Professional Documents
Culture Documents
Trademarks
Notice
The information in this manual is subject to change without
notice. Every effort has been made in the preparation of this manual
to ensure accuracy of the contents, but all statements, information,
and recommendations in this manual do not constitute the warranty
of any kind, express or implied.
EchoLife HG520 Home Gateway
Quick Guide
Welcome to purchase the EchoLife HG520 Home Gateway device(the
HG520 for short). With your HG520, you can access the Internet using
your high-speed ADSL AP router.
This manual shows how to install your HG520.
Getting to Know
The HG520 is a kind of Internal ADSL AP router for high speed
internet access.It has a 10/100Base-T Ethernet router to provide
Internet connectivity to all computers on your LAN. It also support
IEEE 802.11g 54Mbit/s Access Point.
Rear Panel
The rear panel provides ports for the HG520 to receive/send data and
get power supply..
Label Function
Front Panel
The front panel provides LED indicators to indicate the device status.
1
Label Color Function
Before Installation
The HG520 is used indoors only. Pay attention to the following when
installing and using the HG520.
Environment
2
Cleaning
Before cleaning the HG520, cut off the power supply.
Clean it using a piece of soft cloth. Do not use liquid or gas solution.
Power supply
• Use the power adapter delivered with the HG520.
• The voltage of the power supply shall meet the requirement of the
input voltage of the power adapter.
• In the case of thundering, unplug the power adapter;If the HG520
is not in use for a long time, unplug the power adapter.
• Do not open the cover of the HG520.
3
Follow the steps listed below to install it.
4
Note: Although you use the same type of cable, ADSL and
PHONE ports are not interchangeable. Do not route
the ADSL connection through the PHONE port.
Setp2 Connect the Ethernet cable
Attach one end of a provided network cable to a regular hub port and
the other to the Ethernet port on the HG520.
Step3 Attach the power adapter
Connect the AC power adapter to the PWR connector on the rear of
the device and plug in the adapter to a wall outlet or power extension.
Step4 Turn on the HG520 and power up computers and LAN
devices
Press the power switch on the rear panel of the device to the ON
position.
Turn on and boot up your computer(s) and any LAN devices such as
hubs or switches.
FAQs
Failure Instruction
LAN LINK • Ensure you use the right cables from the
light is out router to your computer
• Ensure the connection is secured;Check if the
NIC LED lights up;
• Ensure your NIC works normally by examining
whether the item of “Networking Device” is
labeled with “?” or “!”. If it is, you may delete it
5
Failure Instruction
and then click <Refresh> to reinstall.
• Otherwise you may try the NIC in another slot.
As a last resort, you have to replace the NIC.
Technical Specifications
Item Specification
Frequency: 50Hz-60 Hz