Professional Documents
Culture Documents
GHS Classification
Not a hazardous substance or mixture.
GHS Label element
Not a hazardous substance or mixture.
Potential Health Effects
Carcinogenicity:
IARC No component of this product present at levels greater
than or equal to 0.1% is identified as probable, possible
or confirmed human carcinogen by IARC.
Emergency Overview
Appearance liquid
Odour mild
Hazardous components
CAS-No. Chemical Name Concentration (%)
64742-53-6 Distillates (petroleum), hydrotreated light 70 - 90
naphthenic
72623-86-0 Lubricating oils (petroleum), C15-30, hy- 10 - 20
drotreated neutral oil-based
128-37-0 Butylated hydroxytoluene 0.1 - 1
Specific hazards during : Do not allow run-off from fire fighting to enter drains
firefighting or water courses.
Methods and materials : Wipe up with absorbent material (e.g. cloth, fleece).
for containment and Keep in suitable, closed containers for disposal.
cleaning up
Conditions for safe stor- : Keep container tightly closed in a dry and well-
age ventilated place.
Containers which are opened must be carefully re-
sealed and kept upright to prevent leakage.
Electrical installations / working materials must com-
ply with the technological safety standards.
Hand protection
Remarks : The suitability for a specific workplace should be dis-
cussed with the producers of the protective gloves.
Appearance : liquid
Odour : mild
pH : No data available
Solubility(ies)
Water solubility : slightly soluble
vents
Conditions to avoid : Keep away from heat, flame, sparks and other ignition
sources.
Acute toxicity
Product:
Acute inhalation toxicity : Assessment: The substance or mixture has no acute
inhalation toxicity
Components:
64742-53-6:
Acute oral toxicity : LD50 (Rat, male and female): > 5,000 mg/kg
GLP: yes
Acute dermal toxicity : LD50 (Rabbit, male and female): > 2,000 mg/kg
Method: Fixed dose procedure
Symptoms: Local irritation
GLP: yes
72623-86-0:
Acute oral toxicity : LD50 (Rat, male and female): > 5,000 mg/kg
Method: OECD Test Guideline 401
Acute inhalation toxicity : LC50 (Rat, male and female): 2.18 mg/l
Method: OECD Test Guideline 403
Assessment: The component/mixture is toxic after
short term inhalation.
Acute dermal toxicity : LD50 (Rabbit, male and female): > 2,000 mg/kg
Method: OECD Test Guideline 402
128-37-0:
Acute oral toxicity : LD50 (Rat, male and female): > 6,000 mg/kg
Method: OECD Test Guideline 401
GLP: yes
Acute dermal toxicity : LD50 (Rat, male and female): > 2,000 mg/kg
Method: OECD Test Guideline 402
Symptoms: No mortality observed at this dose.
GLP: yes
Assessment: The substance or mixture has no acute
dermal toxicity
Skin corrosion/irritation
Product:
Result: No skin irritation
Components:
64742-53-6:
Species: Rabbit
Result: Mild skin irritation
72623-86-0:
Species: Rabbit
Method: OECD Test Guideline 404
Result: No skin irritation
128-37-0:
Species: Rabbit
Product:
Result: No eye irritation
Components:
64742-53-6:
Species: Rabbit
Result: No eye irritation
72623-86-0:
Species: Rabbit
Result: No eye irritation
Method: OECD Test Guideline 405
128-37-0:
Species: Rabbit
Result: No eye irritation
Method: OECD Test Guideline 405
Components:
64742-53-6:
Test Type: Buehler Test
Species: Guinea pig
Result: Did not cause sensitisation on laboratory animals.
72623-86-0:
Test Type: Buehler Test
Species: Guinea pig
Method: OECD Test Guideline 406
Result: Did not cause sensitisation on laboratory animals.
128-37-0:
Test Type: Maximization test
Species: Guinea pig
Result: Did not cause sensitisation on laboratory animals.
Test substance: Information given is based on data obtained from similar substanc-
es.
Components:
64742-53-6:
Germ cell mutagenicity- : Tests on bacterial or mammalian cell cultures did not
Assessment show mutagenic effects.
72623-86-0:
Genotoxicity in vitro : Test Type: Chromosome aberration test in vitro
Test species: Chinese hamster ovary (CHO)
Method: OECD Test Guideline 473
Result: negative
Germ cell mutagenicity- : Tests on bacterial or mammalian cell cultures did not
Assessment show mutagenic effects.
128-37-0:
Genotoxicity in vitro : Test Type: Chromosome aberration test in vitro
Test species: Chinese hamster ovary (CHO)
Metabolic activation: with and without metabolic acti-
vation
Result: negative
Germ cell mutagenicity- : Tests on bacterial or mammalian cell cultures did not
Assessment show mutagenic effects.
Carcinogenicity
Components:
64742-53-6:
Carcinogenicity - As- : Not classifiable as a human carcinogen.
sessment
72623-86-0:
Species: Mouse, (male)
NOAEL: 100 mg/kg bw/day
128-37-0:
Species: Rat, (male and female)
Application Route: Oral
Exposure time: 98 wk
Dose: 0, 25, 100, 500 mg/kg bw/day
GLP: yes
Reproductive toxicity
Components:
64742-53-6:
Effects on fertility : Test Type: Screening test
Species: Rat
Application Route: Oral
Duration of Single Treatment: 44 d
General Toxicity - Parent: NOAEL: 1,000 mg/kg bw
Method: OECD Test Guideline 421
72623-86-0:
Effects on fertility : Test Type: Screening test
Species: Rat, male and female
General Toxicity - Parent: NOAEL: >= 1,000
General Toxicity F1: NOAEL: >= 1,000
128-37-0:
Effects on fertility : Species: Rat
Application Route: oral
Dose: 0, 25, 100, 500 mg/kg bw/day
Fertility: NOAEL: 500 mg/kg
Result: Animal testing did not show any effects on
fertility.
