make good round Fire Damper Grille panel (Lower) Clean paint off grille to Fire Damper panel (Lower) Provide proper locking device to Upper Fire Damper Grille (Lower) Terrazzo skirting poorly executed at East Wall (South) and to be redone Make good to arris RH side of door to stair that has been damaged Make good to finish to LH of Door North Make good to floor finish to RH of Door North Running Man Sign obstructs the efficient operation of the South sprinkler and solution is required Remove paint from Running Man Sign and make good Realign Dry Riser outlet so that ease of connection by Fire Brigade is provided Seal internally around Dry Riser Access Panel and make good Seal holes in ceiling at ends of Running Man Sign Replace broken light bulb in H Sign above Dry Riser Inlet Make good to skirting at northeast corner which is poorly executed

Rating Classif. B B B B C B B B B B B B B B B A B A A B A B

Date Rectified

Date Checked

Comments

4/10/2013

306

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17)

Defect Remove paint etc to top edge of skirting throughout and make good Remove paint from Running Man Sign and make good Remove paint from Access Car Reader and make good Remove paint on Smoke Detector and make good Tiled Level 8 floor requires to be polished and sealed and repaired where poor workmanship near divide wall to stair Fixing screws to frame protrude and are to be refixed Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip to open door jamb is short at base and to be replaced Intumescent strip to hinge door jamb is short at base and head and to be replaced Intumescent strip is loose on head frame and requires to be replaced Rubber infill strip to door is missing at head Install door stop to Door Screw missing at lock plate on door Remove paint on door frames and make good Fire/Smoke seal threshold required to entry door Door signage Door intruder alarm contacts to be aligned Remove all remaining protective covering to door Tidy up contact wires to door intruder alarm Align contacts of door intruder alarm Make good to open stair stringer to upper stair flight Make good to open stair stringer to lower stair flight Make good at stair landing head for handrails where black marks etc are on the tiled floor surface Clean two (2) stair flights between Levels 8 and Roof of black paint and mortar stains complete Mid landing tiling is uneven and 'bossed' and requires to be relaid, polished and resealed Door frame is set 9mm above the finished floor level and requires to be reset properly Clean Landing 8 light of paint stains etc. Reset Landing 8 light properly level Clean paint from mid landing light Remove paint stains on door surfaces Re-execute skirting to LH side of door as poor workmanship with rounded corners Re-execute skirting to RH side of door as poor workmanship with rounded corners

Rating Classif. B B B B B B B A A A A B B B B A B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

Why are these required ?

4/10/2013

307

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42

Location Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17) Egress Stair Level 8 (E8E.17)

Defect Replace missing light switch near door to Door as wires are exposed Running Man Sign to be reset properly level and make good Mid landing wall light to be reset properly level Repair to terrazzo skirting broken at RH side of door and repaint as required Make good wall paint where terrazzo tile to upper flight was repaired Make good wall paint where terrazzo tile to lower flight was repaired Replace five (5) chipped stair treads Make good pointing to stair skirting on East Wall Upper flight Make good pointing to stair skirting on West Wall Lower flight

Rating Classif. A B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

308

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05)

Defect Remove paint to three sprinkler heads Make good floor finish to RH side of Door South Frame Remove paint to South Door Frames Fit rubber seal all round door South Intumnescent strip is not installed to side or head frames Fixing screws to frame protrude and are to be refixed to Door South Cover four (4) protruding screw ends in angle plate to top corner to Door South Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door South Remove remaining protective covering to Door South Install fire/smoke seal threshold plate to Door South Screw missing in lock plate to door South Install door closer to Door South Install edging and recut floor covering to door South threshold which is short Clean paint off door frame to Door North Intumescent strip is installed to side or head frames of Door North Fixing screws to frame protrude and are to be refixed to Door North Cover four (4) protruding screw ends in angle plate to top corner to Door North Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to Door North Fit rubber seal all round door North Fire/Smoke Threshold seal is required to door North Install door closer to Door North Remove all remaining parts of protective covering to door Screw missing in lock plate to door North Replace missing skirting and external angle skirting pieces both end between doors to Pantry and Vestibule E8E.08 Why is floor covering a different colour ? Who authorised the change Replace missing external angle skirting corner piece and skirting to RH of Door to Pantry Why is skirting a different colour ? Who authorised the colour change and type ? Remove timber packer to RH top of door frame to door South Seal and point up RH side of door frame to Door South Remove paint from ceiling loudspeaker Remove paint from two (2) ceiling lights

Rating Classif. B B B B A B B A B B A B A B B A B B A B B A B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

309

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41 42 43

Location Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05) Vestibule Level 8 (E8E.05)

Defect Plastic skirting loose to RH side of door to Handicapped Toilet Door E8E.11 Reset double socket outlet near Door South and make level Reset double socket outlet near Door North and make level Install edging strip between PVC floor covering and tile floor finish to Handicapped Toilet E8E.11 Install edging strip between PVC floor covering and tile floor finish to Toilet E8E.12 Install edging strip between PVC floor covering and tile floor finish to Toilet E8E.13 Install edging strip between PVC floor covering and tile floor finish to Toilet E8E.14 Install edging strip between PVC floor covering and tile floor finish to Handicapped Toilet E8E.15 Refix all skirting as attached with panel pins with adhesive or clip-on system Make good floor finish to LH side of Door South Frame

Rating Classif. B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

310

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26

Location Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15 Handicapped Toilet E8E.15

Defect Make good to floor tiling around floor gulley and regrout Clean excess grouting to tiles generally Replace door grill screws (Internal) with white headed screws Make good to floor finish at LH Base Frame of door Make good to floor finish at RH Base Frame of door Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Clean fan outlet in ceiling of dirt/dust etc. WHB tap is loose and to be reset properly Install plug to sink Install rubber seal around door Install Door stop Toilet does not flush as there is no water supply Clean general dirt etc in floor pointing and make good Repoint to wall tiling where short or insufficient Make good to tiled floor finish to door frame bases LH Make good to tiled floor finish to door frame bases RH Make good to wall tiling at north east corner Make good to joint between wall and floor tiling on West Wall Make good to joint between wall and floor tiling on South Wall Make good to poor tiling at base of West Wall Refix soap dispenser straight No water in sink tap supply

Rating Classif. B B B B B B B B B B B B B B B A B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

311

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Location Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14 Toilet E8E.14

Defect Make good the very poor tile grouting etc around floor gulley Make good to base of RH door frames to floor finish Make good to base of LH door frames to floor finish Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug to sink Make good to joint between wall and floor tiling finish in north wall No water supply so toilet does not flush No water supply to sink

Rating Classif. B B B B B B B B B B B B B B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

312

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

Location Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13 Toilet E8E.13

Defect Make good tile grouting etc around floor gulley Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug Touch up missing parts of grouting to wall tiling generally Make good to defective wall tiling in South West Corner Make good to defective wall tiling in South East Corner Clean out at bases of door frame RH and make good floor finishes complete Clean out at bases of door frame LH and make good floor finishes complete Make good at joint between wall tiling and floor tiling on West wall No water supply so toilet does not flush No water supply to sink

Rating Classif. B B B B B B B B B B B B B B B B B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

313

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Location Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12 Toilet E8E.12

Defect Make good tile grouting etc around floor gulley Install door stop Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Touch up chipped paintwork to door frames Replace door grill screws (Internal) with white headed screws Generally clean off excess grouting on wall tiles Clean grout on floor tiles generally WHB tap is loose and to be reset properly Install plug Clean out at bases of door frame RH and make good floor finishes complete Clean out at bases of door frame LH and make good floor finishes complete Make good at joint between wall tiling and floor tiling on North wall Make good at joint between wall tiling and floor tiling on West wall No water supply so toilet does not flush No water supply to sink

Rating Classif. B B B B B B B B B B B B B B B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

314

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27

Location Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11 Handicapped Toilet E8E.11

Defect Make good to floor tiling around floor gulley and regrout Clean excess grouting to tiles generally Replace door grill screws (Internal) with white headed screws Repoint to LH side of door frame Touch up chipped paintwork to door frames Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Clean fan outlet in ceiling of dirt/dust etc. WHB tap is loose and to be reset properly Install plug Install Door stop Install rubber seal around door Clean out at bases to door frames and make good to floor finish Clean general dirt etc in floor pointing and make good Repoint to wall tiling where short or insufficient Make good to joint between wall tiling and floor tiling at North wall Make good to joint between wall tiling and floor tiling at South wall Make good to joint between wall tiling and floor tiling at West wall No water supply so toilet does not flush No water supply to sink Remove screw to LH head of door frame and make good Remove screw to head of LH door head frame and make good Replace missing gulley grating to floor Fix loudspeaker in ceiling and wire up complete

Rating Classif. B B B B B B B B B B B B B B B B B B B B B A A B B A A

Date Rectified

Date Checked

Comments

4/10/2013

315

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18)

Defect Prepare for and paint ceiling Align Access Card Reader which is not level Remove paint stains on floor covering generally Fill in hole to door head frame Remove paint splashes etc on doors Fixing screws to frame protrude and are to be refixed to Door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Intumescent strip is short on both side frames and requires to be replaced Install door stops to Doors Clean paint off Door Frames Door Signage Fire/Smoke Threshold seal is required to door Install closers with selector on doors Remove all remaining parts of the protective covering to doors Install rubber seal to door Intumescent strip to meeting style is not continuous and missing at door lock Inner leaf of door has too much play when closed and to be adjusted Tidy up wiring to door intruder contact Screw missing form door locking plate Touch up to damaged paintwork to door frames generally Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Relay floor covering that is distorted and 'bubbled' and prepare floor screed below Replace skirting external angle corner piece to LH side of lift entrance return Replace missing skirting and external angle corner piece to RH side of lift entrance return Skirting missing to RH side of entrance to Service Elevator Lobby Skirting missing to LH side of entrance to Service Elevator Lobby Seal and make good to conduit at ceiling level (East Wall) Paint sprinkler pipework Tidy up joint at sprinkler head and elbow joints including removing excess joint hemp fibres on sprinkler pipework Replace screws at grille to LH side with white headed screws as elsewhere Seal and make good to conduit at ceiling level (North Wall) Seal and make good to large hole with two (2) conduits at northeast corner at ceiling level

Rating Classif. B B B B B B B A A B B B A A B B A A B B B B B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

316

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37 38 39 40 41

Location Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18) Service Elevator Vestibule (E8E.18)

Defect Seal and make good to one (1) sprinkler pipe in northeast corner at near ceiling level Refix loose skirting on West Wall Remove remaining parts of protective covering to Lift frames Clean off paint splashes on Lift Door and frames Edging strip required to floor covering at Lift threshold Complete conduit to ceiling smoke detector Remove red paint stain on North Wall Floor covering missing at entrance to Service Elevator Lobby

Rating Classif. B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

317

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14

Location Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08 Vestibule E8E.08

Defect Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Make good to floor finishes at door frame base RH Make good to floor finishes at door frame base LH Remove polythene cover to ceiling light Clean light of dirt and paint stains Touch up chipped paint on door frames Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Two (2) screws missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system

Rating Classif. B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

318

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14

Location Data Room E8E.10 Data Room E8E.10 Data Room E8E.10 Data Room E8E.10 Data Room E8E.10 Data Room E8E.10 Data Room E8E.10 Data Room E8E.10 Data Room E8E.10 Data Room E8E.10 Data Room E8E.10 Data Room E8E.10 Data Room E8E.10 Data Room E8E.10

