You are on page 1of 3

FABIA 2000 1.2/40; 1.

2/47 Engine, Mechanical Components

13

13 Crankgear
13-1 Removing and installing V-ribbed belt

Summary of components
Note
Mark the rotation direction before removing the V-ribbed belt. Reversing the rotation direction of an already used

belt may destroy it.

Pay attention to the correct position of the V-ribbed belt in the belt pulley when installing it. Vehicles without an air-conditioning system do not have an air-conditioning compressor or guide pulley.

1 - 22 Nm 2 - Belt pulley on the coolant pump 3 - Trim 4 - Tensioner with tensioning pulley do not remove the tensioning pulley. 5 - 40 Nm 6 - Generator to facilitate positioning of the generator on the cylinder block, drive the threaded bushings of the screws slightly backwards 7 - Guide pulley 8 - Washer Camber towards the outside 9 - Belt pulley for crankshaft 10 - 90 Nm + torque a further 90 (1/4 turn) replace interlock the crankshaft with a drift -T10121- for loosening and tightening it up Chapter 13-3 11 - Distance sleeve for generator 12 - 23 Nm 13 - Distance sleeve for the AC compressor 14 - Dowel sleeves for AC compressor must be inserted in the cylinder block 15 - V-ribbed belt Routing of the V-ribbed belt vehicles without air conditioning Fig. 1 in 13-1 page 2 Vehicles with air conditioning Fig. 2 in 13-1 page 3 removing and installing 13-1 page 2

Edition 08.02 S00.5322.00.20

Removing and installing V-ribbed belt

13-1 page 1

13
Removing

FABIA 2000 1.2/40; 1.2/47 Engine, Mechanical Components

Mark the rotation direction of the V-ribbed belt. Lever off the cover for the tensioning roller -A-. Swing out the tensioning roller -A- with Torx key 50 -Bin the direction of travel up to the stop and remove the V-ribbed belt. Note The tensioning roller can be interlocked by inserting a rig pin.

Installing
Note
Inspect V-ribbed belt Inspection and Maintenance. Before fitting the V-ribbed belt make sure that all as-

semblies (generator, coolant pump and AC compressor) are securely mounted. guide pulley.

Check smooth operation of belt pulley, tensioning and Pay attention to the rotation direction of already used

V-ribbed belts. guide pulley.

Position the V-ribbed belt on the belt pulleys and Swing out the tensioning roller -A- with Torx key 50 -Bin the direction of travel up to the stop and lay the Vribbed belt in place.

Press on the cover of the tensioning roller -A-. Start engine and check belt run.
Fig. 1: 1234V-ribbed belt run - without an air conditioning system

Belt pulley - crankshaft Belt pulley - coolant pump Tensioning pulley Belt pulley - generator

13-1 page 2

Removing and installing V-ribbed belt

Edition 08.02 S00.5322.00.20

FABIA 2000 1.2/40; 1.2/47 Engine, Mechanical Components Fig. 2: 123456V-ribbed belt run - with an air conditioning system

13

Belt pulley - crankshaft Belt pulley - coolant pump Tensioning pulley Belt pulley - generator Belt pulley - AC compressor Guide pulley

Edition 08.02 S00.5322.00.20

Removing and installing V-ribbed belt

13-1 page 3

You might also like