Professional Documents
Culture Documents
Features 1) Low-voltage operation and single power supply drive enabled. (Single power supply: 4 to 32V, dual power supply: 3 to 16V) 2) Low noise level. (Vn = 1.0Vrms typ. : RIAA) 3) High slew rate. (SR = 3V / s, GBW = 10MHz typ.)
4) Low offset voltage. (VIO = 0.5mV typ.) 5) High gain and low distortion. (GVO = 110dB, THD = 0.0015%) 6) Pin connections are the same as with standard dual operational amplifiers, and outstanding characteristics make these products compatible with the 4558 and 4560 models.
Block diagram
BA15218 / BA15218F BA15218N
OUT1 1 8 VCC + 1ch + 2ch
IN1 2 + IN1 3
1ch + 2ch +
OUT2
IN2
7 OUT2
OUT1
+ IN1
+ IN2
IN1
IN2
VCC
VEE
VEE 4
+ IN2
Standaed ICs
Q16
Q17
Q6 Q7 R4
Q12
R2 VEE
R3
OUT
Standaed ICs
20
10
100
1k
10k
100k
1M
10M
FREQUENCY: f (Hz)
Standaed ICs
32 MAXIMUM OUTPUT VOLTAGE: VOM (V) INPUT BIAS CURRENT: IB (nA) 28 24 20 16 12 8 4 0 100 1k 10k 100k 1M
100
75
60
50
40
25
20 20
10
20
30
40
FREQUENCY: f (Hz)
10
5 0
5 0 10 20 TIME (s) 30 40
10
20 0
20
Operation notes (1) Unused circuit connections If there are any circuits which are not being used, we recommend making connections as shown in Figure 9, with the non-inverted input pin connected to the potential within the in-phase input voltage range (VICM).
VCC
To potential in VICM
VEE
Standaed ICs
BA15218F
5.0 0.2 8 6.2 0.3 4.4 0.2 5
1 0.51Min.
4 7.62
0.11
0.3 0.1
1.5 0.1
2.54
0.5 0.1
0~15
1.27
0.4 0.1
0.3Min. 0.15
DIP8
BA15218N
SOP8
2.8 0.2
1.2
SIP8
0.15 0.1