Professional Documents
Culture Documents
Contents
1 Focus on commandline
2 Lines
3 Circles
4 Other commands
4.1 DRAW CMD:
4.2 ZOOM CMD:
4.3 EDIT CMD:
4.4 DIMENSION CMD:
4.5 TOOL CMD:
4.6 MODIFY CMD:
4.7 SNAP CMD:
4.8 SELECTION CMD:
Focus on commandline
Press Space bar or Ctrl-m to put the user input focus on the command line, where you can type in 'common'
short-cut key commands.
Some users may prefer to use ' keyboard' shot-cuts - see below:
Lines
For example entering ' l ' or ' li ' in the commandline will execute the line tool ' Line with two points ' . specify first
point > specify next point.
Circles
For example entering ' ci ' or ' circle ' in the commandline will execute the Circle tool > Specify centre > specify
radius.
Other commands
DRAW CMD:
wiki.librecad.org/index.php/Commands_and_tools_-_using_the_command_line
1/3
04/10/13
DrawPoint
po, point
DrawLine
l, li, line
DrawPolyline
polyline
DrawLineParallel
DrawArc3P
a, arc
DrawCircle
ci, circle
text
ZOOM CMD:
ZoomRedraw zr, rg, regen, zoom - redraw
ZoomWindow zw, zoom - window
ZoomAuto
ZoomPan
EDIT CMD:
EditUndo
u, undo
EditRedo
r, redo
EditKillAllActions k, kill
DIMENSION CMD:
DimAligned
DimLinear
TOOL CMD:
ToolRegenerateDimensions dimregen
MODIFY CMD:
wiki.librecad.org/index.php/Commands_and_tools_-_using_the_command_line
2/3
04/10/13
ModifyTrim
ModifyTrim2
ModifyMove
ModifyBevel
EditRedo
SNAP CMD:
SnapFree
SnapGrid
SnapEndpoint
SnapMiddle
SnapOnEntity
SELECTION CMD:
DeselectAll tn, deselect - all
Retrieved from "http://wiki.librecad.org/index.php?title=Commands_and_tools__using_the_command_line&oldid=745"
This page was last modified on 31 October 2012, at 12:45.
This page has been accessed 8,277 times.
Content is available under Creative Commons Attribution Share Alike.
wiki.librecad.org/index.php/Commands_and_tools_-_using_the_command_line
3/3