You are on page 1of 4

ACROPOLIS TECHNICAL CAMPUS, INDORE 452020

Department of Electronics & Communication Lab Session No. 008 Page No.1/3 Electronic Devices &Circuits CS- 304 Enrolment No. 0875 Batch No.

Performance Evaluation:
Name
Performing on Extra regular First Submission Second Submission

Grade and Remarks by the Tutor 1. Clarity about the objective of the experiment 2. Clarity about the problem statement 3. Submitted the work in desired format 4. Shown capability to solve the problem 5. Contribution to the team work. Others:

Grade

Signature

EEPERIMENT - 8 1. Title: To study operation of OPAMP as inverting DC amplifier. 2. Aims:


a) b) c) d) e) To understand the working principle of OP-AMP as inverting amplifier. To observe and calculate output voltage when OP-AMP works as inverting amplifier. To calculate gain of amplifier. To understand the effect of feedback on amplifier. To understand the different parameters of the amplifier

3. Objectives: After completing the experiment, the student should be able:


a) To draw the input-output response of amplifier. b) To draw the frequency response of amplifier 4. THEORY: Inverting Amplifier: An inverting amplifier uses negative feedback to invert and amplify a voltage. The R f resistor allows some of the output signal to be returned to the input. Since the output is 180 out of phase, this amount is effectively subtracted from the input, thereby reducing the input into the operational

ACROPOLIS TECHNICAL CAMPUS, INDORE 452020


Department of Electronics & Communication Lab Session No. 008 Page No.2/3 Electronic Devices &Circuits CS- 304 Enrolment No. 0875 Batch No.
amplifier. This reduces the overall gain of the amplifier and is dubbed negative feedback. Zin = Rin (because V is a virtual ground) A third resistor, of value, added between the non-inverting input and ground, while not necessary, minimizes errors due to input bias currents. Design R1 =1 K_ resistor RF = 2 K_ resistor. RL = 1 K_ resistor. Calculated gain =2. Do the calculation using design formulas

(Fig. OP amp as Inverting Amplifier)

5. Procedure:
1. Make the connections on OPT-01 board as shown in practical circuit. 2. Apply 1.4 V DC using VR1as input to op-amp. 3. Apply 15 V to op-amp. 4. Switch on power supply. 5. Vary i/p DC voltage from 1.4 to 5V and note down the corresponding readings of o/p voltage Vo.

6. Voltage Gain Observation:

ACROPOLIS TECHNICAL CAMPUS, INDORE 452020


Department of Electronics & Communication Lab Session No. 008 Page No.3/3 Electronic Devices &Circuits CS- 304 Enrolment No. 0875 Batch No.

7. Self Assessmetnt:
a) What is term OP AMP. b) Write the importance of differential amplifier in OP AMP.

Conclusion: Thus Gain for the designed inverting DC Amplifier is observed.

8. Report should comprise of interpretation on following observations :


a. Ensure that the line supply is & the meters are properly working i.e., showing suitable deflections. b. Ensure that there is no metallic surrounding near the vicinity within 2 m from the trainer

kit.

Prepared by Nasreen Noorani

Date 25/06/13

Modified on

You might also like