You are on page 1of 21

301

DRIVE SHAFT / PROPELLER SHAFT DRIVE SHAFT, PROPELLER SHAFT, AXLE

DRIVE SHAFT, PROPELLER SHAFT, AXLE


3005C02

PROBLEM SYMPTOMS TABLE


Use the table below to help you find the cause of the problem. The numbers indicate the priority of
the likely cause of the problem. Check each part in order. If necessary, replace these parts.
Symptom Suspect Area See page
5. Wheel 281
6. Front wheel alignment 266
7. Rear wheel alignment 274
Wander
8. Hub bearing (Worn) 302
9. Front shock absorber 2610
10.Rear shock absorber 278

1. Wheel (Imbalance) 281


2. Hub bearing (Worn) 302
3. Lower suspension arm ATM: 2616
Front wheel shimmy
4. Lower suspension arm MTM: 2621
5. Lower ball joint (Worm) 2624
6. Front shock absorber 2610

1. Front drive shaft 306


2. Front shock absorber 2610
Noise (Front)
3. Hub bearing (Worn) 302
4. Lower ball joint (Worm) 2624

1. Hub bearing (Worn) 302


Noise (Rear)
2. Rear shock absorber 278

AVENSIS REPAIR MANUAL (RM1018E)


302
DRIVE SHAFT / PROPELLER SHAFT DRIVE SHAFT, PROPELLER SHAFT, AXLE
3005B02

ONVEHICLE INSPECTION

1. INSPECT FRONT AXLE HUB BEARING BACKLASH


(a) Using a dial indicator, check the backlash near the center
of the axle hub.
Maximum: 0.05 mm (0.0020 in.)
If the backlash exceeds the maximum, replace the bearing.

D26919

2. INSPECT FRONT AXLE HUB DEVIATION


(a) Using a dial indicator, check the deviation at the surface
of the axle hub outside the hub bolt.
Maximum: 0.05 mm (0.0020 in.)
If the backlash exceeds the maximum, replace the axle hub.

D26920

3. INSPECT REAR AXLE HUB BEARING BACKLASH


(a) Using a dial indicator, check the backlash near the center
of the axle hub.
Maximum: 0.05 mm (0.0020 in.)
If the backlash exceeds the maximum, replace the axle hub as-
sembly.

C98714

4. INSPECT REAR AXLE HUB DEVIATION


(a) Using a dial indicator, check the deviation at the surface
of the axle hub outside the hub bolt.
Maximum: 0.07 mm (0.0028 in.)
If the backlash exceeds the maximum, replace the axle hub as-
sembly.

C98715

AVENSIS REPAIR MANUAL (RM1018E)


3021
DRIVE SHAFT / PROPELLER SHAFT FRONT AXLE HUB SUBASSY LH

FRONT AXLE HUB SUBASSY LH


3009102

COMPONENTS

Front Stabilizer Link Assy LH


Speed Sensor Front LH
8.0 (82, 71 in.lbf)
74 (755, 55)

 Cotter Pin
19 (194, 14)

220 (2,243, 162)


Front Axle Assy LH

Front Drive Shaft 49 (500, 36)


Assy LH

102 (1,040, 75)


Tie Rod End Subassy LH

Front Disc
Front Disc Brake
Caliper Assy LH

Front Suspension Arm


Subassy Lower No. 1 LH  Front Axle  216 (2,200, 159)
89 (908, 66) LH Hub Bolt Front Axle Hub LH Nut
 Front Axle Hub
LH Snap Ring Steering Knuckle LH

Disc Brake Dust Cover Front LH


 Front Axle Hub
LH Bearing
 Cotter Pin 8.3 (85, 73 in.lbf)

103 (1,050, 76)

Lower Ball Joint


Assy Front LH

8.3 (85, 73 in.lbf) Front Axle


Nm (kgfcm, ftlbf) : Specified torque Hub Subassy LH
 Nonreusable parts
 D30592

AVENSIS REPAIR MANUAL (RM1018E)


3022
DRIVE SHAFT / PROPELLER SHAFT FRONT AXLE HUB SUBASSY LH
300JY01

REPLACEMENT
HINT:
Replace the RH side by the same procedures as the LH side.
1. REMOVE FRONT WHEEL
2. SEPARATE FRONT STABILIZER LINK ASSY LH (See page 306)

3. REMOVE FRONT AXLE HUB LH NUT


(a) Using SST and a hammer, unstake the staked part of the
axle hub LH nut.
SST
SST 0993000010
(b) While applying the brakes, remove the axle hub LH nut.

