You are on page 1of 8

www.jntuworld.

com

www.jwjobs.net

Code No: 56020 Set No. 1 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD III B.Tech. II Sem., II Mid-Term Examinations, April 2012 HEAT TRANSFER Objective Exam Name: ______________________________ Hall Ticket No. A I 1. Choose the correct alternative: The thickness of thermal and hydrodynamic boundary layer is equal than a) Pr=1 b)Pr>1 c)Pr<1 d)Pr=Nu [

Answer All Questions. All Questions Carry Equal Marks.Time: 20 Min. Marks: 10.

2.

In radiative heat transfer, a gray surface is one [ ] a) Which appears gray to the eye b) whose emissivity is independent of wavelength c) which has reflectivity equal to zero d) which appears equally bright from all directions For evaporators and condensers, for the given conditions, the logarithmic mean temperature difference for parallel flow is [ ] a) Equal to that for counter flow b) Greater than that for counter flow c) Smaller than that for counter flow d) Very less smaller than that for counter flow Dropwise condensation usually occurs on a) Glazed surface b) smooth surface

3.

4.

5.

The ratio of surface convection resistance to internal conduction resistance is [ a) Granshoff number b)Biot number c) Stanton number d)Prandtl number The burnout heat flux in the nucleate boiling regime is a function of [ a) Heat of evaporation b) Density of vapour and Density of liquid c)Vapour-liquid surface tension d) All The ratio of energy transferred by convection of that by conduction is called a) Stanton number b)nusselt number c) biot number In a parallel flow gas turbine recuperator, the maximum effectiveness is a) 100% b) 75% c) 50% d)< 50% In a shell and tube heat exchanger, baffles are provided on the shell side to a) Prevent the stagnation of shell side fluid b) improve heat transfer c) Provide support for tubes d) All

6.

7.

8.

T N

W U

R O

D L

c) oil surface

[ ] d) coated surface ]

[ ] d)preclet number [ ]

9.

10.

Suns surface at 5800 K emits radiation at a wavelength of 0.5. A furnace at 3000C will emit through a small opening, radiation at a wavelength of nearly [ ] a) 10 b) 5 c) 0.25 d) 0.025 Cont.2

www.jntuworld.com

www.jntuworld.com

www.jwjobs.net

Code No: 56020 II 11. Fill in the blanks Water at 200C, = 1.002 10 3 ________________ 12. 13. 14. 15.

:2:

Set No. 1

kg W kj , C p = 4.183 and k = 0.603 then Prandtl number is m.s kg.K m.K

Multiple pass heat exchangers is used ________________ Heat transfer in liquid and gases takes place by _____________ Thermal radiation extends over the range of _______________ When there is a flow of fluid over a flat plate of length l, the average heat transfer coefficient is ________________ Plancks law holds good for _____________

16. 17.

The value of logarithmic mean temperature for counter-flow heat exchanger as compared to parallel flow exchanger is___________ The ratio of the energy absorbed by the body to total energy falling on it is called as ___________ The rate of heat transfer from a solid surface to a fluid is obtained from_____________ The heat transfer takes place according to ___________law of thermodynamics

18. 19. 20.

T N

W U
-oOo-

R O

D L

www.jntuworld.com

www.jntuworld.com

www.jwjobs.net

Code No: 56020 Set No. 2 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD III B.Tech. II Sem., II Mid-Term Examinations, April 2012 HEAT TRANSFER Objective Exam Name: ______________________________ Hall Ticket No. A I 1. Choose the correct alternative: Dropwise condensation usually occurs on a) Glazed surface b) smooth surface

Answer All Questions. All Questions Carry Equal Marks.Time: 20 Min. Marks: 10.

c) oil surface

[ ] d) coated surface ]

2.

The ratio of surface convection resistance to internal conduction resistance is [ a) Granshoff number b)Biot number c) Stanton number d)Prandtl number The burnout heat flux in the nucleate boiling regime is a function of [ a) Heat of evaporation b) Density of vapour and Density of liquid c)Vapour-liquid surface tension d) All The ratio of energy transferred by convection of that by conduction is called a) Stanton number b)nusselt number c) biot number In a parallel flow gas turbine recuperator, the maximum effectiveness is a) 100% b) 75% c) 50% d)< 50% In a shell and tube heat exchanger, baffles are provided on the shell side to a) Prevent the stagnation of shell side fluid b) improve heat transfer c) Provide support for tubes d) All

3.

4.

5.

6.

7.

Suns surface at 5800 K emits radiation at a wavelength of 0.5. A furnace at 3000C will emit through a small opening, radiation at a wavelength of nearly [ ] a) 10 b) 5 c) 0.25 d) 0.025 The thickness of thermal and hydrodynamic boundary layer is equal than a) Pr=1 b)Pr>1 c)Pr<1 d)Pr=Nu

8.

T N

W U

R O

D L

[ ] d)preclet number [ ]

9.

In radiative heat transfer, a gray surface is one [ ] a) Which appears gray to the eye b) whose emissivity is independent of wavelength c) which has reflectivity equal to zero d) which appears equally bright from all directions For evaporators and condensers, for the given conditions, the logarithmic mean temperature difference for parallel flow is [ ] a) Equal to that for counter flow b) Greater than that for counter flow c) Smaller than that for counter flow d) Very less smaller than that for counter flow Cont.2

10.

www.jntuworld.com

www.jntuworld.com

www.jwjobs.net

Code No: 56020 II 11. 12. Fill in the blanks

:2:

Set No. 2

Thermal radiation extends over the range of _______________ When there is a flow of fluid over a flat plate of length l, the average heat transfer coefficient is ________________ Plancks law holds good for _____________ The value of logarithmic mean temperature for counter-flow heat exchanger as compared to parallel flow exchanger is___________ The ratio of the energy absorbed by the body to total energy falling on it is called as ___________ The rate of heat transfer from a solid surface to a fluid is obtained from_____________ The heat transfer takes place according to ___________law of thermodynamics Water at 200C, = 1.002 10 3 ________________

13. 14.

15. 16. 17.

18.

kg W kj , C p = 4.183 and k = 0.603 then Prandtl number is m.s kg.K m.K

19. 20.

Multiple pass heat exchangers is used ________________ Heat transfer in liquid and gases takes place by _____________

T N

W U
-oOo-

R O

D L

www.jntuworld.com

www.jntuworld.com

www.jwjobs.net

Code No: 56020 Set No. 3 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD III B.Tech. II Sem., II Mid-Term Examinations, April 2012 HEAT TRANSFER Objective Exam Name: ______________________________ Hall Ticket No. A I 1. Choose the correct alternative: The burnout heat flux in the nucleate boiling regime is a function of [ a) Heat of evaporation b) Density of vapour and Density of liquid c)Vapour-liquid surface tension d) All The ratio of energy transferred by convection of that by conduction is called a) Stanton number b)nusselt number c) biot number In a parallel flow gas turbine recuperator, the maximum effectiveness is a) 100% b) 75% c) 50% d)< 50%

Answer All Questions. All Questions Carry Equal Marks.Time: 20 Min. Marks: 10.

2.

3.

4.

In a shell and tube heat exchanger, baffles are provided on the shell side to a) Prevent the stagnation of shell side fluid b) improve heat transfer c) Provide support for tubes d) All

5.

Suns surface at 5800 K emits radiation at a wavelength of 0.5. A furnace at 3000C will emit through a small opening, radiation at a wavelength of nearly [ ] a) 10 b) 5 c) 0.25 d) 0.025 The thickness of thermal and hydrodynamic boundary layer is equal than a) Pr=1 b)Pr>1 c)Pr<1 d)Pr=Nu

6.

7.

In radiative heat transfer, a gray surface is one [ ] a) Which appears gray to the eye b) whose emissivity is independent of wavelength c) which has reflectivity equal to zero d) which appears equally bright from all directions For evaporators and condensers, for the given conditions, the logarithmic mean temperature difference for parallel flow is [ ] a) Equal to that for counter flow b) Greater than that for counter flow c) Smaller than that for counter flow d) Very less smaller than that for counter flow Dropwise condensation usually occurs on a) Glazed surface b) smooth surface [ ] d) coated surface ]

8.

T N

W U

R O

D L

[ ] d)preclet number [ ]

9.

c) oil surface

10.

