Professional Documents
Culture Documents
PCU2-E C110629
Figure 5: Jumpers, DIP switch and backplane connectors of plug-in unit PCU2-E
Standard settings are presented in the table below, the jumpers must be set as shown during normal operation.
There are no alternative settings available on the plug-in unit, except for jumper W1.
DIP switch SW1 is used for setting the interchangeability code of the plug-in unit when required, see the table
below.
W12;1 - 2 1-2 ON RS-232 port speed is 115200 bps (OFF = 9600 bps)
W12;3 - 4 3-4 OFF no IPETC cartridge usage
1 of 3 10/8/2013 10:16 AM
PCU2-E C110629 http://127.0.0.1:43231/NED/NED?service=printview&library=a25003a...
W1 1-4 OFF Full 8M PCM mode. Concerning new delivery Flexi BSC
selected for PCU2-Es in slots 03-07 in BCSU 1-6.
Concerning upgraded BSC3i selected for PCU2-Es in slots
03-05 in BCSUs 0-3 and in slots 03-07 in BCSUs 4-6
W13 1-2 OFF MPC 8567 emulator is disabled. Setting ON will enable
MPC 8567 emulator.
W13 3-4 OFF MPC 8567 watchdog is enabled. Setting ON will disable
watchdog.
D OFF OFF ON ON
F OFF ON OFF ON
G OFF ON ON OFF
H OFF ON ON ON
K ON OFF OFF ON
L ON OFF ON OFF
M ON OFF ON ON
2 of 3 10/8/2013 10:16 AM
PCU2-E C110629 http://127.0.0.1:43231/NED/NED?service=printview&library=a25003a...
N ON ON OFF OFF
P ON ON OFF ON
R ON ON ON OFF
3 of 3 10/8/2013 10:16 AM