ELECTRONICS & ELECTRICAL ENGINEERING (Year-2013-14) Max Marks: 50
Q.1 (a) Explain the following pins: ALE, RST, PSEN (06) (b) Explain following registers with respect to 8051 microcontroller TMOD, TCON
(06) OR Q.2 (a) Write short note on SFR. (06) (b) Differentiate between serial communication & parallel communication in 8051 microcontroller. (06)
Q.3 (a) A three-phase, 4 pole, 75kW, 600V, 60Hz induction motor runs at 1763 r.p.m. on full load. The stator losses are 5kW and mechanical losses are 1.2kW. Calculate: 1) Rotor copper loss per phase 2) Mechanical power developed 3) Efficiency of motor
(06) (b) Derive torque equation of D.C. Shunt motor (07) OR Q.4 (a) A 200V d.c. series motor is running at a speed of 800 r.p.m. & draws 100 Amp. Calculate the speed of the motor when it develops half the torque. The armature resistance is 0.06 ohm and that of field is 0.04 ohm and magnetic field is unsaturated. (06) (b) Define slip of induction motor. Explain the effect of slip on the following rotor parameters i) Frequency ii) Power Factor iii) Impedance (07)
Q.5 (a) Draw the block diagram & explain the working of basic electronic voltmeter. State its advantages. (06) (b) Compare analog and digital instruments. (06)
OR
Q.6 (a) Draw the Wein bridge oscillator using op-amp and explain its operation. State its advantages. (06) (b) Draw the block diagram of simple C. R. Oscilloscope & explain its various blocks in brief. (06)
Q.7 (a) Two wattmeters are connected to measure total input power in a three phase, star connected balanced inductive load circuit. Draw the neat connection diagram & derive the equation for reading on each wattmeter (07) (b) A Schering bridge has the following particulars: Arm AB-The unknown capacitance to be measured. BC- resistance of 20k CD- 1 k resistance in parallel with a capacitance of 200 pF DA- Standard Capacitor of 0.05 F Calculate the capacitance and loss angle at frequency of 1 kHz. (06) OR Q.8 (a) Derive general bridge balance equation with diagram. What are different types of detectors used in A. C. bridges? (06) (b) Write short note on A.C. and D.C. potentiometer. (07)