You are on page 1of 17

HOME

Chapter 7

Electricity

7-1. Main control circuits .................................


7-1-1. Toner density control .............................
7-1-2. Fusing temperature control ...................
7-1-3. JAM detection .........................................
7-1-4. Safety circuit ...........................................

7-1
7-1
7-2
7-3
7-4

7-2. Timing chart ............................................... 7-5


7-2-1. A4, TWO COPIES, CASSETTE PAPER
FEED (UPPER) ........................................ 7-5
7-2-2. A4, TWO COPIES, CASSETTE PAPER
FEED (LOWER) ....................................... 7-5
7-3. Connector list ............................................ 7-6
7-3-1. Main CB (UNIT MAIN) ............................. 7-6
7-3-2. High voltage unit (UNIT HV) ................... 7-9
7-3-3. Power supply board (UNIT PSU) ......... 7-12
7-4. IC list ........................................................ 7-13
7-5. Test points and VR list ............................ 7-14
7-6. Electrical parts layout drawing ...............
7-6-1. PCB, lamp (heater), fuse (rating) .........
7-6-2. Clutches (solenoid) and motors ..........
7-6-3. Sensors and switches ..........................

7-14
7-14
7-15
7-15

HOME
Chapter 7 Electricity

7-1. Main Control Circuits


7-1-1. Toner Density Control
1. Toner Density Detection
The TNS signal detected by the toner sensor is relayed by the high voltage unit (UNIT HV) and connected to
CN191-20 on the main CB (UNIT MAIN). After the TNS signal is changed to a partial voltage (TNS! signal) by the
registance in the main PCB, it is input into the IC121 (CPU) pin no. 77. The TNS! signal can be measured with the
test point (TP103).
2. Toner Motor Drive Control
As the toner is consumed and the toner density becomes lighter than the optimum density, the TMS signal is
output (HIGH -> LOW) from the IC121 no. 23 pin. The drive circuit in the high voltage PCB (UNIT HV) is activated
to rotate the toner motor (pulse motor) and supply the toner.
Supply time: 3.25 seconds
3. Forced Toner Supply Mode
If the toner sensor detects a light density 1% less than the optimum density three times in succession, this unit will
stop the copy operation, and forcibly supply toner. During this modes operation, P25 will display (forcibly supplying
toner).time: maximum 250 seconds
When the toner density is recovered (6%), the stopped copy job will automatically resume. However, if the density
is not recovered, P25 will blink (toner empty), and after 30 copies, the copy operation will stop.
4. Initialization of Developing Unit
When the units power is turned on in the unused state (when installed), P26 will light (developer not initialized),
and the standby state will not be entered. This is so that the compensation voltage TNSC signal (analog voltage)
applied on the toner sensor can be calculated beforehand so that the TNS signal will become the reference
voltage in the new developer (unused) state. When the initialization operation (user mode C-51) is carried out, the
detected compensation data will be saved in the main PCBs EEPROM (IC123). (Note: The developing unit must
be initialized also when it has been replaced.)
Initialization time: 6 minutes (3 minutes agitation + 3 min. reading & compensation data registration)
+5V

UNIT HV

+24V

/TSM
Q1251

CI1251B

TNM0

CN1251
1

CI1251C
Q1255

Q1252
Toner supply
motor
Q1253

CN1261-5

TSMCLK

TNM1
CI1251A

+24V

CI1251D
Q1254

Q1256

GND24

TNS

3
4
5
6
CN1261-4
CN191-19

UNIT MAIN

TP103

TNSC
TNS!

TSMCLK

77

CN191-18
TP104
CN191-17

IC121
TNSC!

/TSM

TSMCLK
TSM

7-1

45
23

Toner sensor

HOME
Chapter 7 Electricity

7-1-2 Fusing Temperature Control


The surface temperature of the heat roller is detected with a thermistor, and is kept to a constant optimum temperature (188C) by turning the fusing heater ON and OFF with the SSR circuit on the power supply PCB (UNIT
PSU).
1. Temperature Detection
The temperature detection thermistor is contacted against the surface of the heat roller. The registance value
changes according to the temperature.
Low temperature (68F) : 95KW ~145KW
Optimum temperature (370F) : 0.9KW ~1.0KW
The FUTHM signal detected by the thermistor is relayed by the power supply PCB (UNIT PSU), and connected to
CN151-B12 in the main PCB (UNIT MAIN). The signal is changed to a partial pressure (TEMP signal) by the
registance in the main PCB. The TEMP signal is changed into a further partial voltage(FU TEMP signal) by the
registance, and input into the IC121 (CPU) pin no. 76. The TEMP signal is approximately 4.14V at the optimum
temperature (standard 370F), and can be measured with the test point (TP102).
2. Error Detection
The TEMP signal is used also to monitor for thermistor errors. If an overheat (FUOVH) or thermistor open
(FUTHOPN) is detected, the heater power is cut off by the safety circuit. If a fault (hardware circuit fault or software hang up) that causes the fusing heater to remain lit occurs, the thermostat connected in series to the fusing
heater operates and cuts off the heater power.
(F34: High temperature error, F35: Low temperature error, F36: Thermistor error -> Must be released with service
mode 25-47)
3. SSR Circuit
If the fusing temperature drops below the optimum temperature (188C), the SSR signal (LOW-> HIGH) is output
from the IC121 (CPU) pin No. 32, and reversed (HIGH->LOW) by the IC124. Then, the SSR circuit in the power
supply PCB (UNIT PSU) is driven to light the fusing heater.
UNIT MAIN