Defect Remove paint on door frames and make good Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Install rubber seal around door Install door stop Seal North wall to two (2) HVAC pipes and make good all round Refix all plastic skirting as fixed with panel pins and make good with adhesive or clip-on system Paint ceiling and beams Seal conduit at ceiling level on East Wall and make good Seal conduit at ceiling level on South Wall and make good Complete conduit to Smoke Detector (done to two different types of conduit) Remove timber formwork on East Wall between beam and slab and make good

Rating Classif. B B B B B B B A B B A A C B

Date Rectified

Date Checked

Comments

4/10/2013

319

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36

Location Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09 Electrical Closet E8E.09

Defect Paint ceiling Skirting fixed with panel pins and to be re-fixed with adhesive or clip-on system Make good to floor level on South Wall near door and refix floor covering Install skirting to South Wall as missing Door dented at lock plate and to be made good as may inhibit the door closing Skirting loose on northern side of East Wall Skirting is missing on West wall (North) Make good to north wall next floor sinking and refix floor covering complete Infill large hole in southeast of room (fire stopping) Hole at present is a safety issue Skirting missing at North wall Skirting under Electrical Cabinet TUPS-8E on West wall is short and to be replaced Paint walls Make good to door plasterboard ingoings to both door frames and head frame Remove paint to Door Frames Fit rubber seal all round door Intumescent strip is short to hinge frame at base of door and to be replaced Intumescent strip is short to open frame at base and to be replaced Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to door Remove remaining protective covering to door Install fire/smoke seal threshold plate to door Screw missing in lock plate to door Make good to floor covering cut short in front of Electrical Cabinet TL8-E Install door closer Door LH to Electrical Cabinet TL8-E is not fixed to head hinge and will fall out when opened Door sign Make good to wall base at return to East wall in middle and repaint Replace upper panel to RH of Electrical Cabinet TL8-E which is damaged Screw in the twenty eight (28) missing screws to the seven (7) control boxes to RH of SBS-12E Install missing skirting to LH return to door with and including external corner angle piece Realign top panel in Electrical Cabinet TCT-8E Replace label to cabinet SBS 12E which is plastic with paper printed sign and install ivorine label Clean paint from two (2) ceiling lights and make good Reconnect or remove two loose cables in Box No 2 above SBS 12E

Rating Classif. B B B B B B B B A B B B B B B A A B B A B B A B B A A B B A B B A B B A

Date Rectified

Date Checked

Comments

4/10/2013

320

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07 Janitor Closet E8E.07

Defect Install protection to water pipe with meter Replace door grill screws (Internal) with white headed screws Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Remove all remaining parts of protective covering to door Remove paint on door frames and make good Remove wall paint on trims to suspended ceilings and make good Redo angle edge to vertical corner to LH of door and make good Redo angle edge to vertical corner southeast and make good Make good to joint between wall and floor tiling on South Wall Make good to joint between wall and floor tiling on West Wall Make good ceiling trim at Column B16 Install trough LH tap in wall is loose and requires to be fixed properly Tidy up loose layout of pipework connected with boiler RH tap in wall is loose and requires to be fixed properly Make good to VERY untidy suspended ceiling around Column B16 Make good grouting etc to floor gulley Install door stop Make good to floor finish (ceramic tiles) to RH door frame Remove plastic protection from gulley grating Make good to floor finish (ceramic tiles) to LH door frame Make good to wall around conduit and four pipes to Boiler Unit and repaint Make good to hole in wall at corner behind boiler and repaint Paint behind Boiler which is missing Repair ceiling trim at North wall to RH side of door Make good to hole around water pipe on North Wall tiling Make good to hole around water pipe on East Wall tiling Make good to tile external angle at Column B 16 Touch up damaged and chipped paintwork to door frames Remove paint on Smoke Detector and make good Make good floor tiling at base of Column B 16 Make good to top of wall tiling at Column B 16

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments W4A to review and advise

4/10/2013

321

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06

Defect Wall tiling is generally poor workmanship Make good joint between wall and floor tiling on North Wall Clean off excess grouting throughout Repair boiler leak and install proper safety valve Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Screw missing to lock plate on door Remove all remaining parts of protective covering to door Replace door grill screws (Internal) with white headed screws Install rubber seal to door all round Touch up chipped paintwork to door frames Redo angle piece on wall tiling at head of door to Janitor Closet Redo angle piece on wall tiling at external angle to LH of door to Janitor Closet Redo angle piece on wall tiling at external angle to RH of door to Janitor Closet Door frames are set above floor finish by 5mm and require to be reset Redo seal at worktop at North Wall Replace wall tiling angle piece to duct in southeast corner and make good all round Install skirting at base of duct in southeast corner between base cabinets Install plug to sink Seal floor cabinet units between wall and units LH side and make good (East Wall) Seal floor cabinet units between wall and units RH side and make good (East Wall) Make good untidy joint between wall tiling and suspended ceiling on North Wall Install door stop Install edging to PVC floor covering at door entrance Make good to floor finishes at base of LH door frame to Vestibule Make good to floor finishes at base of RH door frame to Vestibule Reset to level position for power socket outlet (double) at floor level on North Wall Are suspended ceiling tiles water resistant (pantry has boiling kettles etc.) Seal floor cabinet units between wall and units LH side and make good (South Wall) Double Sink shown on plans - who authorised change ? Wall cabinets on South wall are not level : reset Clean paint to ceiling trim at bulkhead Water pressure is very poor at tap

Rating Classif. B B B A B B B B B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

W4A to review and advise W4A to advise

4/10/2013

322

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 34 35 36 37

Location Pantry E8E.06 Pantry E8E.06 Pantry E8E.06 Pantry E8E.06

Defect Make good tiling around door top Janitor Closet Make good to ceiling trim along North Wall Make good to wall finish to RH side of wall cabinets South Wall to reveal Make good messy repair to LH door of Wall Cabinets on South Wall

Rating Classif. B B B B

Date Rectified

Date Checked

Comments

4/10/2013

323

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Location Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy

Defect Window No 1 North Repair tighten window handle Window No 2 North Repair tighten window handle Window No 3 North Repair tighten window handle Window No 4 North Repair tighten window handle Window No 5 North Repair tighten window handle Window No 6 North Repair tighten window handle Window No 7 North Repair tighten window handle Window No 8 North Repair tighten window handle Window No 9 North Repair tighten window handle Window No 10 North tighten window handle Window No. 11 North tighten window handle Window No 12 North repair defective angle seal at bottom Window No 13 North tighten window handle Window No 14 North tighten window handle Window No 2 East Tighten window handle Window No 4 East make good to angle piece seal at bottom Window Fan No 1 East tighten window handle Window Fan No 1 East upper seal to window sash is missing Window Fan No 1 East remove excess mastic and sealant. Window Fan No 1 South Repair seal at LH and RH to top of opening sash frame Window Fan No 1 South tighten window handle Window Fan No 2 South make good to two (2) holes in cill frame and replace Window Fan No 2 South make good to window seal in distress at LH which is also broken and needs to be replaced Window Fan No 2 South tighten window handle Window Fan No 3 South tighten window handle Window Fan No 3 South make good to window seal in distress at LH which is also broken and needs to be replaced Window Fan No 3 South tighten window handle Window Fan No 3 South Make good to frame seal that is loose and distorted at bottom both ends Window Fan No 1 South Remove excess mastic and sealant Window Fan No 2 South Remove excess mastic and sealant Window Fan No 3 South Remove excess mastic and sealant Window Fan No 4 South Remove excess mastic and sealant Window Fan No 5 South Remove excess mastic and sealant Window Fan No 6 South Remove excess mastic and sealant

Rating Classif. B B B B B B B B B B B B B B B B B B B A B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

324

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67

Location Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy

Defect Window Fan No 4 South Make good to damaged cill frame and replace Window Fan No 4 South Make good to inner opening sash seal where damaged at RH top Window Fan No 5 South Make good to outer seal of opening sash seal upper LH and RH where damaged at top Window Fan No 5 South tighten window handle Window Fan No 6 South Repair make good to inner window sash seal damaged at bottom RH side Window Fan No 6 South tighten window handle Window Fan No 6 South adjust as difficult to close opening sash Window Fan No 7 South Make good to outer seal of opening sash where damaged at LH at top Window Fan No 7 South tighten window handle Remove paint in ceiling edge trim throughout Remove paint on ceiling diffusers on North Faade Remove paint on ceiling diffusers on South Faade Remove paint on ceiling diffusers on East Faade Window No 3 North repair to bottom angle seal in frame Window No 6 North repair to bottom angle seal in frame and distressed bottom seal Window No 7 North repair to bottom angle seal in frame Window No 5 East repair bottom angle seal and bottom seal in distress Make good pointing to Window at Boiler flue Replace broken glass at window return (South) Window Fan No 2 South adjust window as difficult to close Window Fan No 7 South remove excess mastic and sealant Replace suspended ceiling U bar where broken mid-span AB 14/15 Replace dirty suspended ceiling tile in AB 14/15 Remove labels on all windows generally Clean general building debris out of runnels to all twenty eight (28) opening sashes Window No 1 North repair broken restrainer Window No 2 North repair broken restrainer Window No 12 North repair broken restrainer Tidy up ceiling trims generally Replace water stained suspended ceiling tile AB 15/16 Replace damaged ceiling suspension system at AB 19/20 Replace two (2) damaged suspended ceiling tiles in AB 19/20 Replace five (5) suspended ceiling tiles in BC 18/20 that are dirty or damaged

Rating Classif. B B B B B B B B B B B B B B B B B B A B B B B B B A A A B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

325

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92

Location Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy Level 8 Japanese Embassy

Defect Make good to suspended ceiling at Area B/C 19 where the ceiling dips and requires adjustment Replace two (2) dirty suspended ceiling tiles in CD 17/18 Replace two (2) dirty suspended ceiling tiles in CD 15/16 Replace damage U bar of the suspended ceiling system in CD 15/16 Replace two (2) dirty suspended ceiling tiles in CD 13/14 Replace damage U bar of the suspended ceiling system in CD 13/14 Remove paint on two HVAC controller on Column A13 Remove paint on two HVAC controller on Column D13 Remove paint on three HVAC controller on Column A14 Remove paint on three HVAC controller on Column D14 Remove paint on three HVAC controller on Column A15 Remove paint on three HVAC controller on Column D15 Remove paint on three HVAC controller on Column A16 Remove paint on three HVAC controller on Column D16 Remove paint on three HVAC controller on Column A17 Remove paint on three HVAC controller on Column D17 Remove paint on three HVAC controller on Column A18 Remove paint on three HVAC controller on Column D18 Remove paint on three HVAC controller on Column A19 Remove paint on three HVAC controller on Column D19 Remove paint on three HVAC controller on Column A20 Remove paint on three HVAC controller on Column D20 Remove paint stains on ceiling diffusers on North Elevation Remove paint stains on ceiling diffusers on South Elevation Remove paint stains on ceiling diffusers on East Elevation

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

326

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

Location East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation East Triangle : East Elevation

