You are on page 1of 1

Summary

Nodal analysis, defined as a systems approach to the optimization of oil andgas wells, is used to evaluate
thoroughly a complete producing system. Everycomponent in a producing well or all wells in a producing system
can beoptimized to achieve the producing system can be optimized to achieve theobjective flow rate most
economically. All present components-beginning withthe static reservoir pressure, ending with the separator, and
includingpressure, ending with the separator, and including inflow performance, as wellas flow across the
completion, up the tubing string (including any downholerestrictions and safety valves), across the surface choke
(if applicable),through horizontal flow lines, and into the separation facilities-areanalyzed.
Introduction
The objectives of nodal analysis are as follows.
1. To determine the flow rate at which an existing oil or gas well willproduce considering wellbore geometry and
completion limitations (first bynatural flow).
2. To determine under what flow conditions (which may be related to time) awell will load or die.
3. To select the most economical time for the installation of artificiallift and to assist in the selection of the
optimum lift method.
4. To optimize the system to produce the objective flow rate mosteconomically.
5. To check each component in the well system to determine whether it isrestricting the flow rate unnecessarily.
6. To permit quick recognition by the operator's management and engineeringstaff of ways to increase production
rates. production rates. There arenumerous oil and gas wells around the world that have not been optimized
toachieve an objective rate efficiently. In fact, many may have been completed insuch a manner that their
maximum potential rate cannot be achieved. Also, manywells potential rate cannot be achieved. Also, many wells
placed on artificiallift do not achieve the efficiency placed on artificial lift do not achieve theefficiency they should.
The production optimization of oil and gas wells by nodal systems analysishas contributed to improved
completion techniques, production, and efficiencyfor many wells. Although this type of analysis was proposed by
Gilbert in 1954.it has been used proposed by Gilbert in 1954. it has been used extensively inthe U.S. only in the
last few years. One principal reason for this was thechanging of allowable producing rates, and another has been
the developmentproducing rates, and another has been the development of computer technologythat allows rapid
calculation of complex algorithms and provides easilyunderstood data.

You might also like