Professional Documents
Culture Documents
Technical Note
Title:
Date:
23/01/2004
Versions:
2003.04+
Program:
Introduction
Where we have several horizontal and Inclined planes
sharing a member, (eg M1) the gravity area loading panel
selection can get confused.
In the diagrams opposite the panel defined by
M1, M2, M3 & M4 will get confused by the
members in the sloping panel M1, M8, M9 &
M22.
In defining the Eaves floor spanning front to
back you will obtain a weird area loading
diagram like this below in fig 2.
Fig 1
Solution
The solution is in done in three stages.
Fig 2
Fig 4
Regards
MasterSeries Team