You are on page 1of 2

Satellite NIM Tuner Module

FS2507
FS2507 is optimized for use in DVB-S/S2 and ABSS applications. The module complies with the required regulatory requirements and follows NuTunes CTASTM (Common Tuner Application Standard), which allows different Tuner options using the same mechanical form factor and pin-outs. Product Range

Electrical Specifications
No. 1 2 3 4 5 6 7 Parameter Frequency range Input level range Return Loss Noise Figure Fine Tune step Acquisition Time Oscillator phase noise At 1 KHz At 10 KHz At 100 KHz Conditions Min. 950 -85 -75 4 Typ. 8 5.5 1 50 -85 -95 -105 0.5 0.5 1 Max. 2150 -5 -5 85 45 Unit MHz dBm dB dB MHz Ms dBc/Hz Remarks -

8 9 10 11 12

AGC Range I/Q Amplitude in balance I/Q Phase in-balance I/Q filter bandwidth step size I/Q filter bandwidth

dB dB dB MHz MHz

12C programmable

2011 NuTune all rights reserved. The information presented in this document is the exclusive property of NuTune and should not be disclosed by the recipient to third parties without the prior written agreement of NuTune. The information contained in this specification does not form part of any quotation or contract, is believed to be accurate and reliable and may be changed without notice by NuTune. No liability will be accepted by NuTune for any consequence of its use. Publication does not convey nor imply any license under patent or other industrial or intellectual property rights. For more information visit us at: http://www.nutune.com.

Pin Configuration
Pin 1 2 3 4 5 6 7 8 9 10 11 12 13 14 Function N.C. Ant_Pwr GND Vs RF AGC GND Vp(tun) Vt GND IF out AS SCL SDA 4MHz REF Description Not Connected Antenna Power 5V Ground Supply +5V External RF AGC Input Ground Supply +5V tuner For Tuner Process use only Ground IF output for testing only Tuner Address Select

Packaging Specifications:

15 16 17

IF AGC D-IF out + D-IF out -

4MHz reference frequency output, AC coupled IF Amplifier AGC Control 0 3V Digital IF Output Balanced Digital Output Balanced

Product Dimensions The drawing below is for the vertical version of the Tuner. All measurements are in millimetres and tolerance is 0.5mm. Example, Product Drawing:

2011 NuTune all rights reserved. The information presented in this document is the exclusive property of NuTune and should not be disclosed by the recipient to third parties without the prior written agreement of NuTune. The information contained in this specification does not form part of any quotation or contract, is believed to be accurate and reliable and may be changed without notice by NuTune. No liability will be accepted by NuTune for any consequence of its use. Publication does not convey nor imply any license under patent or other industrial or intellectual property rights. For more information visit us at: http://www.nutune.com.

You might also like