 F45751

4. DISCONNECT SPEED SENSOR FRONT LH


(a) Remove the bolt, and disconnect the speed sensor wire
and flexible hose from the shock absorber.

C80291

(b) Remove the bolt, separate the speed sensor front LH


from the steering knuckle.
NOTICE:
 Be careful not to damage the speed sensor.
 Prevent foreign matter from attaching to the speed
sensor.

F44775

5. SEPARATE FRONT DISC BRAKE CALIPER ASSY LH


(a) Removing the 2 bolts, separate the disc brake caliper
assy LH from the steering knuckle.
NOTICE:
Use a string or other device to keep the brake caliper from
hanging down.

C67088

AVENSIS REPAIR MANUAL (RM1018E)


3023
DRIVE SHAFT / PROPELLER SHAFT FRONT AXLE HUB SUBASSY LH

6. REMOVE FRONT DISC

7. SEPARATE TIE ROD END SUBASSY LH


Turn SST
(a) Remove the cotter pin and nut.
(b) Using SST, separate the tie rod end subassy LH from the
steering knuckle.
SST 0962862011

Hold

F40217

8. SEPARATE FRONT SUSPENSION ARM SUBASSY


LOWER NO.1 LH
(a) Remove the bolt and 2 nuts, and separate the suspension
arm subassy lower No.1 LH from the lower ball joint.

C80293

9. REMOVE FRONT AXLE ASSY LH


(a) Using a plastic hammer, separate the drive shaft assy LH
from the axle hub.
NOTICE:
Be careful not to damage the boot and ABS speed sensor
rotor.

D27403

(b) Remove the 2 bolts, nuts and steering knuckle with the
shock absorber.

C83023

AVENSIS REPAIR MANUAL (RM1018E)


3024
DRIVE SHAFT / PROPELLER SHAFT FRONT AXLE HUB SUBASSY LH

10. REMOVE LOWER BALL JOINT ASSY FRONT LH


SST (a) Remove the cotter pin and nut.
(b) Using SST, remove the ball joint.
SST 0962862011

F40228

11. REMOVE FRONT AXLE HUB LH HOLE SNAP RING


(a) Using snap ring pliers, remove the hole snap ring.

F40229

12. REMOVE FRONT AXLE HUB SUBASSY LH


(a) Using SST, remove the axle hub subassy.
SST
SST 0952000031

F40156

(b) Using SST, remove the bearing inner race (outside) from
the axle hub subassy.
SST
SST 0995040011 (0995104020, 0995204010,
Turn
0995304030, 0995404010, 0995504061,
0995704010, 0995804010), 0995060010
(0995100370)

Hold SST

C53088 F45153

13. REMOVE DISC BRAKE DUST COVER FRONT LH


(a) Remove the 3 bolts and disc brake dust cover front LH.

AVENSIS REPAIR MANUAL (RM1018E)


3025
DRIVE SHAFT / PROPELLER SHAFT FRONT AXLE HUB SUBASSY LH

14. REMOVE FRONT AXLE HUB LH BEARING


(a) Place the bearing inner race (outside) on the axle hub LH
SST bearing.
(b) Using SST and a press, remove the axle hub LH bearing
from the steering knuckle.
SST 0952717011, 0995060010 (0995100640),
0995070010 (0995107100)
SST

F40230

15. INSTALL FRONT AXLE HUB LH BEARING


(a) Using SST and a press, install a new axle hub LH bearing
to the steering knuckle.
SST
SST 0995060020 (0995100720), 0995070010
(0995107100)

F40231

16. INSTALL DISC BRAKE DUST COVER FRONT LH


(a) Install the disc brake dust cover with the 3 bolts.
Torque: 8.3 Nm (85 kgfcm, 73 in.lbf)

17. INSTALL FRONT AXLE HUB SUBASSY LH


(a) Using SST and a press, install the axle hub subassy.
SST SST 0960832010, 0995060010 (0995100600),
0995070010 (0995107100)

SST
F40232

18. INSTALL FRONT AXLE HUB LH HOLE SNAP RING


(a) Using snap ring pliers, install the hole snap ring.

