Professional Documents
Culture Documents
Previous Screen
Product: TRACK-TYPE TRACTOR
Model: D8T TRACK-TYPE TRACTOR J8B
Configuration: D8T Track-Type Tractor J8B00001-UP (MACHINE) POWERED
BY C-15 Engine
NOTICE
Care must be taken to ensure that fluids are contained during
performance of inspection, maintenance, testing, adjusting, and repair
of the machine. Be prepared to collect the fluid with suitable containers
before opening any compartment or disassembling any component
containing fluids.
Dispose of all fluids according to local regulations and mandates.
Introduction
The following test will determine whether the pressure of the transmission lubrication oil is at the
specified limit. This oil is delivered from the power train oil cooler to the lubrication distribution
manifold.
Required Tools
Illustration 1
Tooling (A)
g01089423
Illustration 2
Tooling (B) ( 6V-7830 Pressure Gauge (Tetragauge))
Table 1
Required Tools
g01089425
Tooling
Item
Part
Number
Description
A1
8T-0853
Pressure Gauge
400 kPa (58 psi)
A2
6V-3989
Fitting
A3
6V-4143
Coupler
Qty
Hose As
A4
177-7861
1
41370 kPa (6000 psi)
Pressure Gauge
B1
8T-0862
1
500 kPa (72 psi)
Pressure Gauge
B2
8T-0860
1
40000 kPa (5800 psi)
Pressure Gauge
B3
8T-0855
1
4000 kPa (580 psi)
Hose As
B4
6V-3081
1
41500 kPa (6020 psi)
B5
4S-6399
Connector
B6
6V-4144
Coupler
Test Procedure
1. Move the machine to a smooth horizontal location.
2. Lower all of the implements.
Illustration 3
(1) Pressure Tap ("L1")
g01090783
3. Locate pressure tap (1) ("L1") on the machine. Pressure tap (1) ("L1") is located above the five
pressure taps for the transmission at the rear of the machine.
Illustration 4
(1) Pressure Tap ("L1")
g01090785
7. Check the pressure at tooling (A) . The pressure at tooling (A) should be 210 70 kPa (30
10 psi).
8. Operate the engine at LOW IDLE (700 rpm). Make sure that the steering control lever is in the
NEUTRAL position.
9. Check the pressure at tooling (A) . The pressure at tooling (A) should be 14 + 14 - 10 kPa (2 +
2 - 1.5 psi).
Reference: See Specifications, Systems Operation/Testing and Adjusting, "Pressure Charts"
in this module for additional pressure values.