Subject : Chemistry QUIZ-(Unit 3)(first set) Total 20 questions
1. Octane number helps to check the quality of:
(a) Petrol (b) Diesel (c) Petrol and Diesel (d) None of the above 2. The purest quality of coal is (a) lignite (b)peat (c) anthracite (d) none of these 3. Water gas is a mixture of: (a) N2+CO (b) N2+ H2 (c) H2 +CH4 (d) CO+ H2 4. Lowest moisture and highest carbon content is present in (a) Peat (b) Lignite (c) Anthracite (d) Bituminous coal 5. Fermentation of alcohol is possible by (a) Starch (b) Molasses (c) Both (d) None 6. Condition for fermentation is (a) High temperature (b) Very low temperature (c) 25-35 0C 7. Bomb calorimeter is used to calculate the _________ of a solid fuel 8. Condition for highest octane number are (a) Long chain (b) Low degree of branching (c) High degree of braching 9. 18. A biochip can perform (a) Thousands of simultaneous biochemical reaction at a time
(b) One biochemical reaction at a time
10. Octane number helps to check the quality of: (a) Petrol (b) Diesel (c) Petrol and Diesel (d) None of the above 11. The purest quality of coal is (a) lignite (b)peat (c) anthracite (d) none of these 12. Water gas is a mixture of: (a) N2+CO (b) N2+ H2 (c) H2 +CH4 (d) CO+ H2 13. Lowest moisture and highest carbon content is present in (a) Peat (b) Lignite (c) Anthracite (d) Bituminous coal 14. Fermentation of alcohol is possible by (a) Starch (b) Molasses (c) Both (d) None 15. Condition for fermentation is (a) High temperature (b) Very low temperature (c) 25-35 0C 16. Bomb calorimeter is used to calculate the _________ of a solid fuel 17. Condition for highest octane number are (a) Long chain (b) Low degree of branching (c) High degree of braching 18. Prevention of Diesel knocking a) By using Diesel containing more straight chain hydrocarbon (b) By using Diesel containing more branched chain hydrocarbon (c) By using Diesel containing more cyclic compounds 19% nitrogen in a fuel can be determined by: (a) Proximate analysis (b) Ultimate analysis
(c)Proximate and utlimate analysis
(d)None of the above
20. Producer gas is a mixture of:
(a) N2+CO (b) N2+ H2 (c) H2 +CH4 (d) CO+ H2 21. Characteristics of a good fuel (a) Low calorific value (b) High ignition temperature (c) Both (d) None 22. 1 calorie is how many joules (a) 4.184 (b) 4.184 10 3 (c) 4.184 10 7 23. Fermentation of alcohol is possible by (a) Starch (b) Molasses (c) Both (d) None 24. Composite material consists of two components matrix phase and disperse phase (a) True (b) False 25. Condition for fermentation is (a) High temperature (b) Very low temperature (c) 25-35 0C 26. Secondary fuel is (a) Coal (b) Lignite (c) LPG (d) Natural Gas 27. Transducer is used to convert non electrical signal to ________ signal 28. Addition of alcohol or ether in petrol (a) Will increase the octane rating (b) Will decrease the octane rating 29. Out of the following compounds which has zero octane number (a) Heptane (b) (2, 2, 4)-trimethyl pentane (c) Cyclohexane 30. Catalytic cracking involves large molecule breaks down into several smaller ones (a) True (b) False
31. Scope and use of biotechnology is to generate economic benefit, including
improved plants and animals (a) True (b) False 32. Fiber reinforced composite (a) Have high specific strength and high specific modulus (b) Have high specific strength and low specific modulus (c) Have low specific strength and high specific modulus (d) Have low specific strength and low specific modulus 33. Single fiber counterparts are better than hybrid composites (a) True (b) False 34. Composite materials are better than conventional material (a) Low density and more stiffness (b) Low density and low stiffness (c) More density and more stiffness (d) More density and low stiffness 35. E10 fuel contains (a) 10 % ethanol and 90% petrol (b) 10 % petrol and 90 % ethanol 36. Biomass refers to any fuel that has been derived from biofuel (a) True (b) False 37. Biodiesel is a (a) Biochip (b) Biosensor (c) Biofuel 38. E20 fuel contains (a) 20% ethanol and 80% petrol (b) 20 % petrol and 80 % ethanol
39. Alcohol is used as biofuel mostly in
(a) India (b) Japan (c) Brazil (d) USA 40 .Composite materials are classified based on: (a) Type of matrix (b) Size-and-shape of reinforcement (c) Both (d) None 41. Usually softer constituent of a composite is (a) Matrix (b) Reinforcement (c) Both are of equal strength (d) Cant define 42. Effect of adding particulates to matrix material a. Surface hardness is increased b. Performance at elevated temperature is increased c. Both are correct d. none is correct 43. Mechanical properties of fiber-reinforced composites depend on (a) Properties of constituents (b) Interface strength (c) Fiber length, orientation, and volume fraction (d) All the above 44. Example of laminar composite is Plywood a. True
b.False
45. Biochip is one of the major applications of
(a) Software technology (b) Biotechnology (c) Geophysics (d) Radiology 46. Major load carrier in dispersion-strengthened composites (a) Matrix (b) Fiber (c) Both (d) Cant define 47. Usually stronger constituent of a composite is (a) Matrix (b) Reinforcement (c) Both are of equal strength (d) Cant define 48. Al-alloys for engine/automobile parts are reinforced to increase their
(a) Strength (b) Wear resistance (c) both (d) none
49. A vaccine produced by biotechnology is Penicillin