F40229

AVENSIS REPAIR MANUAL (RM1018E)


3026
DRIVE SHAFT / PROPELLER SHAFT FRONT AXLE HUB SUBASSY LH

19. INSTALL LOWER BALL JOINT ASSY FRONT LH


(a) Install the lower ball joint and torque the nut.
Torque: 103 Nm (1,050 kgfcm, 76 ftlbf)
(b) Install a new cotter pin.
NOTICE:
If the holes for the cotter pin are not aligned, tighten the nut up to 60_ further.

20. INSTALL FRONT AXLE ASSY LH


(a) Install the 2 bolts, nuts and steering knuckle with 2 bolts
and nuts to the shock absorber.
Torque: 220 Nm (2,243 kgfcm, 162 ftlbf)
NOTICE:
Only when reusing the bolts and nuts, apply engine oil to
the screw part of the nuts.
(b) Push the front axle assy toward the outside of the vehicle,
C83023 fit the splined part of the drive shaft assy to that of the front
axle assy and insert the drive shaft assy into the front axle
assy.
NOTICE:
S Do not push out the front axle assy excessively.
S Be careful not to damage the drive shaft outboard
joint boot.
S Be careful not to damage the speed sensor rotor.

21. INSTALL FRONT SUSPENSION ARM SUBASSY


LOWER NO.1 LH
(a) Install the front suspension arm subassy lower No.1 LH
and lower ball joint with the 2 nuts and bolt.
Torque: 89 Nm (908 kgfcm, 66 ftlbf)

C80293

22. INSTALL TIE ROD END SUBASSY LH


(a) Install the tie rod end subassy LH to the steering knuckle.
(b) Install the nut and a new cotter pin.
Torque: 49 Nm (500 kgfcm, 36 ftlbf)
NOTICE:
If the holes for the cotter pin are not aligned, tighten the nut up to 60_ further.
23. INSTALL FRONT STABILIZER LINK ASSY LH (See page 306)
24. INSTALL FRONT DISC

AVENSIS REPAIR MANUAL (RM1018E)


3027
DRIVE SHAFT / PROPELLER SHAFT FRONT AXLE HUB SUBASSY LH

25. INSTALL FRONT DISC BRAKE CALIPER ASSY LH


(a) Install the disc brake caliper assy with the 2 bolts to the
steering knuckle.
Torque: 104 Nm (1,040 kgfcm, 75 ftlbf)

C67088

26. INSTALL FRONT AXLE HUB LH NUT


(a) Using a socket wrench (30 mm), install a new axle hub LH nut.
Torque: 216 Nm (2,200 kgfcm, 159 ftlbf)
27. SEPARATE FRONT DISC BRAKE CALIPER ASSY LH
(a) Removing the 2 bolts, separate the disc brake caliper assy from the steering knuckle.
NOTICE:
Use a string or other device to keep the brake caliper from hanging down.
28. REMOVE FRONT DISC
29. INSPECT BEARING BACKLASH (See page 302)
30. INSPECT AXLE HUB DEVIATION (See page 302)
31. INSTALL FRONT DISC
32. INSTALL FRONT DISC BRAKE CALIPER ASSY LH
(a) Install the disc brake caliper assy with the 2 bolts to the steering knuckle.
Torque: 104 Nm (1,040 kgfcm, 75 ftlbf)

33. CONNECT SPEED SENSOR FRONT LH


(a) Install the speed sensor front LH to the steering knuckle
with the bolt.
Torque: 8.0 Nm (82 kgfcm, 71 in.lbf)

F44775

(b) Connect the speed sensor wire and flexible hose to the
shock absorber with the bolt.
Torque: 19 Nm (194 kgfcm, 14 ftlbf)
NOTICE:
 Be careful not to damage the speed sensor.
 Keep the speed sensor clean.
 Do not twist the sensor wire when installing the sen-
sor.
C80291

AVENSIS REPAIR MANUAL (RM1018E)


3028
DRIVE SHAFT / PROPELLER SHAFT FRONT AXLE HUB SUBASSY LH

34. INSTALL FRONT AXLE HUB LH NUT


(a) While applying the brakes, install a new axle hub LH nut.
Torque: 216 Nm (2,200 kgfcm, 159 ftlbf)
(b) Using a chisel and hammer, stake the axle hub LH nut.

