Professional Documents
Culture Documents
, Ltd
Model: AVL02
st
China
Product Description:
GPS Tracker
Tested Model:
Report No.:
AVL02
STR14028169E-3
2014-02-22 to 2014-02-27
M.
Tested Date:
Te
FCC Rule(s):
2014-02-27
Tested By:
Reviewed By:
SE
Issued Date:
Prepared By:
Note: This test report is limited to the above client company and the product model only. It
may not be duplicated without prior permitted by Shenzhen SEM.Test Technology Co., Ltd.
PAGE 1 OF 25
Model: AVL02
TABLE OF CONTENTS
1. GENERAL INFORMATION...................................................................................................................................3
1.1 PRODUCT DESCRIPTION FOR EQUIPMENT UNDER TEST (EUT)...............................................................................3
1.2 TEST STANDARDS...................................................................................................................................................4
1.3 TEST METHODOLOGY .............................................................................................................................................4
1.4 TEST FACILITY .......................................................................................................................................................4
1.5 EUT SETUP AND OPERATION MODE ......................................................................................................................5
2. SUMMARY OF TEST RESULTS ...........................................................................................................................6
st
Te
SE
M.
PAGE 2 OF 25
Model: AVL02
1. GENERAL INFORMATION
1.1 Product Description for Equipment Under Test (EUT)
Client Information
Applicant:
Address of applicant:
Manufacturer:
Address of manufacturer:
GPS Tracker
TZONE
AVL02
AVL201, AVL202, AVL301, AVL05, AVL09, AVL10,
AVL19, AVL219
Te
Adding Model(s):
st
Note: The test data is gathered from a production sample, provided by the manufacturer. The appearance of
others models listed in the report is different from main-test model AVL02 but the circuit and the electronic
construction do not change, declared by the manufacturer.
DC 36V
2A
7.3728MHz
1575.42MHz
Global Positioning System
SE
M.
PAGE 3 OF 25
Model: AVL02
st
All measurements contained in this report were conducted with ANSI C63.4-2003, American National Standard
for Methods of Measurement of Radio-Noise Emissions from Low-Voltage Electrical and Electronic Equipment in
the range of 9 kHz to 40 GHz.
Te
M.
SE
PAGE 4 OF 25
Model: AVL02
Description
Remark
TM1
TM2
Connect to PC
TM3
TM4
Cable Description
Length (m)
GPS Cable
GPRS Cable
Shielded/Unshielded
Shielded
Without Ferrite
Shielded
Without Ferrite
Model
Serial Number
Stoex
SPP34-12.0/5.0-2000
SAMSUNG
R20
N/A
SE
M.
Notebook
Manufacturer
Te
Description
st
PAGE 5 OF 25
Model: AVL02
Description of Test
Result
Compliant
Compliant
SE
M.
Te
st
PAGE 6 OF 25
Model: AVL02
3. CONDUCTED EMISSIONS
3.1 Measurement Uncertainty
Base on NIS 81, The Treatment of Uncertainty in EMC Measurements, the best estimate of the uncertainty of any
conducted emissions measurement is + 2.88 dB.
Manufacturer
Model
Serial Number
Cal. Date
Due. Date
ESPI
NSLK8126
ESH3-Z2
101611
8126-224
100911
2013-05-07
2014-05-06
2013-05-07
2014-05-06
2013-05-07
2014-05-06
Schwarz beck
st
Te
Test is conducting under the description of ANSI C63.4-2003, American National Standard for Methods of
Measurement of Radio-Noise Emissions from Low-Voltage Electrical and Electronic Equipment in the range of 9
kHz to 40 GHz.
SE
M.
PAGE 7 OF 25
Model: AVL02
23 C
Relative Humidity:
52%
ATM Pressure:
1011 mbar
SE
M.
Te
st
PAGE 8 OF 25
Model: AVL02
No.
Frequency
Reading
Correct
Result
Limit
Margin
(MHz)
(dBuV)
(dB/m)
(dBuV)
(dBuV)
(dB)
0.5940
32.26
9.59
41.85
56.00
-14.15
peak
0.5940
19.99
9.59
29.58
46.00
-16.42
AVG
SE
M.