GLP: yes
Components:
72623-86-0:
Exposure routes: Target Organs: Assessment: Remarks:
Adrenal gland, Causes damage to
Bone, Liver, Kid- organs through
ney, Immune sys- prolonged or re-
tem peated exposure.,
The substance or
mixture is classified
as specific target
organ toxicant, re-
peated exposure,
category 1.
Components:
64742-53-6:
Species: Rat
LOAEL: 125 mg/kg
Application Route: Oral
Exposure time: 13 w
Number of exposures: 5 d/w
Method: OECD Test Guideline 408
72623-86-0:
Species: Rat, male
LOAEL: 125 mg/kg
Application Route: Oral
Method: OECD Test Guideline 408
128-37-0:
Species: Rat, male and female
NOAEL: 25 mg/kg
LOAEL: 100 mg/kg
Application Route: Oral
Dose: 0, 25, 100, 500 mg/kg bw/day
Symptoms: Liver effects
Aspiration toxicity
Product:
No aspiration toxicity classification
Components:
72623-86-0:
May be fatal if swallowed and enters airways.
128-37-0:
No aspiration toxicity classification
Further information
Product:
Remarks: No data available
Ecotoxicity
Components:
64742-53-6:
Toxicity to fish : LL50 (Pimephales promelas (fathead minnow)): > 100
mg/l
Exposure time: 96 h
Toxicity to daphnia and : LL50 (Daphnia magna (Water flea)): > 1,000 mg/l
other aquatic inverte- Exposure time: 48 h
brates Test Type: Immobilization
72623-86-0:
Toxicity to fish : LL50 (Pimephales promelas (fathead minnow)): > 100
mg/l
Exposure time: 96 h
Test Type: static test
Method: OECD Test Guideline 203
Toxicity to daphnia and : LL50 (Gammarus pulex (Scud)): > 5,000 mg/l
other aquatic inverte- Exposure time: 24 h
brates Method: OECD Test Guideline 202
128-37-0:
Toxicity to fish : LC50 (Oncorhynchus mykiss (rainbow trout)): 0.199
mg/l
Exposure time: 96 h
Toxicity to daphnia and : EC50 (Daphnia magna (Water flea)): 0.48 mg/l
other aquatic inverte- Exposure time: 48 h
brates Test Type: static test
Method: OECD Test Guideline 202
GLP: yes
Ecotoxicology Assessment
Acute aquatic toxicity : Very toxic to aquatic life.
Chronic aquatic toxicity : Very toxic to aquatic life with long lasting effects.
Components:
64742-53-6:
Biodegradability : Inoculum: activated sludge
Concentration: 44 mg/l
Biodegradation: 31 %
Exposure time: 28 d
GLP: yes
Remarks: Readily biodegradable
72623-86-0:
Biodegradability : Remarks: No data available
128-37-0:
Biodegradability : Result: Not readily biodegradable.
Biodegradation: 4.5 %
Exposure time: 28 d
Bioaccumulative potential
Components:
64742-53-6:
Partition coefficient: n- : log Pow: Calculated 3.9 - 6
octanol/water
128-37-0:
Mobility in soil
No data available
Other adverse effects
No data available
Product:
Regulation 40 CFR Protection of Environment; Part 82 Protection
of Stratospheric Ozone - CAA Section 602 Class I Sub-
stances
Remarks This product neither contains, nor was manufactured
with a Class I or Class II ODS as defined by the U.S.
Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A
+ B).
Disposal methods
Waste from residues : Dispose of in accordance with all applicable local,
state and federal regulations.
For assistance with your waste management needs -
including disposal, recycling and waste stream reduc-
tion, contact NEXEO's Environmental Services Group
at 800-637-7922.
WHMIS Classification : D2A: Very Toxic Material Causing Other Toxic Effects
SARA 313 : This material does not contain any chemical compo-
nents with known CAS numbers that exceed the
threshold (De Minimis) reporting levels established by
SARA Title III, Section 313.
California Prop 65 This product does not contain any chemicals known to
State of California to cause cancer, birth defects, or
any other reproductive harm.
HEALTH 1
1
Instability
Health
1 0 FLAMMABILITY 1
PHYSICAL HAZARD 0
The information accumulated is based on the data of which we are aware and is
believed to be correct as of the date hereof. Since this information may be ap-
plied under conditions beyond our control and with which we may be unfamiliar
and since data made become available subsequently to the date hereof, we do
not assume any responsibility for the results of its use. Recipients are advised to
confirm in advance of need that the information is current, applicable, and suita-
ble to their circumstances. This MSDS has been prepared by NEXEO Solutions
EHS Product Safety Department (1-855-429-2661) MSDS@nexeosolutions.com.
Material number:
16058857, 16058856, 16058855, 16058854
Key or legend to abbreviations and acronyms used in the safety data sheet
ACGIH American Conference of Gov- LD50 Lethal Dose 50%
ernment Industrial Hygienists
AICS Australia, Inventory of Chem- LOAEL Lowest Observed Adverse Effect
ical Substances Level
DSL Canada, Domestic Substanc- NFPA National Fire Protection Agency
es List
NDSL Canada, Non-Domestic Sub- NIOSH National Institute for Occupational
stances List Safety & Health
CNS Central Nervous System NTP National Toxicology Program