Professional Documents
Culture Documents
IPN = 5-6-8-12-25 At
16080
Features
Electrical data
IPN
Primary nominal current rms
IPM
Primary current, measuring range
RM
Measuring resistance @
with 15 V
@ 25 At max
@ 36 At max
ISN
Secondary nominal current rms
K N
Conversion ratio
VC
Supply voltage ( 5 %)
IC
Current consumption
25
At
0 .. 36
At
TA = 70C
TA = 85C
RM min RM max RM min RM max
100 320 100 315
25
mA
1-2-3-4-5 : 1000
15
V
10 + IS
mA
IO
IOM
IOT
t r
di/dt
BW
General data
TA
TS
RP
RS
RIS
m
- 40 .. + 85
- 45 .. + 90
< 1.25
110
115
> 1500
22
EN 50178: 1997
C
C
m
M
g
Advantages
Excellent accuracy
Very good linearity
Low temperature drift
Optimized response time
Wide frequency bandwidth
No insertion losses
High immunity to external
interference
Current overload capability.
Applications
AC variable speed drives and
servo motor drives
Static converters for DC motor
drives
Battery supplied applications
Uninterruptible Power Supplies
(UPS)
Switched Mode Power Supplies
(SMPS)
Power supplies for welding
applications.
Application domain
Industrial.
9November2011/version 14
LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice
www.lem.com
2.5
9
Min
10.63
10.63
175
kV
kV
mm
mm
Applications examples
According to EN 50178 and IEC 61010-1 standards and following conditions:
Over voltage category OV 3
Pollution degree PD2
Non-uniform field
EN 50178
IEC 61010-1
Nominal voltage
Basic insulation
1700 V
1700 V
Reinforced insulation
600 V
600 V
dCp, dCI, Vw
Safety
Page 2/3
9November2011/version 14
LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice
www.lem.com
Connection
Number of
primary turns
Primary current
nominal
IPN [A]
25
Nominal
output
current
maximum
I
[mA]
SN
IP [A]
36
25
Turns ratio
KN
1 / 1000
Primary
resistance
RP [m]
0.3
Primary insertion
inductance
LP [H]
Recommended
connections
12
18
24
2 / 1000
1.1
12
24
3 / 1000
2.5
24
4 / 1000
4.4
25
5 / 1000
6.3
9November2011/version 14
10
IN
10
10
IN
IN
10
10
IN
Remarks
Mechanical characteristics
General tolerance
Fastening & connection of primary
Fastening & connection of secondary
Recommended PCB hole
IN
0.58
OUT
0.37
OUT
0.21
OUT
0.09
OUT
0.023
OUT
0.2 mm
10 pins 0.7 x 0.6 mm
3 pins 1 mm
1.2 mm
LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice
www.lem.com