Professional Documents
Culture Documents
Step 3. If Machine
Group is not dis-
played in Opera-
tions Manager,
click Machine
Type Menu >
Mill > Default,
Fig. 1.
Fig. 1
Step 4. Expand Properties (click +) in Toolpaths
Manager, Fig. 1.
Step 6. Click left front top corner of the stock Click corner to
to move the origin, Fig. 2. After you move arrow
click corner the arrow will point to cor-
ner.
Step 3. Click OK in
the NC name dialog,
Fig. 5.
Fig. 4 Fig. 5
12-2-13
Mastercam X7 BOAT TOOLPATH Page 33-1
HST OptiCore and Waterline
Cudacountry.net Tech Ed
http://www.cudacountry.net email:cudacountry@hotmail.com
Step 4. Click both surfaces to select as Drive surfaces, Fig. 6. Drive
surfaces
The surfaces will highlight when selected.
Chain
Fig. 8
Fig. 7 Fig. 9
Step 9. Click OK in Chaining dialog box,
Fig. 7.
Step 10. Confirm 2 Drives surfaces and 1 Material boundary in Toolpath/surface selection dialog
box, then click OK in, Fig. 9.
click Select
library tool
Fig. 10.
Fig. 10
Fig. 11
Fig. 12
Tool # 1
Head # 1
Feed rate 60
Plunge rate 30
Fig. 14.
Cutting meth-
od Climb
Stepover Fig. 14
Absolute Dis-
tance .15
Stepdown
Absolute Dis-
tance .25
Stock to leave
on walls and
floors .04
Fig. 15.
Fig. 15
Mastercam X7 BOAT TOOLPATH Page 33-4
HST OptiCore and Waterline
Step 18. Select Material boundary from tree control and set:
Material
boundary
Compensate
to: Center
Fig. 16.
Retracts
Clearance
plane .2
All Leads 0
Fig. 17.
Fig. 16
Fig. 17
check Line/
Arc Filtering
Setting
Cut tolerance
25%
check Line/
Arc Filtering
Setting
uncheck One
way filtering
Fig. 18.
Fig. 22
Fig. 21
Finishing
Waterline
Fig. 25.
Fig. 25
Feed rate 80
Plunge rate 40
Fig. 26.
Cutting
method
Climb
Stepdown .02
Fig. 26
Check Add
cuts
Too contain-
ment
Compensate
to: Outside
Stock to leave
on walls and
floors 0
Fig. 27.
Fig. 27
Clearance
plane .2
Part clearance
.2
All Leads 0
Fig. 29.
Step 8. Click OK
in Wa-
terline dialog
box.
Fig. 28
Step 9. Save (Alt-F S).
E. Verify Toolpaths.
Step 1. In the Toolpaths Manager, click Regen-
erate all dirty operations , Fig. 29.