You are on page 1of 3

Multiple choice questions

CHAPTER 1 INTRODUCTION
Choose the appropriate answer of the following multi choice questions:-
1.) Construction of dam come under the category of
(a.) Advanced construction
(b.) Environmental engineering
(c.) Structural analysis & design
(d.) Town planning
2.) Hydrological cycle come under the category of
(a.) Advanced construction
(b.) Structural analysis & design
(c.) Town planning
(d.) Water resource engineering
3.) Study of pollution & its control comes under the category of
(a.) Geotechnical engineering
(b.) Advanced construction
(c.) Environmental engineering
(d.) Water resource engineering
4.) Study of traffic engineering comes under the category of
(a.) Transportation engineering
(b.) Environmental engineering
(c.) Structural analysis & design
(d.) Geotechnical engineering
5.) Study of zoning of land comes under the category
(a.) Town planning
(b.) Structural analysis & design
(c.) Advanced construction
(d.) Building planning & construction
6.) Investigation of soil & foundation design comes under the category of
(a.) Town planning
(b.) Water resource engineering
(c.) Environmental engineering
(d.) Geotechnical engineering
7.) Irrigation engineering comes under the category of
(a.) Transportation engineering
(b.) Building planning & construction
(c.) Both (a) & (b)
(d.) None of the above
CHAPTER 2: SURVEYING- INTRODUCTION

8.) The main principle of surveying is to work from


(a.) The centre of the boundary
(b.) The whole to the part
(c.) The part to the whole
(d.) Higher to lower level
9.) The curvature of the earth is ignored in
(a.) Geodatic surveying
(b.) Plane surveying
(c.) Aerial surveying
(d.) Hydrographic surveying
10.) The curvature of the earth is taken into account when the extent of volume is more than
2
(a.) 50 km
2
(b.) 100 km
3
(c.) 250 km
(d.) None of the above
3 3
11.) If scale of map is 20 cm = 160000 m ,R.F. is
1
(a.)
20
4
(b.)
8000
1
(c.)
20000
1
(d.)
2
12.) Vernier scale is used to measure
(a.) Fractional part of a graduated scale
(b.) Fractional part of a plain scale
(c.) Fractional part of a diagonal scale
(d.) None of the above
13.) In surveying the linear measurements are taken in
(a.) Horizontal plane
(b.) Vertical plane
(c.) Horizontal & inclined plane
(d.) (a) & (b)
14.) The survey in which the curvature of the earth is taken into account is called (Dec. 2013)
(a.) Plane survey
(b.) Geological survey
(c.) Geodatic survey
(d.) Hydrographic survey
15.) Which of the following scale is the smallest one?
(a.) 1cm=10m
(b.) 10cm=10m
(c.) 100cm=10m
(d.) 1000cm=10m

You might also like