Professional Documents
Culture Documents
PROTECTIVE COATINGS
RECOMMENDED
USES
TECHNICAL DATA
COLOUR, DRY FILM
FINISH, DRY FILM
VOLUME SOLIDS
(ASTM D2697)
SPECIFIC GRAVITY
THEORETICAL
SPREADING RANGE
RECOMMENDED DFT
RANGE (DRY FILM
THICKNESS)
RECOMMENDED WFT
RANGE (WET FILM
THICKNESS)
FLASH POINT
White
Smooth / Matt
50 2%
1.20 0.05
2.5 2.0 M2/LTR
200 250 Microns/Coat (Optimum dry film thickness 1000 microns)
(approx.)
400 500 Microns/Coat
32C
DRYING TIME
Drying time @ 30C (Temperature, humidity, air movement, film thickness and number of coats
all affect the drying time.)
TOUCH DRY
DRY TO RECOAT
HARD DRY
2 hours
24 hours
72 hours
ADVANTAGES
NATIONAL
INTUMESCENT PAINT
SYSTEM
Rev. 05/10
Page 1/3
www.national-paints.com
APPLICATION INSTRUCTION
For metal: Sandblast the surface to min. Sa2.5 surface should be
free of oil, grease, dust and loose particles. For mechanical
cleaning surface should be sandblasted to min. St2. A sound
prepared surface will lead to a better paint application. When used
over old coating systems, the surface must be clean, dry and
properly anchored.
For wooden and concrete surfaces: For optimum service life, the
surface should be completely free of contaminants that might
impair performance and should be treated to ensure good and
permanent adhesion of the paint system. For removing dust and
loose particles, cleaning by air blasting is recommended.
SURFACE PREPARATION
APPLICATION DATA
APPLICATION METHOD
CLEANING/THINNING
THINNER (VOLUME)
CONV. SPRAY REQUIREMENTS
AIRLESS SPRAY REQUIREMENTS
NOZZLE SIZE
MIXING RATIO (BY VOLUME)
POT LIFE @ 30c (100 ml)
SYSTEM
For ferrous surfaces:
RECOMMENDED SYSTEM
To be applied on prepared surface.
- Clean the surface of metal.
- Sand blast the surface, if ferrous.
- For non-ferrous surface, apply wash
primer, then directly apply National
Intumescent Paint.
SPECIFIC PROPERTIES AS
INTUMESCENT PAINT
Rev. 05/10
Page 2/3
: 1 coat
: 1 coat
www.national-paints.com
ADDITIONAL DATA
SHELF LIFE @ 30C
NOTE: We warranty only the quality of our product and this data sheet is based on results obtained from experience and tests.
We reserve the right to change data without prior notice. For surface preparation, safety details refer specifier and safety
data.
This data sheet supersedes all previous issued.
Issued: 0608
Rev. 05/10
Page 3/3
www.national-paints.com