Professional Documents
Culture Documents
B) Plant Manager
D) Piping Engineer
B) Fatigue Cracking
D) Environmental Cracking
B) API 577
D) ASME Sec VIII
Answer = A, API 570, Para 8.2.1 & API 577 Sect 11.2 on Hot Taps &
In-serv welding
4. Following a significant change in operating condition:
A) Onstream thickness data must be collected within six months
B) Inspection interval must be renewed and adjusted
C) Re-inspect at quarter life interval
D) The previously established inspection interval must be reduced
Answer = B is most correct, API 570, Para 7.1.2 Estimate new
corrosion rate using experience or similar service (renew, adjust) or
utilize the 3 months rule
5. The following thickness information was noted for a piping
inspection:
Jan 1993 - 0.32 Jan 2004 - 0.20 (After this a process change
initiated) Jan 2009 - 0.18
The retirement thickness of the piping which is 0.15 shall be
reached in:
A) Jan 2012
C) Jun 2016
B) Jun 2014
D) Jan 2020
OPEN Book Questions API 570 Sept 2013 Exam Memories (Roy
Orbison)
01. For piping systems where service conditions have been changed,
if data for the same or similar service is not available, a corrosion
rate is estimated from the experience of the owner/operator or
from:
A) Published data on piping systems in comparable service
B) The highest known corrosion rate in the unit
C) A default corrosion rate of 10 mils per year
D) Worst case industry data
Answer: A API 570, Para. 7.1.2.b Should expect this as closed
book also
02. A welding discontinuity is:
A) Condition of being imperfect/departure of quality characteristic from its
intended cond
B) An imperfection or unintentional nonconformance that is detectable by
NDE
C) A lack of cohesion; an interruption in the normal physical structure
D) The response or evidence from the application of NDE
Answer: C API 577, Table 8, Page 56, Definition A-2 Very hard to
find Make notes in definitions to look here Be smart!!!!
3. The size of the fillet weld refers to the dimension of the welds:
A) Throat
C) Reinforcement
B) Leg
D) Toe
B) 25%
D) 75%
Ans: D API 570, Para. 6.4 & Table 3 Damaged Column = 75% for
Class 1