Professional Documents
Culture Documents
Supercast TP Waterstop
Uses
The Supercast TP range of PVC waterstop are recommended for sealing joints in in-situ
concrete construction. They are specifically recommended for sealing joint subject to high water pressure.
The Supercast TP range of waterstop, with incorporation of eyeleted anchorage point, are suitable for
construction and contraction joints.
Advantages
Technical support
Fosroc offer a comprehensive range from high performance, high quality, and construction products
Fosroc offer a comprehensive range from high performance, high quality, and construction products
all backed by BS 5750 certification. Fosroc offers a technical support package to specifiers and contractors
and technical advice from staff with unrivalled experience in the industry.
Description
Supercast TP waterstop are extruded a high grade PVC compound which has been formulated to give
excellent flexibility and longevity characteristic.
They are available as straight lengths and factory produced intersections or as factory prefabricated segment of a
network to minimize site jointing.
concrete thickness, the aggregate size and the position ofthe reinforcement.
Supercast TP sections
Supercast TP W200
Supercast TP W250
waterstop. The design profile enables the jointing between the two Supercast waterstop through the use of factory made
intersections.
Properties
Installation instruction
Waterstop must be installed so that they are securely held in their correct position while the concrete is being
placed. Concrete must be fully compacted around the waterstop to ensure no voids or porous areas remain.
Where reinforcement is present, an adequate clearance must be left to permit proper compaction.
The brass eyelets used for securing the waterstop are located outside the edge bulbs so as not to create water paths
around the profile.
Jointing of Supercast TP waterstop is carried out using Fosroc Heat Welding Equipment. The ends to be joined are cut
square and held in alignment in a special heated blade, until an even, molten bead of PVC appears around the section.
The heated blade is then removed and the molten ends pressed fully together. The PVC cools to form a strong fusion
welded joint.
An experienced technician can perform the jointing of the waterstop without using the jig, subject to prior training
and approval by Fosroc Technical Department.
Estimating
Equipment
Electric heater blades are available from Fosroc (110v and 220v and 350W)
Precautions
Hot weld jointing of PVC waterstop results in the liberation of hydrogen chloride mist and vapour. The OEL
(operational exposure limit) of 5 ppm can be exceeded in still air confined spaces. Therefore ventilation must be
provided or a suitable respirators used.
Follow
Powered by WordPress.com