Defect Install sixteen (16) black bolt caps to elevation of corrugated sheeting Make good poor joint near Car Park Entry on south east between short width of sheeting near corner Edge of corrugated sheeting is not fully masked by angle at southeast corner near Car Park entry Remove cement stains to base of corrugated sheeting Remove coil of wire on corrugated sheeting Seal East Wall where it joins soffit of First Floor level which has not been properly addressed Corrugated sheeting is badly cut at First Floor Level next to glazing return and needs to be sealed and made good Angle mask is required at First floor level where corrugated sheeting meets the glazing panels Refit loose rubber seal to glazed are on LH side of East Elevation Make good to several uneven panel joins to corrugated sheeting on East Elevation at higher levels Replace two (2) damaged soffit panels at end of East Building on East Elevation near angle Seal corrugated sheeting where it is in distress near glazed area Make good the window seal in middle of glazed area that is debonding Make good mastic seal to glazed panels as required Seal to glazing next to corrugated sheeting on return is in distress and to be made good Mastic at RH side at angle with glazed return requires to be made good Seal joint of underside steel plating to corrugated sheeting above black rendered wall to car park ramp Seal open joint at bottom RH of East Elevation which also requires to be aligned Make good to badly cut sheets on RH side of East Elevation at base Make good to badly cut sheets on RH side of East Elevation above base Make good to badly cut sheets on RH side of East Elevation at upper level Angle piece (vertical) on RH side of East Elevation is not straight and to be refixed Refix seal in middle of glazed area East Elevation LH side Refit top sheet as badly fitted to RH side of East Elevation at Level 2 Terrace Install two (2) black bolt caps to elevation of corrugated sheeting at Level 2 Terrace Make good gap and seal between corrugated sheeting and parapet wall Level 2 Terrace Make good and seal gap at top of parapet rail at Level 2 Terrace Make good angle joint with corrugated cladding to RH side at upper part of Level 2 Terrace

Rating Classif. B B B B B A B A B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

327

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12

Location East Triangle : West Elevation East Triangle : West Elevation East Triangle : West Elevation East Triangle : West Elevation East Triangle : West Elevation East Triangle : West Elevation East Triangle : West Elevation East Triangle : West Elevation East Triangle : West Elevation East Triangle : West Elevation East Triangle : West Elevation East Triangle : West Elevation

Defect Provide threshold plate seal to single leaf entry door Replace thirty two (32) screws fixing corrugated sheeting with standard fixing bolts and black cover caps Install twenty (20) black bolt caps to elevation of corrugated sheeting Make good seal between base profile and adjoining paviors Make good seal between corrugated sheeting and wall glazing to LH side of Glass Wall Remove labels on glass panels Fit missing seal to glazed panel above door Refix uneven corrugated panels above glazed wall with especial reference to joints Form base skirting to area of cladding at Level 2 Terrace Make good to joint between main sheeting and short cut panels on RH side at Level 2 Terrace Reset capping to top of wall on West Elevation as uneven Seal hole at bottom LH near parapet at Level 2 Terrace

Rating Classif. B B B B B B A B B B B B

Date Rectified

Date Checked

Comments Door LOCKED

4/10/2013

328

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Location North Elevation to East Bridge North Elevation to East Bridge

Defect Remove labels and make good Remove excess mastic on glass

Rating Classif.

Date Rectified B B

Date Checked

Comments Level 1 Mall Corridor Level 1 Mall Corridor

4/10/2013

329

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Location East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building East Elevation Main Building

Defect Capping to white corrugated wall is uneven and distorted and to make level and proper at Level 2 terrace Install eighty one (81) white bolt caps to elevation of corrugated sheeting First Floor level Remove red vertical 'builder' lines three (3) no on white corrugated sheeting and make good at First Floor level Provide joint seal to corrugated sheeting to RH side at first floor level Repair distorted and bulging white corrugated sheeting at First Floor level to South side of elevation and make good Replace angle seal at lower part of white corrugated sheeting at northern end at junction with Ground Floor soffit Review siting of two (2) CCTV cameras which seem to cover the same area Five downlighters have been placed out of line in soffit ceiling to Ground level and to be reset properly Soffit ceiling lining has been poorly cut round both boiler flues and requires to be recut or a trim made and fitted Double door requires a threshold plate and seal Remove labels to shopfront glazing Door intruder alarm white cable is set in black mastic window joint Remove wire fastening in window joint Ground Floor shopfront in second glazed panel from boiler flues RH Remove wire fastening in window joint Ground Floor shopfront in third glazed panel from boiler flues RH Seal glazed panel at base to LH side of double entry door Make good to poor joint at Ground Floor level to black corrugated sheeting at Northern end where it meets soffit lining Install twelve (12) black bolt caps to elevation of corrugated sheeting Make good to poor joint at Ground Floor level to black corrugated sheeting at Northern end where it meets paviors at base

Rating Classif. B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

small length untidy W4A to review and advise

Why does door have intruder alarm

Ref.

Location

Defect

Rating

Date

Date

Comments

4/10/2013

330

AMERICA HOUSE

SNAGGING LIST (EAST)

No. 1 2 3 4 5 6 7 8 9 10 South Elevation Grd to Level 2 South Elevation Grd to Level 2 South Elevation Grd to Level 2 South Elevation Grd to Level 2 South Elevation Grd to Level 2 South Elevation Grd to Level 2 South Elevation Grd to Level 2 South Elevation Grd to Level 2 South Elevation Grd to Level 2 South Elevation Grd to Level 2 Realign irregular gaps between soffit panels under First Floor mall corridor to walkway at South Elevation Remove builder's marks for downlighters to nine (9) mostly at eastern end CCTV camera set at Main Office Entrance is obstructed by wing fang and should be positioned for clear view Clean soffit lining to walkway (GF) as area BA 12/13 as very dirty and make good Clean soffit panel at southern edge between A 12/23 and make good Remove several pieces of protective covering and masking tape in gaps to soffit panels along GF walkway A12/23 Remove buckled soffit panel in Area A22/.23 and replace at GF walkway Repair beige coloured reveal at edge of ceiling soffit to GF walkway between A13/14 that should match the rest and be black Make good to ceiling trim around Column A 17 which is in distress Remove paint splashes to ceiling trim at columns A13 to 19

Classif. B B A B B B B B B B

Rectified

Checked

W4A to review and advise

Affects two panel bays

Ref. No.

Location

Defect

Rating Classif.

Date Rectified

Date Checked

Comments

4/10/2013

331

AMERICA HOUSE

SNAGGING LIST (EAST)

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29

Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14 Roof Landing B/C 14

Terrazzo tiling to floor is uneven and discoloured and requires to be replaced or evened, polished and resealed Remove paint etc to top of terrazzo skirting throughout Make good to terrazzo skirting damage at stairhead near door Make good to joint with wall head just above landing floor level at northeast corner of landing slab Make good to lining to smoke ventilation roof opening on South side Clean wall mounted light of paint and dirt etc. and make good Reset wall mounted light so that it is level Make good terrazzo skirting to door at LH side and rounded arris at edge Make good terrazzo skirting to door at RH side and rounded arris at edge Door frames are set 6mm above floor and are to be set level Remove paint to Door Frames Fit rubber seal all round door Intumescent strip is short to hinge frame at base of door and to be replaced Intumescent strip is short to open frame at base of door and to be replaced Fixing screws to frame protrude and are to be refixed to door Cover four (4) protruding screw ends in angle plate to top corner to door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to door Remove remaining protective covering to door Install fire/smoke seal threshold plate to door Screw missing in lock plate to door Install door closer Replace missing lock and handles Door signage Make good pointing to LH side of door to plaster and repaint Make good pointing to RH side of door to plaster and repaint Light switch plate is missing and bare wires are unprotected and exposed Remove paint splashes etc on door surfaces Running Man Sign to be reset level

B B B B B B B B B B B B A A B B A B B A B A A B B B A B C

Ref. No. 1

Location Roof Corridor B/C 14/15

Defect Terrazzo tiling to floor is uneven and discoloured and requires to be replaced or evened, polished and resealed

Rating Classif. B

Date Rectified

Date Checked

Comments

4/10/2013

332

AMERICA HOUSE

SNAGGING LIST (EAST)

2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15

Remove paint etc to top of terrazzo skirting throughout Terrazzo floor in lieu of cement screed in front of Electrical Cabinets Install Terrazzo skirting to three side of ingoing to Electrical cabinets Terrazzo skirting is missing to the RH of Electrical Cabinets on main wall Terrazzo skirting is missing to the LH of Electrical Cabinets on main wall Terrazzo skirting is uneven to northern end of East wall and to be made good Terrazzo skirting is broken to RH side of Egress Stair Door and to be repaired Terrazzo skirting to West Wall is poor workmanship and to be made good Terrazzo skirting is broken to RH side of West Wall towards Door North and to be repaired Terrazzo skirting is of poor workmanship at North Wall and to be made good Terrazzo skirting is damaged on West Wall and to be made good Redo RH return of terrazzo skirting to Egress Stair door and provide rounded arris on angle Redo LH return of terrazzo skirting to Egress Stair door and provide rounded arris on angle Install operator sign on Fire Alarm Bell Point to LH side of door Replace broken 'break' glass to Fire Alarm Bell Point Install operator sign on Door Maglock release to RH side of door Install Door Emergency release Break Glass to LH side of door Remove paint from Fire Alarm Bell to LH side of Egress Stair Door Repair damaged edge arris to LH side of door to Egress Stair and repaint Realign conduit to light switch to LH side of door to Egress Stair which is not straight Consider repositioning light switch so as not to be so near Fire Alarm Bell Point Clean paint splashes etc from two (2) light fittings Seal North Wall to Rah side at junction with East Wall Provide Handrail to North Door Stair Mage good joint between door frame and wall at LH side of door vertically Make good to wall below threshold of Door North and repaint Seal Wall to North Wall at junction with West Wall just below the threshold of Door North Make good cable to North door contact intruder alarm which is very untidy Make good cable to South door contact intruder alarm which is very untidy Remove steel reinforcement rod to RH side of East Wall and make good Repoint to Electrical cabinets which is crazed and cracked all round Seal wall to LH side of Electrical cabinets and repaint

B C C B B B B B B B B B B A A A A B B C C B B A B B B B B B B B

Ref. No. 34 35

Location Roof Corridor B/C 14/15 Roof Corridor B/C 14/15

Defect Seal wall to RH side of Electrical Cabinets and make good all round Remove polystyrene packing to Door South and refix with non-combustible material

Rating Classif. B A

Date Rectified

Date Checked

Comments

No polystyrene to a FIRE DOOR

4/10/2013

333

AMERICA HOUSE

SNAGGING LIST (EAST)

36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15

Provide handrail for Door South Stair Make good to wall below Door South threshold and repaint Make good damaged wall to RH side of South Wall blow door opening Make good patch of damaged wall to LH side at low level Seal for one (1) conduit near ceiling on South Wall and make good Seal for six (6) conduits near ceiling on East Wall and make good Seal for three (3) conduits near ceiling on East Wall and make good Seal hole near ceiling on West Wall and make good Seal for one (1) conduit near ceiling on North Wall and make good Seal hole to LH side of West Wall for flexible conduit (intruder alarm) and make good Seal hole to RH side of West Wall for flexible conduit (intruder alarm) and make good Door Frame to South Door is set at an angle in the opening and to be reset Remove paint to South Door Frames Fit rubber seal all round South door Intumescent strip is short to hinge frame at base of South door and to be replaced Intumescent strip is short to open frame at base of South door and to be replaced Fixing screws to frame protrude and are to be refixed to South door Cover four (4) protruding screw ends in angle plate to top corner to South door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to South door Remove remaining protective covering to South door Install fire/smoke seal threshold plate to South door Screw missing in lock plate to South door Install door closer to South Door Remove paint splashes to South door surfaces and make good Door signage to South Door Replace damaged prong receiver on hinge frame of door South Install permanent handles to door South Install permanent lockset to Door South Remove paint to North Door Frames Fit rubber seal all round North door