C68609

35. INSTALL FRONT WHEEL


Torque: 103 Nm (1,050 kgfcm, 76 ftlbf)
36. INSPECT AND ADJUST FRONT WHEEL ALIGNMENT (See page 266)
37. CHECK ABS SPEED SENSOR SIGNAL
(a) ABD WITH EBD SYSTEM (See page 05699)
(b) ABD WITH EBD & BA & TRC & VSC SYSTEM ( See page 05756)

AVENSIS REPAIR MANUAL (RM1018E)


3029
DRIVE SHAFT / PROPELLER SHAFT FRONT AXLE LH HUB BOLT

FRONT AXLE LH HUB BOLT


3009202

REPLACEMENT
HINT:
 COMPONENTS: See page 3021
 Replace the RH side by the same procedures as the LH side.
1. REMOVE FRONT WHEEL
2. SEPARATE FRONT DISC BRAKE CALIPER ASSY LH (See page 3022)
3. REMOVE FRONT DISC

4. REMOVE FRONT AXLE LH HUB BOLT


(a) Using SST and a hammer handle or an equivalent to hold
the axle hub subassy LH, remove the LH hub bolt.
SST 0962810011

Hold

SST Turn D27405

5. INSTALL FRONT AXLE LH HUB BOLT


(a) Install a washer and nut to a new LH hub bolt as shown
Washer in the illustration.
Nut
(b) Using a hammer handle or an equivalent to hold the axle
hub subassy LH, install the LH hub bolt by tightening the
Hold nut.

Turn D27401

6. INSTALL FRONT DISC


7. INSTALL FRONT DISC BRAKE CALIPER ASSY LH (See page 3022)
8. INSTALL FRONT WHEEL
Torque: 103 Nm (1,050 kgfcm, 76 ftlbf)

AVENSIS REPAIR MANUAL (RM1018E)


303
DRIVE SHAFT / PROPELLER SHAFT FRONT DRIVE SHAFT

FRONT DRIVE SHAFT


300JW01

COMPONENTS

Front Drive Shaft Assy RH


 Front Drive Shaft RH
Hole Snap Ring
3ZZFE/
1ZZFE: Front Drive Shaft LH
Hole Snap Ring
Front Drive Shaft LH
Hole Snap Ring

1AZFSE/
1AZFE/ Front Drive Shaft Assy LH
1CDFTV: 3ZZFE/
1ZZFE/
64 (650, 47)
1AZFSE (AT)/
1AZFE (AT):

Speed Sensor Front LH


Front Drive Shaft Assy RH
8.0 (82, 71 in.lbf)
64 (650, 47)

1AZFSE (MT)/
1AZFE (MT)/
Front Drive Shaft Assy LH 1CDFTV: 49 (500, 36)

Front Stabilizer Link Assy LH

Cotter Pin

Tie Rod End Subassy


Flexible Hose 74 (755, 55)

19 (194, 14)
 216 (2,200, 159)
Front Axle Hub LH Nut
Front Suspension


Arm Subassy No.1 LH


89 (908, 66)

Nm (kgfcm, ftlbf) : Specified torque


 Nonreusable parts F44751

AVENSIS REPAIR MANUAL (RM1018E)


304
DRIVE SHAFT / PROPELLER SHAFT FRONT DRIVE SHAFT

LH:
 Front Drive Shaft Dust Cover LH

Front Drive Inboard Joint Assy LH

 Front Drive Inner Shaft


Inner LH Shaft Snap Ring

Front Axle Inboard Joint Boot LH Clamp

Tripod Joint Assy Except


1AZFSE (MT)/
1AZFE (MT)/
 Front Axle Inboard Joint Boot LH No.2 Clamp 1CDFTV:

Front Drive Shaft Inboard


Joint Boot

Drive Shaft Damper Clamp

Drive Shaft Damper

 Front Drive Shaft Out board Joint Boot


 Front Axle Outboard Joint Boot LH No.2 Clamp

Front Drive Outboard Joint Shaft Assy LH

 Front Axle Outboard


Joint Boot LH Clamp

  Nonreusable parts F45574

AVENSIS REPAIR MANUAL (RM1018E)


