Professional Documents
Culture Documents
(CDR)
CDR Number:
For Mechanical, Corrosion and
Erosion damage anomalies.
GP III
07-029
Pipework
Section 1 :
Installation :-
Details of System
Date Reported :-
N/A
2/18/2005
Design parameters
Yes
GP3001-PR-PI-0003
Component History
Pressure (bar.g)
Temperature C
Flow (m/s)
18"-PL-01011-D15A
24/08/2007
Details of Anomaly
Drawing No.
Material Type :-
22Cr Duplex
Component OD:-
2" (50)
Type
Location
Anomaly Type:-
Vibration
Equipment Type:-
Anomaly Location:-
External
Component:-
Pipework
Dead Leg/ Low Flow
Leak:-
No
Anomaly Mechanism:-
Deferment:-
No
Pitting Depth :-
N/A
N/A
Anomaly Found:
N/A
Oil = m3
Value =
Extent:-
Gas = scfd
Value =
WI = m3
Value =
Solids present:-
Area:-
Weld
Routine Inspection
N/A
Fabric Maintenance
Coating system:-
Not Coated
Substrate:-
Heat Traced:-
Break down %
N/A
Substate Condition:-
CAT 1 No Corrosion
Insulation Class:-
Anodes Fitted:-
No
Unknown
Insulation Defect:-
No
N/A
Section 2: Additional information not covered in Section 1 above. (Note - use Sheet 2 for sketch / photo of defect location).
2" bypass from 18"-PL-01011-D15A is under supported (existing support partially effective). Vibration noted in service which will result in
dynamic loads being imposed at flowline connections.Recommend that existing support be cross braced. See original JMD VRA report
GP3/05/060 on page 2 for details.
Print name
G. Strang
Job Title:
JMD Specialist
Date
18/02/2005
D. Bromby
Date
8/24/2007
Recommend that anomaly location be included in future JMD workscopes for checking. Due date - 31/03/2008.
ACTION
Print name
C. Beedie
Signature
Date
Signature
Date
Signature
Date
Signature
Date
04/09/2007
Glenn Turner
10/12/2007
Job Title
Date
No
Continuation Sheet
2 of 2
Continuation sheet for further text, sketches etc. If not in electronic format, forward separately through internal mail system.
CDR Number:
GP III
07-029
Pipe Details
18"-PL-01011-D15A
WO Number
CDR Number
Location
Line Number
Material / Grade
P&ID Number
Wall Thickness
Medium
Temperature Rating
Pipe Coating
Pressure Rating
N/A
07-029
Turret - top level
18"-PL-01011-D15A
22Cr Duplex
Design/S
Current
Operatin 0
Not Coated
Operatin 0
Desig
Comment
Desig
Comment
Attach drawings of pipe system, inspection reports, etc where available. Indicate any access restrictions a
proximity to other equipment.
Repair Specification
ICP approved
Nature of Defect
Current Size
Cause
Effect
Yes/No
Other (specify in Page 2)
Area
Corrosion Yes/No
External Yes/No
Perforate Yes/No
d
Depth
Erosion
Internal
Yes/No
Yes/No
Maximu
m
Maximu
Minimum
Minimum
Other Information
Note: This should include any remarks on previous repairs, fire protection requirements, etc
Integrity Review
Date Fitted
Inspection
Frequency
Inspection Method
Last
inspection
Date
Current WT
Life of repair
ea
Yes/No
Yes/No
mentation of Repair
requirements, etc