+5V

TP102
CN151-B12
FUTHM
CN1031-B12
+5V

Thermostat

FU-N

CN1037-1
CN1037-2
CN1002-2

FU-L

CN1002-1

Thermostor
Fusing heater

+5V

6
5

TEMP

FUOVH

IC141B

+5V

+24V

2
8
UNIT PSU

+5V

FUTHOPN

1
4

AC-L
IC141A

Fusing heater power

D1002

AC-N
IC121

/SSR
+24V

FUTEMP
D1001

76

SSR circuit
IC124

CN1031-B15

Safety circuit

/SSR

CN151-B15

15

2
8

7-2

SSR

32

Safety circuit

HOME
Chapter 7 Electricity

7-1-3. JAM Detection


Paper jams are detected with the JAM1 sensor (photo coupler) installed at the paper feed section and the JAM2
sensor (switch) installed at the paper exit section. The JAM1 sensor is set before the slip roller, and also acts as
the manual feed detection sensor.
1. JAM1 Sensor
The JAM1 signal (HIGH->LOW when there is paper) output from the JAM1 sensor is relayed by the power supply
PCB (UNIT PSU), and is connected to the main PCB (UNIT MAIN) CN151-B1. It is then input into the IC121
(CPU) pin no. 63.
2. JAM2 Sensor
The JAM2 signal (HIGH->LOW when there is paper) output from the JAM2 sensor is relayed by the power supply
PCB (UNIT PSU), and is connected to the main PCB (UNIT MAIN) CN151-B13. It is then input into the IC121
(CPU) pin no. 64.

UNIT PSU
+5V

JAM1 sensor
(photo coupler)

CN1034
1

UNIT MAIN

+5V

LEDJ1

+5V

CN1031
CN151
2

JAM1

B1

JAM2

B13

IC121
JAM1!

B1

63

JAM2 sensor
(SM)

CN1038
2

JAM2!

B13

64

3. JAM Detection Conditions


Display code

Detection conditions

Unit operation

J11

* Paper was incorrectly fed from unit standard cassette (upper cassette).
* Paper did not reach the JAM1 sensor within 1.3 sec. after the upper cassette
paper feed solenoid turned ON.

* Operation stops after the


previous paper is exited.

J12

* Paper was incorrectly fed from option cassette feeder (lower cassette).
* Paper did not reach the JAM1 sensor within 3.21 sec. after the lower
cassette paper feed solenoid turned ON.

* Operation stops after the


previous paper is exited.

J16

* There was paper on the JAM1 sensor when the power was turned
ON or the upper cover closed.

* Instantaneous stop
* Fusing heater turns OFF.

J31

* The JAM2 sensor did not turn ON within 2.85 to 3.54 sec. after the
regist clutch turned ON.

* Instantaneous stop
* Fusing heater turns OFF.

J32

* The JAM2 sensor did not turn OFF within 2.85 to 3.54 sec. after the
JAM1 sensor turned OFF.
* There was paper on the JAM2 sensor while waiting.

* Instantaneous stop
* Fusing heater turns OFF.

JAM releasing method: Remove the jammed paper, and then open and close the upper cover.
* After the jam releasing procedure was carried out, J16 may occur again when the paper which was at the paper
feed path was fed. In this case, release the jam again.

7-3

HOME
Chapter 7 Electricity

7-1-4. Safety Circuit


With this unit, the interlock switch and upper cover open switch are turned OFF when the user opens the upper
cover. The AC power for the fusing lamp and exposure lamp, and the DC power (+24) for the high voltage circuit
shown in the circuit diagram and that for the main motor are cut off. The main relay is cut off in the same manner
when an error signal is detected on the main PCB (UNIT MAIN).
1. Exposure Lamp Error
The exposure lamp lighting signal (AVRERR: this is not an error signal) is detected and regulated its waveform by
the exposure lamp lighting detection circuit on the power supply PCB. The AVRERR signal is connected to the
main PCB (UNIT MAIN) by the CN1031-B16, and monitors whether the lamp is continuously lit (approximatey 15
seconds). If it is detected that the lamp is continuously lit for 15 seconds or more, the main relay is cut off by the
AVRERR signal (LOW-> HIGH).
2. Fusing Heater Error
When an error signal (FUTHOPN: thermistor open, FUOVH: fusing overheat) is detected with the fusing temperature control circuit, the AVRERR signal (LOW->HIGH) is generated in the same manner as the exposure lamp
error, and the main relay is cut off.
(F34: High temperature error, F35: Low temperature error, F36: Thermistor error -> Must be released with service
mode 25-47)

Exposure lamp

Double terminal
CN1011-2
Fusing heater
T1011

CN1011-1
UNIT PSU

+24V

+24V

S24V
Q1034

Q1033

CN1036-2
High voltage circuit
(Charge/transfer/bias)
Exposure lamp drive circuit
AC-N IN

S24V
D1032

CN1001-3

D1033

D1031

EXPERR

Upper cover open switch(Tums OFF when upper cover is opened)


CN1036-1

Main relay
CN1001-1

CN1031-B16

AC-L IN
Interlock switch

GND24
Exposure lamp lighting detection circuit

CN1031-B14

Main motor drive circuit

/MRL
CN151-B14

UNIT MAIN

+5V
+24V

IC126A

IC125
15

IC126B
6

2 3

MRL

27

2
IC121

IC152A
FUTHOPN
FUOVH
EXPERR!
+5V
EXPERR
CN151-B16

1
2

Main relay drive circuit

EXPERR!

