Professional Documents
Culture Documents
J. Praks
When environmental temperatures move out of the thermoneutral zone (or comfort zone) dairy
cattle begin to experience either heat stress or cold stress. Either stress requires the cow to
increase the amount of energy used to maintain the body temperature and there is less energy
available to produce milk. Thermoneutral zone is the range of environmental temperatures
where normal body temperature is maintained and heat production is at the basal level. The
ranges of thermoneutral zone are from lower critical temperature (LCT) to upper critical
temperature (UCT). LCT is the environmental temperature at which an animal needs to
increase metabolic heat production to maintain body temperature. UCT is the environmental
temperature at which the animal increases heat production as a consequence of a rise in body
temperature resulting for inadequate evaporative heat loss (Yousef, 1985). Thermoneutral
zone depends on the age, breed, feed intake, diet composition, previous state of temperature
acclimatization, production, housing and stall conditions, tissue (fat, skin) insulation and
external (coat) insulation, and the behaviour of the animal. UCT is given as 25-26 C , LCT as
a range from -16 to -37 C for dairy cows (Berman et al., 1985; Hamada, 1971). LCT for
newborn calves is 10 C in dry and draught-free environment. LCT decreases to 0 C by the
time the calf is 1 month old.
The principle of THI is that as the relative humidity at any temperature increases, it becomes
progressively more difficult for the animal to cool itself. (RCI Technical Information. The
influence of temperature humidity index on cow performance).
THI values of 70 or less are considered comfortable, 75 78 stressful, values greater than 78
cause extreme stress.
(http://www.guaranteedweather.com/page.php?content_id=25)
Heat stress
Heat stress for the dairy cow can be understood to indicate all high temperature-related forces
that induce adjustments occurring from the sub-cellular to the whole animal level to help the
cow avoid physiological dysfunction and for it to better fit its environment (Kadzere et al.,
2002).
Restlessness
Crowding under shade or at water tanks
Panting (open-mouthed breathing)
Increased salivation
Increased respiration rate (gasping):
80 to 120 breaths per minute moderate heat stress
120 to 160 breaths per minute strong heat stress
Over 160 breaths per minute severe heat stress
Rates of gut and ruminal motility are reduced
Lethargy
Decreased activity
Reduced feed intake
Under continuous heat stress lactating cows begin to show a decline in the
intake at 25-27 C with a marked decline of 40% above 30 C. (RCI Heat stress
in dairy cattle).
Increased sweating
In dairy cows two types of sweating can be distinguished: both are involved in
heat dissipation. The first type is insensible sweating or perspiration that leaves
the body at all times, unless the relative humidity is 100%. The other type,
thermal sweating, occurs as the principle evaporative cooling mechanism of the
cow when the ambient temperature rises.
Metabolic responses
Under heat stress metabolism is reduced, which is associated with reduced thyroid hormone
secretion and gut motility, resulting in increased gut fill. Plasma growth hormone concentration
and secretion rate declines with hot temperature (35 C). Ruminal pH is typically lower in heat
stressed cattle (quoted by Kadzere et al., 2002).
There are great changes in dietary electrolyte balance and acid/base balance associated with
heat stress. The major electrolytes involved in dietary electrolyte balance are Na+, K+, CL and
the buffer HCO3. S= is not considered so critical in the equation of dairy cattle. Na+, K+, CL
are the main ions involved in sweat.
The effects of heat stress on dietary electrolyte balance may be summarised as:
Appetite is depressed, there is some indigestibility of feed and gut motility is
slowed
Milk yield - at 35 C there is up to 33 % depression and at 40 C, as much as
50%
Loss in milk quality - fat and protein content declines
Water metabolism
The total body water is estimated to range between 75 and 81% of the body weight for
lactating dairy cows. Temperature is among the most important environmental factors
controlling water intake in lactating dairy cows. Heat stress simultaneously influences both
energy and water metabolism (Silanikove, 1992). Under thermal stress cows tend to have
increased water content in the rumen as a result of an accelerated water turnover rate. Water
loss from an animal is a continuous process; taking place all the time and increasing during the
heat stress because of additional evaporative water loss. Water intake of a dairy cow under
heat stress increases significantly.
Physical protection
Natural shade
Trees are an excellent natural source of shade on the pasture. Trees are not effective
blockers of solar radiation but the evaporation of moisture from leaf surface cools the
surrounding air.
Artificial shade
Solar radiation is a major factor in heat stress. Blocking its effects through the use of
properly constructed shade structures alone increases milk production remarkably. Two options
are available: permanent shade structures and portable shade structures (Shearer et al., 2005).
The evaporative cooling pad (corrugated cardboard or similar material) and a fan
system which uses the energy of air to evaporate water is a more economically feasible method
to cool the micro-environment.