A B B B B B B B B B B C B B A A B B A B B A B A B B B B B B B

Ref. No. 67 68 69

Location Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15

Defect Intumescent strip is short to hinge frame at base of North door and to be replaced Intumescent strip is short to open frame at base of North door and to be replaced Fixing screws to frame protrude and are to be refixed to North door

Rating Classif. A A B

Date Rectified

Date Checked

Comments

4/10/2013

334

AMERICA HOUSE

SNAGGING LIST (EAST)

70 71 72 73 74 75 76 77 78 79 80

Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15 Roof Corridor B/C 14/15

Cover four (4) protruding screw ends in angle plate to top corner to North door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to North door Remove remaining protective covering to North door Install fire/smoke seal threshold plate to North door Screw missing in lock plate to North door Install door closer to North Door Remove paint splashes to North door surfaces and make good Door signage to North Door Install permanent handles to door North Install permanent lockset to Door South

B A B B A B A B B B B

Ref. No. 1 2 3 4

Location North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20

Defect Make good corrugated sheeting to two (2) fire hosereel connections Remove cement mortar to base of elevation D16/20 and make good Remove timber packing piece below base profile Seal between base profile and concrete paving base D16/20

Rating Classif. B B B B

Date Rectified

Date Checked

Comments

4/10/2013

335

AMERICA HOUSE

SNAGGING LIST (EAST)

5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20

Inverted L Vent No 1 RH make good to loose vertical ingoing lining and refix Inverted L shaped Vent No 1 LH make good to loose vertical ingoing lining and refix Inverted L shaped Vent No 1 LH make good to poor mitred joint at top. Inverted L shaped Vent No 1 remove mortar cement drippings in ventilator Realign ceiling soffit panel near rectangular Vent No 2 D 20 Inverted L shaped Vent No 3 RH make good to loose vertical ingoing lining and refix Inverted L shaped Vent No 3 LH make good to loose vertical ingoing lining and refix Inverted L shaped Vent No 32 LH make good to poor mitred joint at top. Inverted L shaped Vent No 3 remove mortar cement drippings in ventilator Elongated rectangular Vent No 4 LH make good to loose vertical ingoing lining and refix Elongated rectangular Vent No 4 RH make good to loose vertical ingoing lining and refix Elongated rectangular Vent No 4 replace bent louvre towards the top Redo lining ingoing at cill to Elongated rectangular Vent No 4 as uneven and poor workmanship Install eighty six (86) black bolt caps to elevation of corrugated sheeting Refix loose ingoing lining to Fire Escape Door LH side D18/19 Refix loose ingoing lining to Fire Escape Door RH side D18/19 Make good to floor base at Fire Escape Door at D 18/19 Remove protective covering from door frames etc to Fire Escape Door D 18/19 Remove all mortar and paint splashes from door frames to Fire Escape Door D 18/19 Door seal loose at door base of Fire Escape Door and refix Make good to three (3) holes in hinge frame of Fire Escape Door D 18/19 Remove all mortar and paint splashes from door to Fire Escape Door D 18/19 Provide door threshold to Fire Escape Door D18/19 Make good sinking in floor to LH side of door frame to Fire Escape Door D18/19 Make good sinking in floor to RH side of door frame to Fire Escape Door D18/19 Make good to LH side of Door Plinth 1 joint between corrugated cladding and concrete and repaint to Transformer Room Make good to RH side of Door Plinth 1 joint between corrugated cladding and concrete and repaint to Transformer Room Make good to LH side of Door Plinth 2 joint between corrugated cladding and concrete and repaint to Transformer Room Make good to RH side of Door Plinth 2 joint between corrugated cladding and concrete and repaint to Transformer Room

B B B B B B B B B B B B B B B B B B B B B B B B B B B B B

Ref. No. 34 35 36 37 38

Location North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20

Defect Make good to LH side of Door Plinth 3 joint between corrugated cladding and concrete and repaint to Transformer Room Make good to RH side of Door Plinth 3 joint between corrugated cladding and concrete and repaint to Transformer Room Make good crack to plinth step to Transformer Room Door No 2 and repaint Make good crack to plinth step to Transformer Room Door No 3 and repaint Remove remaining parts of protective covering to doors and frames to Transformer Door No 1

Rating Classif. B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

336

AMERICA HOUSE

SNAGGING LIST (EAST)

39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20

Remove remaining parts of protective covering to doors and frames to Transformer Door No 2 Remove remaining parts of protective covering to doors and frames to Transformer Door No 3 Make good open mitred joint to top LH of Fire Escape Door side and head frame D 18/19 Refix loose ingoing lining to Transformer Door No 1 LH side and make good all round Refix loose ingoing lining to Transformer Door No 1 RH side and make good all round Refix loose ingoing lining to Transformer Door No 2 LH side and make good all round Refix loose ingoing lining to Transformer Door No 2 RH side and make good all round Refix loose ingoing lining to Transformer Door No 3 LH side and make good all round Refix loose ingoing lining to Transformer Door No 3 RH side and make good all round Remove paint etc. from frames to Transformer Room Door No 1 and make good Remove paint etc. from frames to Transformer Room Door No 2 and make good Remove paint etc. from frames to Transformer Room Door No 3 and make good Remove paint etc from door surfaces of Transformer Door No 1 and make good Remove paint etc from door surfaces of Transformer Door No 2 and make good Remove paint etc from door surfaces of Transformer Door No 3 and make good Install seal between lining and door frame to Transformer Door No 1 on RH side which is missing Reset angle piece at top between Transformer Doors 1 and 2 and make good Reset angle piece at top between Transformer Doors 2 and 3 and make good Reset angle piece at top between Transformer Door 3 and Vent Panel No 5 and make good Seal base profile end which is open to LH of Transformer Door No 1 at ground level and make good Seal base profile end which is open to RH of Transformer Door No 1 at ground level and make good Seal base profile end which is open to LH of Transformer Door No 2 at ground level and make good Seal base profile end which is open to RH of Transformer Door No 2 at ground level and make good Corrugated sheet lining between Transformer Doors 1 and 2 is short to base profile and requires to be redone Seal base profile end which is open to LH of Generator Door No 1 at ground level and make good Seal base profile end which is open to RH of Generator Door No 1 at ground level and make good Seal base profile end which is open to LH of Generator Door No 2 at ground level and make good Seal base profile end which is open to RH of Generator Door No 2 at ground level and make good

B B B B B B B B B B B B B B B A B B B B B B B B B B B B

Ref. No. 67 68 69 70 71 72

Location North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20

Defect Seal base profile end which is open to LH of Generator Door No 3 at ground level and make good Seal base profile end which is open to RH of Generator Door No 3 at ground level and make good Seal base profile end which is open to LH of Main Switch Room Door No 1 at ground level and make good Seal base profile end which is open to RH of Main Switch Room Door No 1 at ground level and make good Repair bottom LH mitred joint to ingoing lining to rectangular Vent. No 5 at ceiling level and make good Remove all protective covering to Vent No 5

Rating Classif. B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

337

AMERICA HOUSE

SNAGGING LIST (EAST)

73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99

North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20

Refix loose ingoing lining to Main Switch Room Door No 1 LH side and make good all round Refix loose ingoing lining to Main Switch Room Door No 1 RH side and make good all round Refix loose ingoing lining to Generator Room Door No 1 RH side and make good all round Refix loose ingoing lining to Generator Room Door No 1 LH side and make good all round Refix loose ingoing lining to Generator Room Door No 2 RH side and make good all round Refix loose ingoing lining to Generator Room Door No 2 LH side and make good all round Refix loose ingoing lining to Generator Room Door No 3 RH side and make good all round Refix loose ingoing lining to Generator Room Door No 3 LH side and make good all round Remove protective covering from frames to Generator Room Door No 1 and make good Remove protective covering from frames to Generator Room Door No 2 and make good Remove protective covering from frames to Generator Room Door No 3 and make good Remove paint and mortar splashes from door frames to Generator Room Door No 1 and make good Remove paint and mortar splashes from door frames to Generator Room Door No 2 and make good Remove paint and mortar splashes from door frames to Generator Room Door No 3 and make good Remove paint and mortar splashes to door surfaces to Generator Room Door No 1 and make good Remove paint and mortar splashes to door surfaces to Generator Room Door No 2 and make good Remove paint and mortar splashes to door surfaces to Generator Room Door No 3 and make good Remove paint and mortar splashes from door frames to Main Switch Room Door No 1 and make good Remove paint and mortar splashes to door surfaces to Main Switch Room Door No 1 and make good Make good dent at end of Generator Exhaust No 1 Make good dent at end of Generator Exhaust No 2 Seal and make good poorly cut corrugated sheeting around exhaust duct No 1 to generators or install circular trim Seal and make good poorly cut corrugated sheeting around exhaust duct No 2 to generators or install circular trim Make good to frame base to Main Switch Room Door No 1 at LH side Change fuel pipe filling points to coupling type to Generator No 1 Change fuel pipe filling points to coupling type to Generator No 2 Make good to corrugated wall covering around fuel filling point to Generator No 1

B B B B B B B B B B B B B B B B B B B B B B B B A A B

Ref. No. 100 101 102 103 104 105 106

Location North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20

Defect Make good to corrugated wall covering around fuel filling point to Generator No 1 Make good corrugated sheeting where patch inserted between Main Switch Room Door No 1 and Generator Room Door No 1 Make good corrugated sheeting where patch inserted between Generator Room Door No 3 and end of wall to Docking Bay Reset angle piece at top between Main Switch Room Door No 1 and Generator Room Door No 1 and make good Reset angle piece at top between Generator Room Doors No 1 and 2 and make good Reset angle piece at top between Generator Room Doors No 3 and Docking Bay return and make good Angle piece at top near Docking Bay is incomplete and to be replaced

Rating Classif. B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

338

AMERICA HOUSE

SNAGGING LIST (EAST)

107 108 109

North Elevation Grd. D 16/20 North Elevation Grd. D 16/20 North Elevation Grd. D 16/20

Install vertical angle piece to corrugated sheeting wall at return to Docking Bay and make good all round Corrugated sheeting at Docking Bay return is short at base and to be replaced Redo base profile at return to Docking Bay and make good

B B B

Ref. No. 1 2 3 4

Location East Triangle : South Elevation East Triangle : South Elevation East Triangle : South Elevation East Triangle : South Elevation

Defect Remove mortar and paint stains on Corrugated wall sheeting at Level 2 Terrace and make good Redo corrugated sheeting to LH side where joint is untidy Level 2 Terrace Finish skirting to base and joint to paved terrace and make good all round Reset capping pieces which are uneven and untidy

