You are on page 1of 14

,-V',

'\

NOTICE
SUB:- QRS/SPECIFICATIONIN RIO ROVERVEHICLE
This is general information ofthe firms/manufacturers dealing with the light
motor vehicle(4x2,4x4) that mentioned QRs as per appendix-"A" & Provision .for
Fixing, Installing Telecommunication
Equipments as per appendix- "B" enclosed
,
With Drawing have been framed by board of officer of sub group of CAPF.All the
1
interested vendors/firms are requested
to go through the same and give their
,
comments/suggestions. if any by.07-01-15 on e.maillD .Itcelldelhi@ITBP.Gov-in

2. A hard copy of suggestion may also be sent in Fax no.(011-26046834) To Dy.


Inspector General, SHQ(DELHI)I ITBPOLICE
MHA/Govt. Of India. Po- Madangir
.
Tigri Camp New Delhi 110062 ,so as to reach this office byt5'-01-15.

Ii

II

II!
I

\
I
1
I

It
I'

Appendix "A"

O.R.lSpecification

& Trial Directives

in R/o Rover Vehicles

.w
S.No Parameter

General

Engine

Clutch

rransmission

O.R.lSnecification
i) The vehicle primarily be used fo
providing effective communication between
carcade /convey and also up to base station
(i.e. Coy/unit HQ.Other estt. etc.)
ii) Vehicles should be Light Motor Vehicle
4X2 / 4X4 wheel drive meeting latest CMVR
norms. (user to decide as per their
reauirement & area of deolovmentl
Engine should be direct injection common
rail turbo charged diesel engine with
provision of overheat protection and to
prevent seizure of engines in extreme cold
condition, engine shall meet at least 8S.11I
or better (user to specify as per their area
of deployment) emission norms prescribed
in latest CMVR with modification &
applicable to special purpose vehicles
wherever
required
confirming
to
ARAI/SAE/VRDE standard
max gross
power not less than SOkw, Torque not less
170 NM in between 1000-2200 RPM.
OR
Petrol engine MPFI with provision of
overheat protection & to prevent seizure of
engine in extreme cold conditions. Engine
shall meet at least 8S-11Ior better(user to
specify as per their area of deployment) &
above emission norms prescribed in latest
CMVR, with modification & applicable to
special
purpose
vehicles
wherever
required
conforming
to
ARAI/SAE
standard. max gross power not less than
70kw Torque not less 130NM @ 10002800RPM.
(Note:- Diesel/Patrol engine- user to decide
as per reauirement & area of deployment.)
Sin!!le Plate drv friction tvDe
i) Minimum S speed manual.
ii) Type synchromesh in all fwd gears &
constant mesh in reverse gear.
iii) No of gear minimum S forward & one
reverse.

Steerin!!

Suspension

8rakes

Tyres

Power steerin!!
Front-Independent Suspension along with
anti roll bar, telescopic shock absorber
Rear-semi elliptical spring telescopic shock
absorber
i) Service brake-Tandem Master Cylinder
vacuum assisted with anti-lock brake
system.
ii) Front-Ventilated Disc/drum.
iii) Rear- Disc/Drum Type
i) Radial Tubeless Tyres and provision
with fitting customized non-skid chain.
ii) Provision for spare wheel.

Suggestions/comments

,.
' .

I:

Fuel tank
capacity
10 Turning Rad.
11 Ground
clearance
12 Grade ability
13 Piston
Displacement
14 Overall
dimensions

15

Load body

16

Seats

17
18

Speed
Special
Feature

19

Not more than 07 mtrs.


