You are on page 1of 1

When you receive your controller make sure you

sync it with your Xbox before you do anything else

3.5GTD Rapid Fire User Instructions

Enable / Disable Rapid Fire


To enable rapid fire simply press the sync button once and you will see the numbers change on the
display, the numbers represent the mode you are in. If the display is not lit up then the mod is
disabled.

Display Types:-
1. Mode 1 = (Call Of Duty World at War)
2. Mode 2 = (Call of Duty 3 & 4)
3. Mode 3 = (Halo, Gears of War, 50 Cent)
4. Mode 4 = (Halo, Gears of War, 50 Cent)
Modes 5 – 8 = Are the same speed as above so mode 5 = Mode 1 speed, Mode 6 = Mode 2
speed and so on but Modes 5 – 8 are Burst Fire modes, one quick press of the right or left trigger
will unleash 3 - 4 shots in one go.
One Quick press of the sync button will cycle you through these modes I.E.:-

Mod Disabled  1  2  3  4  5  6  7  8  Mod Disabled

Quick Disable of mod and reset


If a quick disable of the mod is required this can be done without cycling through all of the modes,
simply press the sync button twice, this will switch the mod off also resetting the left trigger if
enabled (see enabling / disabling left trigger).

Enabling /Disabling left trigger


To enable the left trigger for rapid fire action, hold down the left trigger button then press the sync
button this will enable the rapid fire on the left trigger. To disable the left trigger simply hold down
the left trigger button and press the sync button, the left trigger then returns to normal.

Memory
What ever mode you are in when the battery is removed or the pad switched off will be
remembered by the mod, when the controller is switched back on it will return to its previous state.

Updating
This is only advisable if the mod is detected by the game and your fire rate decreases. (Mode 1
update only)
If your game as been updated and the mod is detected please follow the procedure below:-
1. Remove battery.
2. Hold down left trigger
3. Insert battery
4. Power pad on holding while still holding left trigger
5. The display will then count to 9, once the display reads 9 release the left trigger & press sync
button.
6. The update will be confirmed with one flash of the decimal led.
Note.
When using this mod with Call of Duty 5, the pad will need to be in Mode 1 or Mode 5 otherwise the
rapid fire will be detected by the game, using any other Mode will activate the game patch and
decrease your fire rate, if you forget and play Call of Duty 5 in any other Mode you will need to reset
the game patch, to do this you will need to come out the game and then load back in. This mod will
not be detected when using Mode 1 or Mode 5.

You might also like