Rating Classif. B B B B

Date Rectified

Date Checked

Comments

4/10/2013

339

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9

Location North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16

Defect Install nine (9) black bolt caps to elevation of corrugated sheeting on RH return to Docking Bay Remove protective covering to profiles between side door and roller shutter door in Docking Bay and make good Corrugated sheeting to RH return of Docking Bay is short and to be replaced Make good to sagging soffit panels above Roller Shutter door area and realign Reset angle at ceiling level above Security Room window and grille LH side D 15 Make good to bottom LH mitred joint to grille above Security Room Make good to badly cut and fitted corrugated wall sheeting above Security Room Window Refix loose corrugated wall sheeting to RH side of Grille above Security Room and make good Refix loose ingoing linings LH to Security Room Window

Rating Classif. B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

340

AMERICA HOUSE

SNAGGING LIST (EAST)

10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16 North Elevation G to 2 D 13/16

Refix loose ingoing linings RH to Security Room Window Make good to bottom LH mitred joint to Security Room window Make good to corrugated sheeting under Security Room window where short to base profile and replace Supply and fit missing bolt fixing at base of corrugated sheeting under Security Room window Align base profile near Security Room window and to the right side of it and make good Corrugated sheeting has been cut short to base profile under Security Room window and to be replaced Remove all paint and mortar splashes on corrugated wall sheeting Refix RH ingoing linings to Vertical rectangular Vent No 6 and make good Refix LH ingoing linings to Vertical rectangular Vent No 6 and make good Refix RH ingoing linings to Vertical rectangular Vent No 7 and make good Refix LH ingoing linings to Vertical rectangular Vent No 7 and make good Refix RH ingoing linings to Vertical rectangular Vent No 8 and make good Refix LH ingoing linings to Vertical rectangular Vent No 8 and make good Make good at bottom LH mitred joint to ingoing linings to Vent Rectangular No 6 Make good at bottom RH mitred joint to ingoing linings to Vent Rectangular No 7 Make good at bottom LH mitred joint to ingoing linings to Vent Rectangular No 8 Install seventy nine (79) black bolt caps to elevation of corrugated sheeting on North Elevation Grd to 2nd D 13/16 Remove mortar to louvres and frame of rectangular ventilator No 6 and make good Remove mortar to louvres and frame of rectangular ventilator No 7 and make good Remove mortar to louvres and frame of rectangular ventilator No 8 and make good Refit Ventilator No 7 as badly fitted complete Replace forty (40) silver coloured headed screws to ventilation panel at First Floor ceiling level to match black frame Replace damaged louvre in rectangular Vent No 9 Corrugated sheeting is badly cut to expansion joint and is damaged in parts and to be made good and angle inserted

B B B B B B B B B B B B B B B B B B B B B B B B

Ref. No. 1 2 3 4 5 6 7 8 9 10

Location North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18

Defect Install two (2) white bolt caps to elevation of corrugated sheeting First Floor level at return D 18 Repair Damage to Panel 7 on RH side to base angle and base corrugated sheeting Install missing bolt fixing to base sheet in Panel 7 Refix bottom edge of top corrugated panel in Panel 7 Refix warped and irregular capping to Panel 7 at Level 2 Terrace Make good to poor joint to angle, capping etc at top RH side of Corrugated Wall Sheeting on Panel 7 Refix warped and irregular capping to Panel 6 at Level 2 Terrace Refix joint between top corrugated sheet and sheet 2 to RH side of Panel 6 Refix joint between corrugated sheet 2 and sheet 3 to RH side of Panel 6 Refix joint between corrugated sheet 3 and sheet 4 to RH side of Panel 6

Rating Classif. B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

341

AMERICA HOUSE

SNAGGING LIST (EAST)

11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32

North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18 North Elevation First Floor D20/18

Refix joint between corrugated sheet 4 and sheet 5 to RH side of Panel 6 Refix joint between corrugated sheet 5 and bottom sheet RH side of Panel 6 Make good to distorted Sheet 2 in Panel 6 at LH side that has lifted Make good to poor fitting of bottom sheet in Panel 6 to base profile angle Remove wire cable coming out of building above ventilator grille in panel 4 and make good to sheeting etc. Refix joint between top corrugated sheet and sheet 2 to LH side of Panel 5 Refix joint between corrugated sheet 2 and sheet 3 to full width side of Panel 5 Refix joint between corrugated sheet 3 and sheet 4 to RH side of Panel 6 Refix joint between corrugated sheet 4 and bottom sheet RH side of Panel 6 Refix joint between top corrugated sheet and sheet 2 at LH side of Panel 4 Refix joint between corrugated sheet 2 and sheet 3 at LH side of Panel 4 Refix joint between corrugated sheet 3 and sheet 4 at LH side of Panel 4 Refix joint between corrugated sheet 4 and sheet 5 at LH side of Panel 4 Make good to distorted Sheet 5 in Panel 2 at RH side that has lifted Make good to distorted Sheet 5 in Panel 1 at RH side that has lifted Refix joint between top corrugated sheet and sheet 2 to RH side of Panel 2 Refix joint between corrugated sheet 2 and sheet 3 to RH side of Panel 2 Refix joint between corrugated sheet 3 and sheet 4 to RH side of Panel 2 Refix joint between corrugated sheet 4 and sheet 5 to RH side of Panel 2 Install seventy nine (79) white bolt caps to elevation of corrugated sheeting First Floor level Refix warped and irregular capping to return at D18 at Level 2 Terrace Make good to angle between return and main elevation at D 18 where angle is short at the base

B B B B B B B B B B B B B B B B B B B B B B

Ref. No. 1 2 3 4 5 6

Location Soffit Grd Flr D16/20 Soffit Grd Flr D16/20 Soffit Grd Flr D16/20 Soffit Grd Flr D16/20 Soffit Grd Flr D16/20 Soffit Grd Flr D16/20

Defect Remove pencil marks on soffit lining to eleven (11) light fittings and make good Clean soffit panel with dirt and paint splashes at eastern end Clean Grille No 1 of adhesive etc Clean Grille No 2 of adhesive etc Relevel soffit lining as there are several variations and it is like a drawing of a wavy sea Reset several panels that dip below the edge of the base profile to the white corrugated sheeting wall above

Rating Classif. B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

342

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12

Location South Elevation 2 to 8 South Elevation 2 to 8 South Elevation 2 to 8 South Elevation 2 to 8 South Elevation 2 to 8 South Elevation 2 to 8 South Elevation 2 to 8 South Elevation 2 to 8 South Elevation 2 to 8 South Elevation 2 to 8 South Elevation 2 to 8 South Elevation 2 to 8

Defect Make good to Joint lining panels between East and West which are not aligned or properly installed Cap ends of ALL profiles at joint between East and West buildings and make good including mastic excess removal Make good to soffit panel outer at A13 Terrace Level 2 which is short and a gap formed Profile frame at base on main faade Level 2/3 is short near Column A 14 LH and to be replaced Refix loose outer soffit panel to RH of Column A14 and make good all round Profile frame at base on main faade Level 2/3 is short near Door West to Westfourth Area and to be replaced Remove all remaining parts of protective covering to profiles, soffit panels etc for whole of South Faade Relevel outer soffit panel near Door East Westfourth Area and make good Profile frame at base on main faade Level 2/3 is short near Door East to Westfourth Area and to be replaced Profile frame at base on main faade Level 2/3 is short near Column A 17 RH and to be replaced Profile frame at base on main faade Level 2/3 is short near Door West to Euroest Invest Area and to be replaced Profile frame at base on main faade Level 2/3 is short near Door East to Euroest Invest Area and to be replaced

Rating Classif. B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

343

AMERICA HOUSE

SNAGGING LIST (EAST)

13 14 15

South Elevation 2 to 8 South Elevation 2 to 8 South Elevation 2 to 8

Refix loose outer soffit panel near Door West to Euroest Invest Area Profile frame at base on main faade Level 2/3 is short near Column A 18 LH and to be replaced Remove paint splashes to underside of soffit to Terrace Level 2

B B B

Ref. No. 1 2 3 4 5 6 7

Location East Elevation 2 to 8 East Elevation 2 to 8 East Elevation 2 to 8 East Elevation 2 to 8 East Elevation 2 to 8 East Elevation 2 to 8 East Elevation 2 to 8

Defect Make good to profile frame damage Level 2/3 on LH side of elevation East Seal hole to left of Boiler Flue at base of 3rd Floor vertical profile Repaint to rusty part of frame holdfasts to Boiler Flue from Level 2 through to Level 8 Remove all remaining protective cover from profiles, frame and soffit lining for East Faade Levels 2 through to Level 8 Make good joint between soffit lining and upper faade Level 3 where joint in profile frame 2/3 is short and to be replaced Remove all mortar and paint stains on profiles, soffit linings panels and frames on East Faade Replace white wire on black coloured faade at Terrace Level 2

Rating Classif. B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

344

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14

Location North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8

Defect Make good to exposed padding at soffit joint between Panels 1 and 2 Make good open joint at soffit between Panel 2 and 3 Make good open joint at soffit between Panel 3 and 4 Make good open joint at soffit between Panel 4 and 5 Make good open joint at soffit between Panel 5 and 6 Make good open joint at soffit between Panel 6 and 7 Make good open joint at soffit between Panel 7 and 8 Make good open joint at soffit between Panel 8 and 9 Make good open joint at soffit between Panel 9 and 10 Make good open joint at soffit between Panel 10 and 11 Make good open joint at soffit between Panel 11 and 12 Make good open joint at soffit between Panel 12 and 13 Make good open joint at soffit between Panel 13 and 14 Make good open joint at soffit between Panel 14 and 15

Rating Classif. B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

345

AMERICA HOUSE

SNAGGING LIST (EAST)

15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8

Make good open joint at soffit between Panel 15 and 16 Make good open joint at soffit between Panel 16 and 17 Make good open joint at soffit between Panel 17 and 18 Make good open joint at soffit between Panel 18 and 19 Make good open joint at soffit between Panel 19 and 20 Make good open joint at soffit between Panel 20 and 21 Make good open joint at soffit between Panel 21 and 22 Make good open joint at soffit between Panel 22 and 23 Make good open joint at soffit between Panel 23 and 24 Make good open joint at soffit between Panel 24 and 25 Make good open joint at soffit between Panel 25 and 26 Make good open joint at soffit between Panel 26 and 27 Make good open joint at soffit between Panel 27 and 28 Make good open joint at soffit between Panel 28 and 29 Make good open joint at soffit between Panel 29 and 30 Make good open joint at soffit between Panel 30 and 31 Capping to windows between D16 and D15 at Terrace Level 2 Window 1 Capping to windows between D16 and D15 at Terrace Level 2 Window 2 Capping to windows between D16 and D15 at Terrace Level 2 Window 3

B B B B B B B B B B B B B B B B B B B

Ref. No. 34 35 36 37 38 39 40 41

Location North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8 North Elevation Level 2 to 8

Defect Capping to windows between D16 and D15 at Terrace Level 2 Window 4 Capping to windows between D16 and D15 at Terrace Level 2 Window 5 Capping to windows between D16 and D15 at Terrace Level 2 Window 6 Capping to windows between D16 and D15 at Terrace Level 2 Window 7 Capping to windows between D16 and D15 at Terrace Level 2 Window 8 Capping to windows between D16 and D15 at Terrace Level 2 Window 9 Capping to windows between D16 and D15 at Terrace Level 2 Window 10 Capping to windows between D16 and D15 at Terrace Level 2 Window 11

Rating Classif.

