Professional Documents
Culture Documents
2.2
Attachment 1
Testing Items and Specification Values for the Third Generation Mobile
Telecommunication Femtocell Access Point (WCDMA FDD) Radio Frequency
Equipment
Ite
ms
Testing Items
Frequency Bands
Specification Value
Receiver bandwidth from 1920 to 1980MHz; transmitter
bandwidth from 2110 to 2170 MHz
Maximum Output
Power
Frequency error
With test
report
With test
report
Remarks
With test
Under the normal condition:
report
The rated maximum output power is 20dBM, where the
tolerance range of the measurement value and suppliers rated
value is within 2.7dB.
With test
0.25ppm
report
Spectrum emission The specification value of the spectrum emission mask is shown With test
report
mask
as the attached table 1.
Adjacent Channel
Leakage Ratio
(ACLR)
With test
report
With test
report
The carrier level for transmitting intermodulation shall not With test
report
exceed the specification value of radiated spurious emission
(RSE) (for modulated interference signal lower than the main
signal at 30dB carrier level, its frequency differed from the
main
signal
can
only
differ
within
5MHz10MHz15MHz). Any interference outside the
transmitter bandwidth within 2110 to 2170 MHz is not under
the consideration.
Home BS output According to the configuration listed in attached table 3-1, the With test
report
power for adjacent specification value must be in compliance with the specification
channel protection value in attached table 3-2, whereas the maximum output power
shall be listed within the specification value 2.7dB listed in
attached table 3-2.
Attached Table 1
Frequency offset of
station
measurement filter-
(BS)
3dB point, f
Maximum level
Measurement
bandwidth
maximum
output
power, P
P 20
-20.5 dBm
30 kHz
dBm
30 kHz
-32.5 dBm
30 kHz
-19.5 dBm
1 MHz
-23.5 dBm
1 MHz
6P20
P 54.5dBm
1 MHz
-48.5 dBm
1 MHz
dBm
P<6 dBm
Remarks:
f_offsetmax: Between 12.5 MHz and the center carrier frequency from 2110 to 2170 MHz, the one that
has a bigger frequency deviation.
fmax: f_offsetmax half amount of the measurement bandwidth.
Attached Table 2
Maximum level
Measurement Bandwidth
9kHz 150kHz
- 36 dBm
1 kHz
150kHz 30MHz
- 36 dBm
10 kHz
30MHz 1GHz
-36 dBm
100 kHz
-30 dBm
1 MHz
-15 dBm
1 MHz
-30 dBm
1 MHz
Remarks
Remarks:
Fc1: the first transmitted center carrier frequency.
Fc2: the last transmitted center carrier frequency.
Attached Table 3-1
Test Parameters of the Home BS Output Power for Adjacent Channel Protection
Testing
Environment
c (dBm)
CPICH E
Ioh (dBm)
-80
-50
-90
-60
-100
-70
-100
-50
Specification Value of the Home BS Output Power for Adjacent Channel Protection
Input Conditions
Output Power
c +43dB
Ioh > CPICH E
c -105dBm
and CPICH E
+10dBm
c +43dB
Ioh CPICH E
c -105dBm
and CPICH E
c +100dB))
max(8 dBm, min(20dBm, CPICH E
Remarks:
c : the code power of adjacent channels common pilot channel.
CPICH E
Ioh: received power density including the signal and interferences; however, the signal of the object to
be measured is excluded.