Minimum 190
Min 30 degree & side slope sustaining
capabilitv at least max 15 de"ree.
1200-3000cc
i) Length 3900mm-6000mm
ii) Width 1500mm-2000mm
iii) Height 1700mm-2000mm
iv)wheel base 2400mm-2900mm
where telecom equipments need to be
installed minimum area length 1600mm
width 1500mm
Seats for four person(R.O. 02, R.T.01 &
Runner with weapon 01) & all seats
provided with safety seat belts.
a) Not less than 90kmph fully loaded on.
Provision for Toe- Hooks & Di)
shackles at front & rear.
i) Cold starting facility and able to operate
on Sub Zero level temperature up to -40'C
ii) Bracket arrangement for fitting
GPS/Fire Extinguishers etc.
a) Provision with tool kit rack, mechanical
jack, Shovel 01, Pick axis 01, Toe Wire 01
workshop manual & service manual.
b) Proper & secured place for keeping
Stove with K oil should be provided ..
c) . In addition to abdve space for keeping
J
Dry Ration, rice, dal etc provision should be
provided.
Supplier to impart training to force
personnel for operation and maintenance
of the vehicle.
Logistic support package shall be provided
workshop
repair
manual.
including
illustrated parts catalogue operation and
maintenance manual.
After sale service to be provided on
requirement along with supply of spare
parts, maintenance parts should be readily
available for 15 years from the date of
purchase.
will provide
guarantee
for
Supplier
maintaining the vehicle for three year with
further extended warranty for the next five
year rates for such warranty should be
quoted in offer as of cost.
j

Facilities &
Equipments
Required

20

Documents
and tools

21

Training

22

Logistics

23

After sale
service

24

Not less than 50 Itrs

Warranty

(
Appendix "B"
1- PROVISION FOR FIXING, INSTALLINGFOLLOWINGTELECOMMUNICATION EQUIPMENTS :S.NO
1

PARTICULARS
IQtv
Mounting Bracket of HF TX / Rx LHP01
26SD

Mounting Bracket of Mobile data


equipment(SMART)

01

Provision for Printer LX800DX (will


be fitted with well crow sten)
Provision for VHF set 25watt (will be
fitted on mountin. bracket1
ISATphone (it is hand held but can
be fitted on ducking unit for use with
external antenna 1
provision for fitting of Vehicular
antenna for LHP-265D(rear side of
the vehicle)
Battery Bank of 12V 65AHC SMF
VRLABtvs.
AC/DC Gen set EM6S0 Honda/

01

4
5

7
8

Wei~ht (K.1
OSkg (+ 10kg for HF TX / Rx
LHP-265D1
=15 k.
05 kg (+ 4.4 kg for Mounting
data equipment (SMART)
will be fitted on mounting
trav1
= 9.4 k.
04kg

01

03kg

01

03

90kg

01

03kg

01

20 kg

"'uouestions 'comments

OR/soecifications

a) No unfinished joint are left open without finding and


burning.
b) Any supporting reinforcement from inside to protect from
inside to protect the vehicle against any side damage.
c) All electrical wiring harness should be properly secured &
have safe roof.
for fitting latest wireless
and radio
d) .Provision
communication.
e) Fitting of the telecommunication equipment should be such
that it prevent the entry of dust and particles into the system.
sufficient
space
should
be provided
so
that
&
telecommunication equipment be fitted easily.
f) Proper space for battery box with provisioo of sliding
(accommodating three batteries and printer will he placed)
g) Propel' space for AC/DC Gen Set EM-650.

kirloskar etc.

Dimensions:S.NO

PARTICULARS

1
2
3
4
5
6

Lower racklfibre/wooden 1
UDDerracklfibre/wooden 1
LHD-265 with mountin. trav
SMARTwith mountin. trav
Printer
EM-650 Gen Set

LENGTH
rmm)
1000-1020
1000-1020
263-283
305-315
430-440
410-420

7
8

Seat-l for
Seat-2 for

1000-1020
1000-1020

001'.
001'.

and co-onr.
and co-onr.

BREATH
rmm)
600-610
400-410
231-241
305-315
315-325
270-280

HEIGHT
. rmm1
300-310
150-150
150-160
210-215
158-165
375385

WEIGHT/
HEIGHT FROM FLOOR
7S0mm above from the
floor of veh.
8ke
6ke
5ke
2Skg

375-385
375-385

525-535
252-260

S2Smm above from the


floor of veh.

Suggestions/comments

-;"

'

..':' .

. ~. LAYOUT PLAN Of="ROVER" .VEHICL,E--.


-

HE ANTENNA

...