Date Rectified

Date Checked

Comments

4/10/2013

346

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

Location Lifts Lifts Lifts Lifts Lifts Lifts Lifts Lifts Lifts Lifts Lifts Lifts Lifts Lifts Lifts

Defect Provide fixing to stop 'wobble' of call button panel in Service Elevator Remove all protective covering to handrail in Service lift/elevator Realign gap between Car ceiling and top of mirror wall which is uneven to Lift PE 09 Refix skirting to back wall of lift car to Lift PE 09 which is loose Refix front skirting to RH side of Lift Car which is loose to Lift PE 09 Clean plastic head piece to call button panel and refix to PE 09 Provide fixing to stop 'wobble' of call button panel in Lift PE 09 Realign gap between Car ceiling and top of mirror wall which is uneven to Lift PE 08 Clean plastic head piece to call button panel and refix to PE 08 Provide fixing to stop 'wobble' of call button panel in Lift PE 08 Refix rear skirting to RH side of Lift Car which is loose to Lift PE 08 Refix skirting to LH side below mirror that is badly fixed in place and make good Realign gap between Car ceiling and top of mirror wall which is uneven to Lift PE 07 Clean plastic head piece to call button panel and refix to PE 07 Clean marks at top RH side of Lift car to Lift PE 07

Rating Classif. B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

347

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Location Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15

Defect Paint ceiling Paint floor including steps Paint walls Cover up exposed reinforcement to LH lower of East Wall and make good Seal to duct on LH side of East wall near North wall and make good all round Seal hole above duct to LH side of East Wall near North Wall and make good Make good to two (2) formwork fixing holes and seal to East Wall Remove steel rod below large duct Right and make good to wall complete to East Wall Remove timber formwork in bottom RH of East Wall and make good and repaint Make good to honeycombed wall to right of main ducts and repaint complete to East Wall Make good to exposed steel reinforcement under and to right of main ducts o East Wall and repaint Make good and seal to conduit near ceiling on East Wall Seal around LH large duct to East Wall and make good all round and repaint Seal around RH large duct to East Wall including large hole to right of duct in wall and make good all round and repaint Seal hole above vent opening to RH upper of South Wall and make good Remove two conduit holdfasts (obsolete) on South Wall to right of vent opening and make good Make good and level ingoing to vent opening and paint

Rating Classif. B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

348

AMERICA HOUSE

SNAGGING LIST (EAST)

18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15

Make good to eight (8) formwork fixing holes and seal to South Wall Remove nail in lower part of South Wall and make good to wall Make good to honeycombed wall to left part repaint complete to West Wall Seal and make good to conduit on West Wall (South) Seal and make good to conduit on West Wall (Centre) Remove two conduit holdfasts (obsolete) on West Wall to right of near North Wall and make good Seal large hole with two ventilation ducts to West Wall and make good all round Make good to six (6) formwork fixing holes and seal to West Wall Remove two (2) steel bolt fixings at West Wall lower in middle and make good Remove one conduit holdfast (obsolete) on West Wall (Centre) and make good Remove polystyrene to North Door as this is a fire door and polystyrene is combustible Make good to wall above door top frame and repaint Clean conduit of paint to RH side of door for full height Concrete steps are very rough and need to be properly levelled and shaped Provide handrail to stair Remove steel reinforcement rod to LH side of North Wall at lower level and make good

B B B B B B A B B B A B B B A B

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51

Location Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15

Defect Remove two (2) steel reinforcement rods to RH side of North Wall at lower level and make good Remove paint etc. from conduit to RH side of North Wall door Make good to six (6) formwork fixing holes and seal to North Wall Tidy up wires to Door intruder alarm contact Seal ventilator duct in northeast corner of room to floor and make good all round Complete blockwork housing and capping to ventilation duct in northeast corner of room Seal and make good to hole in floor slab at southeast corner Remove paint to North Door Frames Fit rubber seal all round North door Intumescent strip is short to hinge frame at base of North door and to be replaced Intumescent strip is short to open frame at base of North door and to be replaced Fixing screws to frame protrude and are to be refixed to North door Cover four (4) protruding screw ends in angle plate to top corner to North door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to North door Remove remaining protective covering to North door Install fire/smoke seal threshold plate to North door Screw missing in lock plate to North door

Rating Classif. B B B B A A A B B A A B B A B B A B

Date Rectified

Date Checked

Comments

4/10/2013

349

AMERICA HOUSE

SNAGGING LIST (EAST)

52 53 54 55 56 57 58 59 60 61 62

Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15 Service Lift Motor Room BC 14/15

Door is fouling on lightning protection system which requires to be relocated Remove paint splashes to North door surfaces and make good Door signage to North Door Install permanent handles to door North Intumescent strip is partly missing on head frame and to be replaced Lockset is missing and to be installed Replace damaged strike plate to Door North Make good to rust on door head and repaint Touch up chipped/damaged paintwork to frames Remove manufacturer's labels on door and make good Install door closer to North Door

A B B B A A A B B B A

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Location Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17

Defect Paint ceiling Paint floor including steps Paint walls not yet properly painted Make good to concrete steps and make necessary remedial works Install handrail to stairs Make good wall around Fan on North Wall and repaint Remove paint on wall telephone on North Wall Make good hole to RH of steps on North Wall and repaint as required Light switch to LH side of door to be set at a more workable height Make good to thirty one (31) formwork fixing holes and seal to all walls Remove steel rod at ceiling level on North Wall and make good Remove two steel rods at LH of North Door on North Wall and make good Remove one steel rod at RH of North Door on North Wall and make good Remove paint on conduit to LH side of North Door Remove paint on flexible conduit above LH of Door North Make good to 'messy' lower trunking on North Wall and seal/cap ends as required Make good to 'messy' upper trunking on North Wall and seal/cap ends as required Make good to Floor cover plates that have openings still viewable (3 No) Make good to square hole in South Wall and seal all round

Rating Classif. B B B B A B B B A B B B B B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

350

AMERICA HOUSE

SNAGGING LIST (EAST)

20 21 22 23 24 25 26 27 28 29 30 31 32 33

Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17

Remove paint on conduit on West Wall especially near ceiling Make good to wall where two (2) conduits pass through to West Wall and seal Make good all round to ventilator opening on South Wall at head and repaint as required Set Running Man Sign level Complete conduit to ceiling mounted Smoke Detector Remove paint to North Door Frames Fit rubber seal all round North door Intumescent strip is short to hinge frame at base and head of North door and to be replaced Intumescent strip is short to open frame at base and head of North door and to be replaced Fixing screws to frame protrude and are to be refixed to North door Cover four (4) protruding screw ends in angle plate to top corner to North door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to North door Remove remaining protective covering to North door

B B B B B

A A

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46

Location Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17 Lift Motor Room BC 16/17

Defect Install fire/smoke seal threshold plate to North door Screw missing in lock plate to North door Replace lockset with permanent locks Remove paint splashes to North door surfaces and make good Door signage to North Door Install permanent handles to door North Intumescent strip is missing on head frame and to be replaced Replace temporary door handles with permanent ones Install door closer to North Door Make good to holes in floor near door north Touch up chipped/damaged paintwork to frames Remove manufacturer's labels on door and make good Repair damage to door head frame

Rating Classif. A B B B B B A B A B B B B

Date Rectified

Date Checked

Comments

4/10/2013

351

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

Location Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18

Defect Paint ceiling Paint walls Paint floor including steps Fit rubber seal all round North door Intumescent strip is missing to hinge frame North door and to be replaced Intumescent strip is missing to open frame of North door and to be replaced Fixing screws to frame protrude and are to be refixed to North door Cover four (4) protruding screw ends in angle plate to top corner to North door Intumescent strip not continuous to side frames due to incorrect placement of strike plate & security prong and to be corrected Install door stop to North door Remove remaining protective covering to North door Intumescent strip is missing from head frame of Door North and to be replaced Install fire/smoke seal threshold plate to North door Screw missing in lock plate to North door Replace lockset with permanent locks Remove paint splashes to North door surfaces and make good Door signage to North Door Install permanent handles to door North Intumescent strip is missing on head frame and to be replaced Replace temporary door handles with permanent ones Install door closer to North Door

Rating Classif. B B B B A A B B A B B A A B B B B B A B A

Date Rectified

Date Checked

Comments

4/10/2013

352

AMERICA HOUSE

SNAGGING LIST (EAST)

22 23 24 25 26 27 28 29 30 31 32 33

Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18

Touch up chipped/damaged paintwork to frames Remove manufacturer's labels on door and make good Make good to rough steps and level and carry out required remedial works Install stair handrail Make good to poor concrete on North wall Cap or cut four bolts to floor plate near door Provide protection at eye level to steel channel near door Change Panel label SBS 13E which is a plastic holder with paper sign with Ivorine label In southwest corner, cap or cut four (4) bolts to four (4) stanchion base plates at floor level Seal wall in southeast corner at duct Make good render to wall at blockwork ventilation enclosure in southeast corner Remove general snots of concrete on floor (before painting)

B B B A B A A B B B B B

Ref. No. 34 35 36 37 38 39 40

Location Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18 Mechanical Room : Roof BC 17/18

Defect On East Wall cap or cut four (4) bolts to three (3) stanchion plates at floor level In middle of room, cap or cut four (4) bolts to three (3) stanchions at floor level Tidy up and gully and reset gulley grating in recessed frame complete Pipe insulation to pipework to gulley is poor workmanship and the copious usage of tape in a probably water filled area is bad Finish block work to ventilator duct on West Wall (South) Repair blockwork on South Wall near duct exit and make good and seal to duct and pipes Make good missing blockwork at wall return on West Wall High level) and seal all round

Rating Classif. B B B B A A A

Date Rectified

Date Checked

Comments

4/10/2013

353

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Location Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External

Defect Fix lightning strip on LH side to South wall and make good Fix lightning strip on RH side to South wall and make good Paint patch repair above door on South wall Paint patch repair to LH side of door on South Wall Paint two (2) repair patches to Left of Door at base of South wall Paint two (2) repair patches to Left Door at South Paint LH ingoing of door on South Wall Paint RH ingoing of door on South Wall Paint head ingoing of door to South Wall Seal around duct to RH of door on South Wall and paint all round Make good to chipped threshold step Paint to patch near and around patch to ventilator fan Patch and paint to LH duct at low level near roof duct channel Remove paint on conduit to light on East Wall Seal and repaint around pipe patch repair on RH side of East Wall (upper) Seal to LH duct and make good and paint around to East Wall (upper) Seal to RH duct and make good and paint around to East Wall (upper) Install proper seal collar to three (3) vent pipes on walkway channel to East Wall Make good to edge of walkway channel on East wall at edge and repaint complete Make good to south end of walkway channel at East Wall and repaint complete Make good to north end of walkway channel at East Wall and repaint complete Make good to paint at repairs at base of East Wall (Lower) Make good to duct in East Wall Lower, seal and paint all round to RH side

Rating Classif. A A B B B B B B B B A B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

354

AMERICA HOUSE

SNAGGING LIST (EAST)

24 25 26 27 28 29 30 31 32 33

Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External

Level and fix capping to South Wall Level and fix capping to East Wall Level and fix capping to North Wall Level and fix capping to West Wall Fix lightning strip on LH side to North wall and make good Fix lightning strip on RH side to North wall and make good Reconnect or remove cable on North Wall that is open Remove paint on conduit to light on North Wall Seal hole for conduit and make good and paint at north wall above door to Roof Corridor Seal wall at four (4) access ladder fixing points at North Wall

