You are on page 1of 2

Materials

1/2" Hardwood Plywood @ 16" x 12": One piece for the Top Panel

3/4" x 6" x 27" Oak or other desired Wood: for all remaining pieces

1 1/4" Kregg Screws

1 1/4" Wood Screws

Sandpaper

Wood Filler and Glue

Satin Finish Polyurethane

Step 1: Cut the Book Stand Pieces - Determine the desired size of your Stand

Select the 1/2" Plywood Panel; cut one piece for the Top Panel @ 12" x 16"

Select the 3/4" material; cut the two Legs, Brace, and Lip per the dimensions above

Select all pieces; Sand all pieces

Step 2: Assemble the Stand Pieces - Select all pieces

Select the Lip and Top Panel; Attach the Lip to the top panel with glue and two wood
screws from the bottom as shown above

Select the two Legs and the Bottom Brace; Connect the two Legs to the Bottom Brace from
the bottom side with the Kregg system, as shown above

Select the Leg and the Top Assembly; Center the assemblies and with glue and screws,
attach them together

Step 3: Finish the Shelf - Select the finishing materials

Fill all holes and cracks with filler; sand all surfaces

Apply poly

Enjoy your Book Stand

You might also like