Professional Documents
Culture Documents
http://www.tp-link.com
FCC STATEMENT
This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures: Reorient or relocate the receiving antenna. Increase the separation between the equipment and receiver. Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. Consult the dealer or an experienced radio/ TV technician for help.
This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: 1) 2) This device may not cause harmful interference. This device must accept any interference received, including interference that may cause undesired operation.
Any changes or modifications not expressly approved by the party responsible for compliance could void the users authority to operate the equipment. Note: The manufacturer is not responsible for any radio or tv interference caused by unauthorized modifications to this equipment. Such modifications could void the users authority to operate the equipment.
CE Mark Warning
This is a class B product. In a domestic environment, this product may cause radio interference, in which case the user may be required to take adequate measures.
National Restrictions 2400.0-2483.5 MHz Country Bulgaria Restriction Reason/remark General authorization required for outdoor use and public service Outdoor use limited to 10 mW e.i.r.p. within the band 2454-2483.5 MHz Military Radiolocation use. Refarming of the 2.4 GHz band has been ongoing in recent years to allow current relaxed regulation. Full implementation planned 2012 If used outside of own premises, general authorization is required None General authorization required for network and service supply(not for spectrum) This subsection does not apply for the geographical area within a radius of 20 km from the centre of Ny-lesund Only for indoor applications
France
Italy
Luxembourg
Norway
Implemented
DECLARATION OF CONFORMITY
For the following equipment: Product Description: 54Mbps High Power Wireless Access Point Model No.: TL-WA5110G Trademark: TP-LINK We declare under our own responsibility that the above products satisfy all the technical regulations applicable to the product within the scope of Council Directives: Directives 1999/5/EC The above product is in conformity with the following standards or other normative documents ETSI EN 300 328 V1.7.1: 2006 ETSI EN 301 489-1 V1.8.1:2008& ETSI EN 301 489-17 V1.3.2:2008 EN 61000-3-2:2006 EN 61000-3-3:1995+A1:2001+A2:2005 EN60950-1:2006 Recommendation 1999/519/EC EN62311:2008 Directives 2004/108/EC The above product is in conformity with the following standards or other normative documents EN 55022:2006 +A1:2007 EN 55024:1998+A1:2001+A2:2003 EN 61000-3-2:2006 EN 61000-3-3:1995+A1:2001+A2:2005 Directives 2006/95/EC The above product is in conformity with the following standards or other normative documents EN60950-1:2006 Person is responsible for marking this declaration:
TP-LINK TECHNOLOGIES CO., LTD. South Building, No.5 Keyuan Road, Central Zone, Science & Technology Park, Nanshan,
Shenzhen, P. R. China
CONTENTS
Package Contents ................................................................................................................................. 1 Chapter 1 1.1 1.2 1.3 Product Overview...........................................................................................................2
Overview of the Product........................................................................................................... 2 Features ................................................................................................................................... 2 Conventions ............................................................................................................................. 3 Hardware Installation .....................................................................................................4
The Front Panel ....................................................................................................................... 4 The Rear Panel........................................................................................................................ 4 System Requirements.............................................................................................................. 5 Environment Requirements .....................................................................................................5 Connecting the Device............................................................................................................. 5 Quick Installation Guide ................................................................................................7
Configure the PC ..................................................................................................................... 7 Quick Setup ...........................................................................................................................10 AP Client Router & AP Router Operation Mode ........................................................15
Login ......................................................................................................................................15 Status .....................................................................................................................................15 Quick Setup ...........................................................................................................................17 Operation Mode .....................................................................................................................17 Network ..................................................................................................................................17 LAN.................................................................................................................................18 WAN ............................................................................................................................... 18 MAC Clone .....................................................................................................................23
Wireless .................................................................................................................................23 Basic Settings.................................................................................................................24 Wireless Mode................................................................................................................25 Security Settings ............................................................................................................27 MAC Filtering..................................................................................................................30 Wireless Statistics ..........................................................................................................32 Distance Setting .............................................................................................................32 Antenna Alignment .........................................................................................................33 Throughput Monitor ........................................................................................................34
DHCP .....................................................................................................................................34 DHCP Settings ...............................................................................................................35 DHCP Clients List...........................................................................................................36 Address Reservation ......................................................................................................36
4.8 4.9
Wireless settings....................................................................................................................38 Forwarding .............................................................................................................................38 Virtual Servers................................................................................................................39 Port Triggering................................................................................................................40 DMZ................................................................................................................................42 UPnP ..............................................................................................................................43
Security ..................................................................................................................................43 Firewall ...........................................................................................................................44 IP Address Filtering ........................................................................................................45 Domain Filtering .............................................................................................................46 MAC Address Filtering ...................................................................................................48 Remote Management.....................................................................................................49 Advanced Security .........................................................................................................50
Static Routing.........................................................................................................................52 IP & MAC Binding ..................................................................................................................53 Binding Setting ...............................................................................................................53 ARP List..........................................................................................................................55
Dynamic DNS ........................................................................................................................ 56 Dyndns.org DDNS..........................................................................................................56 Oray.net DDNS ..............................................................................................................56 Comexe.cn DDNS ..........................................................................................................57
System Tools .........................................................................................................................58 Time................................................................................................................................59 Firmware.........................................................................................................................60 Factory Defaults .............................................................................................................61 Backup & Restore ..........................................................................................................61 Ping Watch Dog .............................................................................................................62 Speed Test .....................................................................................................................62 Reboot ............................................................................................................................63 Password........................................................................................................................64 Syslog............................................................................................................................. 64 Statistics .....................................................................................................................65 AP Operation Mode ......................................................................................................67
4.14.1 4.14.2 4.14.3 4.14.4 4.14.5 4.14.6 4.14.7 4.14.8 4.14.9 4.14.10 Chapter 5 5.1 5.2 5.3 5.4 5.5
Login ......................................................................................................................................67 Status .....................................................................................................................................67 Quick Setup ...........................................................................................................................68 Operation Mode .....................................................................................................................69 Network ..................................................................................................................................69
II
5.6
Wireless .................................................................................................................................70 Basic Settings.................................................................................................................70 Wireless Mode................................................................................................................72 Security Settings ............................................................................................................77 MAC Filtering..................................................................................................................80 Wireless Statistics ..........................................................................................................82 Distance Setting .............................................................................................................83 Antenna Alignment .........................................................................................................83 Throughput Monitor ........................................................................................................84
DHCP .....................................................................................................................................84 DHCP Settings ...............................................................................................................85 DHCP Clients List...........................................................................................................86 Address Reservation ......................................................................................................86
Wireless settings....................................................................................................................88 System Tools .........................................................................................................................88 Firmware.........................................................................................................................89 Factory Defaults .............................................................................................................90 Backup & Restore ..........................................................................................................90 Ping Watch Dog .............................................................................................................91 Speed Test .....................................................................................................................91 Reboot ............................................................................................................................92 Password........................................................................................................................93 Syslog............................................................................................................................. 93
III
Package Contents
The following items should be found in your package: One TL-WA5110G 54Mbps High Power Wireless Access Point One power Adapter for TL-WA5110G 54Mbps High Power Wireless Access Point One Power Injector Mounting Kits Quick Installation Guide One Resource CD for TL-WA5110G 54Mbps High Power Wireless Access Point, including: This User Guide Other helpful information