"

In

EJIII- (i5() GEN

NOrE-- ALL }>IMENSION

'N

MM

"""",
m.e.~~"lIo_:~~,

Pf

.,

~. ,",

'

Tx DATA }
:OCATA

RS 232C

Nfr OIClrAJ.
llEIWORK

".'

..':'
. \.,
.:". .:."~" .
.'. '.

,
SMART EOUIPMEi'fT

SETUP FO
Fig. 4.5

I TERFACE WITH DIGI~AL NETWORK


(UNE DIAGRAM)

.. --

..

..

.....

,"

.. ,!.

,.

:, ,

..
,..

.\

:: }
,......

"\

.'

;;,

"

~:
....

'.,

.~ ,. -

,.

. ~...
.:

.~'

'.'

:"

,.

-'

'oQ'J

'. 'l~:
'.,

:.J'"

..
i..
'.

.._- .. ,:;~
.. ~ ""\ .. ""'"
/-:d

..

',,~
,
. ~.:

"

~. : : '.

'

:.:' ,t ~.

':',.' ',:',:,;;::-:
:,~,
";'::~".~,~,::,':~',~,;,:,~',,(~;::,;,:,
...:,:.. ..:
~
.

,::~

'.

;
:;

:'
~.. ..

<.>....:";. ," :.,'....

,.,':

'

..... -

'

:'....

'

.,,',

.'

~-.",',

...... ,
"

~1-2

~-m-~(~"tIls)

.'
".

'.:'
,

LHP 265D, m-qp;r~


.

'..1Jnr
"~~65D
,(.
- <]'n=4
Cl- "'1 till

,".
!

.- 4-

"

,
I
I'

"

"-

"-

'

.. ~
"

.:~'!E'.~"'.r'.

~.~@O

MARKING DETAIS

1. BATTERY PACK
2. BATTERY BOX

RY CHARGING ADAPTER

3. INTERCONNECTING CABLE

i12

. HAND SET
5. EXTERNAl BATIERY ADAPTER BOX (EBAB)
6.

MAINS (lDAPTER UNIT (MAU)

7. BATTERY CABLE (FOR EBAB)

..

8. MAINS CABLE

13

9. INTERCONNECTING.

eAaLE

(EBAB TO MAU)

I.'

Il~. ;

10. NINIPRINTER
11. ImtRCONNECTlNG

CABLE

(SUARr

TO PRINTER)

12. BATTERY CHAGING ADOPTER (BCA)


._--_ ...

-;-=.:..- ._--- ..
13. KEYBOARD illUMINATION UNIT

14. CARRYING HARNESS


15 CARRYING CASE
14

15

16. MOUNTING TRAY fOR SMART

FIG. 1.6
16

LIST OF ACCESSORIES

OF EQUIPMENT SMART

-_.

~ ..

/lVft
.

.-1

,f

. I

.I

.'!

.'

,.._~_'

~fr

;' I

"-j

.i

t .

~............

f
.'

r"

f .f~,~J -r:f.l..
,

w.iJi

--tt;"> !
"''Il41W4

.._I()l'f!o~

..
>.

- -

.~~.

...

~--..,,..,,,..

-I
..

.,,

_./L'
8 '1.'-(, G-P...Y

1t~.~{.fJf"~J'~

of t-et..

~ PI H r"

;"...

-'

-_.

..
!
I .

.:; 66: -rc:-),-'\

C)

f<Pr-Ck

E~ at1:

. ,

~>~

t:'c.
.

_.J.. ..

",

-- -_.
-,

- ....

_-

-- -_.-._-

~.;,
..-..

..

-~
'.-'.-

_:.

r;J.~:'
!

. ....

'

.!

-,l:

'~/RTr
.
-16.