53

+5V
+5V

+5V

IC152A
7

5
6

1
2

R154
1.5M 1/10W

+5V

IC151C

IC151D

IC151D
12
13

11

C154
10U 6.3V

9
10
4

/RESET
Exposure lamp continuous lighting (approx.15sec.)
detection circuit

7-4

8
AVRERR
6

39

HOME
Chapter 7 Electricity

7-2. Timing Chart


7-2-1. 8.5 x 11, TWO COPIES, CASSETTE PAPER FEED (UPPER)
5260

First

Main motor
Main erase lamp
Mirror feed
Mirror return
Mirror HP sensor
Exposure lamp
Side erase lamp
Developer bias
Charging
Transfer
Transfer polarity
Paper feed solenoid(U)
Regist clutch
JAM1 sensor
JAM2 sensor
Fan high-speed
Fan low-speed
Toner supply motor
Total counter

10220

Multi

Last

200

12850

200

12850
6610

5440

1650

5460

10400

6530

11490

10420

6510 6630

1670
300
1810

11400

5430

6390

10390

5330

6550

10290

12850

100

13350

200

12850

200

12850
2320

5930

10890

7280

5260 5730

300 770
1880

5650

970

5040

6840

10610

5930

10000
7770

4230

12730

9190

13350
13350
5130

1880

10090

6840

12850 13350

10

11

12

13

14

15

16

17

18

19

20

21

17

18

19

20

21

7-2-2. 8.5 x 11, TWO COPIES, CASSETTE PAPER FEED (LOWER)

Main motor
Main erase lamp
Mirror feed
Mirror return
Mirror HP sensor
Exposure lamp
Side erase lamp
Developer bias
Charging
Transfer
Transfer polarity
CF motor
Paper feed solenoid(L)
Regist clutch
JAM1 sensor
JAM2 sensor
Fan high-speed
Fan low-speed
Toner supply motor
Total counter

6440

First

11440

Multi

Last
15430

200
3050

6840

9190

6860
3070

12980

7930

12960

7910 6860

300

6830

13900

8910

6730

3210

14030

12790

9350

15430

12870

100

15930

200

15430

200

15430
7330

3720
300

9860

3030 3280

13470

9170 9420

15430

6440 6910

300 770
3280

7050

2310

13190

9420
8450

6440
5630

12580
11770

9170

15310
15930
15930

6530

3280

12670

9420

15430 15930

7-5

10

11

12

13

14

15

16

HOME
Chapter 7 Electricity

7-3. Connector List


7-3-1. Main CB (UNIT MAIN)
CN - No.

Pin

Symbol

CN131
CN131
CN131
CN131
CN131
CN131
CN131
CN131
CN131
CN131
CN131
CN131

1
2
3
4
5
6
7
8
9
10
11
12

STBLED
/E2000
VRGND
EXPVR
KEY2
KEY1
VR5V
/LEDLD
LEDCKL
LEDDO
DGND
+5V

Not used
Not used
Exposure density adjustment VR signal
Key switch No. 2 group
Key switch No. 1 group
Exposure density adjustment VR, +5V for each key
LED serial data load signal
LED serial data transfer clock
LED lighting serial data
Digital ground
+5V power supply

IN
IN
IN

CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151
CN151

A1

/PRC
/PSC
STB5
S24V
GND24
GND24
+24V
DGND
DGND
+5V

Paper regist clutch drive signal

OUT Drive at LOW


OUT Drive at LOW

A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
B1
B2
B3
B4
B5
B6
B7
B8
B9
B10
B11
B12
B13
B14

+5V
+5V
+5V
/PWR
/EXP
EXPCONT
JAM1
/PE
S24V
S24V
GND24
+24V
+24V
DGND
DGND
+5V
/CSOPNU
FUTHM
JAM2
/MRL

IN/OUT

Details

Active

Remarks

Exposure density adjustment VR, analog ground for each key

Paper feed solenoid(U) drive signal (Drive at Lo)

Not used
+24V power supply via cover open switch
+24V drive system ground
+24V drive system ground
+24V power supply
Digital ground
Digital ground
+5V power supply
+5V power supply
+5V power supply
+5V power supply
Not used
Exposure lamp lighting signal (Lights at Lo)
Exposure lamp lighting voltage control signal (analog)

JAM1 sensor signal


Upper cassette out of paper signal
+24V power supply via cover open switch
+24V power supply via cover open switch
+24V drive system ground
+24V power supply
+24V power supply
Digital ground
Digital ground
+5V power supply
Not used
Fusing temperature (thermistor) detection signal
JAM2 sensor signal
Main relay ON/OFF signal

7-6

Analog signal
Analog signal
Analog signal

OUT Load at LOW


Measurement not possible
OUT Clock signal
OUT LED lights at HIGH

OUT
OUT
IN
IN

Lights at LOW
Analog signal
Paper detected at LOW
HIGH when out of paper
Upper cover open: OFF
Upper cover open: OFF

Analog signal
IN
Paper detected at LOW
IN
OUT Relay drive at LOW

HOME
Chapter 7 Electricity
Pin

Symbol

CN151 B15
CN151 B16
CN152 1

/SSR
EXPERR
S24V

CN - No.