B B B B A A A B B B

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57

Location Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External Roof Housing BC 14/15 External

Defect Make good to damaged step to Roof Corridor and seal Seal to Upper Duct between doors on North Wall, make good and paint all round Seal to Lower Duct between doors on North Wall, make good and paint all round Repaint to LH side of Door to Service Elevator Motor Room Repaint to RH side of Door to Service Elevator Motor Room Repaint to head of Door to Service Elevator Motor Room Paint LH ingoing of door on North Wall to Roof Corridor Paint RH ingoing of door on North Wall to Roof Corridor Paint head ingoing of door on North Wall to Roof Corridor Plastic roof cover to smoke ventilation is damaged on northeast corner and to be replaced Smoke Ventilator is inoperable as broken Access Ladder is made of reinforcement steel (backstreet) and should be replaced Access Ladder to be repainted as it is rusting in several places with external weather resistant paint Access Ladder to be fixed to parapet as the top guide handle are 'shaking' and unstable Remove paint on conduit to wall light on West Wall (Upper) Make good to edge of walkway channel on West wall at edge and repaint complete Make good to south end of walkway channel at West Wall and repaint complete Make good to north end of walkway channel at West Wall and repaint complete Seal to large duct to LH side of East Wall Lower and make good and paint all round Seal to large duct to middle of East Wall Lower and make good and paint all round Seal to large duct to RH side of East Wall Lower and make good and paint all round Make good poor repair render above RH side duct and repaint Make good to paint at repairs at base of west Wall (Lower) Make good to wall along horizontal duct pipe and paint all round at East Wall Lower

Rating Classif. B B B B B B B B B B A C B A B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

355

AMERICA HOUSE

SNAGGING LIST (EAST)

58 59

Roof Housing BC 14/15 External Roof Housing BC 14/15 External

Make good to two large duct pipes and paint all round to East Lower Wall Make good to top of plasterboard linings to smoke vent shaft in roof

B B

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25

Location Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18

Defect Remove three (3) supports to cable tray built into West Wall (Lower), reset and make good to wall complete Seal at base of West Wall Lower and repaint along full length Seal to conduit tray and cables to LH side of West Lower Wall and make good all round and repaint Seal to conduit tray and cables to middle of West Lower Wall and make good all round and repaint Make good to poor workman ship to cable tray along full length of West Wall Lower Make good painting to two (2) areas on West Wall Lower that were repaired but not painted Seal and make good to vent duct to LH side of West Wall Lower and repaint all round Seal and make good to vent duct to RH side of West Wall Lower and repaint all round Seal and make good to circular vent duct to RH side of West Wall Lower and repaint all round Make good to edge with walkway and repaint for full length of West Wall Lower Make good to edge of LH return to West Wall Lower at walkway at North End Make good to edge of RH return to West Wall Lower at walkway at South End Seal and make good around Vent pipe with proper collar piece on West Wall walkway Remove three (3) adhesive/glue fixings to flexible conduit and fix to wall with proper fixings Point and paint to West Wall just below capping and make good for full length of wall Repair to South End of walkway edging and make good and repaint Repair to North End of walkway edging and make good and repaint Make good to top LH of South Faade at capping where damaged and repair and repaint Seal and make good to duct on LH side of South Wall and repaint all round Make good to South Wall above RH side of LH ventilator duct and repaint Make good to slit opening at bottom of South Wall LH and repaint Seal and make good to two (2) conduits to LH side bottom of South Wall and repaint Seal and make good to hole to LH side bottom of South Wall and repaint Fix lightning rod strip LH properly to South wall as at present it has no fixings Fix lightning rod strip RH properly to South wall as at present it has no fixings

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B A A

Date Rectified

Date Checked

Comments

4/10/2013

356

AMERICA HOUSE

SNAGGING LIST (EAST)

26 27 28 29 30 31 32 33

Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18

Seal and make good to one (1) conduit to South Wall and repaint towards the middle Seal and make good to upper vent duct on South Wall (middle) and repaint all round Seal and make good to lower vent duct on South Wall (middle) and repaint all round Make good rough wall around two circular duct pipes and seal and make good and repaint all round Repair damaged capping on East Wall and make good and repaint to wall surface Seal and make good to one (1) conduit to East Wall and repaint towards the middle Repaint return wall south at East Wall Repaint edge to east facing upper part of enclosure on East Wall and make good

B B B B B B B B

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59

Location Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18

Defect Seal and make good to LH ventilator duct to East Wall and repaint all round Seal and make good to RH ventilator duct to East Wall and repaint all round Make good to northern return to East Wall and repaint at upper walkway Seal and make good around Vent pipe with proper collar piece on East Wall walkway (North) Repaint wall where repaired at former opening for ventilator duct to LH side of North Wall Seal and make good to LH ventilator duct on LH side of North Wall and repaint all round Seal and make good to RH ventilator duct on LH side of North Wall and repaint all round Make good step to Mechanical Room and paint Make good to hole at base of RH door frame to Mechanical Room and seal and paint Make good to hole at base of LH door frame to Mechanical Room and seal and paint Repaint repair above door to Mechanical Room on North Wall Seal and make good to ventilator duct to RH of door to mechanical Room on North Wall and repaint all round Seal and make good to ventilator fan to Lift Motor Room on North Wall in infill hole at top and paint all round Seal and make good to one (1) conduit on North Wall and paint Repair wall where damaged by door handle of door to Lift Motor Room North Wall and repaint Repaint wall to LH side of Door to Lift Motor Room North Wall Repaint wall to RH side of Door to Lift Motor Room North Wall Repaint wall to head of Door to Lift Motor Room North Wall Repair capping above door to Lift Motor Room and make good Repair to gap where capping is damaged and seal and make good and repaint Fix lightning rod strip LH properly to North wall as at present it has no fixings Fix lightning rod strip RH properly to North wall as at present it has no fixings Repair step to Lift Motor Room and make good and paint Seal and make good to four (4) ladder fixings to wall at North Wall Access Ladder is made of reinforcement steel (backstreet) and should be replaced Access Ladder to be repainted as it is rusting in several places with external weather resistant paint

Rating Classif. B B B B B B B B B B B B B B B B B B B B A A B B C B

Date Rectified

Date Checked

Comments

4/10/2013

357

AMERICA HOUSE

SNAGGING LIST (EAST)

60 61 62 63 64 65 66

Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18 Roof Housing External BC 16/18

Access Ladder to be fixed to parapet as the top guide handle are 'shaking' and unstable Make good to top of plasterboard linings to smoke vent shaft in roof Smoke Ventilator is inoperable as broken Make good to gulley opening and form good receptor Fit missing dome grating to roof gulley Screed expansion strips are generally becoming loose and missing and requires to be repaired and replaced Make good to Lift Motor Room door that id damaged on the hinge edge

A B A B B B B

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

Location Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17 Roof Well BC 15/17

Defect Seal and make good to four (4) ladder fixings to wall at North Wall Seal and make good to four (4) ladder fixings to wall at South Wall Access Ladder to North Wall is made of reinforcement steel (backstreet) and should be replaced Access Ladder to South Wall is made of reinforcement steel (backstreet) and should be replaced Access Ladder to South Wall to be repainted as it is rusting in several places with external weather resistant paint Access Ladder to North Wall to be repainted as it is rusting in several places with external weather resistant paint Refix top RH ladder fixing on North Wall that is loose and make good Fix lightning rod strip LH properly to North wall as at present it has no fixings Fix lightning rod strip RH properly to North wall as at present it has no fixings Fix lightning rod strip LH properly to South wall as at present it has no fixings Fix lightning rod strip RH properly to South wall as at present it has no fixings Access Ladder upper above duct is not stable and requires stay support on North Side Access Ladder upper above duct is not stable and requires stay support on South Side Make good to North Wall at base in middle and repaint Make good to roof gulley and refix dome grating complete Ventilation WC Unit is not properly set on roof with absorbers etc.

Rating Classif. B B C C B B A B B B B A A B B A

Date Rectified

Date Checked

Comments

4/10/2013

358

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26

Location Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14 Roof Well BC 13/14

Defect Seal and make good to four (4) ladder fixings to wall at North Wall Seal and make good to four (4) ladder fixings to wall at South Wall Access Ladder to North Wall is made of reinforcement steel (backstreet) and should be replaced Access Ladder to South Wall is made of reinforcement steel (backstreet) and should be replaced Access Ladder to South Wall to be repainted as it is rusting in several places with external weather resistant paint Access Ladder to North Wall to be repainted as it is rusting in several places with external weather resistant paint Refix top RH ladder fixing on North Wall that is loose and make good Access Ladder upper above duct is not stable and requires stay support on North Side Access Ladder upper above duct is not stable and requires stay support on South Side Make good to roof gulley and refix dome grating complete Fix lightning rod strip LH properly to North wall as at present it has no fixings Fix lightning rod strip LH properly to South wall as at present it has no fixings Seal and make good to South Wall LH side to cable tray and two (2) conduits and repaint Seal at wall base for full length and repaint to South Wall Repaint repair to top of RH of South Wall and make good Make good to edge of roof and divider wall and repaint along full length Make good to edge of roof and Wall to Roof Housing BC 14/15 East Make good to return wall at Divider Wall on North Wall and repaint Access ladder North Wall requires to be repaired as top rungs are missing (Ladder is substandard manufacture) Clean mortar etc from angle channel in RH side on North Wall and repaint Seal and make good to gap on North wall near return to divider wall Seal and make good to conduit at wall base to North Wall and repaint Seal and make good to three ducts on RH side of North Wall and repaint all round Repaint repair at lower RH side of North Wall Repaint repair near access ladder at top of North Wall Repaint repair near access ladder towards North wall base

Rating Classif. B B C C B B A A A B A A B B B B B B A B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

359

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29

Location Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19

Defect Seal to wall to Roof Housing BC 14/15 near roof duct and make good and repaint wall (South) Generally tidy up lightning strip installation and cover plates and brick anchors in area B 13/19 Generally tidy up lightning strip installation and cover plates and brick anchors in area C 13/19 Generally tidy up lightning strip installation and cover plates and brick anchors in area B/C 19 AHU near Roof Housing BC 14/15 is set on Roof Duct and not the design position and blocks walkway roof duct Roof duct screed in area C 13/17 is badly cracked and crazed and to be repaired and made good Screed expansion strips are generally becoming loose and missing and requires to be repaired and replaced Make good to hose clips used to join flexible conduits to steel conduits near BC 14/15 housing (2 No.) Change rusty plug caps to Glycol Tank (2 No) Seal and make good to four (4) ladder fixings to wall at South Wall of duct at B 13 Seal and make good to four (4) ladder fixings to wall at South Wall of duct at B 16 Seal and make good to two (2) ladder fixings to wall at South Wall of duct at B 16 Access Ladder to South Duct Wall (B 13) is made of reinforcement steel (backstreet) and should be replaced Access Ladder to South Duct Wall (B 16) is made of reinforcement steel (backstreet) and should be replaced Sloping Access ladder to South Duct wall at B16 requires to be painted in external weather resistant paint as rusting Access Ladder to South Duct Wall (B13) to be repainted as it is rusting in several places with external weather resistant paint Access Ladder to South Duct Wall (B16) to be repainted as it is rusting in several places with external weather resistant paint Remove steel reinforcement rod near B15 in South Duct wall and make good and repaint Remove three (3) steel reinforcement rods near B16 in South Duct Wall and make good and repaint Remove steel reinforcement rod near B18 in South Duct wall and make good and repaint Remove five (5) steel reinforcement rods near B18/19 in South Duct Wall and make good and repaint Repaint repair at LH end of South Duct Wall Seal to base of South Duct Wall at B 14/15 and repaint Seal to base of South Duct Wall at B 16 and repaint Seal and make good to conduit on South Duct Wall B 14/15 and repaint Fix lightning rod strip at B 14 properly to South Duct wall as at present it has no fixings Fix lightning rod strip at B 15 properly to South Duct wall as at present it has no fixings Fix lightning rod strip at B 17 properly to South Duct wall as at present it has no fixings Fix lightning rod strip at B 18 properly to South Duct wall as at present it has no fixings