The ratio of surface convection resistance to internal conduction resistance is [ a) Granshoff number b)Biot number c) Stanton number d)Prandtl number Cont.2

www.jntuworld.com

www.jntuworld.com

www.jwjobs.net

Code No: 56020 II 11. 12. Fill in the blanks Plancks law holds good for _____________

:2:

Set No. 3

The value of logarithmic mean temperature for counter-flow heat exchanger as compared to parallel flow exchanger is___________ The ratio of the energy absorbed by the body to total energy falling on it is called as ___________ The rate of heat transfer from a solid surface to a fluid is obtained from_____________ The heat transfer takes place according to ___________law of thermodynamics Water at 200C, = 1.002 10 3 ________________

13. 14. 15. 16.

kg W kj , C p = 4.183 and k = 0.603 then Prandtl number is m.s kg.K m.K

17. 18. 19. 20.

Multiple pass heat exchangers is used ________________

Heat transfer in liquid and gases takes place by _____________ Thermal radiation extends over the range of _______________

When there is a flow of fluid over a flat plate of length l, the average heat transfer coefficient is ________________

T N

W U
-oOo-

R O

D L

www.jntuworld.com

www.jntuworld.com

www.jwjobs.net

Code No: 56020 Set No. 4 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD III B.Tech. II Sem., II Mid-Term Examinations, April 2012 HEAT TRANSFER Objective Exam Name: ______________________________ Hall Ticket No. A I 1. Choose the correct alternative: In a parallel flow gas turbine recuperator, the maximum effectiveness is a) 100% b) 75% c) 50% d)< 50% In a shell and tube heat exchanger, baffles are provided on the shell side to a) Prevent the stagnation of shell side fluid b) improve heat transfer c) Provide support for tubes d) All [

Answer All Questions. All Questions Carry Equal Marks.Time: 20 Min. Marks: 10.

2.

3.

Suns surface at 5800 K emits radiation at a wavelength of 0.5. A furnace at 3000C will emit through a small opening, radiation at a wavelength of nearly [ ] a) 10 b) 5 c) 0.25 d) 0.025 The thickness of thermal and hydrodynamic boundary layer is equal than a) Pr=1 b)Pr>1 c)Pr<1 d)Pr=Nu

4.

5.

In radiative heat transfer, a gray surface is one [ ] a) Which appears gray to the eye b) whose emissivity is independent of wavelength c) which has reflectivity equal to zero d) which appears equally bright from all directions For evaporators and condensers, for the given conditions, the logarithmic mean temperature difference for parallel flow is [ ] a) Equal to that for counter flow b) Greater than that for counter flow c) Smaller than that for counter flow d) Very less smaller than that for counter flow Dropwise condensation usually occurs on a) Glazed surface b) smooth surface

6.

7.

T N

W U

R O

D L

c) oil surface

[ ] d) coated surface ]

8.

The ratio of surface convection resistance to internal conduction resistance is [ a) Granshoff number b)Biot number c) Stanton number d)Prandtl number The burnout heat flux in the nucleate boiling regime is a function of [ a) Heat of evaporation b) Density of vapour and Density of liquid c)Vapour-liquid surface tension d) All The ratio of energy transferred by convection of that by conduction is called a) Stanton number b)nusselt number c) biot number

9.

10.

[ ] d)preclet number Cont.2

www.jntuworld.com

www.jntuworld.com

www.jwjobs.net

Code No: 56020 II 11. 12. 13. Fill in the blanks

:2:

Set No. 4

The ratio of the energy absorbed by the body to total energy falling on it is called as ___________ The rate of heat transfer from a solid surface to a fluid is obtained from_____________ The heat transfer takes place according to ___________law of thermodynamics Water at 200C, = 1.002 10 3 ________________

14.

kg W kj , C p = 4.183 and k = 0.603 then Prandtl number is m.s kg.K m.K

15. 16. 17. 18.

Multiple pass heat exchangers is used ________________ Heat transfer in liquid and gases takes place by _____________ Thermal radiation extends over the range of _______________

When there is a flow of fluid over a flat plate of length l, the average heat transfer coefficient is ________________ Plancks law holds good for _____________

19. 20.

The value of logarithmic mean temperature for counter-flow heat exchanger as compared to parallel flow exchanger is___________

T N

W U
-oOo-

R O

D L

www.jntuworld.com

You might also like