Details

IN/OUT

SSR ON/OFF signal


Exposure lamp lighting monitor signal

OUT
IN

Active

Remarks

Fusing heater drive at LOW

HIGH when exposure lamp is lit

S24V with ON/OFF control

Upper cover open: OFF

(+24V except power save mode)

CN152
CN152
CN152
CN152
CN152
CN152
CN152
CN152
CN152
CN152
CN152
CN152
CN152
CN152

GND24
GND24
GND24
+24V
+24V
+24V
SDHFAN
FSLOCK
FOLOCK1
FAN24
MHP
DGND
DRV5V
SDHTHM

+24V drive system ground


+24V drive system ground
+24V drive system ground
+24V power supply
+24V power supply
+24V power supply
SDH fan ON/OFF signal
SDH fan lock signal
OP fan lock signal
OP fan drive signal
Mirror home position sensor signal
Digital ground
+5V with ON/OFF control

CN161 1

2
3
4
5
6
7
8
9
10
11
12
13
14
15

OUT
IN
IN
OUT
IN

Drive at HIGH
HIGH when locked
HIGH when locked
OP fan drive at +24V
HIGH at set position
+5V when not in power save mode

SDH temperature detection (thermistor) signal

OUT
IN

/MMLOCK

Main motor speed control lock signal

IN

LOW when locked

CN161 2

/MMST

24/ Main motor drive signal

OUT

CN161 3

DRV24V

Power supply (24V) with ON/FF control and safety circuit

OUT

Drive at LOW
0V during power save

CN161 4

GND24

+24V drive system ground

CN162 1

/TPC

Total paper counter drive signal

OUT

Count up at LOW

CN162 2

+24V

+24V power supply

CN171 1

/CSOPNL

Lower cassette not mounted signal

CN171 2

DGND

Digital ground

CN171 3

+5V

+5V power supply

CN171 4

/LPE

Lower cassette out of paper signal

CN171 5

DGND

Digital ground

CN171 6

DGND

Digital ground

CN171 7

+5V

+5V power supply

CN171 8

PTM

Cassette feeder paper feed motor clock

OUT

CN171 9

/LMST

Cassette feeder paper feed motor ON/OFF signal

OUT

Clock signal
Drive at HIGH

CN171 10

GND24

+24V drive system ground

CN171 11

+24V

+24V power supply

CN171 12

+24V

+24V power supply

CN171 13

/LPSC

Paper feed solenoid (L)

OUT

Drive at LOW

CN171 14

NC

Not connected

CN191 1

/DRUM

Drum unit not mounted detection signal

IN

HIGH when on mounted

CN191 2

/TSE

Not used

CN191 3

/GRID

GRID terminal ON/OFF signal

OUT

GRID output at LOW

CN191 4

/HVCC

CC terminal ON/OFF signal

OUT

CN191 5

/HVTP

TC polarity changeover signal

OUT

CC output at LOW
TC + polarity at LOW

7-7

(8P, 9P, 15P:


factory option)

Analog signal

Upper cover open: OFF

HIGH when no cassette is mounted

HIGH when out of paper

Measurement not possible

HOME
Chapter 7 Electricity
CN - No.

Pin

Symbol

CN191

/HVTC

CN191

/LMB

CN191
CN191

8
9

/LMA
LMB

CN191

10

CN191

11

CN191

IN/OUT

Active

TC terminal ON/OFF signal

OUT

Lens motor drive excitation signal (/B phase)


Lens motor drive excitation signal (/A phase)

OUT

Lens motor drive excitation signal (/B phase)

OUT

LMA

Lens motor drive excitation signal (/A phase)

OUT

/SMB

Mirror motor drive excitation signal (/B phase)

12

/SMA

Mirror motor drive excitation signal (/A phase)

OUT
OUT

CN191

13

SMB

OUT

CN191
CN191

14
15

SMA
LHP

Mirror motor drive excitation signal (/B phase)


Mirror motor drive excitation signal (/A phase)
Lens home position sensor signal

IN

TC output at LOW
Clock signal
Clock signal
Clock signal
Clock signal
Clock signal
Clock signal
Clock signal
Clock signal
HIGH at set position

CN191

16

TRAYS

Not used

CN191

17

/TSM

Toner motor drive signal

CN191

18

TSMCLK

Toner motor drive clock

CN191

19

TNSC

CN191

20

TNS

Signal for toner sensor output adjustment


Toner sensor output signal

CN191

21

DGND

Digital ground

CN191

22

AE

Not used

CN192
CN192

1
2

CCL
/SER6

Main erase lamp drive signal


Side erase lamp drive signal(D56,D66)

OUT
OUT

CN192

/SER5

Side erase lamp drive signal(D55,D65)

OUT

CN192

/SER4

Side erase lamp drive signal(D54,D64)

CN192

/SER3

CN192
CN192

6
7

/SER2
/SER1

Side erase lamp drive signal(D53,D63)


Side erase lamp drive signal(D52,D62)

OUT
OUT

CN192

/SER0

Details

OUT

OUT

OUT
OUT
OUT
IN

OUT

Side erase lamp drive signal(D51,D61)

OUT

Side erase lamp drive signal

OUT

ON at LOW
60Hz pulse
Analog signal
Analog signal

Remarks

Measurement not possible


Measurement not possible
Measurement not possible
Measurement not possible
Measurement not possible
Measurement not possible
Measurement not possible
Measurement not possible

