Professional Documents
Culture Documents
Professional experience:
2.0 years of experience in piping stress analysis of onshore piping with leading MNC
in oil and gas field.
Educational Qualifications:
Higher Secondary Education in Science from Nasik Board with distinction (90.17%,
March 2009)
Secondary School Education from Nasik Board with distinction (84.30%, March
2007)
Software proficiency:
CAESAR II
PDMS
Autocad
Well versed in using codes ASME B31.3, ASME section II part D, ASME section
VIII DIV-1 for the piping stress analysis.
Stress analysis of high temperature lines connected to Fired heater, steam turbine,
centrifugal pumps (Top Top pumps), Submersible Pumps, Air fin fan cooler,
Hairpin type exchanger, shell & tube heat exchangers, Plate and Frame Heat
Exchangers, pressure vessels, columns, pressure relief valve, and rack piping.
Flange leakage checking as per equivalent pressure method, ASME Section VIII
Div-1 Appendix-2 method.
Support selection for small bore high temperature lines without computer analysis.
Indian Statutory Rules & Regulations for plant Layout (OISD-118, SMPV rules)
and IBR act.
1 of 3
Lean gas Scrubber Equipment Layout and Piping design including stress analysis
and 3D modeling during PGD Piping design & Engineering
Job responsibilities:
Preparation of critical line list.
Stress critical system forming on P & ID from critical line list & P & ID.
Stress analysis of Air fin fan cooler consisting of 12 number of bays and 24
number of bundles.
Stress analysis of open PSV systems.
Stress analysis of close PSV systems.
Stress analysis of hairpin type exchangers.
Actively involved in stress analysis and problem solving for critical lines
connected to centrifugal pumps, steam turbines, Fired heater, Steam jet vacuum
Ejectors, vacuum column, pressure vessels, air fin fan coolers, hairpin type
exchangers, PSVs, silencers, shell & tube heat exchangers.
Data sheet preparation for special supports such as springs, struts & snubbers.
Vendor drawing review for spring supports.
Prepared cleat support loading for tower connected lines.
Flange leakage checking as per equivalent pressure method, ASME Section VIII
Div-1 Appendix-2 method.
Checking IFC isometrics from stress & supporting point of view & signing off
the same.
Preparation & issuing support loading information to civil for piling
(foundation) design & structure design.
Checking Special Pipe support (SPS) drawings.
Interdisciplinary coordination with piping design and Civil (Structure).
2 of 3
3 of 3