305
DRIVE SHAFT / PROPELLER SHAFT FRONT DRIVE SHAFT

RH:

 Front Axle Outboard Joint Boot RH No.2 Clamp

Drive Shaft Outboard Joint Boot

 Front Axle Out board Joint Boot RH Clamp

1AZFSE/
1AZFE/
3ZZFE/ 1CDFTV:
1ZZFE:  Front Axle Inboard Joint Boot RH Clamp

Drive Shaft Inboard Joint Boot

Front Axle Inboard Joint


Boot RH No.2 Clamp

Drive Shaft Damper

Front Drive Outboard Joint Shaft Assy RH


1AZFSE/ Tripod Joint Assy
1AZFE/
1CDFTV:
3ZZFE/
 Drive Shaft Bearing  Front Drive Inner
1ZZFE:
Case Snap Ring Shaft Inner RH
Shaft Snap Ring
 Front Drive Shaft Bearing

Front Drive Inboard


 Straight Pin
Front Drive Inboard Joint Assy RH
Joint Assy RH

 Front Drive Shaft Drive Shaft Bearing Case


Dust Cover RH
 Front Drive Shaft
Hole Snap Ring
 Front Drive Shaft
Dust Cover
 Front Drive Shaft
Dust Cover RH
F44753  Nonreusable parts
F45575

AVENSIS REPAIR MANUAL (RM1018E)


3030
DRIVE SHAFT / PROPELLER SHAFT REAR AXLE CARRIER SUBASSY LH

REAR AXLE CARRIER SUBASSY LH


3009302

COMPONENTS
Skid Control Sensor Wire

5.0 (51, 44 in.lbf)

Upper Control Arm Assy LH


Rear Disc Brake Caliper Assy LH
74 (755, 55)

47 (475, 34)  Clip

60 (612, 44) Lower Control Arm Assy LH

Parking Brake Shoe Lever LH


 Clip Parking Brake Shoe

Rear Disc
74 (755, 55)

105 (1,071, 77)

Parking Brake Cable


Assy No.3
Parking Brake Shoe Parking Brake Adjuster Kit
140 (1,428, 103)
Parking Brake Shoe
56 (571, 41)
Adjusting Screw Set
x4

Rear Axle Hub Bolt


Rear Axle Carrier Subassy LH

Rear Axle Hub & Bearing Assy LH

Back Plate Assy LH


Nm (kgfcm, ftlbf) : Specified torque
 Nonreusable parts
 F45576

AVENSIS REPAIR MANUAL (RM1018E)


3031
DRIVE SHAFT / PROPELLER SHAFT REAR AXLE CARRIER SUBASSY LH
300JZ01

REPLACEMENT
HINT:
Replace the RH side by the same procedures as the LH side.
1. INSPECT REAR AXLE CARRIER SUBASSY LH
(a) Check that there is no looseness on the ball joint by shaking the lower arm up and down with a force
of 294 N (30kgf, 66 lbf).
2. REMOVE REAR WHEEL

3. DISCONNECT SKID CONTROL SENSOR WIRE


(a) Remove the bolt, disconnect the skid control sensor wire.
(b) Disconnect the connector.

 F45267

4. SEPARATE REAR DISC BRAKE CALIPER ASSY LH


(a) Removing the 2 bolts and rear disc brake caliper assy.
NOTICE:
Use a string or other device to keep the brake caliper from hanging down.
5. REMOVE REAR DISC
6. REMOVE PARKING BRAKE ADJUSTER KIT (See page 3314)
7. REMOVE PARKING BRAKE SHOE ADJUSTING SCREW SET (See page 3314)
8. REMOVE PARKING BRAKE SHOE KIT (See page 3314)
SST 0971800010
9. REMOVE PARKING BRAKE SHOE LEVER LH (See page 3314)
10. DISCONNECT PARKING BRAKE CABLE ASSY NO.3
(a) Using needlenose pliers, and disconnect the parking
brake cable assy No.3 from the backing plate.

