‘8 TECH-32x OBD controller - connection with OBD
| TECH 32x OBD controllers 150 157654 CAN (11/500, 29/500, 11/250, 29/500),
‘eh, can connect with protocols: 160 9141-2, 0 14230 (slow fast)
ISO 15765-4 CAN fiz)
‘o, ‘To connect with SAE J1850 VPW i SAE 2850 PWM protocol,
canign SCANNER TECH-ORD has to be used.
Geceece) (GREECE opp cocker
Gener EEEEEEE] back view
Socket wth €AN 150 15765 protcol has signal ins in comector 61 14
Solder white wi to ren connec ne.
Solder green wie to wren connec nec,
ISO 9141-2 ISO 14230 fast"
GREECE) (EEEEED opp cocker
Genser) Seamer) back view
‘ Laine
Socket with 1S0 9142 and 1S 14230 has signal pins located in connector eset coe te
no.7 and optionally no. vires white and steen far pg cotvller SoS
Farnese connect to O80 socket, Slger white wre from Ipg contrllet
fatness to wie connector no.7 W there Is in no.15 located in the
rocket then solder ‘mess to wren
fonnectr ne.35
In case ofthe absence of pins 6 and 16 in the dagnostc socket ofthe car, where
the detected transmission protocel is ISO 15765-8 CAN, connect the Wires a5
Folows
(eTECH ‘The white one from the scanner to pin 3in a car socket
Sones ‘The yellow one for the scamer te pln 1 ina ca socket8 TECH-32x OBD controller technical description
LPGICNG injection controller.
7 Automatic, intelligent OBD data trouble codes
erasing,
Automatic, real time LPG/CNG injection time
correction based on petrol ECU parameters readed
via OBD bus.
7 OBD mapping while driving without PC connection
need.
~ OBD scanner function - OBD parameters, data trouble
codes reading and erasing.
~ Support up to 4/6/8 cylinders - depends on controller
version
Ability to work in MASTER/SLAVE mode for up to 16
cylinder support
TECH algorithm + automatic correction system
(adaptation)
Configurating software with TECH and STANDARD
option
Self-diagnostic system
Short-circuit and thermal protection
7 Aluminium case
Supported OBD protocols: CAN (11/500; 29/500;
11/250; 29/500), ISO 14230 slow, ISO 14230
fast, ISO 9141 (using the same wires for CAN
and ISO). In some cars (especially USA cars) SAE
J1850 VPW/PWM p rotocols are used. In this
‘case SCANNER TECH-OBD should be used
‘After ear conversion to Ipg/eng
‘smear the OBD socket
2.in the engine compartment
‘warning stickers should be placed: