Professional Documents
Culture Documents
Street
Postcode / City
Phone Fax
Project
Application
Remarks
COMPUFIX 8.4
8.4.4840.25953/15/2479
Page No 1 of print-out No 21
Date: 10/14/2014
Dimensions/loads:
Design actions
(*) Not true to scale
[mm], [kN], [kNm]
Static actions
Anchor Bolt FAZ II 12 / 50 A4 (Art. Nr. 501419) made from stainless steel (grade 316)
Non-cracked concrete, normal reinforcement
Concrete compressive strength class: C 40/50
No influence
Unavailable
No design available
Print sender
Project
Application
Anchor
Page No 2 of print-out No 21
Important:
As a pre-condition the anchor plate is assumed to be flat when subjected to the actions. Therefore, the plate must be
sufficiently stiff. The COMPUFIX anchor plate design is based on a proof of stresses and does not allow a statement
about the stiffness of the plate. The proof of the necessary stiffness is not carried out by COMPUFIX.
The design utilises specific values for each anchor. When alterations will be made, even for similar products, a new design
calculation is required.
With slotted holes the design is carried out under the assumption that the anchor is located in the centre of the hole.
Please check that the fixing thickness of the fixing is adequate.
Maximum hole diameter in the attachement: 14 mm.
To ensure the structural component's capacity, the proofs in accordance with Section 7 of ETAG Annex C must be observed.
All additional conditions of the Approvals are to be observed.
Tension load, Steel failure:
Unit
NRk,s
kN
gMs
NRd,s
kN
NhSd
kN
b N,s
-
Sd
41.50
1.50
27.67
8.73
0.32
Sd
35.25
1.50
23.50
8.73
0.37
Sd
29.50
1.25
23.60
0.95
0.04
Print sender
Project
Application
Anchor
Tension load
Pull-through / pull-out:
Splitting:
Result:
Sd
41.83
441.00
441.00
1.00
1.00
1.00
1.00
1.00
1.50
62.74
1.50
41.83
8.73
0.21
Steel failure:
Concrete cone failure:
Page No 3 of print-out No 21
Used capacity
4.0 %
4.4 %
1.4 %
Combined tensile
Used capacity
and shear load
23.6 %
Print sender
Project
Application
Anchor
Page No 4 of print-out No 21
Installation details
[mm]
[mm]
[Nm]
[mm]
[mm]
[mm]
[mm]
[mm]
50
12
60
19
14
70
12
140
Print sender
Project
Application
Anchor
Page No 5 of print-out No 21