F44818

11. SEPARATE LOWER CONTROL ARM ASSY LH


(a) Loosen the lower control arm assy bolt (member side).
(b) Remove the clip and nut.
(c) Using SST, separate the lower control arm assy from the
axle carrier.
SST 0961020012
SST

 F45752

AVENSIS REPAIR MANUAL (RM1018E)


3032
DRIVE SHAFT / PROPELLER SHAFT REAR AXLE CARRIER SUBASSY LH

12. SEPARATE REAR SUSPENSION ARM ASSY NO.1 LH


(a) Remove the clip and nut.
SST
(b) Using SST, separate the rear suspension arm assy No.1
(ball joint side).
SST 0962862011

Turn

Hold
 F45753

(c) Remove the bolt and nut, separate the rear suspension
arm assy No.1.
NOTICE:
When removing the bolt, hold the nut not to rotate.

G21537

13. SEPARATE UPPER CONTROL ARM ASSY


(a) Remove the bolt and nut, separate the upper control arm
assy from the axle carrier.
NOTICE:
When removing the bolt, hold the nut not to rotate.

G21542

14. REMOVE REAR AXLE CARRIER SUBASSY LH


(a) Remove the 4 bolts and nut, hub & bearing assy and axle
carrier subassy.

G20965

AVENSIS REPAIR MANUAL (RM1018E)


3033
DRIVE SHAFT / PROPELLER SHAFT REAR AXLE CARRIER SUBASSY LH

15. INSPECT REAR AXLE CARRIER SUBASSY LH


(a) As shown in the illustration, flip the ball joint stud back and
forth 5 times, before installing the nut.
(b) Using a torque wrench, turn the nut continuously at a rate
of 3 5 seconds per turn and take the torque reading on
the 5th turn.
Turning torque (Maximum):
3.0 Nm (30 kgfcm, 27 in.lbf)
G21613 NOTICE:
 Neither abnormal drag nor rattle exists during the
rotation.
 Neither crack nor grease leakage exists and deforma-
tion on the dust cover.

16. INSTALL REAR AXLE CARRIER SUBASSY LH


(a) Install the hub & bearing assy and rear axle carrier sub
assy with the 4 bolts and nut.
Torque:
Bolt: 56 Nm (571 kgfcm, 41 ftlbf)
Nut: 140 Nm (1,428 kgfcm, 103 ftlbf)

G20965

17. TEMPORARILY TIGHTEN UPPER CONTROL ARM


ASSY
(a) Temporarily tighten the upper control arm assy with the
bolt and nut.
Temporarily tighten torque:
7 13 Nm (71 133 kgfcm, 5.1 9.6 ftlbf)
HINT:
Insert the bolt from the rear side of the vehicle and temporarily
G21542 install the bolt.

18. TEMPORARILY TIGHTEN REAR SUSPENSION ARM


ASSY NO.1 LH
(a) Temporarily tighten the rear suspension arm assy (ball
joint side) with the nut.
(b) Temporarily tighten the bolt and nut.
Temporarily tighten torque:
7 13 Nm (71 133 kgfcm, 5.1 9.6 ftlbf)
HINT:
G21537 Insert the bolt from the rear side of the vehicle and temporarily
install the bolt.

AVENSIS REPAIR MANUAL (RM1018E)


3034
DRIVE SHAFT / PROPELLER SHAFT REAR AXLE CARRIER SUBASSY LH

19. TEMPORARILY TIGHTEN LOWER CONTROL ARM


ASSY LH
(a) Temporarily tighten the lower control arm assy with the
nut.
Temporarily tighten Torque:
7 13 Nm (71 133 kgfcm, 5.1 9.6 ftlbf)

G21543

20. CONNECT PARKING BRAKE CABLE ASSY NO.3


(a) Connect the parking brake cable assy No.3 to the backing
plate.

F44820

21. INSTALL PARKING BRAKE SHOE LEVER LH (See page 3314)


22. INSTALL PARKING BRAKE SHOE KIT (See page 3314)
SST 0971800010
23. INSTALL PARKING BRAKE SHOE ADJUSTING SCREW SET (See page 3314)
24. INSTALL PARKING BRAKE ADJUSTER KIT (See page 3314)
25. CHECK PARKING BRAKE INSTALLATION (See page 3314)
26. INSPECT BEARING BACKLASH (See page 302)
27. INSPECT AXLE HUB DEVIATION (See page 302)
28. INSTALL REAR DISC
29. ADJUST PARKING BRAKE SHOE CLEARANCE (See page 3314)
30. INSTALL REAR DISC BRAKE CALIPER ASSY LH
(a) Install the rear disc brake caliper with the 2 bolts.
Torque: 47 Nm (475 kgfcm, 34 ftlbf)

31. CONNECT SKID CONTROL SENSOR WIRE


(a) Connect the skid control sensor wire with the bolt.
Torque: 5.0 Nm (51 kgfcm, 44 in.lbf)
(b) Connect the connector.
HINT:
Do not twist the sensor wire when installing the sensor.

