1.1 Design Condition Effort force at the end of the arm or handle F = 322.3 Weight or load Q = 11023.1 Pitch distance or lead of thread in one turn P = 0.2 Pitch radius of screw r = 0.8 lever-arm radius R = 2.4 1.2 The effort force for a screw jack when neglecting friction can be expressed as F = 146.1986 kg Doc. No : W.O : Revision No : B Sheet : 1 lb 146.1986 kg.mm lb 5000 kg in 5 mm in 20 mm in 60 mm allowable stress : 2/3 of yield strength or about 1/4 of ultimate tensile strength Ultimate tensile strength, 58-80ksi 400-550 MPa Yield point, min., 36 KSI 250MPa Source(s): ASME II Part A 166.6667 SCREW JACKS CALCULATION 1. Calculate screw jacks effort force 1.1 Design Condition Effort force at the end of the arm or handle F = 464.1 Weight or load Q = 11023.1 Pitch distance or lead of thread in one turn P = 0.2 Pitch radius of screw r = 0.8 lever-arm radius R = 2.0 Motor speed N = 1400.0 Linier speed v = 15.7 Length of moving L = 39.4 Rotation of Screw N1 66.7 Gear Ration Rt 21.0 Time of rotaion t = 2.5 1.2 The effort force for a screw jack when neglecting friction can be expressed as F = 210.526 kg Doc. No : W.O : Revision No : B Sheet : 1 lb 210.526 kg.mm 0.210526 kg.m lb 5000 kg in 6 mm in 20 mm in 50 mm rpm in/m 400 mm/m in 1000 mm rpm menit allowable stress : 2/3 of yield strength or about 1/4 of ultimate tensile strength Ultimate tensile strength, 58-80ksi 400-550 MPa Yield point, min., 36 KSI 250MPa Source(s): ASME II Part A 166.6667 SCREW JACKS CALCULATION 1. Calculate screw jacks effort force 1.1 Design Condition Weight or load Q = 29.4 Lifting Screw lead Ls = 1000.0 Pitch distance or lead of thread in one turn P = 8.0 Time of rotaion t = 2.5 Raise Rate P = 400.0 Rotation of Screw N = 50.0 Rotation of Motor Nm = 1400.0 Gear Ration Rt = 28.0 1.2 Operating Input Power Input Power = 0.7 1.3 Operating Input Torque Input Torque = 136.1 1.4 Actuator Start-Up Torque Start-Up Torque = 6.4 Doc. No : W.O : Revision No : B Sheet : 1 Kn 3000 kg mm mm menit mm/M rpm rpm Kw Nm Nm allowable stress : 2/3 of yield strength or about 1/4 of ultimate tensile strength Ultimate tensile strength, 58-80ksi 400-550 MPa Yield point, min., 36 KSI 250MPa Source(s): 166.6667
The Turning Movement of a Particle About the Axis of Rotation is Called the Angular Momentum of the Particle and is Measured by the Product of the Linear Momentum and the Perpendicular Distance of the Line of Action From the Ax