Professional Documents
Culture Documents
GHS07 GHS08
Signal word (GHS-US) : Danger
Hazard statements (GHS-US) : H315 - Causes skin irritation
H319 - Causes serious eye irritation
H336 - May cause drowsiness or dizziness
H341 - Suspected of causing genetic defects
H350 - May cause cancer
Precautionary statements (GHS-US) : P201 - Obtain special instructions before use
P202 - Do not handle until all safety precautions have been read and understood
P261 - Avoid breathing fume, gas, mist, spray, vapors
P264 - Wash exposed skin thoroughly after handling
P271 - Use only outdoors or in a well-ventilated area
P280 - Wear eye protection, protective gloves
P302+P352 - If on skin: Wash with plenty of water/
P304+P340 - If inhaled: Remove person to fresh air and keep comfortable for breathing
P305+P351+P338 - If in eyes: Rinse cautiously with water for several minutes. Remove contact
lenses, if present and easy to do. Continue rinsing
P308+P313 - If exposed or concerned: Get medical advice/attention
P312 - Call a poison center/doctor/ if you feel unwell
P321 - Specific treatment (see ... on this label)
P332+P313 - If skin irritation occurs: Get medical advice/attention
P337+P313 - If eye irritation persists: Get medical advice/attention
P362 - Take off contaminated clothing and wash before reuse
P403+P233 - Store in a well-ventilated place. Keep container tightly closed
P405 - Store locked up
01/02/2015 EN (English US) Page 1
UVA201 Clue Spray
Safety Data Sheet
according to Federal Register / Vol. 77, No. 58 / Monday, March 26, 2012 / Rules and Regulations
trichloroethylene (79-01-6)
OSHA Not applicable
trichloroethylene (79-01-6)
LD50 oral rat 4920 mg/kg (Rat)
LD50 dermal rabbit > 20000 mg/kg (Rabbit)
LC50 inhalation rat (mg/l) 66 mg/l/4h (Rat)
LC50 inhalation rat (ppm) 12000 ppm/4h (Rat)
ATE US (oral) 4920.000 mg/kg body weight
ATE US (gases) 12000.000 ppmV/4h
ATE US (vapors) 66.000 mg/l/4h
ATE US (dust, mist) 66.000 mg/l/4h
trichloroethylene (79-01-6)
IARC group 2A - Probably carcinogenic to humans
trichloroethylene (79-01-6)
LC50 fish 1 40.7 mg/l (96 h; Pimephales promelas)
LC50 other aquatic organisms 1 20 mg/l (48 h; Plankton)
EC50 Daphnia 1 39 - 51 mg/l (48 h; Daphnia pulex; Static system)
LC50 fish 2 45 mg/l (96 h; Lepomis macrochirus)
EC50 Daphnia 2 20.8 mg/l (48 h; Daphnia magna)
TLM fish 1 100 - 1000,96 h; Pisces
TLM other aquatic organisms 1 100 - 1000,96 h
Threshold limit other aquatic organisms 1 20 mg/l (48 h; Plankton)
Threshold limit algae 1 > 100 mg/l (Scenedesmus quadricauda)
Threshold limit algae 2 63 mg/l (Microcystis aeruginosa)
Effect on the global warming : No known ecological damage caused by this product.
ADR
No additional information available
Transport by sea
No additional information available
Air transport
UN-No.(IATA) : UN1950
Proper Shipping Name (IATA) : Aerosols, flammable
Class (IATA) : 2.1 - Gases : Flammable
Packing group (IATA) : II - Medium Danger
EU-Regulations
No additional information available
NFPA health hazard : 1 - Exposure could cause irritation but only minor residual
injury even if no treatment is given.
NFPA fire hazard : 4 - Will rapidly or completely vaporize at normal pressure
and temperature, or is readily dispersed in air and will burn
readily.
NFPA reactivity : 0 - Normally stable, even under fire exposure conditions,
and are not reactive with water.
The information above is believed to be accurate and represents the best information currently available to us . However, we make no warranty of merchantability or any other warranty, expressed or
implied, with respect to such information, and we assume no liability resulting from its use. Users should make their own investigation to determine the suitability of the information for their particular
purposes.