Voltage rises at
low density

Drive at +24V
Lights at LOW
Lights at LOW
Lights at LOW
Lights at LOW
Lights at LOW
Lights at LOW
Lights at LOW

(D71 to D78,D81 to D88)


(9 to 12P, 14 to 18P
: factory option)
CN192
CN192

9
10

/AMB
/AMA

SDH motor drive excitation signal (/B phase)

OUT

SDH motor drive excitation signal (/A phase)

OUT

CN192

11

AMB

SDH motor drive excitation signal (/B phase)

OUT

CN192

12

AMA

SDH motor drive excitation signal (/A phase)

OUT

CN192

13

MRM

Mirror motor, SDH motor exciting current changeover signal

CN192

14

SDHPC

OUT
OUT

CN192

15
16

CN192
CN192
CN192

SDH paper feed clutch drive signal


SDHOPN SDH open detection sensor signal
SDH B4 size detection sensor signal
/CS3

17

/CS2

SDH document regist sensor signal

18

/CS1

SDH no original detection sensor signal

7-8

IN

Clock signal
Clock signal
Clock signal
Clock signal
Low current at HIGH
Clutch ON at HIGH
HIGH at open

IN

LOW at B4 detection

IN

LOW when original feed

IN

LOW when original is detected

Measurement not possible


Measurement not possible
Measurement not possible
Measurement not possible

HOME
Chapter 7 Electricity

7-3-2. High Voltage Unit (UNIT HV)


CN - No.
CN1201
CN1201
CN1201
CN1201
CN1201
CN1201
CN1211
CN1211
CN1211
CN1211
CN1211
CN1231
CN1231
CN1231
CN1231
CN1231
CN1231
CN1231
CN1231
CN1231
CN1231
CN1251
CN1251
CN1251
CN1251
CN1251
CN1251
CN1261
CN1261
CN1261
CN1261
CN1261
CN1261
CN1261
CN1261
CN1261
CN1261
CN1261
CN1261
CN1261
CN1261

Pin

Symbol

Details

1
2
3
4
5
6
1
2
3
4
5
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6

LMOA
LMOB
/LMOA
/LMOB
LM24V
LM24V
SMOA
SMOB
/SMOA
/SMOB
SM24V
+24V
/SDHPC
+24V
/SDHPC
AMOA
AMOB
/AMOA
/AMOB
AM24V
AM24V
TNM0
TNM1
TNSC
+24V
DGND
TNS

Lens motor drive excitation signal (/A phase)Output


Lens motor drive excitation signal (/B phase)Output
Lens motor drive excitation signal (/A phase)Output
Lens motor drive excitation signal (/B phase)Output
Lens motor power supply
Lens motor power supply
Mirror motor drive excitation signal (/A phase)Output
Mirror motor drive excitation signal (/B phase)Output
Mirror motor drive excitation signal (/A phase)Output
Mirror motor drive excitation signal (/B phase)Output
Scanner motor power supply
+24V power supply
SDH shutter solenoid output
+24V power supply
SDH paper feed clutch output
SDH motor drive excitation signal (/A phase)Output
SDH motor drive excitation signal (/B phase)Output
SDH motor drive excitation signal (/A phase)Output
SDH motor drive excitation signal (/B phase)Output
SDH motor power supply
SDH motor power supply
Toner motor drive power supply output
Toner motor drive power supply output
Signal for toner sensor output adjustment
+24V power supply
Digital ground
Toner sensor output signal

1
2
3

AE
DGND
TNS

Not used
Not used
Toner sensor output signal

4
5
6
7
8
9
10
11
12
13
14

TNSC
TSMCLK
/TSM
TRAYS
LHP
SMA
SMB

Signal for toner sensor output adjustment


Toner motor drive clock
Toner motor drive signal
Not used
Lens home position sensor signal
Mirror motor drive excitation signal (/A phase)
Mirror motor drive excitation signal (/B phase)
Mirror motor drive excitation signal (/A phase)
Mirror motor drive excitation signal (/B phase)
Lens motor drive excitation signal (/A phase)
Lens motor drive excitation signal (/B phase)

/SMA
/SMB
LMA
LMB

IN/OUT

7-9

Active

Remarks

OUT
OUT
OUT
OUT

Clock signal
Clock signal
Clock signal
Clock signal

Measurement not possible

OUT
OUT
OUT
OUT

Clock signal
Clock signal
Clock signal
Clock signal

Measurement not possible

Measurement not possible


Measurement not possible
Measurement not possible

Measurement not possible


Measurement not possible
Measurement not possible

(factory option)
ON at LOW

OUT
OUT
OUT
OUT

ON at LOW
Clock signal
Clock signal
Clock signal
Clock signal

OUT
OUT
OUT

60Hz pulse
60Hz pulse
Analog signal

IN

Analog signal

Voltage rises at
low density

IN

Analog signal

Voltage rises at
low density

OUT
OUT
OUT

Analog signal
60Hz pulse
ON at LOW

IN
OUT
OUT
OUT
OUT
OUT
OUT

HIGH at set position


Clock signal
Clock signal
Clock signal
Clock signal
Clock signal
Clock signal

Measurement not possible


Measurement not possible
Measurement not possible
Measurement not possible

Measurement not possible

Measurement not possible


Measurement not possible
Measurement not possible
Measurement not possible
Measurement not possible
Measurement not possible

HOME
Chapter 7 Electricity
Symbol

IN/OUT

Active

Remarks

CN - No.

Pin

CN1261

15

/LMA

Lens motor drive excitation signal (/A phase)

OUT

Clock signal

Measurement not possible

CN1261

16

/LMB

Lens motor drive excitation signal (/B phase)

OUT

Clock signal

Measurement not possible

CN1261

17

/HVTC

TC terminal ON/OF signal

OUT

TC output at LOW

CN1261

18

/HVTP

TC polarity changeover signal

OUT

TC + polarity at LOW

CN1261

19

/HVCC

CC terminal ON/OF signal

OUT

TC output at LOW

CN1261

20

/GRID

GRID terminal ON/OF signal

OUT

TC output at LOW

CN1261

21

/TSE

Not used

CN1261

22

/DRUM

Drum unit not mounted detection signal

IN

HIGH when not mounted

CN1262

/CS1

SDH no original detection sensor signal

IN

LOW when original is

Details

detected

(1 to 5P: factory
option)

CN1262

/CS2

SDH document regist sensor signal

IN

LOW when original feed

CN1262

/CS3

SDH B4 size detection sensor signal

IN

LOW at B4 detection

CN1262

SDHOPN SDH open detection sensor signal

IN

HIGH when open

CN1262

SDHPC

SDH paper feed clutch drive signal

OUT

Clutch ON at HIGH

CN1262

MRM

Mirror motor, SDH motor exciting current changeover signal

OUT

Small current at HIGH

CN1262

AMA

SDH motor drive excitation signal (/A phase)

OUT

Clock signal

Measurement not possible (pulse

CN1262

AMB

SDH motor drive excitation signal (/B phase)

OUT

Clock signal

wave)

CN1262

/AMA

SDH motor drive excitation signal (/A phase)

OUT

Clock signal

Measurement not possible (pulse

CN1262

10

/AMB

SDH motor drive excitation signal (/B phase)

OUT

Clock signal

wave)

CN1262

11

/SER0

Side erase lamp drive signal

OUT

Lights at LOW

Measurement not possible (pulse

(D71 to D78,D81 to D88)

wave)

CN1262

12

/SER1

Side erase lamp drive signal(D56,D66)

OUT

Lights at LOW

Measurement not possible (pulse

CN1262

13

/SER2

Side erase lamp drive signal(D55,D65)

OUT

Lights at LOW

wave)

CN1262

14

/SER3

Side erase lamp drive signal(D54,D64)

OUT

Lights at LOW

CN1262

15

/SER4

Side erase lamp drive signal(D53,D63)

OUT

Lights at LOW

CN1262

16

/SER5

Side erase lamp drive signal(D52,D62)

OUT

Lights at LOW

CN1262

17

/SER6

Lights at LOW

CN1262

18

CCL

Side erase lamp drive signal(D51,D61)


Main erase lamp drive signal

OUT

CN1263

SDHTHM SDH temperature detection (thermistor) signal

IN

Analog signal

CN1263

DRV5V

OUT

+5V when not in

CN1263

DGND

CN1263

MHP

CN1263

CN1263

Digital ground
Mirror home position sensor signal
FAN24
OP fan drive signal
FOLOCK1 OP fan lock signal

CN1263

CN1263

CN1263

+24V

+24V power supply

CN1263

10

+24V

+24V power supply

CN1263

11

+24V

+24V power supply

CN1263

12

GND24

+24V drive system ground

CN1263

13

GND24

+24V drive system ground

CN1263

14

GND24

+24V drive system ground

CN1263

15

S24V

+24V power supply via cover open switch

+5V with ON/OFF control

OUT
(1 to 5P: factory
option)

power save mode


IN

HIGH at set position


OP fan drive at +24V

IN

HIGH when locked

FSLOCK SDH fan lock signal

IN

HIGH when locked

SDHFAN SDH fan ON/OFF signal

OUT

Drive at HIGH

7-10

Upper cover open: OFF

HOME
Chapter 7 Electricity
CN - No.

Pin

CN1271
CN1271
CN1271
CN1271
CN1272
CN1272
CN1272
CN1273
CN1273
CN1273
CN1274
CN1274
CN1275
CN1275
CN1275
CN1276
CN1276

1
2
3
4
1
2
3
1
2
3
1
2
1
2
3
1
2

+5V
LHP
DGND
NC
+5V
MHP

+5V power supply

DGND

Digital ground

GND24
FOLOCK1

Ground

FAN24

OP fan drive signal

+5V

+5V power supply

SDHTHM

SDH temperature detection (thermistor) signal

+5V

CN1276
CN1276
CN1276
CN1276
CN1276
CN1276
CN1277
CN1277
CN1277
CN1278
CN1278
CN1281
CN1281
CN1281
CN1281
CN1281
CN1281
CN1281
CN1281
CN1281
CN1282
CN1282
CN1282

3
4
5
6

SER1
SER2
SER3
SER4
SER5
SER6
GND24
FSLOCK
SFAN24
+24V
/CCL
/CS1
DGND
+5V
/CS2
DGND
/CS3
DGND
SDHOPN
DGND
GND24
FOLOCK2
FAN24

Not used
Not used
Not used
+24V power supply
Side erase lamp drive signal
(D71~D78,D81~D88)
Side erase lamp drive signal(D51,D61)
Side erase lamp drive signal(D52,D62)
Side erase lamp drive signal(D53,D63)
Side erase lamp drive signal(D54,D64)
Side erase lamp drive signal(D55,D65)
Side erase lamp drive signal(D56,D66)
+24V drive system ground
SDH fan lock signal
SDH fan power supply output
+24V power supply
Main erase lamp drive signal
SDH no original detection sensor signal
Digital ground
+5V power supply
SDH document regist sensor signal
Digital ground

7
8
1
2
3
1
2
1
2
3
4
5
6
7
8
9
1
2
3

Symbol

AE
DGND
+24V
SER0

IN/OUT

Details

Lens home position sensor signal

Active

IN

HIGH at set position

IN

HIGH at set position

IN
OUT

HIGH when locked


OP fan drive at +24V

IN

Analog signal

OUT

Lights at LOW

OUT
OUT
OUT
OUT
OUT
OUT

Lights at LOW
Lights at LOW
Lights at LOW
Lights at LOW
Lights at LOW
Lights at LOW

Remarks

Digital ground
Not connected
+5V power supply
Mirror home position sensor signal

OP fan 1 lock signal

(Factory option)

SDH B4 size detection sensor signal

(Factory option)
IN

HIGH when locked


SDH fan drive at +24V

OUT
IN

Lights at LOW
LOW when original is detected

Detected when LOW


IN

LOW when original feed

IN

LOW at B4 detection

IN

HIGH when open

IN

HIGH when locked

Digital ground
SDH open detection sensor signal
Digital ground
Ground
OP fan 2 lock signal
OP fan 2 power supply output

7-11

(Factory option)

HOME
Chapter 7 Electricity

7-3-3. Power Supply Board (UNIT PSU)


CN - No.

Pin

CN1001
CN1001
CN1001
CN1002
CN1002
CN1011
CN1011
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1031
CN1032
CN1032
CN1032
CN1032

1
2
3
1
2
1
2
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
B1
B2
B3
B4
B5
B6
B7
B8
B9
B10
B11
B12
B13
B14
B15
B16
1
2
1
2

Symbol
AC-L
NC
AC-N
FU-L
FU-N
EXP-L
EXP-N
/PRC
/PSC
STB5
S24V
GND24
GND24
+24V
DGND
DGND
+5V
+5V
+5V
+5V
/PWR
/EXP
EXPCONT
JAM1
/PE
S24V
S24V
GND24
+24V
+24V
DGND
DGND
+5V
/CSOPNU
FUTHM
JAM2
/MRL
/SSR
EXPERR
+24V
/PSC
+24V
/PRC

Details

IN/OUT

Power supply input(L)

Active

IN

AC primary circuit

Power supply input(N)

IN

AC primary circuit

Fusing heater output(L)

OUT

Fusing heater output(N)

OUT

Exposure lamp output(L)

OUT

Exposure lamp output(N)

OUT
OUT
OUT

AC primary circuit
AC primary circuit
AC primary circuit
AC primary circuit

Remarks

Not connected

Paper regist clutch drive signal


Paper feed solenoid(U) drive signal (Drive at Lo)

Drive at LOW
Drive at LOW

Not used
+24V power supply via cover open switch
+24V drive system ground
+24V drive system ground
+24V power supply
Digital ground
Digital ground
+5V power supply
+5V power supply
+5V power supply
+5V power supply
Not used
Exposure lamp lighting signal (Lights at Lo) OUT
Exposure lamp lighting voltage control signal (analog) OUT
JAM1 sensor signal
IN
Not used

Lights at LOW
Analog signal
Paper detected at LOW

+24V power supply via cover open switch


+24V power supply via cover open switch
+24V power supply
+24V power supply
+24V power supply
Digital ground
Digital ground
+5V power supply
Standard cassette not mounted signal
Fusing temperature (thermistor) detection signal

JAM1 sensor signal


Main relay ON/OFF signal
SSR ON/OFF signal
Exposure lamp lighting monitor signal

Upper cover open: OFF


Upper cover open: OFF

IN
IN
IN
OUT
OUT
IN

No cassette mounted at HIGH

OUT

Drive at LOW

OUT

Drive at LOW

Analog signal
Paper detected at LOW
Relay drive at LOW
Fusing heater drive at LOW
HIGH when exposure lamp is lit

+24V power supply


Paper feed solenoid(U) drive signal
+24V power supply
Regist clutch drive signal

7-12

HOME
Chapter 7 Electricity
CN - No.

Pin

Symbol

Details

CN1034 1
CN1034 2
CN1034 3

LEDJ1
JAM1
DGND

+5V power supply for JAM1 sensor


JAM1 sensor signal
Digital ground

CN1035 1
CN1035 2
CN1035 3

LEDPE
/PE
DGND

+5V power supply for PE sensor


Upper cassette out of paper signal
Digital ground

CN1036
CN1036
CN1037
CN1037
CN1038
CN1038
CN1038

+24V
S24V
+5V
FUTHM
NC
JAM2
DGND

+24V power supply


+24V power supply via cover open switch
+5V power supply
Fusing temperature (thermistor) detection signal
Not connected
JAM2 sensor signal
Digital ground

1
2
1
2
1
2
3

IN/OUT

IN

Active

Remarks

Paper detected at LOW

HIGH when out of paper


OUT
IN

Upper cover open: OFF

IN

1Analog signal

IN

Paper detected at LOW

7-4. IC List
PCB

Location No.

