Professional Documents
Culture Documents
COM
Power Electronics Expected MCQ PDF 2 For Coal India Limited (CIL) MT Exam
2017
1) An ideal diode is
a. Unidirectional
b. Bidirectional
a. Diode
b. BJT
c. SCR
d. TRIAC
ANSWER: TRIAC
3) With gate open, the maximum anode current at which SCR is turned off from ON
condition is called
a. breakdown voltage
c. holding current
d. latching current
4) The curve between V and I of SCR when anode is positive w.r.t cathode and when
anode is negative w.r.t cathode are known as
WWW.ALLEXAMREVIEW.COM
a. Root mean square value of voltage and current to its peak value
b. Root mean square value of voltage and current to its average value
c. Average value of current and voltage to its root mean square value
d. Peak value of current and voltage to its root mean square value
ANSWER: Root mean square value of voltage and current to its average value
b. Average value of the ac component of load voltage to the peak value of voltage
ANSWER: DC output power to the transformer volt - amp rating required by secondary
8) In a 3 phase half wave rectifier, when firing angle is less than 90 degree, then the
average dc output voltage becomes
a. Positive
b. Negative
c. Zero
d. None of these
ANSWER: Positive
9) If the firing angle becomes negative, then the rectifier begins to work as
a. A rectifier
b. An inverter
c. A chopper
d. A regulator
ANSWER: An inverter
a. Current transformer
b. Potential transformer
c. Power transformer
d. SCR
11) DIAC and TRIAC both are semiconductors devices and conduct in
d. None of these
13) The phase angle of gate signal in TRIAC can be shifted by using
a. A capacitor
b. A variable resistor
c. An inductor
c. Soft starting
d. All of these
d. All of these
d. None of these
a. Cmin = V / ( Vr L f2 )
b. Cmin= ( 1 D ) V / ( Vr L f2 )
c. Cmin= ( 1 2 D ) V / 32 ( Vr L f2 )
WWW.ALLEXAMREVIEW.COM
d. Cmin= ( 1 2 D ) V / 42 ( Vr L f2 )
ANSWER: Cmin= ( 1 2 D ) V / 32 ( Vr L f2 )
19) In a flyback converter, the inductor of the buck-boost converter has been replaced by
a
a. Flyback capacitor
b. Flyback resistor
c. Flyback transformer
d. Flyback transistor
d. None of these
21) The ac output voltage waveform of VSI and AC output current waveform of CSI
respectively is composed of
22) If energy is taken from the AC side of the inverter and sends it back into the DC side,
WWW.ALLEXAMREVIEW.COM
then it is known as
d. None of these
23) A combination of synchronized leading edge and trailing edge modulation has also
been used to control a
d. None f these
b. Rectifiers
25) In a 3 phase VSI SPWM to use a single carrier signal and preserve the features of
PWM technique, the normalized carrier frequency should be
a. Multiple of two
ANSWER: Cannot control the load voltage except by means of dc link voltage
27) For commutation in three phase PAC, normally balanced three phase voltages VR, VY
and VB are connected to the three legs of the converter via
a. Three inductances
b. Three capacitances
c. Three resistance
d. Three transistors
28) If all the SCRs of 3 phase PAC is replaced by diodes, they would be triggered
a. 120 degree after the zero crossing of the corresponding line voltages
c. 120 degree before the zero crossing of the corresponding line voltages
ANSWER: 60 degree after the zero crossing of the corresponding line voltages
29) The ability of an electronic system to function properly in its intended electromagnetic
WWW.ALLEXAMREVIEW.COM
a. Susceptibility
b. Emission
c. Interference
d. Electromagnetic compatibility
a. Immunity
b. Emission
c. Interference
d. Electromagnetic compatibility
ANSWER: Immunity
d. None of these
a. Electric traction
b. Electric vehicles
c. Machine tools
WWW.ALLEXAMREVIEW.COM
d. All of these
33) In a lossless inverter, the average power absorbed in one period by the load must be
34) In a full bridge VSI, in order to avoid the short circuit across the DC bus and the
undefined AC output voltage condition, the modulating technique should ensure that
d. None of these
a. Square
b. Sinusoidal
c. Triangular
d. Saw - tooth
ANSWER: Sinusoidal
a. Time domain
b. Frequency domain
d. None of these
a. Linear function
c. Constant function
d. None of these
a. Phase lead helps to increase the phase margin of the control loop
b. Phase lag helps to increase the phase margin of the control loop
c. Phase lead helps to decrease the phase margin of the control loop
d. Phase lag helps to decrease the phase margin of the control loop
ANSWER: Phase lead helps to increase the phase margin of the control loop
d. All of these
WWW.ALLEXAMREVIEW.COM
40) In a square - wave operation of 3 phase CSIs, the power values are on for
a. 60 degree
b. 90 degree
c. 120 degree
d. 150 degree