 F45267

32. INSTALL REAR WHEEL


Torque: 103 Nm (1,050 kgfcm, 76 ftlbf)
33. STABILIZE SUSPENSION (See page 278)

AVENSIS REPAIR MANUAL (RM1018E)


3035
DRIVE SHAFT / PROPELLER SHAFT REAR AXLE CARRIER SUBASSY LH

34. FULLY TIGHTEN UPPER CONTROL ARM ASSY


(a) Fully tighten the bolt.
Torque: 74 Nm (755 kgfcm, 55 ftlbf)
NOTICE:
When installing the bolt, hold the nut not to rotate.
35. FULLY TIGHTEN REAR SUSPENSION ARM ASSY NO.1 LH
(a) Fully tighten the nut (ball joint side).
Torque: 105 Nm (1,071 kgfcm, 77 ftlbf)
(b) Install the clip.
NOTICE:
If the holes for the clip are not aligned, tighten the nut up to 60_ further.
(c) Fully tighten the bolt and nut.
Torque: 74 Nm (755 kgfcm, 55 ftlbf)
NOTICE:
When installing the bolt, hold the nut not to rotate.
36. FULLY TIGHTEN LOWER CONTROL ARM ASSY LH
(a) Fully tighten the nut.
Torque: 60 Nm (612 kgfcm, 44 ftlbf)
(b) Install the clip.
NOTICE:
If the holes for the clip are not aligned, tighten the nut up to 60_ further.
(c) Fully tighten the bolt (member side).
Torque: 105 Nm (1,071 kgfcm, 77 ftlbf)
NOTICE:
When installing the bolt, hold the nut not to rotate.
37. INSPECT AND ADJUST PARKING BRAKE LEVER TRAVEL (See page 332)
38. INSPECT AND ADJUST REAR WHEEL ALIGNMENT (See page 274)
39. CHECK ABS SPEED SENSOR SIGNAL
(a) ABD WITH EBD SYSTEM (See page 05699)
(b) ABD WITH EBD & BA & TRC & VSC SYSTEM ( See page 05756)

AVENSIS REPAIR MANUAL (RM1018E)


3036
DRIVE SHAFT / PROPELLER SHAFT REAR AXLE LH HUB BOLT

REAR AXLE LH HUB BOLT


300K001

REPLACEMENT
HINT:
 COMPONENTS: See page 3030
 Replace the RH side by the same procedures as the LH side.
1. REMOVE REAR WHEEL
2. SEPARATE REAR DISC BRAKE CALIPER ASSY LH
(a) Removing the 2 bolts and rear disc brake caliper assy.
NOTICE:
Use a string or other device to keep the brake caliper from hanging down.
3. REMOVE REAR DISC

4. REMOVE REAR AXLE LH HUB BOLT


(a) Turn the axle hub to move the LH hub bolt and SST, that
SST
are to be removed, to the place shown in the illustration.
NOTICE:
Do not replace the hub bolt in any places other than that in
the illustration.
Hold (b) Using SST and a hammer handle or an equivalent to hold
the axle hub, remove the LH hub bolt.

Turn SST 0962810011
F45577

Washer
5. INSTALL REAR AXLE LH HUB BOLT
(a) Install a washer and nut to a new LH hub bolt as shown
Nut
in the illustration.
(b) Using a hammer handle or an equivalent to hold the axle
hub, install the LH hub bolt by torquing the nut.

Hold

Turn
 F45578

6. INSTALL REAR DISC


7. INSTALL REAR DISC BRAKE CALIPER ASSY LH
(a) Install the rear disc brake caliper assy with the 2 bolts.
Torque: 47 Nm (475 kgfcm, 34 ftlbf)
8. INSTALL REAR WHEEL
Torque: 103 Nm (1,050 kgfcm, 76 ftlbf)

AVENSIS REPAIR MANUAL (RM1018E)

You might also like