Te
st
Test Specification:
Detector
3*
4.4339
33.23
10.00
43.23
56.00
-12.77
peak
4.4339
22.36
10.00
32.36
46.00
-13.64
AVG
22.6780
18.21
12.23
30.44
50.00
-19.56
AVG
27.1180
18.46
13.00
31.46
50.00
-18.54
AVG
28.6380
29.27
13.00
42.27
60.00
-17.73
peak
PAGE 9 OF 25
Line
Frequency
Reading
Correct
Result
Limit
Margin
(MHz)
(dBuV)
(dB/m)
(dBuV)
(dBuV)
(dB)
0.1940
42.26
9.50
51.76
63.86
-12.10
peak
0.4780
38.08
9.50
47.58
56.37
-8.79
peak
3*
4
5
6
Detector
0.4860
29.50
9.50
39.00
46.24
-7.24
AVG
0.7260
25.38
9.73
35.11
46.00
-10.89
AVG
1.2780
25.27
10.00
35.27
46.00
-10.73
AVG
2.7780
34.36
10.00
44.36
56.00
-11.64
peak
3.9900
32.63
10.00
42.63
56.00
-13.37
peak
SE
M.
No.
Te
st
Test Specification:
Model: AVL02
PAGE 10 OF 25
Model: AVL02
4. RADIATED EMISSION
4.1 Measurement Uncertainty
Base on NIS 81, The Treatment of Uncertainty in EMC Measurements, the best estimate of the uncertainty of any
radiation emissions measurement is + 5.10 dB.
Serial Number
Cal. Date
Due. Date
FSP
ESVB
8447F
PAP-0118
836079/035
2013-05-07
2014-05-06
825471/005
3113A06717
24002
2013-05-07
2014-05-06
2013-05-07
2014-05-06
2013-05-07
2014-05-06
SCHWARZBECK
VULB9163
9163-333
2013-04-20
2014-04-19
ETS
SCHWARZECK
3117
HFRA 5165
00086197
9365
2013-04-20
2014-04-19
2013-04-20
2014-04-19
st
Spectrum Analyzer
EMI Test Receiver
Pre-amplifier
Pre-amplifier
Trilog Broadband
Antenna
Horn Antenna
Loop Antenna
Manufacturer
R&S
R&S
Agilent
Compliance Direction
Te
Description
SE
M.
The setup of EUT is according with per ANSI C63.4-2003 measurement procedure. The specification used was
with the FCC Part 15.109 Limit.
The external I/O cables were draped along the test table and formed a bundle 30 to 40 cm long in the middle.
The spacing between the peripherals was 10 cm.
PAGE 11 OF 25
Model: AVL02
Frequency :30MHz-1GHz
RBW=120KHz,
VBW=300KHz
Sweep time= Auto
Trace = max hold
Detector function = peak, QP
st
The Corrected Amplitude is calculated by adding the Antenna Factor and the Cable Factor, and subtracting the
Amplifier Gain from the Amplitude reading. The basic equation is as follows:
Corr. Ampl. = Indicated Reading Corr. Factor
Te
The Margin column of the following data tables indicates the degree of compliance with the applicable limit.
For example, a margin of -6dBV means the emission is 6dBV below the maximum limit for a Class B device.
The equation for margin calculation is as follows:
Margin = Corr. Ampl. FCC Part 15.109(a) Limit
Relative Humidity:
55 %
ATM Pressure:
1011 mbar
M.
Temperature:
SE
According to the data, the EUT complied with the FCC Part 15.109(a) rule, and had the worst margin of:
-5.69 dB at 285.9778 MHz in the Horizontal polarization, TM2 mode, 9 kHz to 1 GHz, 3Meters
PAGE 12 OF 25
Model: AVL02
Frequency
Reading
Correct
Result
Limit
Margin
Degree
Height
(MHz)
(dBuV/m)
dB/m
(dBuV/m)
(dBuV/m)
(dB)
( )
(cm)
53.3179
23.66
-7.78
15.88
40.00
-24.12
12
100
peak
2*
150.0108
45.25
-12.95
32.30
43.50
-11.20
12
100
peak
-1.29
21.45
46.00
-24.55
12
100
peak
SE
No.
M.
