Professional Documents
Culture Documents
=0.7V. The mode of operation of the BJT in the accompanying figure is:
#10. Determine the voltage output (Vo) of the op-amp in the accompanying figure in terms of V1 and V2.
#11*. An amplifier using an op amp with slew rate=1V/s has a gain of 40 dB. If the amplifier has to faithfully
amplify the signal from DC to 20 kHz without any distortion, then the signal amplitude should not exceed what
maximum value?
#12. Determine voltage (
) for the circuit in the accompanying figure assuming both diodes to be made up of
Silicon.
#13*. Given a train of n equally spaced pulses, the first at t = 0 and the last at t = (n 1) T.
(a) Draw a logic system which will deliver only one pulse at t = 0. HINT: Use a delay and an inhibitor.
(b) Repeat the same for a system which will deliver a single pulse at t = n T.
#14. Find the current flowing through the 2K resistor in the accompanying network.
1k
10Vdc
0
1k 1k
10Vdc
2k 1k
#15*. In the accompanying figure is shown a network in which a steady state is reached with the switch open. At t =
0, the switch is closed. For the element values given, determine the values of v
a
(0-) and v
a
(0+)
R6
20 ohms
V2
DC = 5v
Va
R7
10 ohms
Vb
0
C1
2F
U1
TCLOSE = 0
1
2
R3
10 ohms
R4
10 ohms