1 Purpose This LESER Global Standard (LGS) shows the process for safety valves to repair.
2 Scope This LGS applies to all members of the LESER Quality Cluster.
3 Introduction The following flow chart shows the process steps, which are necessary for valve repair.
The right side give references to forms of inspection documentation, LESER standards, instructions and spare part lists.
LGS_1111 LESER Global Standard Process for Safety Valves to Repair Page 2/2
disclosure cat.: II proofread: OR published date: 17.11.10 effect. date: 18.11.2010 author: Niehus released by: KUW replaces: initial status: valid resp. depart.: PP date of release: 8.11.10 revision No.: 0 doc. type: LGS change rep. No.: 00651A retention period: 10y
p r o t e c t e d
4 Safety valve to repair
valve forwarded visually inspection disassembling report 1.1 visually inspection inside parts assembling instruction (LLS...) report 1.2 cleaning good parts original spare parts finishing (if necessary) Assembling instruction catalogue assembling the valve setting of the valve tighness test assembling instruction (LLS) AA-EF and LWN 220-01-0-EN type test approval plate / or customer identfication plate assembling (if assembling instruction (LLS) AA-EF-080 and LWN 201-01-EN paint finish visually inspection delivery to customer assembling instruction (LLS) material safety data sheets assembling instruction (LLS...) report 1.4 assembling instruction to cleaning good parts (LLS) assembling instruction to finishing report 1.3