Te
st
Test Specification:
492.4685
22.74
PAGE 13 OF 25
Remark
Vertical
Reading
Correct
Result
Limit
Margin
Degree
Height
(MHz)
(dBuV/m)
dB/m
(dBuV/m)
(dBuV/m)
(dB)
( )
(cm)
49.8814
28.79
-7.44
21.35
40.00
-18.65
120
100
peak
95.7622
31.43
-10.08
21.35
43.50
-22.15
120
100
peak
134.0882
40.16
-12.91
27.25
43.50
-16.25
120
100
peak
4*
148.9625
43.24
-12.98
30.26
43.50
-13.24
120
100
peak
M.
Frequency
Remark
SE
No.
Te
st
Test Specification:
Model: AVL02
PAGE 14 OF 25
Model: AVL02
Frequency
Reading
Correct
Result
Limit
Margin
Degree
Height
(MHz)
(dBuV/m)
dB/m
(dBuV/m)
(dBuV/m)
(dB)
( )
(cm)
165.4866
33.90
2.65
36.55
43.50
-6.95
100
peak
175.0368
33.42
2.71
36.13
43.50
-7.37
100
peak
SE
No.
M.
Te
st
Test Specification:
Remark
239.9874
28.70
6.33
35.03
46.00
-10.97
100
peak
4*
285.9778
31.67
8.64
40.31
46.00
-5.69
100
peak
PAGE 15 OF 25
Vertical
Frequency
Reading
(MHz)
(dBuV/m)
1*
38.6160
22.98
174.4241
29.90
244.2321
Correct
Result
Limit
Margin
Degree
Height
dB/m
(dBuV/m)
(dBuV/m)
(dB)
( )
(cm)
9.01
31.99
40.00
-8.01
10
100
peak
2.71
32.61
43.50
-10.89
10
100
peak
46.00
-12.35
10
100
peak
M.
No.
Te
st
Test Specification:
Model: AVL02
27.16
6.49
33.65
Remark
SE
Note: Testing is carried out with frequency rang 9kHz to 1GHz, which emissions below 30MHz are attenuated
more than 20dB below the permissible limits or the field strength are not list above.
PAGE 16 OF 25
Model: AVL02
st
Specifications: Text is Black in color and is justified. Labels are printed in indelible ink on permanent adhesive
backing or silk-screened onto the EUT or shall be affixed at a conspicuous location on the EUT. Where the EUT is
constructed in two or more sections connected by wires and marketed together, the above statement is required to
be affixed only to the main control unit. When the EUT is so small or for such use that it is not practicable to place
the statement on it, the above information shall be placed in a prominent location in the instruction manual or
pamphlet supplied to the user or, alternatively, shall be placed on the container in which the device is marketed.
SE
M.
Te
PAGE 17 OF 25
Model: AVL02
SE
M.
EUT View 2
Te
st
EUT View 1
PAGE 18 OF 25
Model: AVL02
SE
M.
EUT View 4
Te
st
EUT View 3
PAGE 19 OF 25
Model: AVL02
SE
M.
Te
st
EUT View 5
PAGE 20 OF 25
Model: AVL02
Te
st
SE
M.
PAGE 21 OF 25
Model: AVL02
SE
M.
Te
st
PAGE 22 OF 25
Model: AVL02
SE
M.
Te
st
PAGE 23 OF 25
Model: AVL02
SE
M.
Te
st
PAGE 24 OF 25
Model: AVL02
FCC Caution
st
This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This
device may not cause harmful interference, and (2) this device must accept any interference received, including
interference that may cause undesired operation.
M.
Te
NOTE 1: This equipment has been tested and found to comply with the limits for a Class B digital device,
pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful
interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy
and, if not installed and used in accordance with the instructions, may cause harmful interference to radio
communications. However, there is no guarantee that interference will not occur in a particular installation. If this
equipment does cause harmful interference to radio or television reception, which can be determined by turning
the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following
measures:
- Reorient or relocate the receiving antenna.
- Increase the separation between the equipment and receiver.
-Connect the equipment into an outlet on a circuit different from that to which the receiver is connected.
-Consult the dealer or an experienced radio/TV technician for help.
SE
NOTE 2: Any changes or modifications to this unit not expressly approved by the party responsible for
compliance could void the user's authority to operate the equipment.
PAGE 25 OF 25