Professional Documents
Culture Documents
Testing Laboratory
of
Ferromagnetic materials,
parts and fabrications,
including weldings
Ferromagnetic steel
forgings
BS EN 10228-1: 1999
Ferromagnetic cast
products
BS EN 1369: 1997
Founding- Magnetic particle inspection
BS EN 571-1:1997
12.9.2011
Materials / Products to be
tested
Parts and Fabrications,
including Weldings
Welds of Metallic
Materials
Steel Forgings
BS EN 10228-2:1998
Non-Destructive Testing of Steel ForgingsPart 2: Penetrant Testing
BS EN 1371-1:1997
Founding. Liquid Penetrant Inspection.
Part 1: Sand, gravity die and low pressure die
castings
Ultrasonic testing
BS EN 583-1: 1999
Non-Destructive Testing-Ultrasonic
Examination-Part 1: General Principles
ELOT EN 1714: 1997
ELOT EN 1714/1: 2002
ELOT EN 1714/2: 2005
Non-Destructive Examination of WeldsUltrasonic Examination of Welded Joints
ELOT EN 1712: 1997
ELOT EN 1712/1: 2002
ELOT EN 1712/2: 2005
Non-Destructive Examination of WeldsUltrasonic Examination of Welded JointsAcceptance Levels
ELOT EN 1713: 1998
ELOT EN 1713/1: 2002
ELOT EN 1713/2: 2005
Non-Destructive Examination of WeldsUltrasonic Examination-Characterization of
Indications in Welds
Welds of Metallic
Materials (cont.)
Metallic Plates
Ultrasonic Thickness
Measurement
Page 2 of 4
12.9.2011
Materials / Products to be
tested
Welds of Metallic
Materials
BS EN 444: 1994
Non-Destructive TestingGeneral Principles for Radiographic
Examination of metallic materials by X and
gamma rays
ASME : 2010 Boiler and Pressure Vessel
Code.
Section V, Non Destructive Examination.
Article 2 : Radiographic Examination
ISO 5579 :1998
Non Destructive TestingRadiographic Examination of Metallic
MaterialsGeneral Rules
ASTM E 94: 2004 (2010)
Standard Guide for Radiographic
Examination
ASTM E 1032: 2006
Standard Test Method for Radiographic
Examination of Weldings
BS EN 1435: 1997
Non Destructive Examination of WeldsRadiographic Examination of Welded Joints
Mechanical tests
Welds,
Plates
Welds,
Plates
Macrography
(detection of discontinuities by
visual inspection)
Fillet welds
Welds,
Plates
Fracture test
(detection of discontinuities by
visual inspection)
Bending
(detection of discontinuities by
visual inspection)
Site of assessment: Permanent laboratory premises, Patima, GR-196 00 Mandra, Attiki, Greece.
Approved signatories: Pan. Golfinopoulos.
This Scope of Accreditation replaces the previous one dated 29.4.2011.
The Accreditation Certificate No. 124-4, to ELOT EN ISO/IEC 17025: 2005, is valid until 5.3.2015.
Page 3 of 4
12.9.2011
Page 4 of 4
12.9.2011