Professional Documents
Culture Documents
Name:
Class:
Date:
1.
A vernier caliper is used to measure the thickness of the wall of the test
tube. The inner diameter and outer diameter is as shown in Fig. 1.1 and
Fig. 1.2 respectively
What is the thickness of the test tube?
2
10
Fig. 1.1
A
C
2.
10
Fig. 1.2
0.37 cm
0.73 cm
B
D
0.38 cm
0.76 cm
The time taken for a pendulum to swing from the rest position X to its
maximum displacement Y is 1.5 s.
What is the frequency of the pendulum?
Z
X
A
C
0.17 Hz
4.5 Hz
B
D
3.0 Hz
6.0 Hz
3.
Which of the following set of forces would not have a resultant force of 5
N?
A
1 N and 4 N
B
2 N and 6 N
C
3 N and 8 N
D
5 N and 11 N
4.
Oil drips at a constant rate from a moving car. The diagram shows the
pattern of the drips on a road.
Y
X
121 m
If the dripping rate is 1 drop per 0.5 s, calculate the average speed of the
moving car from X to Y.
A
10 m/s
B 11 m/s
C 22 m/s
D 121 m/s
An object is released from rest at a height in a vacuum. The same object is
then released from the same height in air. How would the objects time of
flight and acceleration change?
5.
6.
time of flight
acceleration
decrease
increase
increase
decrease
same
decrease
same
increase
R
P
7.
600 N
2400 N
3000 N
3600 N
9.
8.
0.008 g/cm3
8.33 g/cm3
B
0.013 g/cm3
10.0 g/cm3
empty
water
water
sand
2
mass = 308 g
mass = 808 g
mass = 1200 g
mass = 1500 g
If the density of water is 1.00 g/cm3, what is the density of the sand?
A
C
10.
11.
1.78 g/cm3
3.13 g/cm3
2.97 g/cm3
4.46 g/cm3
B
D
Size of base
high
large
high
small
low
large
low
small
12.
fluid
1000
2000
2500
10 000
13.
14.
In the diagram, two copper cans X and Y with outer surface of different
texture are filled with the same amount of water at boiling point and left in
the room. After a short while, the temperature of the two cans are different
because
dull
surface
A
B
C
D
15.
polished
surface
When two bodies are in contact with each other, heat always flows from the
body of
A
B
C
D
16.
The diagram shows a ray of light passing through a rectangular glass block.
b
18.
sin(90 a)
sin(90 b)
sin(90 e)
sin(90 f)
sin a
sin b
sin e
sin f
A lens is used to form a sharp image of a bright object on a screen. The top
half of the lens is now covered with an opaque material. How would the
image be affected?
A
B
C
D
19.
The two peaks, X and Y, as shown below were produced on the screen of a
cathode ray oscilloscope when high frequency radio waves (radar) were
sent out (X) and returned (Y) after bouncing off an aeroplane.
1320 m
300 km
600 km
1200 km
20. Two of the following wires P, Q, R and S are to be connected to the points X
and Y to form a complete circuit. Which two wires should be used so that
the ammeter A gives the lowest reading?
Q
3
S
A
C
P and R
Q and R
B P and S
D
R and S
21.
Identical iron and steel cylinders are magnetised by placing them inside a
solenoid (coil) connected to a d.c. supply.
Which pair of statements about the strength of the magnetic field produced
by the iron and steel cylinder is correct.
with supply switched on
22.
Two plotting compasses are placed on top and below a long conducting
wire carrying a current as shown
Current direction
X
Y
Which of the following shows the correct directions of the pointers of the 2
compasses?
A