High pressure foggers disperse a very fine droplet of water which quickly evaporates,
cooling the surrounding air and raising the relative humidity. The typical design incorporates a
ring of fogger nozzles attached to the exhaust side of the fan. As fog droplets are emitted they
are immediately dispersed into the fan's air stream where they soon evaporate. Animals are
cooled as the cooled air is blown over their body and as they inspire the cooled air.
Misters. A mist droplet is larger than a fog droplet but cools air by the same principle.
These systems do not work well in windy conditions or in combination with fans in humid
environments, where mist droplets are too large to fully evaporate before setting to the ground.
The consequence is wet bedding and feed.
Cooling in hot and humid climates emphasizes shade, wetting the skin, and moving air to
enhance the cow's major mechanism for the dissipation of heat evaporative cooling from the
skin.
Evaporative heat loss through sweating and panting is the primary mechanism for heat loss at
high environmental temperatures. As a result of water loss from sweating at high temperatures
thirst is increased, more urine is excreted and the huge waterflux resulting from increased
water consumption also causes heavy loss of electrolytes. Potassium (K+ ) loss from the skin
increases by 500% in unshaded cattle. In attempts to conserve K+, cows increase urinary
excretion rates of Na+.
In high temperature there is panting respiration (an important reaction to cool the body by
evaporative cooling). The rapid loss of C02 results in respiratory alkalosis. Cows compensate
by increasing urinary output of HC03-. Constant replacement of this ion is critical to
management of blood chemistry. Heat stress increases dietary requirements for the key
electrolytes, Na+, K+ and HC03-.
Management of the dietary electrolyte balance is based on adding essential body salts and
electrolytes to the drinking water and feed. It stabilises the dietary electrolyte balance,
promotes homeostasis, assists the osmoregulation of body fluids, stimulates appetite, ensures
normal skeletal development etc.(RCI Heat Stress in Dairy Cattle;
http: //www.rci.com.au/)
Cold stress
European cattle tend to be tolerant to cold. It is the reason why the impact of cold stress on
nutrient utilization and animal performance in cattle has received less research attention. Dairy
cattle are housed in the cowsheds that minimize the impact of environmental temperature
fluctuations on the animals.
During the last decade uninsulated loose housing cowsheds for dairy cattle have become
common also in northern countries. The temperature in the animal's rooms is only a few
degrees higher than the temperature outside the cowshed. This trend in dairy cattle keeping
increases the importance of cold stress investigations.
The next systemic reactions take place in animals suffering from cold stress:
Increased dry matter intake
Increased rumination
Increased gastrointestinal tract motility
Increased rate of passage of feed and liquid in the rumen and digestive tract
Increased basal metabolic rate and maintenance energy requirements
Increased body oxygen consumption
Increased cardiac output
Increased adrenalin, cortisol and growth hormone levels
Increased lipolysis, glyconeogenesis, glycogenolysis
Increased hepatic glycose output
For the dairy cows cold should be considered as a local problem. Direct chilling of the udder
depends as much on the thermal properties of the floor as on the temperature.
Recommended literature
Berman, A., Folman, Y.M., Kaim, M., Mamen, Z., Herz, D., Wolfenson, A., Grabber, Y.
Upper critical temperatures and forced ventilation effects for high-yielding dairy cows in a
tropical climate. J. Dairy Sci. 1985, 68, 488-495.
Hamada, T. Estimation of lower critical temperatures for dry and lactating dairy cows.
J. Dairy Sci., 1971, 54, 1704-1705.
Kadzere C.T., Murphy M.R., Silanikove N., Maltz E. Heat stress in lactating dairy
cows: a review. Livestock Production Science 77 (2002) 59-91.
McDowell, R.E., Hooven, N.W., Camoens, J.K.. Effects of climate on performance of
Holsteins in first lactation. J. Dairy Sci., 1976, 59, 965-973.
National Research Council,. Nutrient Requirements of Dairy Cattle. National Academy
Press, Washington, 1989.
RCI Heat stress in dairy cattle. http://www.rci.com.au
Shalit, O., Maltz, E., Silanikove, N., Berman, A. Water, Na, K, and Cl metabolism of
dairy cows at onset of lactation in hot weather. J. Dairy Sci., 1991, 74, 1874-1883.
Shearer J.K., Bray D.R., Bucklin R.A. The management of heat stress in dairy cattle>
what we are learned in Florida.
Silanikove, N. Effects of water scarcity and hot environment on appetite and digestion
in ruminants: a review. Livest. Prod. Sci., 1992, 30, 175-194.
Turnpenny, J.R., Wathes, C.M., Clark, J.A., McArthur, A.J. Thermal balance of
livestock. 2. Applications of a parsimonious model. Agricultural and Forest Meteorology,
2000,m 101, 29-52.
University of Minnesota Extension Service. Managing Dairy Cows in Cold Weather,
2004.
Yousef, M.K. Basic Principles. Stress Physiology in Livestock. Vol. 1. CRC Press,
Boca Raton, Fl, 1985).