UNIT PSU
UNIT PSU
UNIT PSU
UNIT PSU
UNIT OP
UNIT OP
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT HV
UNIT HV
UNIT HV
UNIT HV
UNIT HV

IC1031
IC1051
IC1071
IC1081
IC751
IC770 IC780
IC121
IC122
IC123
IC124
IC125
IC126
IC141
IC151
IC152
IC181 IC182
IC191
IC192 IC193
IC194
IC195
IC1121
IC1122
IC1171
IC1211
IC1251

Part name/type
LA6358NM-TP-T1
MC33262P
UPC1093T-T1
MC34063AP1
LC7932M-TE-R
LC7933M-TE-R
UPD78054FGC
M51953BFP-600C
S-29130AFJ-TB
TD62503F-TP1
TD62003AF-TP1
TC7W02F-TE12L
LA6393M-TP-T1
HD74HC132FP-TR
TC7W02F-TE12L
HD74HC244FP-TR
HD74HC244FP-TR
HD74HC175FP-T
HD74HC175FP-T
TD62503F-TP1
MC33262P
TA78L012AP
LA6082M-TP-T1
MTD1120F
HD74HC00FP-TR

Application
Operation amplifier (for exposure lamp lighting control (AVR))
Switching power control
Reference voltage IC (switching power section)
DC-DC converter IC (+5V power supply)
Serial-parallel driver (for each LED lighting)
Serial driver (for 7-segment LED lighting)
CPU
Reset IC
EEPROM (for electronic counter, setting, adjustment data storage)
Transistor array (for high voltage, exposure and fusing drive)
Transistor array (clutch, solenoid main relay drive)
NOR gate (for main relay control signal)
Comparator (for fusing temperature error detection)
NAND gate (for exposure lamp lighting error detection)
OR gate (for exposure lamp lighting error detection)
Line buffer (stepping motor exciting output)
Line buffer (optical section sensor input selector)
D-TYPE FF (Side erase lamp, mirror motor control output)
D-TYPE FF (SDH clutch, SDH fan control output)
Transistor array (for side erase lamp drive)
Switching power control IC (charge, bias output)
12V 3-terminal regulator
Operation amplifier (for transfer output control)
Stepping motor set current drive driver (mirror scanner)
NAND gate (toner motor section)

7-13

HOME
Chapter 7 Electricity

7-5. Test Points and VR List


Details

Symbol

Remarks

Location

Test point

UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN
UNIT MAIN

TP101
TP102
TP103
TP104
TP105
TP106
TP107
TP108
TP109

DGND
TEMP
TNS!
TNSC
EXPCNT
EXRVR
KEY1
KEY2
AE!

Digital ground
Fusing temperature detection signal
Toner sensor output voltage
Toner sensor control voltage
Exposure lamp lighting voltage control signal (analog)
Exposure lamp lighting voltage adjustment input (analog)
Key switches No. 1 group (analog)
Key switches No. 2 group (analog)
Not used

UNIT PSU
UNIT OP

VR1031
VR723

For exposure voltage output adjustment


For exposure voltage output adjustment

Refer to page 7-2.


Refer to page 7-1.
Refer to page 7-1.
For factory use
For factory use
For factory use
For factory use
For factory adjustment (cannot be used)
For user operations (operation panel)

7-6. Electrical Parts Layout Drawing


7-6-1. PCB, Lamp (Heater), Fuse (Rating)
High voltage unit
(UNIT HV)
Main CB
(UNIT MAIN)

Main erase lamp

Temperature fuse 262 F

Side erase lamp


Exposure lamp
80V 220W (for 120V)
160V 220W (for 220V to 240V)

Power supply board


(UNIT PSU)
Fuse PCB
(UNIT FUSE)

Operation PCB
(UNIT OP)

Cassette heater
fuse
250V 4A

Thermostat
284 F
Fusing heater
120V 800W (for 120V)
230V 800W
(for 220 to 240V)

Main fuse
125V 10A(for 120V)
250V 6.3A
(for 220 to 240V)
Main cassette
dehumidification heater
fuse 250V 1.6A

Main cassette
dehumidification heater

Power supply board main fuse


125V 3.15A(for 120V)
250V 1.6A(for 220 to 240V)
Cassette feeder (option)
Dehumidification heater
Fuse 250V 1.6A

Cassette feeder (option)


dehumidification heater
Cassette feeder motor driver PCB
(UNIT MOTOR DRIVER)

7-14

HOME
Chapter 7 Electricity

7-6-2. Clutches (Solenoid) and Motors

SDH shutter solenoid


SDH paper feed motor

SDH paper feed clutch

SDH cooling fan

Lens drive motor


OP cooling fan
Mirror scan motor
Main motor
Toner supply motor
Regist clutch
Paper feed
solenoid(U)
Cassette feeder
paper feed motor

Paper feed solenoid(L)

7-6-3. Sensors and Switches


SDH original detection sensor

SDH original read


detection sensor

Mirror home position sensor

SDH thermistor
SDH cover open
detection sensor
Operation keys

Interlock switch
Lens home
position sensor

Main switch
JAM2 sensor

JAM1 sensor

Toner sensor

PE sensor

7-15

Thermistor

HOME
Chapter 7 Electricity

This page left blank intentionally.

7-16

You might also like