Rating Classif. B B B B C B B B B B B B B B B B B B B B B B B B B A A A A

Date Rectified

Date Checked

Comments

W4A to review and advise

4/10/2013

360

AMERICA HOUSE

SNAGGING LIST (EAST)

30 31 32 33

Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19

Seal and make good to conduit on South Duct Wall B 17/18 and repaint Make good damaged wall lining to South Duct Wall at B13 and repaint Make good damaged wall lining to South Duct Wall at B14 and repaint Make good damaged wall lining to South Duct Wall at B15 and repaint

B B B B

Ref. No. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63

Location Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19

Defect Make good damaged wall lining to South Duct Wall at B16 and repaint Make good damaged wall lining to South Duct Wall at B17 and repaint Make good to three (3) areas of damaged wall lining to South Duct Wall at B18 and repaint Make good to three (3) areas of damaged wall lining to South Duct Wall at B19 and repaint Make good damaged wall lining to East Duct Wall at B19 and repaint Repaint repair to East Duct Wall at LH end Make good to walkway edge for full length and repaint East Duct Wall upper Remove steel plate and two (2) fixing bolts on LH side of East Duct Wall and make good and repaint Remove six (6) steel reinforcement rods in East Duct Wall and make good and repaint Fix lightning rod strip at LH side of East Duct wall as at present it has no fixings Fix lightning rod strip at RH side of East Duct wall as at present it has no fixings Repaint repairs to RH side at end of East Duct Wall and make good Seal East Duct Wall at base with main roof and repaint Repaint repair area on East Duct Wall to left of three circular ducts Seal and make good to cable tray on LH side of East Duct Wall and repaint Seal and make good to cable tray on RH side of East Duct Wall and repaint Seal and make good to circular ducts (3 No ) and make good and repaint Make good edges to concrete base for AHU on Roof Duct Repaint repair to North Duct Wall at C 19 Repair wall at edge to North Duct Wall at C 18, make good and repaint Repaint repair to North Duct Wall between C 17/18 Seal at base of North Duct Wall for full length C 13/19 and make good and repaint Fix lightning rod strip at C 14 properly to South Duct wall as at present it has no fixings Fix lightning rod strip at C 15 properly to South Duct wall as at present it has no fixings Fix lightning rod strip at C 17 properly to South Duct wall as at present it has no fixings Fix lightning rod strip at C 18 properly to South Duct wall as at present it has no fixings Repaint to repair at C16 to top of North Duct Wall Repaint repair to North Duct Wall between C 16/17 Repaint repair to North Duct Wall at C 16 Fix steel conduit properly to roof duct at C16/17

Rating Classif. B B B B B B B B B B B B B B B B B B B B B B B B B B B B B A

Date Rectified

Date Checked

Comments

4/10/2013

361

AMERICA HOUSE

SNAGGING LIST (EAST)

64 65 66

Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19

Fix two (2) steel conduit properly to roof duct at C14/15 Repaint three repairs to RH side of North Duct Wall C 13/14 for pipes Seal and Make good to two pipes to RH side of North Duct Wall C 13 and repaint

A B B

Ref. No. 67 68 69 70 71 72 73 74 75 76 77 78 79 80

Location Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19 Roof Duct BC 13/19

Defect Seal and make good to four (4) ladder fixings to wall at South Wall of duct at C 13 Seal and make good to four (4) ladder fixings to wall at South Wall of duct at C 16 Seal and make good to two (2) ladder fixings to wall at South Wall of duct at C 16 Access Ladder to South Duct Wall (C 13) is made of reinforcement steel (backstreet) and should be replaced Access Ladder to South Duct Wall (C 16) is made of reinforcement steel (backstreet) and should be replaced Sloping Access ladder to South Duct wall at C16 requires to be painted in external weather resistant paint as rusting Access Ladder to South Duct Wall (C13) to be repainted as it is rusting in several places with external weather resistant paint Access Ladder to South Duct Wall (C16) to be repainted as it is rusting in several places with external weather resistant paint Seal and make good to two (2) circular duct at pipes at C 17 on North Duct wall and repaint Seal and make good to cable tray and cables at C 17 on North Duct Wall and repaint Seal and make good to one (1) conduit at C 16 on North Duct Wall and repaint Seal and make good to two (2) conduits at C 15/16 on North Duct Wall and repaint Seal and make good to hole in North Duct Wall at C 14/16 and repaint Repaint repair at RH end of North Duct wall and on part return to divider wall

Rating Classif. B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

4/10/2013

362

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

Location Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20 Main Roof AD 13/20

Defect Remove adhesive and remnants of polystyrene panels to upstand of parapet on North Wall D 13/20 and make good Remove adhesive and remnants of polystyrene panels to upstand of parapet on South Wall A 13/20 and make good Remove adhesive and remnants of polystyrene panels to upstand of parapet on East Wall A/D 20 and make good Remove timber battens left in screed in area CD 14/18 and make good Remove timber battens left in screed in area B/d 18/20 and make good Make good to roof gulley at C14 Fix dome grating to roof gulley C 14 Make good to roof gulley at C16 Fix dome grating to roof gulley C 16 Make good to roof gulley at C18 Fix dome grating to roof gulley C 18 Make good to roof gulley at C19 Fix dome grating to roof gulley C 19 Make good to roof gulley at B14 Fix dome grating to roof gulley B 14 Make good to roof gulley at B 16 Fix dome grating to roof gulley B 16 Make good to roof gulley at B 18 Fix dome grating to roof gulley B 18 Make good to roof gulley at B 19 Fix dome grating to roof gulley B 19 Make good to area of 'ponding' to roof screed in area CD 15/16 Make good concrete to AHU 02 Chiller base to edges all round AHU 02 is placed on ill cut pink rubber pads and not bespoke absorbers like main chillers Comb out damaged fins to Main Chiller South Comb out damaged fins to Main Chiller North Remove general builder's rubbish on Main Roof Area including broken bricks etc. Generally make good to lightning strips and realign including ant twisting or distortions

Rating Classif. C C C B B B B B B B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

W4A to review and advise

4/10/2013

363

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

Location Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1 Valve Room S1E 14 Level -1

Defect Remove polystyrene foam around door and replace with inert and acceptable filler to the approval of W4A Make good to render above door on outside face and repaint Fixing screws to frame protrude and are to be refixed to North door Cover four (4) protruding screw ends in angle plate to top corner to North door Remove paint to Door Frames Fit rubber seal all round door Touch up chipped paint on door frames Install door stop Replace plastic door handles with anodised handles Remove remaining protective covering from door etc and make good Remove paint stains etc on door frames and make good Replace strikeplate to door frame as showing signs of distress Remove wood block spacer between door frame of blockwork RH side (open) Remove twelve (12) screw fixings to Southwest wall and make good and repaint Remove three (3) reinforcement rods near ceiling on Southwest Wall and make good and repaint Fill in hole left behind after formwork fixings removed and make good and repaint wall Remove cementitious deposits on sprinkler pipe and repaint Render to door returns to sides and head has not been done and to be executed includiong paint finish Repaint fllor that is damaged and poor workmanship Paint wall Paint ceiling

Rating Classif. A B B B B B B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments W4A to review and advise

W4A to review and advise

4/10/2013

364

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5

Location Vestibule Level -1 (SE1 15) Vestibule Level -1 (SE1 15) Vestibule Level -1 (SE1 15) Vestibule Level -1 (SE1 15) Vestibule Level -1 (SE1 15)

Defect Door and Frame to be installed Repaint floor as damaged and poor quality Paint ceiling Remove paint on conduit drop to light switch Make good holes in Northeast wall and make good and repaint wall

Rating Classif. A B B B B

Date Rectified

Date Checked

Comments

W4A to review and advise

4/10/2013

365

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

Location Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016 Storage Area Level -1 S1E 016

Defect Install door Clean floor Clear out general builder's debris etc Make good to square hole in floor slab in southwest corner and make good including floor paint Level floor near East Wall BC 23 where concrete snots and depositis were not removed before floor paint application Remove paint on conduit drop near door and make good Remove paint to conduit drop to telephone outlet on Northeast wall and make good Make good to render above door on Northwest wall at D22 and repaint Seal wall near ceiling on northwest corner of room at D22 and make good around two (2) electrical conduits Remove cementitious deposits on sprinkler pipework and repaint Install missing smoke detector in Area AB 22/23 in Storage Area Realign hangers to sprinkler pipework that are not vertical Clean three (3) ceiling light fittings Paint ceiling Make good to honeycombed area to Southwaest wall and repaint as required

Rating Classif. A B B B B B B B B B B B B B B

Date Rectified

Date Checked

Comments

W4A to review and advise

4/10/2013

366

AMERICA HOUSE

SNAGGING LIST (EAST)

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12

Location Storage under Ramp Level -1 Storage under Ramp Level -1 Storage under Ramp Level -1 Storage under Ramp Level -1 Storage under Ramp Level -1 Storage under Ramp Level -1 Storage under Ramp Level -1 Storage under Ramp Level -1 Storage under Ramp Level -1 Storage under Ramp Level -1 Storage under Ramp Level -1 Storage under Ramp Level -1

Defect Make good to uneven concrete finish to sloping ceiling Remove formwork left at base on ramp to low wall and returns and repaint wall Paint ceiling Make good to very rough area of sloping ceiling near southwest wall and cover up exposed reinforcement etc. Remove formwork left in opening to Southwest wall B23 and make good Fill in hole at B23 in wall and seal completely and repaint Remove metal coverplate on East Wall at B23 including ten (10) reinforcement rod retainers and replace with proper hatch Remove formwork left at southeast corner of area B23 and make good to ceiling Remove reinforcement rod left in southwest wall and make good Fill in three (3) holes left behind after formwork fixings removed and make good and repaint wall Repaint walls Clean floor paint finish which is very dirty and stained

Rating Classif. B B B B B B A B B B B B

Date Rectified

Date Checked

Comments

W4A to review and advise

4/10/2013

367

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

368

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

369

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

370

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

371

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

372

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

373

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

374

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

375

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

376

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

377

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

378

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

379

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

380

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

381

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

382

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

383

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

384

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

385

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

386

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

387

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

388

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

389

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

390

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

391

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

392

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

393

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

394

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

395

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

396

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

397

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

398

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

399

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

400

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

401

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

402

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

403

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

404

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

405

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

406

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

407

AMERICA HOUSE

SNAGGING LIST (EAST)

4/10/2013

408

You might also like