'!fTWffCfi'1~Cf'1H~~LHP265DCfiT~Wi(1~-qim~~tl

_
~~~t

~IM:tH~~~~wNaqfOl,:r~~~~

fcl;~~

~i5T~~~1

~~Wff~~,
q~ttI/Q;n~

17.

'kr

~fiCfi(1llls-q LHP 265D CfiT"WCfi-ut('P:lia1lTT~


# QW4IQ'11
C:liT~tl

4-6 ~~

mvr~>lCfif{CfiT~t

W l1fq nun # t

231

195

18

I.

"

~~:=__.::::::.:::::::::.
...:.Jii.._~:

i:

15 TYl'

'I

'I
1JOEil
i !
i!
Eil

EilO~i

i !
Eil i i

iii

.~ !
:
.iii

iii

Eil

--__

i!

\~ fi
1

Eilill
Eil._.Eil

.ji

----- ----- -w-:-o-l '

- !. ~~--

. ..

,-

LI
_J_

.4-6

+rtafiTr~CfiT
4~~ 14'11 ~

~~

.nr.
~~~

3lT~ft:r4:Tq LHP 265D ~ll16


# ~mR(Slll\jlT~rtl
~
4-81J.Cf4-9#f<;@ljltl
~'l1TfcRfrm~'llfTTetr~1fffi

(a)

~fc6q~q;r~Wnll
6i'RT,~

Cfi~Cf2
<~
(b)

LHP 2650 -

CIi\i'l1T('IT{
etr~~LHP

265D WHIP

Cfif'lWTt 1J.Cf
RF 'W-R CfiT
~

Cfi\illt I

aqlfPI q;nfcfi~t LHP 265D DIPOLE Cf1~Cf2<


cN~

ctlllZCRf)d
mq;r
~

:-

m, 'dOr~~CfiT~~~~-qmm~

m~ (fCfit cw ~

('IT{ CllB ~

HF ~

qiP~:r~
W

W- g<IT~

(1ijHI m'i'f6'f ~

~ ~

~ ~

(~Slt~(1.

~,

<IT~41~("t.1
~)

Clg'lC\ifl<
ll16-q LHP 2650 Cfif1J.Cf~etr~~m~t1J.Cf

'l<:(".[

<l\

>
:~

i!
i

- 66-

--.

/.

D'

..

r,
"

~4-9

LHP 265D CfiT~il~(O\<-q)sit~

,LHP 26SD alR

~gliG<CfiT
$'1;I~~H '

'22,' ~4-1O~*3Wt:{SIQ(<NLHP265D$'~~~~fcim~~,'

'.
,

. ~I
(a)

LHP265D~~~<NOFF~'RW(.4-11cN~)

(b)

t:{Si
Q( $ DCOUTCfiqcR: (

.W1~

7;ff ~

-am- LHP265D~ ~.q-wrr DCCfl4CfC!( ~

S31T ftRT~

ft;rQ:~ tRr I

~hrr

3fTR CfiqCfC!{

~<N~-~q;U1
- (c)'

3WR-~~

~~

W <flU

I CfiqCfC!( $~

HF ~

CfiqCfC!~ <N 3Wffi.q~~~"Q;ili~

Nii~-~~

wR ~

4Q1~mmt nT~

tRr, 11l6i.94 <N'3fcf; q;UNit >lfsf;c:rr <N~


GT mts tffi A1:.$ &RT LHP 265D cf;t:{SfQ( <N oW.rtl

fS*'hqctC
(d)

LHP 2650

'i.~

an

- 69-

I~
I.VI?]H~~~Lh.lliJ.k~~~

k?@~~~

(g)

\-l)W\!>l.W'

-: ~t6ID.
~ }?=I>t<~

dIHM

~~

h\Wi.J:~

~I ~

~lli<JWi~

""k\&12'tl:$ ~

I~~~

~1.HP!f{~. '} ?btlf?

~~~~

It-('?~m.- 'Ct@~.
!O}bPJ.l.!e. (~J ~~

.nI hh.l:t.

JQ)J

(Wh) ~

I. ,

LI-f7P

"-:j .

89

iI
I

I:

',.

II'

Id O~

9l

'1I8p OZ~
"~H~

O:ld
UO"IO~

O"la
eSa

i
,

eu

b}.)~

I~W.!bl7~

14lh.~()~O!b)~~~~~~lt-('?~~
I!\~~

L:l

}14~~1?

I~~ U*bl9. .i.iO ~

~OS9ZdH'I~~e.lH!b~~~~~
,

I:lk'"J!2

You might also like